• Journal of Applied Biological Chemistry
• /
• v.42 no.4
• /
• pp.180-185
• /
• 1999

Protein concentrate was produced and succinylated from rice bran to assess and improve its functional properties for the purpose of expanding the uses of rice bran proteins. The most effective solvent for the extraction of rice bran proteins was 20% aqueous ethanol at pH 9. The protein content of rice bran protein concentrate produced was 70.0% and the total protein yield was 64.3%. The extent of succinylation of free amino groups in the modified products was 72.8%. Though the modified protein products showed good functional properties including solubility, emulsion properties, and oil absorption capacity, it did not form gel. Succinylation improved solubility and emulsion and gelling properties. These improvements in functionality will enhance the value of rice bran proteins, thus enabling them to be more competitive with other food proteins.

• Korean Journal of Agricultural Science
• /
• v.37 no.1
• /
• pp.61-68
• /
• 2010

Rice bran proteins from different cultivars(Youngan, Sindongjin, Suwon 511) were extracted with Xylanase using orthogonal analysis method and their functional properties were investigated. The optimum extraction conditions, based on protein content in the extract found to be at 1 wt% xylanase, pH 7 and 50:1, solvent to rice bran ratio(v/w %). Nitrogen solubility indices(NSI) of rice bran protein concentrates were shown a minimum value at pH 4 ranged 2~23%, varied with different cultivars and a maximum (NSI${\geq}$90% for all cultivars) at pH 10. As for water adsorption and fat adsorption capacity, rice bran protein concentrates were shown to be better than Na-caseinate and isolated soy protein, respectively. Emulsifying activities were observed high in order of Na-caseinate>Youngan rice bran protein>Shindongjin rice bran protein>Suwon 511 rice bran protein>isolated soy protein. In general, the surface tension of rice bran protein solution($10^{-3}$ wt%, 5 mM bis-tris, pH 7) was increased with increasing concentrations and found a minimum value near pI. On heating, it was decreased slightly with increasing temperatures up to $70^{\circ}C$ and then increased above $80^{\circ}C$. Addition of sodium chloride was made the surface tension decrease. In conclusion, with Xylanase, rice bran protein concentrate can be successfully extracted from the rice bran of different cultivars and the Youngan rice bran protein was thought to have best functionality among rice cultivars tested. It might be used as a milk protein substitute.

• Asian-Australasian Journal of Animal Sciences
• /
• v.26 no.6
• /
• pp.812-819
• /
• 2013

Forty two Malpura lambs (21 d old) were divided into three groups of 14 each consisting of 8 females and 6 males. Lambs were allowed to suckle their respective dams twice daily up to weaning (13 wks) and offered free choice concentrate and roughage in a cafeteria system. The lambs in control group were fed conventional concentrate mixture, in RBO group concentrate mixture fortified with 4% industrial grade rice bran oil and in Ca-soap rice bran oil (as in RBO group) was supplemented in the form of calcium soap. The concentrate intake decreased($p{\leq}0.05$) in RBO group as a result total dry matter, crude protein and metabolizable energy intake decreased compared to control whereas Ca-soap prepared from the same rice bran oil stimulated the concentrate intake leading to higher total dry matter, crude protein and energy intakes. The digestibility of dry matter ($p{\leq}0.05$), organic matter ($p{\leq}0.05$) and crude protein ($p{\leq}0.05$) was higher in RBO group followed by Ca-soap and control whereas no effect was observed for ether extract digestibility. Higher cholesterol ($p{\leq}0.05$) content was recorded in serum of oil supplemented groups (RBO and Ca-soap) while no effect was recorded for other blood parameters. Rice bran oil as such adversely affected and reduced the body weight gain ($p{\leq}0.001$) of lambs in comparison to control whereas the Ca-soap of rice bran oil improved body weight gain and feed conversion efficiency in lambs. Fat supplementation decreased total volatile fatty acids ($p{\leq}0.05$) and individual volatile fatty acid concentration which increased at 4 h post feeding. Fat supplementation also reduced ($p{\leq}0.05$) total protozoa count. Ca-soap of rice bran oil improved pre slaughter weight ($p{\leq}0.05$) and hot carcass weight ($p{\leq}0.05$). It is concluded from the study that rice bran oil in the form of calcium soap at 40 g/kg of concentrate improved growth, feed conversion efficiency and carcass quality as compared to rice bran oil as such and control groups.

• Asian-Australasian Journal of Animal Sciences
• /
• v.24 no.9
• /
• pp.1268-1273
• /
• 2011

The present study was conducted to determine a feasible method of protein concentrate extraction from rice bran (RBPC) and its effect as a substitution for skim milk in early weaning pig diets. An investigation to extract protein concentrate from full fat rice bran was undertaken to determine the best ratio of water and rice bran, the amount of NaOH and a HCl solvent to use in a simple paddle-type mixer with modified spinning to produce RBPC. The results stated that the best ratio for water mixing in the RBPC extraction process was 1:5 with 20 g NaOH and 30 min in a paddle-type mixer at 300 rpm. A mix of 250 ml 0.2 N HCl was optimum for neutralization and protein precipitation. After the fluid was spun out with a washing machine, the sediment was left for 12-14 hours to complete the filtration. One kilogram of rice bran could produce an average of 324.5 gram RBPC and it contained 3.40% ash, 496.48 kcal of GE/100 gram, 1.94% crude fiber, 28.20% ether extract, 7.64% moisture and 16.66% crude protein, respectively. A total of 45 crossbred piglets, weaned at 3 weeks of age were allotted into control diet (A) and dietary treatments formulated with a four different rates of RBPC substitution for skim milk at a percentage of 25 (B), 50 (C), 77 (D) and 100 (E) respectively, in a randomized complete block (RCB) design. All piglets had free access to feed and water until 8 week of age when the experiment ended. Feed intake, average daily gain, growth rate and feed efficiency were not affected by dietary treatments. Blood test parameters after completion of the growth trial indicated normal health. Even though the mean of cell hemoglobin concentration was significantly different between treatments (p<0.05) it was still within the normal range. The cost difference for BW gain of 100% RBPC substituted for skim milk in the weaning diet was approximately 35% lower than that of the control and the relative cost of production was 96.67, 92.85, 70.75 and 64.48% lower for the replacement of 25, 50, 75 and 100% of skim milk respectively. These results implied that this technology is feasible for use by small scale farmers to improve their self-reliance.

• Asian-Australasian Journal of Animal Sciences
• /
• v.14 no.5
• /
• pp.646-650
• /
• 2001

The effect of feeding concentrate mixture devoid of grain on the performance of crossbred dairy cows was studied. Twelve crossbred cows of first/second lactation were randomly distributed into two equal groups. The animals of group 1 were fed on a concentrate mixture containing 30% maize grain whereas, the cows of group 2 were offered a concentrate mixture where grain was completely replaced with deoiled rice bran (DORB) and molasses. Wheat straw was given ad libitum to the cows of both the groups. The feeding was continued for 112 days. The intake of dry matter, CP and TDN were similar in both the groups. Digestibility of DM, OM, EE, NDF and ADF were also comparable between the groups. The average daily fat corrected milk (FCM) yield was 7.70 kg and 7.43 kg in group 1 and 2, respectively. The chemical composition of milk (protein, fat and total solids) also remained unaffected. The animals of both the groups gained 9-10 kg body weight which indicates that both the diets were nutritionally adequate and grain can be successfully replaced with DORB and molasses from the diet to sustain about 6-7 kg FCM production.

• Asian-Australasian Journal of Animal Sciences
• /
• v.15 no.9
• /
• pp.1307-1311
• /
• 2002

Twelve dietary combinations were prepared using 70 parts of fermented wheat straw (FWS) as the sole roughage supplemented with 30 parts of either the low protein concentrate mixture (Conc.-I), high protein concentrate mixture (conc.-II), maize grains (M), solvent extracted mustard cake (DMC), deoiled rice bran (DRB), uromol bran mixture (UBM), deep stacked poultry litter (DSPL), dried poultry droppings (DPD), M-DMC mixture (50:50), M-UBM mixture (50:50), M-DPD mixture (50:50) or M-UBM-DPD mixture (50:25:25) and evaluated by in-sacco technique. The above dietary combinations were also evaluated by changing the roughage to concentrate ratio to 60:40. The digestion kinetics for DM and CP revealed that FWS:DPD had the highest, whereas, the FWS:M-DMC had the lowest rapidly soluble fraction. The potentially degradable fraction was found to be maximum in FWS:M and minimum in FWS:DPD dietary combinations. The higher degradation rate of FWS:DRB and FWS:UBM combinations was responsible for their significantly (p<0.05) higher effective degradability as compared to other combinations. The highest undegradable fraction noted in FWS:M-UBM-DPD followed by FWS:DMC was responsible for high rumen fill values. The FWS:DRB, FWS:UBM and FWS:DPD combinations had higher potential for DM intake. The dietary combination with higher concentrate level (60:40) was responsible for higher potentially degradable fraction, which was degraded at a faster rate resulting in significantly higher effective degradability as compared to the corresponding dietary combination with low concentrate level (70:30). The low undegradable fraction in the high concentrate diet was responsible for low rumen fill values, which predicted of high potential for DM intake. Out of 24 dietary combinations, FWS with either of UBM, DRB, DMC, Maize, M-DMC or DPD in 70:30 ratio supplemented with minerals and vitamin A in comparison to conventional feeding practice (roughage and concentrate mixture) could be exploited as complete feed for different categories of ruminants.

• Asian-Australasian Journal of Animal Sciences
• /
• v.30 no.2
• /
• pp.187-191
• /
• 2017

Objective: An experiment was conducted to examine the effect of dietary supplementation of dried and ground foliage of black gram (Vigna mungo L.) on feed intake and utilization, and production performance of crossbred lactating cows. Methods: Eighteen lactating crossbred (Bos taurus${\times}$Bos indicus) cows (body weight $330.93{\pm}10.82kg$) at their second and mid lactation (milk yield $6.77{\pm}0.54kg/d$) were randomly divided into three groups of six each in a completely randomized block design. Three supplements were formulated by quantitatively replacing 0, 50, and 100 per cent of dietary wheat bran of concentrate mixture with dried and ground foliage of black gram. The designated supplement was fed to each group with basal diet of rice straw (ad libitum) to meet the requirements for maintenance and milk production. Daily feed intake and milk yield was recorded. A digestion trial was conducted to determine the total tract digestibility of various nutrients. Results: The daily feed intake was increased (p<0.05) with the supplementation of black gram foliage. Although the digestibility of dry matter, organic matter, crude protein, and ether extract did not vary (p>0.05), the fibre digestibility was increased (p<0.05), which ultimately improved (p<0.05) the total digestible nutrients content of composite diet. Although, the average milk yield (kg/animal/d) and composition did not differ (p>0.05) among the groups, milk yield was increased by 10 per cent with total replacement of wheat bran in concentrate mixture with of black gram foliage. The economics of milk production calculated as feed cost per kg milk yield (INR 10.61 vs 7.98) was reduced by complete replacement of wheat bran with black gram foliage. Conclusion: Black gram foliage could be used as complete replacement for wheat bran in concentrate mixture of dairy cows in formulating least cost ration for economic milk production in small holders' animal production.

• Journal of Animal Science and Technology
• /
• v.57 no.9
• /
• pp.35.1-35.8
• /
• 2015

Background: An experiment was conducted in Vietnam to test the hypothesis that total dry matter (DM) intake and liveweight (LW) gain would increase in a curvilinear manner with increasing amounts of concentrate offered. Method: There were five treatments: a basal diet of Guinea grass fed at 1 % of LW and rice straw fed ad libitum (T0), or this diet supplemented with concentrate at 0.6 (T1), 1.2 (T2), 1.8 (T3), or 2.4 % of LW (T4). The concentrate comprised locally available ingredients, namely cassava chips, rice bran, crushed rice grain, fishmeal, salt, and urea, mixed manually. Results: Concentrate intake increased from T0 to T3, but there was no difference in concentrate intake between T3 and T4. Total feed intake increased in a curvilinear manner from 4.0 to 6.4 kg DM/d as the quantity of concentrate consumed increased. The substitution of concentrate for grass and rice straw increased with increasing consumption of concentrate and was as high as 0.49 kg DM reduction per kg of concentrate consumed. LW gain increased curvilinearly, with significant differences between T0 (0.092 kg/d), T1 (0.58 kg/d) and T2 (0.79 kg/d); but there were no significant differences in LW gain between T2, T3 (0.83 kg/d) and T4 (0.94 kg/d).With increasing amount of concentrate in the diet, the digestibilities of dry matter, organic matter, crude protein, and crude fat increased, but NDF digestibility decreased. Conclusion: Based on these results, young Vietnamese Brahman-cross growing cattle will respond to a locally-sourced concentrate mix offered at a level of up to 1.2 % of LW.

• Asian-Australasian Journal of Animal Sciences
• /
• v.15 no.11
• /
• pp.1568-1572
• /
• 2002

A 152 day trial was conducted to see the effect of feeding naturally fermented wheat straw (FWS) with either energy, protein or energy protein supplements on the growth of buffalo calves. Twenty four male buffalo calves (10-12 months old) divided in 6 equal groups were individually offered FWS as sole roughage along with either conventional concentrate mixture (conc), maize grains (M), solvent extracted mustard cake (DMC), M-DMC mixture (50:50), deoiled rice bran (DRB) or uromol bran mixture (UBM) in 70:30 ratio. The digestibility of nutrients, nitrogen retention and nutritive value was maximum in FWS:UBM followed by FWS:DMC and FWS:Conc groups. Almost, all the blood parameters were observed well within the normal range except that of blood urea (FWS:UBM) and creatinine (FWS:DMC and FWS:DRB). The dietary combination in which FWS was supplemented with only conventional protein supplement like DMC proved to be highly efficient as far as live weight gain was concerned. FWS supplemented with energy-protein combination i.e. MDMC could also be used as complete feed for growing calves in comparison to conventional feeding system.

• Asian-Australasian Journal of Animal Sciences
• /
• v.15 no.1
• /
• pp.45-54
• /
• 2002

Ninety lactating goats (Bachthao, Barbary, Beetal and Jamnapary breeds) were used in an experiment to investigate the replacement value of the tree fodders Flemingia (Flemingia macrophylla) and Jackfruit (Artocarpus heterophyllus). The foliages were used to replace the concentrate in diets based on chopped whole sugar cane (Sacharatum sp.), Para grass (Brachiaria mutica) and dried cassava root (Manihot esculanta). The concentrate was replaced by foliage of Jackfruit or Flemingia at 0%, 20%, 40%, 60% and 80% based on the crude protein (CP) content in the concentrate and foliages, respectively. Average milk yield was 1,617 g/day for goats fed Jackfruit compared to 1,532 g/day for those fed Flemingia. Increasing amounts of Flemingia foliage resulted in reduced dry matter intake and decreased milk yield but milk composition (CP, casein and fat content) was similar up to 60% replacement. Flemingia showed a poor potential as a supplement for lactating goats and replacement levels should not exceed 20% of the protein in the concentrate or 7.5% of the dry matter in the diet. With respect to the combination of milk production and net return over the control a CP replacement rate of 20% was the most promising. For Jackfruit there was similar feed intake and milk yield at a replacement level of 20% of CP in the concentrate (9.2% of DM intake) compared to the control diet. Milk yield at the level of 40% replacement (15% of the DM) in the diet was slightly reduced. Up to a level of CP replacement rate of 60% (21% DM in the diet) can be suggested for on-farm testing as a higher net return over the control was obtained on station.