• Magazine of the Korean Society of Agricultural Engineers
• /
• v.32 no.3
• /
• pp.102-115
• /
• 1990

Importance of anaerobic digestion as an energy generating device has been increased as fuel shortage becomes serieous. Several modification methods on the conventional digesters including Powdered Activated Carbon (PAC) addition and two-phase digestion were studied to enhance the gas production. This study investigated the effects of PAC on anaerobic digestion of chicken manure in terms of gas production and sludge stabilization. As a first experiment, an optimum PAC dose for efficient gas production was determined in a batch test. In semi-continuous experiments, an optimum Sludge Retention Time (SRT) at that PAC concentration and an overall substate utilization rate coefficient were investigated. A portion of gas increased by PAC addition was estimated using a substrate utilization rate coefficient of microorganisms attached on PAC. This test was performed in batch experiments using acetic acid as a substrate. The digesters for all experiments were kept 35${\pm}$ 1˚C in a heated water bath. Mixing was performed manually once a day and the produced gas was collected for daily reading. The following conclusions were made for this study. 1. Cptimum PAC concentration was 5% total solids, where gas production rate was increased by 20 percents. 2. Optimum SRT was 7.5 days. 3. Substrate utilization rate coefficient of microorganisms attached on PAC was about twice as much as that of suspended ones.

• Korean Journal of Materials Research
• /
• v.29 no.12
• /
• pp.798-803
• /
• 2019

The self-discharge behavior of zinc-air batteries is a critical issue induced by corrosion and hydrogen evolution reaction (HER) of zinc anode. The corrosion reaction and HER can be controlled by a gelling agent and concentration of potassium hydroxide (KOH) solution. Various concentrations of KOH solution and polyacrylic acid have been used for gel electrolyte. The electrolyte solution is prepared with different concentrations of KOH (6 M, 7 M, 8 M, 9 M). Among studied materials, the cell assembled with 6 M KOH gel electrolyte exhibits the highest specific discharge capacity and poor capacity retention. Whereas, 9 M KOH gel electrolyte shows high capacity retention. However, a large amount of hydrogen gas is evolved with 9 M KOH solution. In general, the increase in concentration is related to ionic conductivity. At concentrations above 7 M, the viscosity increases and the conductivity decreases. As a result, compared to other studied materials, 7 M KOH gel electrolyte is suitable for Zn-air batteries because of its higher capacity retention (92.00 %) and specific discharge capacity (351.80 mAh/g) after 6 hr storage.

• KSBB Journal
• /
• v.6 no.2
• /
• pp.135-141
• /
• 1991

This study thus looks into two treatment processess : i) Anaerobic digester coupled with hollow fibre membrane unit. Treatment of starch waste with anaerobic digester-membrane system was studied. $0.17\m^2$ area of hollow fibre membrane unit of known pore size was immersed into laboratory-scale anaerobic digestion system. The pore size of membrane was varied from 0.03 to $\0.15mu$m. The hydraulic retention time of anaerobic digester was varied from 1.5 to 10 days. The effect of hydraulic retention time on treatment efficiency was significant while effect of membrane size was not significant. The gas production was about 0.74㎥/kg COD treated. The COD removal efficient was about 80-95% depending on the hydraulic retention time. ii ) Crossflow ultrafiltration as post treatment to anaerobic filter. The effluent from anaerobic filter, which had a total COD in the range of 4,500-5,200 mg/L was treated by crossflow ultrafiltration units. The study conducted with different membrane pore size indicated that membrace with 1,000,000 molecular weight cut-off size gave a higher COD removal efficiency in the range of 83-87% while giving a study flux of $120-130 L/\m^2$.h. A study was conducted to see the long term clogging effect of membrane also.

• Horticultural Science & Technology
• /
• v.28 no.4
• /
• pp.656-663
• /
• 2010

In order to improve the consumer acceptance of fragrant yellow hybrids of $Phalaenopsis$ ($Phal.$), crosses between yellow hybrid varieties were made and the obtained hybrids were investigated for horticultural characteristics as well as difference in fragrance patterns. Cross combination of $Phal.$ Brother lawrence and $Phal.$ Brother saragold yielded good seedling population of 500 plants. Segregation was noticed in color density, spot and stripe patterns on yellow color base of petal and also in fragrance. Six lines with multi-branch on flower stalk and strong fragrance flower were finally selected. Volatile fragrance components were compared among $Phal.$ Brother lawrence, $Phal.$ Brother saragold and their hybrids by GC/SAW electronic nose. In the derivative pattern of chromatogram and polar derivative pattern of fragrance, similar dominant peaks appeared on retention time 7-9 s and some hybrid lines had two strong peaks on retention time 20-25 s, respectively. Also in polar frequency pattern of fragrance obtained by $VaporPrint^{TM}$ image analysis among parent flowers and hybrids, an identical strong peak near 8 s of retention time was shown. This single fragrance component is considered a key element of fragrance in $Phal.$ Brother lawrence, $Phal.$ Brother saragold and their hybrids. This peak could be used as a marker for the breeding of fragrance in $Phalaenopsis$.

• Journal of Microbiology and Biotechnology
• /
• v.5 no.3
• /
• pp.143-148
• /
• 1995

A strain producing soybean paste flavor was isolated from traditional Korean soybean paste. The isolate was identified as Bacillus subtilis PM3. The neutral fraction representing the traditional soybean paste aroma was obtained from the whole volatile components produced by B. subtilis PM3 in cooked soybean. Each separated peak from the neutral fraction of gas chromatogram was identified by gas chromatography-mass spectrometry (GC/MS) and Kovat's retention index, and the aromas of each peak were investigated by a sniffing test with the exercise panel. The twenty-nine components, including six character impact compounds and twelve components of flavors of Korean soybean paste, were confirmed. Some regions of gas chromatogram represented the soybean paste odor. It has been confirmed that traditional Korean soybean paste can be manufactured with the strain B. subtilis PM3.

• Journal of Biosystems Engineering
• /
• v.37 no.4
• /
• pp.233-244
• /
• 2012

Purpose: The kinetic evaluation was performed for swine manure (SM) degradation and biogas generation. Methods: The SM was anaerobically digested using batch digesters at feed to inoculum ratio (F/I) of 1.0 under mesophilic conditions ($36.5^{\circ}C$). The specific gas yield was expressed in terms of gram total chemical oxygen demand (mL/g TCOD added) and gram volatile solids added (mL/g VS added) and their effectiveness was discussed. The biogas and methane production were predicted using first order kinetic model and the modified Gompertz model. The critical hydraulic retention time for biomass washout was determined using Chen and Hashimoto model. Results: The biogas and methane yield from SM was 346 and 274 mL/ TCOD added, respectively after 100 days of digestion. The average methane content in the biogas produced from SM was 79% and $H_2S$ concentration was in the range of 3000-4108 ppm. It took around 32-47 days for 80-90% of biogas recovery and the TCOD removal from SM was calculated to be 85%. When the specific biogas and methane yield from SM (with very high TVFA concentration) was expressed in terms of oven dried volatile solids (VS) basis, the gas yield was found to be over estimated. The difference in the measured and predicted gas yield was in the range of 1.2-1.5% when using first order kinetic model and 0.1% when using modified Gompertz model. The effective time for biogas production ($T_{Ef}$) from SM was calculated to be in the range of 30-45 days and the critical hydraulic retention time ($HRT_{Critical}$) for biomass wash out was found to be 9.5 days. Conclusions: The modified Gompertz model could be better in predicting biogas and methane production from SM. The HRT greater than 10 days is recommended for continuous digesters using SM as feedstock.

• The Korean Journal of Ceramics
• /
• v.5 no.3
• /
• pp.296-302
• /
• 1999

The state of the art of the 2-stage swirl calciner is to make 2-stage counter gas flow in a calciner with cooler hot air. Gas flow in the calciner increases retention time of raw mix particles. Simple structure of the 2-stage swirl calciner operated optimally the rotary cement kiln. In this study, in order to decide the entrance type of the cooler air of the optimal calciner model, an entrance cooler air velocity, the input points of raw mix were analyzed in many aspects with cold model experiment and computational fluidized dynamic simulation. It was found that the entrance type of cooler air fully splite 2-stage for the optimal condition of the cold model calciner. The operation conditions were that the input feeding, the cooler air velocity and the air velocity of throat were 0.33kg/$\textrm m$3$, 15m/s and 20m/s respectively. The performance of 150 t/d the pilot plant connected with the kiln rising duct was that volume capacity of the calciner is over 430 kg/$\textrm m$3$-h, decarbonation rate of raw mix apparently 90%, heat consumption 950 kcal/kg-cli and retention time of raw mix 2.4 sec. Its the best operating condition is cooler air velocity 18m/s, the gas velocity of throat 25m/s, feeding rate of raw mix 10t/h. The operating experience of the pilot plant confirmed the success of scale up for over 3000 t-cli/d.

• Korean Journal of Agricultural Science
• /
• v.45 no.2
• /
• pp.219-228
• /
• 2018

This study evaluated the effects of glycerol polyethylene glycol ricinoleate (GPGR) supplementation in different energy density diets on the growth performance, blood profiles, excreta gas emission, and total tract apparent retention (TTAR) of nutrients in broilers. A total of 544 one-day-old male Ross broilers were used in a 35-day trial. The broilers were allocated into one of four treatment groups in a $2{\times}2$ factorial arrangement with two levels of energy densities (a normal energy or decreased energy density) and GPGR (0 and 0.035%). From day 18 to 35, the GPGR supplemented and normal energy density diet groups showed a significantly improved (p < 0.05) body weight gain (BWG). Meanwhile, the GPGR supplemented diet group had a significantly reduced (p < 0.05) feed conversion ratio (FCR) compared to that of the non-supplemented diet group. From day 0 to 35, the GPGR supplemented diet and the normal energy density diet groups had a significantly increased (p < 0.01) BWG and a reduced (p < 0.01) FCR. Moreover, GPGR supplementation tended to increase (p < 0.1) the TTAR of the dry matter (DM) compared with the non-supplemented diets. Likewise, the normal energy density diets had a significantly improved TTAR for the gross energy (GE) (p < 0.05) than that of the decreased energy density diets. No interactive effects were observed between the energy density and GPGR supplemented diets. In conclusion, both dietary GPGR supplementation and normal energy density diets had beneficial effects on the growth performance of broiler chickens without any adverse effects on blood profiles and excreta gas emission.

• Journal of Environmental Health Sciences
• /
• v.24 no.1
• /
• pp.1-8
• /
• 1998

This study was carried to investigate the treatment characteristics of the phenol and catechol with an anaerobic fluidized bed reactor(AFBR) having a dimension of 9 cm i.d. and 1.25 m height. The reactor was operated at $35\pm 1\circ$C. The COD concentration of the effluent, the gas production rate and the composition of gas were measured to determine the performance of the AFBR as the hydraulic retention time(HRT) was decreased from 2 days to i day at 600 mg/l of the phenol and catechol concentration. Stable treatment of the phenol wastewater could be achieved with the AFBR at 18 days but the catechol wastewater couldn't be. At HRT 2 days, the phenol wastewater showed the COD reduction efficiency of 93% and the gas production of 2.7 l/day and the catechol wastewater was obtained the COD reduction efficiency of 82% and the gas production of 0.72 l/day. Also at HRT 1 day the phenol and catechol wastewater showed the COD reduction efficiency of 95% and 73% and the gas production of 4.0 l/day and 1.25 l/day, respectively.

• Korean Journal of Food Science and Technology
• /
• v.24 no.2
• /
• pp.171-176
• /
• 1992

Volatile flavor components of Codonopsis lanceolata were extracted by gas co-distillation (GCD), solvent extraction/fractionation (SEF), and headspace sampling (HSS) methods. The extracts were analyzed by dual-capillary gas chromatography-retention index (GC-RI) and gas chromatography-mass spectrometry(GC-MS). The two extracts prepared by SEF and HSS gave more similar fragrance to the Codonopsis lanceolata than the GCD extract. The GC profiles of the SEF and HSS extracts were similar to each other except for differences in peak areas. The extract prepared by SEF gave a sweet note while the extract prepared by HSS gave a green note. The GCD extract began to give a burnt note of herb medicine with prolonged distillation. Rapid extraction of flavor components from Codonopsis lanceolata was possible in several short steps by SEF and HSS methods compared to GCD. GC-MS and GC-RI were used for peak identification. GC-RI was more effective for identification of isomers, and polar FFAP column was more suitable for identification of polar compounds. From Codonopsis lanceolata we identified 35 volatile flavor constituents, 24 of which have not been previously reported by simultaneous distillation extraction method $^{(5)}$. trans-2-Hexanal, cis-3-hexen-1-ol, trans-2-hexen-1-ol, and hexanol were considered key components of the green note and 1-octen-3-ol, the component of the fresh note. Esters, including amyl propionate, seem to be responsible for the sweet note particular to Codonopsis lanceolata.