• Mycobiology
• /
• 제34권1호
• /
• pp.14-21
• /
• 2006

Crude protein (CP) content of mechanically ground rice straw into small particles by an electric grinder and reducing value (RV) and soluble protein (SP) in the culture filtrate were lower than that of the chopped straw into $5{\sim}6\;cm$ lengths when both ground and chopped straws were fermented with Aspergillus ochraceus, A. terreus or Trichoderma koningii, at steady conditions. The reduction rate of RV, SP and CP was 22.2, 2.4, 7.3%; 9.1, 4.9, 8.5% or 0.0, 0.0, 3.6% for the three fungi, respectively. Chemical pretreatment of straw by soaking in $NH_{4}OH$ for a day caused significant increase in CP of the fermented straw than the other alkali and acidic pretreatments. Gamma irradiation pretreatment of dry and wet straw with water, specially at higher doses, 100, 200 or 500 kGy, caused significant increase in RV and SP as CP in the fermented straw by any of these fungi. Chemical-physical combination pretreatment of rice straw reduced the applied dose of gamma irradiation required for increasing fermentable ability of fungi from 500 kGy to 10 kGy with approximately the same results. Significant increases in RV and SP of fermented straw generally occurred as the dose of gamma irradiation for pretreated straw, which combined with $NH_{4}OH$, gradually rose. Whereas, the increase percentage in CP of fermented straw that was pretreated by $NH_{4}OH-10\;kGy$ was 12.4%, 15.4% or 8.6% for A. ochraceus, A. terreus or T. koningii, respectively.

• Biotechnology and Bioprocess Engineering:BBE
• /
• 제7권5호
• /
• pp.252-262
• /
• 2002

The growing interest in the application of arachidonic acid (ARA) in various fields of health and dietary requirements has elicited much attention on the industrial production of ARA-containing oil by the cultivation of Mortierella fungi. For the industrial production of ARA, various studies, such as isolation of a high-potential strain and optimization of culture conditions, have been conducted. Studies including the investigation of morphology are important because ARA is accumulated in the mycelia, and thus cultivation with high biomass concentration is essential for obtaining a high ARA yield. Combining the results derived from various studies, a high ARA yield was attained in an industrial fermentor. These ARA production techniques are applicable to the production of other polyunsaturated fatty acids (PUFAs), and will contribute to the improvement of fermentation technology especially in the field of fungal cultivation.

• Mycobiology
• /
• 제30권3호
• /
• pp.166-169
• /
• 2002

Protein productivity by the cellulolytic fungi, Trichoderma viride(MTCC 800), Chaetomium globosum and Aspergillus terreus was compared in co-culture and mixed culture fermentations of cashewnut bran. Co-cultures were more effective in substrate saccharification, which ranged between $85{\sim}88%$ compared to the $62{\sim}67%$ saccharification shown by the monocultures. Maximum saccharification was induced by T. viride and C. globosum co-culture resulting in the highest 34% release of reducing sugars. The maximum 16.4% biomass protein and the highest protein productivity(0.58%) were shown by T. viride and A. terreus co-culture. A. terreus performed better in co-culture in the presence of T. viride rather than with C. globosum. Among the cellulolytic enzymes, FPase(Filter Paper Cellulase) activity was significantly higher in all the co-cultures and in the mixed culture than in their respective monocultures. Mixed culture fermentation involving all the three fungi was not effective in increasing the per cent saccharification or the biomass protein content over the co-cultures.

• Journal of Microbiology and Biotechnology
• /
• 제11권6호
• /
• pp.1120-1123
• /
• 2001

Screening tests against six plant pathogenic fungi were performed in order to develop biopesticides. Actinomycetes were used to discriminate Bacillus thuringiensis for wide use as a microbial pesticide. From more than 100 actinomycetes tested, twelve strains showed potent antifungal activities. We report in vivo screening results from fermentation broths of these twelve strains and identification of the strain taxa.

• Mycobiology
• /
• 제30권4호
• /
• pp.228-232
• /
• 2002

This study focused on the production of high quality compost for the growth of aero-thermophilic fungi, which has a promoting effect on the growth rate and production of oyster mushrooms. The automated solid-state bioreactor system was designed on the basis of a Three-Phase-One system, which controls the serial steps of prewetting, pasteurization and fermentation processes. High numbers of thermophilic fungi and bacteria were recovered from the mushroom composts prepared by this solid-state bioreactor. The rates of composting process were depended on physical as well as chemical factors. Among these factors, the parameters of moisture content and temperature were found to be particularly important. In our automated system, constant levels of moisture content, temperature and ventilation via mixing were provided by a centralized control apparatus including PLC, water tank and water jacket systems. These features induced higher microbiological activity of aero-thermophiles.

• 한국균학회지
• /
• 제51권3호
• /
• pp.219-227
• /
• 2023

This study was conducted to analyze the distribution and characteristics of fungal species in meju using the traditional method. Fungal distribution in meju was investigated using metagenomic and morphological analyses, based on which Aspergillus flavus/oryzae strains were identified as the dominant fungi in all meju samples, followed by Pichia, Rhizopus and Lichtheimia spp. As A. flavus/oryzae was dominant, we further evaluated the aflatoxin production ability and enzymatic activity of the isolates. Thin-layer chromatography and polymerase chain reaction revealed that the A. flavus/oryzae strains isolated from meju are non-aflatoxigenic fungi. Based on the analyses of amylase and protease activities, strains with high activities of amylase or protease were identified, which are proposed to be used as starters for meju fermentation.

• Asian-Australasian Journal of Animal Sciences
• /
• 제20권2호
• /
• pp.208-213
• /
• 2007

The objective of the experiment was to determine the optimum cultural [moisture levels (55, 60 and 70%), days of fermentation (7, 14 and 21), temperature (25 and $35^{\circ}C$) of incubation)] and nutritional parameters (urea addition (0 and 2%) and variable levels of single super phosphate (0.25 and 0.50% SSP)) for bio-processing of the mustard (Brassica campestris) straw (MS) under solid-state fermentation (SSF) system. The performance of SSF was assessed in terms of favorable changes in cell wall constituents, protein content and in vitro DM digestibility of the MS. Sorghum based inoculum (seed culture) of Ganoderma lucidum to treat the MS was prepared. The 50 g DM of MS taken in autoclavable polypropylene bags was mixed with a pre-calculated amount of water and the particular nutrient in the straw to attained the desired levels of water and nutrient concentration in the substrate. A significant progressive increase in biodegradation of DM (p<0.001), NDF (p<0.01) and ADF (p<0.05) was observed with increasing levels of moisture. Among the cell wall constituents the loss of ADF fraction was greatest compared to that of NDF. The loss of DM increased progressively as the fermentation proceeded and maximum DM losses occurred at 28 days after incubation. The protein content of the treated MS samples increased linearly up to the day $21^{th}$ of the incubation and thereafter declined at day $28^{th}$, whereas the improvement in in vitro DM digestibility were apparent only up to the day $14^{th}$ of the incubation under SSF and there after it declined. The acid detergent lignin (ADL) degradation was slower during the first 7 days of SSF and thereafter increased progressively and maximum ADL losses were observed at the day $28^{th}$ of the SSF. The biodegradation of DM and ADL was not affected by the variation in incubation temperature. Addition of urea was found to have inhibitory effect on fungal growth. The effect of both the levels (0.25 and 0.50) of SSP addition in the substrate, on DM, NDF, ADF, cellulose and ADL biodegradation was similar. Similarly, the protein content and the in vitro DM digestibility remain unaffected affected due to variable levels of the SSP inclusion in the substrate. From the results it may be concluded that the incubation of MS with 60 percent moisture for 21 days at $35^{\circ}C$ with 0.25 percent SSP was most suitable for MS treatment with Ganoderma lucidum. Maximum delignification, enrichment in the protein content and improvement in in vitro DM digestibility were achieved by adopting this protocol of bioprocessing of MS.

• 한국수산과학회지
• /
• 제27권4호
• /
• pp.357-365
• /
• 1994

마늘 첨가량을 달리하였을 경우 숙성기간에 따른 오징어 식해의 성분 및 미생물 변화를 측정한 결과는 다음과 같다. 식해 숙성중의 일반성분에 대한 마늘의 영향은 거의 없었으며 pH는 마늘농도 $2\%$와 $3\%$ 사이에는 별 차이가 없었지만 $4\%$ 마늘농도에서는 숙성초기를 제외하고는 마늘농도 $2\%$ 및 $3\%$ 보다 낮은 값을 나타내었다. Lactic acid 량은 $4\%$ 마늘농도에서 $2\%$ 및 $3\%$보다 숙성초기에 많이 생성되었으며 숙성후기에 그 차이는 상당히 줄어들었다. 총 arginine 량 변화에 마늘의 영향은 거의 없었으며 아미노태 질소량은 숙성 초기에는 마늘농도가 증가할수록 낮은 값을 나타내었다. TMAO는 숙성초기에 급격하게 감소하였으며 $2\%$ 및 $3\%$ 농도에는 큰 차이는 없었으나 $4\%$ 농도는 숙성기간이 증가함에 따라 감소비율이 상대적으로 낮았다. TMA 량은 숙성초기에 급격하게 증가하였으나 마늘농도에 따른 차이는 거의 없었으며 숙성 후기에 $2\%$ 마늘농도에서 $3\%$ 및 $4\%$ 농도보다 많이 생성되었다. 미생물 변화를 살펴보면 총균수 및 fungi는 마늘농도가 증가함에 따라 균수는 적었으나 숙성말기에는 그 차이는 크지 않았다. Lactic acid bacteria는 숙성 0일에는 마늘농도가 증가함에 따라 균수가 적었으나 숙성기간 5일 이후로는, 마늘농도가 증가함에 따라 현저한 차이를 나타내었으나 숙성기간이 증가할수록 그 차이는 줄어들었다. Proteolytic bacteria, psychrotroph 및 fungi는 숙성 0일에는 마늘농도가 증가함에 따라 균수는 적었으나, 숙성기간이 증가할수록 균수는 증가하였으며, 숙성말기에 더 큰 감소경향을 나타내었다.

• Mycobiology
• /
• 제42권2호
• /
• pp.189-192
• /
• 2014

During a search for neuraminidase inhibitors derived from medicinal fungi, we found that the fermentation broth of Phellinus linteus exhibited potent neuraminidase inhibitory activity. Through bioassay-guided fractionation, two active compounds were purified from the ethyl acetate-soluble portion of the fermentation broth of P. linteus. These structures were identified as inotilone (1) and 4-(3,4-dihydroxyphenyl)-3-buten-2-one (2) by spectroscopic methods. Compounds 1 and 2 inhibited H1N1 neuraminidase activity with $IC_{50}$ values of 29.1 and 125.6 $125.6{\mu}M$, respectively, in a dose-dependent manner. They also exhibited an antiviral effect in a viral cytopathic effect reduction assay using MDCK cells. These results suggest that compounds 1 and 2 from the culture broth of P. linteus would be good candidates for the prevention and therapeutic strategies towards viral infections.

• Mycobiology
• /
• 제44권3호
• /
• pp.171-179
• /
• 2016

In the screening of marine mangrove derived fungi for lovastatin productivity, endophytic Aspergillus luchuensis MERV10 exhibited the highest lovastatin productivity (9.5 mg/gds) in solid state fermentation (SSF) using rice bran. Aspergillus luchuensis MERV10 was used as the parental strain in which to induce genetic variabilities after application of different mixtures as well as doses of mutagens followed by three successive rounds of genome shuffling. Four potent mutants, UN6, UN28, NE11, and NE23, with lovastatin productivity equal to 2.0-, 2.11-, 1.95-, and 2.11-fold higher than the parental strain, respectively, were applied for three rounds of genome shuffling as the initial mutants. Four hereditarily stable recombinants (F3/3, F3/7, F3/9, and F3/13) were obtained with lovastatin productivity equal to 50.8, 57.0, 49.7, and 51.0 mg/gds, respectively. Recombinant strain F3/7 yielded 57.0 mg/gds of lovastatin, which is 6-fold and 2.85-fold higher, respectively, than the initial parental strain and the highest mutants UN28 and NE23. It was therefore selected for the optimization of lovastatin production through improvement of SSF parameters. Lovastatin productivity was increased 32-fold through strain improvement methods, including mutations and three successive rounds of genome shuffling followed by optimizing SSF factors.