• The Korean Journal of Food And Nutrition
• /
• v.16 no.4
• /
• pp.334-339
• /
• 2003

To increase the utilization of citron, citron juice that is by-product of citron tea was spray dried and freeze dried. Cyclodextrin(CD) was used as wall material to stabilize during drying. The physiochemical properties of citron juice were as follows: water content of 82.3%, pH of 2.45, and there were little different in two kinds of drying or CD added in different ratio. Citric acid, malic acid, succinic acid and lactic acid were detected in all of the samples. Spray and freeze-drying increased markedly yellowness compared to that of citron juice. Heat stability was reduced by both of two kinds of drying, and CD 15% was more decreased than CD 10%. Water uptake by freeze-drying was somewhat higher than that of spray-drying. When sensory properties of original citron juice was compared with those of spray and freeze dried, freeze drying with 10% of cyclodextrin was evaluated as superior to citron juice or other drying conditions.

• Korean Journal of Food Science and Technology
• /
• v.41 no.1
• /
• pp.32-36
• /
• 2009

The physical properties of freeze-dried Aloe vera gel powders were examined according to the influence of the concentration degrees of the gel solutions as raw materials during freeze-drying. As a pre-treatment prior to freeze-drying, the gel solutions were vacuum-concentrated at three concentration levels (g water/g solids): high (H), 76; medium (M), 119; and low (L), 159. The water contents of the three powder samples were almost the same. For their viscosity measurements, non-Newtonian fluid behavior with shear thinning was observed in samples H and M, whereas Newtonian liquid behavior was found in sample L. In electrical conductivity measurements, sample H showed the highest conductivity upon dissolving the powder in water. For their water sorption isotherms, sample H was analyzed to have the least amount of bound water. Finally, it was determined that the degree of concentration caused only slight differences in the physical properties of freeze-dried Aloe gel powders.

• Food Science and Preservation
• /
• v.23 no.2
• /
• pp.145-154
• /
• 2016

This study investigated the possibility of usage of freeze-dried ingredients for the preparation of Nabak kimchi. The quality characteristics of Nabak kimchi using freeze-dried ingredients (radish, kimchi cabbage, green onion, garlic and ginger) were monitored during storage at $4^{\circ}C$. The initial pH of Nabak kimchi was 5.76~5.93, however, it decreased significantly over increasing storage periods (p<0.05). The titratable acidity of Nabak kimchi increased during storage, reaching 0.43~1.08%. Among the freeze-dried samples, those treated with freeze-dried radish and minor ingredients showed lower titratable acidity than that of the control. The initial number of total aerobic and lactic acid bacteria were 5.57~6.25, and 5.52~6.24 log CFU/g, respectively. After 28 days, the population of total aerobic and lactic acid bacteria in the raw ingredients and freeze-dried minor ingredients was less than 8.0 log CFU/g, but more than 9.0 log CFU/g in other samples. Yeasts and molds in Nabak kimchi were detected up to 2~3 log CFU/g, but coliforms were not detected in all samples during storage. The score of firmness and overall acceptability in the control, raw ingredients and freeze-dried minor ingredients were significantly higher than others (p<0.05). These results indicated that freeze-dried ingredients, such as green onion, garlic, and ginger, can be used in kimchi and would delay microbial growth and extend the shelf-life of kimchi without any deduction of sensory quality.

• Preventive Nutrition and Food Science
• /
• v.12 no.2
• /
• pp.89-94
• /
• 2007

Nutrients and hormone levels of dried pig placenta were studied. Placentas were freeze-dried (FD), oven-dried at 60 (OD-60), and 90$^{\circ}C$ (OD-90) and then crushed by a blender into small pieces. FD and OD-60 pig placenta had a higher moisture content than did OD-90, with no difference between FD and OD-60. There were no large differences in compositions of crude protein, crude fat, and crude ash of dried placenta among the treatments and the contents of K, Fe, and ${\alpha}$-tocopherol were highest in FD (p<0.05). Glutamine and glycine were the most abundant amino acids in all dried placenta and tyrosine was highly retained in FD placenta, compared with OD (p<0.05). Estradiol was the major sex hormone, followed by progesterone and testosterone in all dried placentas. Antibiotics including amoxicillin, sulfamethazine, tylosin, and chlorotetracyclin were not detected from the pig placentas tested. These results demonstrate that placenta is a good biomaterial with high nutritional quality, and that freeze drying is superior to oven drying for processing pig placenta.

• Korean Journal of Food Science and Technology
• /
• v.33 no.1
• /
• pp.100-106
• /
• 2001

The objective of this study was to improve the shelf-life of kimchi by freeze drying. Kimchi was freeze dried and stored at $0^{\circ}C$, $5^{\circ}C$ and $28^{\circ}C$ for 60 days. It was reconstituted with water at an interval of ten days and number of total lactic acid bacteria(LAB), sensory properties and shape/color were observed. The results were as follows: (1) Number of total LAB of sample stored at $0^{\circ}C$ or $5^{\circ}C$ for 60 days decreased gradually and the value of 10 day-sample and 30 day-sample was significantly different from the value of 0 day-sample and 20 day-sample, respectively (p<0.05). Number of total LAB of sample stored at $28^{\circ}C$ decreased more rapidly in comparison with that of sample stored at $0^{\circ}C\;or\;5^{\circ}C$. (2) Overall acceptability, taste, moistness and chewiness of freeze dried/reconstituted kimchi slightly decreased by freeze drying. However, acceptability of freeze dried/reconstituted kimchi was relatively good. (3) Overall acceptability of freeze dried/10 days-stored/reconstituted sample was slightly lower than that of reference sample (not-freeze dried sample). Overall acceptability of sample stored at $28^{\circ}C$ for 50 days decreased substantially in comparison with sample stored at $28^{\circ}C$ for 10 day. (4) In case of freeze dried/stored samples, sensory properties of sample stored at $5^{\circ}C$ for 60 days were not different from those of reference(sample stored at $0^{\circ}C$). Overall acceptability, taste, texture and crispness of sample stored at $28^{\circ}C$ started to decrease after 10 days. Odor and color of sample stored at $28^{\circ}C$ were changed after 50 days and 60 days, respectively.

• Korean Journal of Food Science and Technology
• /
• v.41 no.2
• /
• pp.146-150
• /
• 2009

Sliced ginger samples were dried using 30, 50, and 80% maltodextrin, respectively, as a dehydrating agent. The moisture content of the maltodextrin-treated ginger decreased with increasing concentrations of maltodextrin. The dehydrated ginger was compared with hot air-dried and freeze-dried ginger samples in terms of rehydration ratio, gingerol content, color, and sensory characteristics. The rehydration ratio of the maltodextrin-treated ginger was superior to those of the hot-air dried or freeze-dried ginger. In addition, the maltodextrin-treated ginger had the highest content of 6-gingerol among the samples. Color as well as sensory scores for odor, texture, appearance, and overall acceptance were greater for the maltodextrin-treated ginger compared to the hot-air dried or freeze-dried ginger. These results indicate that drying ginger with maltodextrin is very efficient because good rehydration capacity is retained and minimal cell destruction can be achieved.

• The Korean Journal of Food And Nutrition
• /
• v.29 no.6
• /
• pp.1023-1029
• /
• 2016

Probiotic functional foods are known to have various functional effects such as intestinal regulation, modulation of immune system, reduction of allergies, and lowering of cholesterol. The purpose of this study was to select probiotic strain that is most suitable for freeze-dried coffee for the development of functional coffee products. The survival rate of probiotics, at drinking condition of coffee, at acid, at bile and after freeze-dried in coffee were measured on 1 strain isolated from commercial freeze-dried coffee, 8 strains used as fermented milk starter, 1 Bifidobacterium and 1 Bacillus coagulans. Bacillus coagulans showed the highest survival rate from $2.4{\times}10^7cfu/g$ to $2.0{\times}10^7cfu/g$ especially after freeze-drying. The results at drinking condition of coffee, at acid tolerance, at bile tolerance and at storage test showed significantly better survival rate of Bacillus coagulans than that of control (Lactobacillus casei). Especially, Bacillus coagulans showed 3.8-fold higher survival rate at acid tolerance (pH 1, 120 minutes) than control. Thus, the lactic acid-producing Bacillus coagulans is characterized as a probiotic strain suitable for functional coffee formulation and commercialization.

• Food Science and Preservation
• /
• v.15 no.1
• /
• pp.9-14
• /
• 2008

This study compared microbial load, texturre, histological properties, and sensory characteristics of gamma-irradiated (20 kGy) Kimchi and freeze-dried Kimchi under condition; of long-tenn storage. immediately after irradiation, no aerobic bacteria were detected, but microbial load of freeze-dried Kimchi decreased by only 1 log cycle in comparision with the nonirradiated control sample. The firmness of irradiated Kimchi was significantly higher than that of rehydrated freeze-dried Kimchi (p<0.05). Scanning electron microscopy showed collapse of the microstructure in epidermis tissues of rehydrated Kimchi. 'The sensory scores for color, texture, and taste of irradiated Kimchi were higher than those for rehydrated freeze-dried Kimchi.

• Korean Journal of Food Science and Technology
• /
• v.21 no.1
• /
• pp.17-24
• /
• 1989

Effects of cooking and drying methods on the lipids content and neutral lipid component of shrimp, Metapenaeus joyneri, were investigated. Total lipid content of the fresh shrimp was 6.0%(dry basis), which was not changed significantly depending on the cooking and drying methods. Lipid of the fresh shrimp was composed of 36.8% of neutral lipids, 21.5% of glycolipids, and 41.7% of phospholipids. Freeze dried shrimp was substantially higher in neutral lipid contents but lower in glycolipid and phospholipid contents than hot air dried one. Main components of the neutral lipids were triglycerides, free sterols, free fatty acids and esterified sterols. Freeze dried shrimp contained higher triglycerides contents than hot air dried shrimp, whereas free fatty acids content in hot air dried shrimp was greater than that of freeze dried one due to the decomposition of triglycerides to free fatty acids during hot air drying. Major fatty acid composition of the total lipid were palmitoleic acid, eicosapentaenoic acid and docosahexaenoic acid, and that of neutral lipid were palmitic acid, palmitic acid, oleic acid, eicosapentaenoic acid and docosahexaenoic acid in fresh shrimp.

• Korean Journal of Food Science and Technology
• /
• v.44 no.6
• /
• pp.716-721
• /
• 2012

This study was designed to compare the quality characteristics of spray-dried (SD) and freeze-dried (FD) powders prepared with hot water extracts of sea mustard (Undraia pinnatifada) and sea tangle (Laminaria longissima). The moisture content of FD seawed was lower than that of SD, and sea mustard had a higher overall moisture content than sea tangle. The alginic acid content of SD seaweed was significantly higher than that of FD seaweed for both species. There were relatively higher contents of phenolic compounds in SD powders than in FD powders. DPPH radical scavenging ability was significantly greater in SD seaweed, and also, SOD-like activity in SD powders was higher than those of FD powders. However, the nitrite scavenging activity of FD powders of sea mustard (10 mg/mL) was higher than that of SD. In conclusion, spray-dried sea mustard and sea tangle extracts exhibited higher physiological functionalities than their freeze-dried counterparts.