• Tribology and Lubricants
• /
• 제32권5호
• /
• pp.154-159
• /
• 2016

This paper presents an experimental study of the leakage performance and endurance performance of a mechanical face seal in the 7-ton-class turbopump of the Korea Space Launch Vehicle 2 third-stage engine. We install a mechanical face seal between the fuel pump and turbine to prevent the mixing of the fuel and turbine gas. We design and manufacture a prototype mechanical face seal, which has two parts, namely, a bellows seal assembly and mating ring. We set up a test facility to measure the leakage and endurance of the mechanical face seal. For the similarity tests, we use water under real operating conditions such as high rotational speed, high temperature, and high pressure. Through investigation of the leakage and carbon wear rate, it is possible to evaluate the performance of the mechanical face seal. The results of the leakage and endurance performance test demonstrate the absence of any leakage from the prototype mechanical face seal after a trial run and clarify that the acceptable wear rate fully satisfies the turbopump requirements. Finally, we install a qualified mechanical face seal in a 7-ton-class turbopump and perform a validation test in the turbopump real-propellant test facility in the Korea Aerospace Research Institute. The test results confirm that the mechanical face seal works well under real operating conditions.

• Physical Therapy Rehabilitation Science
• /
• 제9권4호
• /
• pp.302-308
• /
• 2020

Objective: The endurance and strength of deep neck flexor (DNF) muscles have a major role on the function and stability of the cervical spine. In recent years, there has been a lack of research that have investigated the muscle tone of the superficial neck muscles. The purpose of this study was to examine the relationship of between contraction ratio of the DNF and sternocleidomastoid (SCM) muscles, DNF endurance, and muscle tension of the neck muscles. Design: Cross-sectional study. Methods: Forty-seven subjects (male=20, female=27) participated in this study. The muscle tone of the upper trapezius (UT), SCM, and suboccipital (SO) muscle was measured using a contact soft tissue tone-measuring instrument. For the contraction ratio of the SCM and longus colli muscle, the thickness of the relaxation and maximum contraction state of the SCM and longus colli muscles were assessed using a diagnostic ultrasound measuring instrument and a pressure biofeedback unit. The deep neck flexor endurance test (DNFET) was performed in a cranio-cervical flexion posture. The correlations between the measured variables were investigated. Results: The relationship between the DNFET and SO tone showed a significant negative correlation (p<0.05). The relationship between the DNFET and contraction ratio showed a significant positive correlation (p<0.01). There was no significant correlation between the DNFET and SCM and UT tone. Conclusions: This study confirmed that there is a relationship between DNF endurance, DNF activation, and SO tone. The information on the results of this study may be used as a reference that can be actively applied in the clinical environment.

• 대한간호학회지
• /
• 제26권4호
• /
• pp.833-852
• /
• 1996

Regular long term dance movement could be one of ways to induce improvement of psychophysiological variables, resulting in improvement of quality of life. However, there have been few studies to evaluate the effect of dance movement training on both physiological and psychological variables in the elderly. This study was focused to determine the effect of Korean traditional dance movement training on psychophysiological variables-body weight, body fat, lean body mass, muscle strength, muscle endurance, flexibility, agility, resting heart rate and blood pressure, depression and life satisfaction-in Korean elderly women. Thirty four subjects, aged between 65 and 75years who have normal cognition, sensory function, cerebellum function, cardiovascular function, participated in this study. Seventeen experimental group subjects were selected from E-elderly university in Kyung Gi province, and Seventeen control group subjects were selected from N-welfare facility in Seoul City. Seventeen experimental group subjects participated for 12weeks dance movement program. Korean traditional dance movement program was developed on the basis of Korean traditional dance and music by the author. The program consisted of approximately 50minutes of dance, 3times a week for 12weeks. During 50minutes workout, there were 15minutes of warm-up dancing, 25minutes of conditioning dance and 10minutes of cool-down dancing. The intensity for the conditioning phase was at between 60% and 65% of age-adjusted maximum heart rates. The body weight, body fat, lean body mass, muscle strength(grip strength, leg strength), muscle endurance, flexibility, agility, resting heart rate and blood pressure, depression and life satis-faction were measured prior to and following the experimental treatment. The participants in dance movement were interviewed focusing on subjective feeling following 12 week's regular dance movement. Data were analyzed with mean, standard deviation, percentage of change, X²-test, t-test, and ANCOVA test using SPSS PC/sup +/ program. Subjective feeling was categorized into cognitopsy-chological and physiological responses. Results were obtained as follows : 1) The body weight (F=15.52, p=.000), body fat (F=18.33, p=.000) and lean body mass (F=7.28, p=.011) of the experimental group were significantly lower than those of the control group following the dance movement training. 2) The leg strength (F=30.96, p=.000), muscle endurance (F=9.06, p=.005), agility(F=44.92, 000), flexibility(F=6.84, p=.014) of the experimental group were significantly higher than those of the control group following the dance movement training. There was no significant difference of grip strength(F=.43, p=.515) between experimental and control groups. 3) The heart rate(F=26.96, p=.000), systolic (F=10.40, p=.000) and diastolic(F=3.99, p=.005) blood pressure at rest of the experimental group were significantly lower than those of the control group following the dance movement training. 4) No significant difference of score of depression (F=3.49, p=.071) was observed between experimental and control groups. 5) Score of life satisfaction of experimental group was remarkably higher than that of control group following 12weeks of dance movement training (p<0.05). 6) Thematic responses about the dance movement following the training were positive. "I feel good" was the most frequent among cognitopsychological responses and "I feel lightness of body" was the most frequent among physiological responses. The results suggest that Korean traditional dance movement training can improve psychophysiological variables of Korean elderly.

• PNF and Movement
• /
• 제16권3호
• /
• pp.461-473
• /
• 2018

Purpose: The purpose of this study was to evaluate and compare the effects of inspiratory muscle training with chest expansion exercises on pulmonary function, maximal inspiratory pressure, and gait in individuals with stroke. Methods: The participants in this study included 36 stroke patients. These patients were randomly divided into three groups: an inspiratory muscle training (IMT) with chest expansion (CE) group (n=12), an IMT group (n=12), and a control group (n=12). Participants in the IMT with CE group underwent IMT and CE exercises 5 times per week for 30 minutes over 4 weeks, whereas those in the CE group and the control group received IMT and conventional physical therapy, respectively, for the same duration. The investigator measured the patients' pulmonary function, maximal inspiratory pressure, and gait endurance. Results: After the intervention, the change values for the forced vital capacity (FVC), forced expiratory volume in one second (FEV1), peak expiratory flow (PEF), maximal inspiratory pressure (MIP), and six-minute walk test (6MWT) in the IMT with CE group and the control group were significantly greater than those of the control group (p<0.05). Similarly, after the intervention, the change values of the FVC, FEV1, PEF, MIP, and 6MWT in the IMT with CE group were significantly greater than those in the IMT group (p<0.05). Conclusion: These findings suggest that IMT with CE could be used to increase pulmonary function, maximal inspiratory pressure, and gait endurance in stroke patients.

• 드라이브 ㆍ 컨트롤
• /
• 제11권4호
• /
• pp.61-67
• /
• 2014

When a manual transmission equipped car stops on an incline where the nose of the car is higher than the rear, hill-start control or hill-holder could prevent the vehicle from rolling backward as the car moves forward. The easy-hill assist valve consists of a check valve and a needle type ON/OFF solenoid valve connected in parallel; it is a hydraulic actuator that can maintain brake pressure using an electrical signal from the ECU. As the EHA valve is a safety-related component of the brake system, high reliability as well as superior dynamic performance is required for it to be applied in commercial vehicles. This paper presents the design of the EHA valve as a piece of equipment that can simulate the brake actuation pressure with a pressurizing piston. Following specific test standards, the experimental results validate the implemented functions of the test equipment, proving the test stand to be effective for the performance and endurance of the EHA valve.

• Tribology and Lubricants
• /
• 제26권6호
• /
• pp.322-328
• /
• 2010

An inter-propellant seal (IPS) for 75 ton class thrust turbopump was tested. Leakage characteristics were presented with a given range of pressure difference under cryogenic as well as room temperature conditions. For cryogenic tests, liquid nitrogen was used as analogic fluid of liquid oxygen (LOX) while water was used instead of kerosene for room temperature condition. Test results showed that IPS had satisfactory leakage performance. Additionally endurance test was conducted to prove the life time of manufactured IPS and the tested IPS had successfully survived during required life time, 2100 seconds.

• 성인간호학회지
• /
• 제14권2호
• /
• pp.233-243
• /
• 2002

Purpose: This study is aimed at testing the effect of health promotion program on health promoting behavior and cardiovascular risk factors of middle-aged women. Method: The research design was the nonequivalent control group pre-post test. Twelve middle-aged women were the experimental group and ten were the control group. The 8-week health promotion program was given to the experimental group. There were health promotion theories, flexibility and muscle strength exercise, cardiopulmonary endurance exercise, nutrition, stress management, cancer prevention and early detection, management of menopause and wrap-up in health promotion program for middle-aged women. The measurement tool was Health Promoting Behavior developed by researcher using serum cholesterol, obesity rate, systolic blood pressure, and diastolic blood pressure as cardiovascular risk factors. Result: The experimental group showed a higher score of health promoting behavior than the control group. There were no differences on cardiovascular risk factors(cholesterol, obesity rate, diastolic blood pressure) between the experimental and control groups except systolic blood pressure. Conclusion: Conclusively, this health promotion program for middle-aged women was effective in increasing health promotion behaviors, but wasn't effective in decreasing cardiovascular risk factors except the systolic blood pressure. It seems it's necessary to re-study this using more samples and a longer duration of the program, and smaller mortality rate.

• 한국항공우주학회지
• /
• 제33권8호
• /
• pp.111-121
• /
• 2005

지상용 장비의 주 동력원으로 사용할 수 있는 출력 100kW급 가스터빈 엔진의 연소기를 개발하여 시험하였다. 이를 위해 환형역류형 연소기와 압력선회식 연료노즐을 채택하였고, 1차원 설계와 3차원 열, 유동해석을 통하여 연소기 설계를 수행하였으며, 연료노즐 시험, 연소기 리그 시험 등을 통하여 개발된 연소기의 성능을 확인하였다. 개발된 연소기를 엔진에 장착하여 각종 환경시험을 수행한 결과, 연소기 저온 점화성능, 내구 성능 등에서 만족할 만한 결과를 도출하였으며, 개발된 연소기는 지상용 주 동력장치에 성공적으로 적용되었다.

• Tribology and Lubricants
• /
• 제21권3호
• /
• pp.114-121
• /
• 2005

As fuel cell system is environmental friendly generator, its performance depends on its air supply system. Because, fuel cell stack generates electrical energy by electron and the electron is generated by reacting between air and hydrogen. So, more and more compressed air is supplied, more and more the energy can be obtained. In this study, turbo-expander supported by air foil bearing is introduced as the air supply system used by fuel cell systems. The turbo-expander is a turbo machine which operates at high speed, so air foil bearings suit its purpose for the bearing elements. Analysis for confirming the stability and endurance is conducted. Based on FDM and Newton-Raphson method, characteristics of air foil bearing, dynamic coefficients, pressure field and load capacity, are obtained. Using the characteristics of air foil bearing, the rotordynamic analysis is performed by finite element method. The analysis (stability analysis and critical speed map) shows that turbo-expander is stability at running speed. After the analysis, the test process and results are presented. The goals of test are running up to 90,000 RPM, flow rate of 150 $m^3/h$ and pressure ratio of 1.15. The test results show that the aerodynamic performance and stability of turbo-expander are satisfied to the primary goals.

• 한국전문물리치료학회지
• /
• 제29권3호
• /
• pp.180-186
• /
• 2022

Background: The craniocervical flexion test (CCFT) was developed for the activation and endurance of deep cervical flexors. However, the muscle thickness and muscle thickness changing ratio of the sternocleidomastoid (SCM) and deep cervical flexor (DCF) muscles in subjects with and without forward head posture (FHP) have not been reported. Objects: To determine the difference in thickness of the SCM and DCF muscles and the difference in the muscle thickness changing ratio between SCM, DCF, and DCF/SCM 20 mmHg and DCF/SCM 30 mmHg between subjects with and without FHP. Methods: Thirty subjects with and without FHP were enrolled. The muscle thickness of the SCM and DCF was measured when maintained at a baseline pressure of 20 mmHg and a maximum pressure of 30 mmHg using a pressure biofeedback unit during the CCFT. Ultrasonography was used to capture images of SCM and DCF muscle thickness during the CCFT, which was calculated using the picture archiving and communication system (PACS). Results: We observed a significant difference within the pressure main effect between SCM and DCF at a baseline pressure of 20 mmHg and a maximum pressure of 30 mmHg (p < 0.05). However, there was no significant difference in the muscle thickness and muscle thickness changing ratio for SCM and DCF during CCFT between subjects with and without FHP. Conclusion: There was no significant difference in the muscle thickness recruitment pattern during CCFT in posture changes between subjects with and without FHP.