• Proceedings of the KSME Conference
• /
• 2004.11a
• /
• pp.1436-1441
• /
• 2004

Achieving the maximum blasting efficiency with minimum abrasive consumption is a critical concern in surface preparation stage of shipbuilding and offshore industry. Increasing the abrasive flow rate beyond the optimum point results in a major reduction in productivity even though the amount of abrasive used is larger. So, this study is intend to find out the optimum abrasive-to-air mixing ratio which can make a significant improvement in blasting efficiency and remarkably reduce the amount of abrasive used. From the test results, it can be identified that as the abrasive feeding rate is increased linearly, blasting efficiency is increased to a maximum point and then gradually decreased in the form of a bell-shaped.

• Proceedings of the KWS Conference
• /
• 2005.06a
• /
• pp.229-231
• /
• 2005

Friction surfacing of STS304 consumable rod on S45C substrate was investigated by microstructural observation and mechanical tests. STS304 layer formed a strongly-bonded thick layer under a wide range of surfacing conditions. The hardness distribution showed the peak value in the boundry layer, while the highest coating efficiency obtained in the condition of 1000rpm-2.5mm/sec-2.5mm/sec. As the consumable rotation rate and the traveling rate increased, the coating efficiency tended to decrease. On the other hand, as the feeding rate increased, the coating efficiency appeared to be increased.

• Asian-Australasian Journal of Animal Sciences
• /
• v.25 no.6
• /
• pp.869-879
• /
• 2012

This study was conducted to investigate the effects of dietary lipid source and level on growth performance, blood parameters, fatty acid composition and flesh quality of sub-adult olive flounder Paralichthys olivaceus. Eight experimental diets were formulated to contain 5% squid liver oil (SLO), 5% linseed oil (LO), 5% soybean oil (SO), a mixture of 1% squid liver oil, 2% linseed oil and 2% soybean oil (MIX), no lipid supplementation with high protein level (LL-HP), 10% squid liver oil (HL-SLO), a mixture of 1% squid liver oil, 4.5% linseed oil and 4.5% soybean oil (HL-VO), and 1% squid liver oil with high starch level (LL-HC), respectively. Two replicate groups of fish (average initial weight of 296 g) were fed the diets for 17 wks. After 5 wks, 11 wks and the end of the feeding trial, five fish from each tank were randomly sampled for analysis of body composition. At the end of the feeding trial, final mean weight of fish fed the LL-HP diet was significantly (p<0.05) higher than that of fish fed the HL-VO diet, but did not differ significantly from those of fish fed the SLO, LO, SO, MIX, HL-SLO and LL-HC diets. Fish fed the LL-HP diet showed significantly higher feed efficiency than fish fed the LO, HL-SLO and HL-VO diets. Feed efficiency of fish fed the LO, SO and MIX diets were similar to those of fish fed the SLO and HL-SLO diets. Fish fed the HL-SLO diet showed significantly higher total cholesterol content in plasma compared with other diets. Fatty acid composition of tissues was reflected by dietary fatty acid composition. The highest linoleic (LA) and linolenic acid (LNA) contents in the dorsal muscle were observed in fish fed the SO and LO diets, respectively, regardless of feeding period. The highest eicosapentaenoic acid (EPA) content in the dorsal muscle was observed in fish fed the LL-HP and LL-HC diets after 11 and 17 weeks of feeding, respectively. Fish fed the SLO and HL-SLO diets showed higher docosahexaenoic acid (DHA) content than that of other treatments after 11 and 17 weeks of feeding, respectively. Dietary inclusion of vegetable oils reduced n-3 HUFA contents in the dorsal muscle and liver of fish. The n-3 HUFA contents in tissues of fish fed the SLO and HL-SLO diets were higher than those of fish fed other diets, except for the LL-HP and LL-HC diets. Hardness, gel strength, chewiness and cohesiveness values of dorsal muscle in fish were significantly affected by dietary lipid source. The results of this study indicate that fish oil in fish meal based diets for sub-adult olive flounder could be replaced by soybean oil and linseed oil without negative effects on growth and feed utilization.

• Korean Journal of Fisheries and Aquatic Sciences
• /
• v.28 no.3
• /
• pp.237-246
• /
• 1995

Larvae of the freshwater shrimp, Macrobrachium nipponense were reared in the laboratory at constant condition $(25^{\circ}C,\;7\%o)$, and their feeding rate, oxygen consumption rate, and growth rate were measured in regular intervals of time during larval development. Regression equations describing rates of feeding, growth and respiration as functions of time during individual larval molt cycles were inserted in a simulation model in order to analyse time-dependent patterns of variation as well as in bioenergetic efficiencies. Absolute values for feeding, growth, respiration and assimilation showed clear changes during the molt cycle, The absolute and specific values of respiration (R: R/C) showed small variation during the individual molt cycles. Significance of respiration in relation to growth (G) increased within the carbon budget, respiration rate (R/C) outbalanced growth rate (G/C) in late premolt. When the portion of metabolizable carbon is respired (R/G), metabolic coefficient was < 1 (i.e. R$(K_2)$ decreased concurrently, In cumulative carbon budget, total feeding was $491.54\;{\mu}g$ C/ind., assimilation was $85.3\%$, respiration was $47.7\%$, and growth was $37.6\%$ from hatching to postlarval stage.

• Asian-Australasian Journal of Animal Sciences
• /
• v.23 no.6
• /
• pp.724-732
• /
• 2010

Two feeding experiments were conducted to investigate the effects of dietary paprika (DP) and lipid (DL) levels on growth performance and skin pigmentation of pale chub, Zacco platypus. Six diets (designated as $P_0L_8,\;P_0L_{17},\;P_8L_8,\;P_8L_{17},\;P_{16}L_8\;and\;P_{16}L_{17}$) were formulated to contain 0%, 8% and 16% paprika with 8% and 17% lipid, respectively. For the growth experiment (Exp I), three replicate groups of fish (average weight 2.6${\pm}$0.2 g) were fed one of the six experimental diets for 8 weeks. At the end of the feeding period, survival was above 94% and not significantly different among dietary treatments. Weight gain, feed efficiency and protein efficiency ratio of fish fed the $P_{16}L_8$ diet were lower than for fish fed the $P_0L_8$ diet. The highest total carotenoid (TC) content was observed in fish fed the $P_{16}L_8$ diet. For the pigmentation experiment (Exp II), each experimental diet was fed to two replicate groups of fish (average weight 9.0${\pm}$0.5 g) for 8 weeks. At the end of the feeding period, TC content of the skin was significantly affected by DP (p<0.05). The highest TC content of the skin was observed after 6 weeks of feeding at all dietary treatments. Astaxanthin content of the skin was not affected by DP and DL (p>0.05). The capxanthin and zeaxanthin contents of skin increased significantly with increasing DP, whereas the opposite trend was observed for lutein and ${\beta}$-cryptoxanthin contents. The skin lightness ($L^*$ values) significantly decreased whereas the values of $a^*$ and $b^*$ were significantly increased in fish fed the diets containing paprika (p<0.05). The present results suggest that feeding a diet containing 8% paprika and 8% lipid for 6 weeks could improve skin pigmentation of pale chub without any adverse effects on growth performance.

• Korean Journal of Fisheries and Aquatic Sciences
• /
• v.44 no.2
• /
• pp.149-154
• /
• 2011

Two experiments were conducted to investigate the effects of dietary moisture content on the growth and gastrointestinal evacuation of sub-adult olive flounder (Paralichthys olivaceus) in the summer and winter seasons. In the first experiment, three experimental diets containing different moisture levels (7%, 15%) and additives were prepared by adding water and commercial additives (1% nutrients, 1% digestives) to commercial extruded pellets. Fish (initial weight: $332{\pm}9.2$ g) were distributed randomly into six 3000 L tanks (25 fish/tank) in a flow-through tank system. Two replicate groups of fish were fed the experimental diets to satiation for 14 weeks during the summer season ($21.4{\pm}2.5^{\circ}C$). Survival, weight gain, feed efficiency, and daily feed intake did not differ significantly among groups. In the second experiment, two experimental diets containing different moisture levels (8%, 23%) were prepared by adding water to commercial extruded pellets. Fish (initial weight: $646{\pm}6.7$ g) were randomly distributed into six 3000 L tanks (20 fish/tank) in a flow-through tank system. Three replicate groups of fish were fed the experimental diets to satiation for 19 weeks during the winter season ($12.2{\pm}1.2^{\circ}C$). Weight gain, feed efficiency, and daily feed intake did not differ significantly among groups. Gastrointestinal evacuation rates were determined after the end of the winter feeding trials. The stomach contents of fish fed diets containing different moisture levels peaked within 3 h after feeding and then decreased gradually over 40 h to approach pre-feeding levels. Intestinal contents began to accumulate 3 h after feeding and reached a maximum at 32 h, then declined until nearly complete evacuation around 56 h. The stomach contents reached moisture levels of approximately 70% within 3 h after feeding and then increased gradually. No considerable difference in moisture levels was observed in the stomach contents of fish fed diets with different moisture contents. The results of this study suggest that the gastric evacuation of sub-adult olive flounder was not affected by dietary moisture level and the addition of water to the diet had no beneficial effect on the growth of sub-adult olive flounder in the summer and winter seasons.

• Korean Journal of Fisheries and Aquatic Sciences
• /
• v.3 no.3
• /
• pp.161-171
• /
• 1970

1. The higher the temperature of the sea water, and the smaller the size of the oriental brown shrimp, the higher the feeding rate of the shrimp will be as long as the temperature ranges from $19^{\circ}\;to\;30^{\circ}C$, and each shrimp weighs from 1.6 to 14.9 grams. The average daily feeding rate is between 18 to 44 percent. 2. The nighttime feeding rate is always higher than the daytime feeding rate. However, the daytime feeding rate can be raised to from 22 to 37 percent of the daily feeding rate iii the non-sediment, dark or direct-sunshine-shielded conditions. Growth can thus be accelerated to that extent under such conditions. 3. When anchovy and short-necked clam meats were simultaneously used as food, a greater quantity of anchovy meat was consumed than short-necked clam meat both during the daytime and nighttime. When anchovy and short-necked clam meats were simultaneously given, the averaged daily feeding rates of anchovy and short-necked clam meats were 12.9 percent and 10.3 percent, respectively. 4. The following equation applies to the relationship between the freight of the oriental brown shrimp (W in grams) and their daily growth rate (DGR in percent): log DGR=0.7035-0.7864 log W. The daily growth rate is in inverse proportion to the size of the shrimp. 5. The efficiency of food conversion of the oriental brown shrimp fluctuates between 2.8 and 7.8 percent without extensive difference depending on the size of the shrimp. This was very small as compared with the corresponding figures so far known for fish and cuttlefish.

• Journal of Nutrition and Health
• /
• v.7 no.4
• /
• pp.1-5
• /
• 1974

Forty weaning albino rats were used to find the effects of alternate feeding of high protein diet with different intervals on growth, feed efficiency, protein efficiency ratio, weight of some internal organ, protein digestibility and nitrogen balance. Results obtained are summarized as follows: 1. The growth rate and feed efficiency of group B fed high protein and low protein alternately in every other day was equal to that of A group fed medium protein diet daily. However, the rats fed high protein diet once every three days or every four days could not result in same growth that obtained by group A. 2. The protein efficiency ratio of each group was the same without significant difference. 3. The liver weight appeared to be in proportion to final body weight, but intestine weight and length appeared not to be affected by treatments. 4. The protein digestibility in each group was insignificant. However, urinary nitrogen loss of intermittent high protein feeding group was lower than that of control group and the nitrogen retention ratio decreased with increased nitrogen intake.

• Korean Journal of Poultry Science
• /
• v.28 no.3
• /
• pp.245-257
• /
• 2001

Localization of livestock facilities leads to concentration of livestock wastes and subsequent leakage of pollutants into the environment, resulting in public concern about their effects. Nitrogen (N) and phosphorus (P) are the most harmful components of animal manure, but odor from the manure itself and the livestock facilities is also a problem. Improving the nutrient efficiency of the livestock helps to decrease excretion of these environmental contaminants. Pigs and chickens are the main experimental models used in studies to improve nutrient efficiency. Addition of feed supplements and modifying feeding systems to improve nutrient efficiency can result in significant decrease in the N, P, odor and dry matter (DM) weight of manure. Examples of these methods include the following. 1) Addition of synthetic amino acids and reducing protein contents resulted N reductions of 10∼27% in broilers, 18∼35% in chicks and layers, 19∼62% in pigs, and a 9∼43% reduction in odor in pigs. 2) Enzyme supplementation resulted in a 12∼15% reduction in DM weight in broiler manure. 3) Phvtase supplementation resulted in P reductions of 25∼35% in chickens and 20∼60% in pigs. 4) Use of growth promoting substances resulted in a 5∼30% reduction in N and a 53∼56% reduction in odor of pigs. 5) Formulating diets closer to requirements (diet modification) reduced N and P by 10∼15% each in chickens and pigs, and odor by 28∼ 79% in pigs. 6) Phase feeding reduced N and P excretion by chicken and pigs from 10∼33% and 10∼13% each, as well as odor in growing and finishing pigs by 49∼79%. 7) Use of highly digestible raw materials in feed reduced N and P excretion by 5% in chickens and pigs.

• Asian-Australasian Journal of Animal Sciences
• /
• v.23 no.11
• /
• pp.1427-1435
• /
• 2010

The present study was conducted to examine the effect of a stair-stepped feed intake pattern on growth, feed efficiency, and meat quality of Hanwoo steers. Twenty-seven 11-month-old Hanwoo steers were randomly divided into three groups. The control group was fed according to the Korean steer feeding program, and the other two groups were fed according to an alternated feeding schedule of 3-2-4-2 months. During the first three months of the experiment, treatment group 1 (T1) and treatment group 2 (T2) were fed 20% and 30% less than the control group, respectively. For the following two months, the T1 group was fed 20% more than the control group while the T2 group was fed 20% less than the control group. In the third step, T1 and T2 groups were fed 20% and 10% less, respectively, than the control group for four months. In the last two months, T1 and T2 groups were fed 20% more than the control group. After the stair-step feeding trial, steers were fed concentrated feed ad libitum for five months. The altered feed intake pattern did not affect daily body weight gain. However, daily feed intake tended to decrease and growth efficiency tended to increase in the two treatment groups compared to the control group. Altered feed intake also affected blood metabolite levels. The serum glucose and BUN level of the T1 group increased in the first re-fed period compared to the T2 and control groups. The serum cholesterol level of the T2 group decreased in the first restricted-re-fed growth period compared to the T1 and control groups. The serum NEFA levels of the two treatment groups increased from the first restricted period compared to the controls. The serum insulin level of the T2 group increased in the last period compared to the T1 and control groups. Regarding meat yield index, the control group was significantly higher than the T2 group (p<0.05). Regarding meat yield grade, the carcass back fat thickness of the T2 group was significantly higher than the control group (p<0.05). In marbling score, the T1 group was the highest (4.9), followed by the control group (4.1) and the T2 group (4.0). These results indicate that using a stair-stepped growth pattern (T1) can contribute to improvements in growth efficiency and muscle marbling.