• 폴리머
• /
• 제28권1호
• /
• pp.35-40
• /
• 2004

복합재료의 물성에 가장 큰 영향을 미치는 기공 결함의 원인에는 각 공정에 따라 다양하게 나타난다. 본 실험을 통해서 폴리에스터 수지 및 에폭시 수지가 경화될 때 결함으로 작용하여 복합재료의 물성을 저하시키는 기공의 생성원인을 분석하였다. 압력에 의한 영향을 알아보기 위하여 진공 챔버를 제작하였고, 작업 및 환경 상 수지가 노출될 수 있는 분위기에 따른 수지의 열분석을 통하여 경화 시 휘발특성을 분석하였다. 휘발가스 성분분석을 위한 GC/MS 분석 결과 폴리에스터 수지 경화 시 반응성 희석제의 스티렌이 80% 이상 차지하였으며 그밖에 소량의 톨루엔이 검출되었다. 에폭시 수지 경화 시에도 저점도 반응성 희석제인 부틸 글리시딜 에테르가 휘발성분의 90% 이상을 차지하였다. 실험 결과 혼합공정에 의하여 수지 자체적으로 기공 생성 자리를 가지고 있으며 수지에 진공을 가하거나 가열하여 이를 효과적으로 제거할 수 있었다. 여러 공정 중 수지에 함유될 수 있는 수분의 경우 초기 휘발특성이 아세톤보다 컸으며 이밖에 반응성 희석제, 첨가제, 반응가스 등이 수지 경화 시 쉽게 휘발되어 기공 성장의 원인이 됨을 알 수 있었다.

• 한국수산과학회지
• /
• 제41권4호
• /
• pp.267-271
• /
• 2008

We experimentally determined the physico-chemical properties of seminal plasma as well as the sperm cryopreservation techniques of masou salmon, Oncorhynchus masou masou. Seminal plasma contained $18{\pm}1mmol/L$ potassium, $144{\pm}4mmol/L$ sodium, $116{\pm}3mmol/L$ chloride, $83.2{\pm}3.1mg/L$ calcium, $14.8{\pm}0.7mg/L$ magnesium, $45{\pm}9mg/L$ glucose, and $1.0{\pm}0.0g/L$ total protein. The osmolality and pH of seminal plasma were $287{\pm}7\;and\;7.7{\pm}0.1mmol/kg$, respectively, and the spermatocrit was $28{\pm}2$. The rate of embryonic survival at the eyed-stage and the hatching rate were highest in 10% methanol with 300 mM glucose. Compared to DMSO or glycerol, methanol served as a better cryoprotectant of masou salmon sperm.

• 한국세라믹학회지
• /
• 제49권4호
• /
• pp.363-368
• /
• 2012

Nitriding and post-sintering behavior of powder mixture compacts were investigated. As mixture compacts are different from simple Si compacts, the fabrication of a sintered body with a mixture composition has engineering implications. In this research, in specimens without a pore former, the extent of nitridation increased with $Si_3N_4$ content, while the highest extent of nitridation was measured in $Si_3N_4$-free composition when a pore former was added. Large pores made from the thermal decomposition of the pore former collapsed, and they were filled with a reaction product, reaction-bonded silicon nitride (RBSN) in the $Si_3N_4$-free specimen. On the other hand, pores from the decomposed pore former were retained in the $Si_3N_4$-added specimen. Introduction of small $Si_3N_4$ particles ($d_{50}=0.3{\mu}m$) into a powder compact consisting of large silicon particles ($d_{50}=7{\mu}m$) promoted close packing in the green body compact, and resulted in a stable strut structure after decomposition of the pore former. The local packing density of the strut structure depends on silicon to $Si_3N_4$ size ratio and affected both nitriding reaction kinetics and microstructure in the post-sintered body.

• 대한수의학회지
• /
• 제29권2호
• /
• pp.41-49
• /
• 1989

The study was undertaken to obtain indirect values of volume of packed red cell (VPRC) without centrifugation, using the erythrocyte sedimentation rate (ESR) of diluted blood in dogs. ESRs of diluted blood using the diluent of autologous plasma in which formed numerous RBC-rouleau clumps, autologous serum in which formed a few RBC-rouleau clumps, and 5% dextrose or 6% sucrose solutions in which formed numerous RBC-aggregation clumps, were accelerated. But, ESR of diluted blood using the 0.9% saline, D-S, ACD-B, CDP or D-PBS solutions were sluggish, because erythrocytes were dispersed in these diluents. Reliable values of VPRC on the basis of the correlating regressive equation to the ESR could be derived from values of$60^{\circ}$-angled-micro-ESR/40 min in the mixture, four parts of 5% dextrose solution and one part of whole blood. In the ESR values of diluted blood with low ratio, 1:1~3:1, $60^{\circ}$-micro-ESR was higher than $60^{\circ}$-Wintrobe-ESR. But, in the diluted blood with high ratio, 4:1~5:1, there was no different ESR values. For an aid of practical use, authers suggested a list of the $60^{\circ}$-micro-ESR/40 min in the diluted blood with equivalent VPRC of whole blood.

• Asian-Australasian Journal of Animal Sciences
• /
• 제14권7호
• /
• pp.1024-1050
• /
• 2001

Avian spermatozoa are characterised by high concentrations of polyunsaturated fatty acids (PUFAs), in particular docosatetraenoic (DTA, 22:4n-6) and arachidonic (AA, 20:4n-6) acids. As a result they are vulnerable to lipid peroxidation, which is considered to be an important factor of male infertility. Antioxidant systems are expressed in spermatozoa and seminal plasma and build three major levels of antioxidant defense. The first level is based on the activity of superoxide dismutase (SOD) which is, in conjunction with glutathione peroxidase (GSH-Px), catalase and metal-binding proteins, responsible for prevention of free radical formation. The second level of defence is responsible for prevention and restriction of chain reaction propagation and includes chain-breaking antioxidants such as vitamin E, ascorbic acid, glutathione and some others. The third level of antioxidant defence deals with damaged molecules, repairing or removing them from the cell and includes specific enzymes such as lipases, proteases, DNA repair enzymes etc. In the review, profiles of PUFAs and the two first lines of antioxidant defence in avian spermatozoa are characterised. Dietary manipulation of the breeder's diet (PUFA, vitamin E and selenium) as an effective means of modulating fatty acid composition and antioxidant system is also considered. Antioxidant properties of seminal plasma and efficiencies of inclusion of antioxidants into semen diluents are also characterised.

• Membrane and Water Treatment
• /
• 제9권6호
• /
• pp.463-471
• /
• 2018

The present paper deals with the liquid-liquid extraction and flat sheet supported liquid membrane studies of Pd(II) separation from nitric acid medium using a novel synthesized ligand, namely, N,N,N',N'-tetraethyl-2,2-thiodiethanthiodiglycolamide (TETEDGA). The effect of various diluents and stripping reagents on the extraction of Pd(II) was studied. The liquid-liquid extraction studies showed complete extraction of Pd(II) in ~ 5 min. The influence of nitric acid and TETEDGA concentration on the distribution of Pd(II) has been investigated. The increase in nitric acid concentration resulted in increase in extraction of Pd(II). Stoichiometry of the extracted species was found to be $Pd(NO_3)_2{\cdot}TETEDGA$ by slope analysis method. Extraction studies with SSCD solution showed negligible uptake of Pt, Cr, Ni, and Fe, thus showing very high selectivity and extractability of TETEDGA for Pd(II). The flat sheet supported liquid membrane studies showed quantitative transport of Pd(II), ~99%, from the feed ($3M\;HNO_3$) to the strippant (0.02 M thiourea diluted in $0.4M\;HNO_3$) using 0.01 M TETEDGA as a carrier diluted in n-dodecane. Extraction time was ~160 min. Parameters such as feed acidity, TETEDGA concentration in membrane phase, membrane porosity etc. were optimized to achieve maximum transport rate. Permeability coefficient value of $2.66{\times}10^{-3}cm/s$ was observed using TETEDGA (0.01 M) as carrier, at 3 M, $HNO_3$ feed acidity across $0.2{\mu}m$ PTFE as membrane. The membrane was found to be stable over five runs of the operation.

• Preventive Nutrition and Food Science
• /
• 제17권4호
• /
• pp.274-279
• /
• 2012

For the quantitative analysis of genetically modified (GM) maize in processed foods, primer sets and probes based on the 35S promoter (p35S), nopaline synthase terminator (tNOS), p35S-hsp70 intron, and zSSIIb gene encoding starch synthase II for intrinsic control were designed. Polymerase chain reaction (PCR) products (80~101 bp) were specifically amplified and the primer sets targeting the smaller regions (80 or 81 bp) were more sensitive than those targeting the larger regions (94 or 101 bp). Particularly, the primer set 35F1-R1 for p35S targeting 81 bp of sequence was even more sensitive than that targeting 101 bp of sequence by a 3-log scale. The target DNA fragments were also specifically amplified from all GM labeled food samples except for one item we tested when 35F1-R1 primer set was applied. A reference plasmid pGMmaize (3 kb) including the smaller PCR products for p35S, tNOS, p35S-hsp70 intron, and the zSSIIb gene was constructed for real-time PCR (RT-PCR). The linearity of standard curves was confirmed by using diluents ranging from $2{\times}10^1{\sim}10^5$ copies of pGMmaize and the $R^2$ values ranged from 0.999~1.000. In the RT-PCR, the detection limit using the novel primer/probe sets was 5 pg of genomic DNA from MON810 line indicating that the primer sets targeting the smaller regions (80 or 81 bp) could be used for highly sensitive detection of foreign DNA fragments from GM maize in processed foods.

• 자원환경지질
• /
• 제48권3호
• /
• pp.221-229
• /
• 2015

약학 분야에서 점토광물은 점토광물 자체의 약리작용을 확인하고 원료의약품으로 활용하거나 희석제, 유화제, 점증제, 활택제 등 의약품 제형의 완성도를 높이는 첨가제로서 사용되고 있다. 벤토나이트(Bentonite), 카올린(Kaolin), 규산알루민산마그네슘(Magnesium aluminum silicate), 탤크(Talc) 등은 원료의약품 혹은 첨가제로서 활용 가능한 대표적인 점토 광물로 국내외 의약품 공정서에 수재되어 있고, 약학적 활용시 의약품등급으로 규제되고 있다. 본 논문에서는 공정서에 수재된 점토 광물을 중심으로 공정서의 규격을 확인하고, 점토광물의 특성 및 원료의약품 혹은 의약품 첨가제로서의 점토 광물에 대한 활용 사례를 소개하고자 한다. 결론적으로 점토광물을 제약산업에 활용하는 것은 점토광물의 고부가가치화를 위한 한 가지 방법이 될 수 있으며, 자원의 개발 및 활용이라는 측면에서 매우 유용할 것이라 사료된다.

• 폴리머
• /
• 제34권6호
• /
• pp.574-578
• /
• 2010

본 연구에서는 고리화합물인 카프로락톤으로부터 2-hydroxyethyl acylate(2-HEA)를 개시제로 사용하여 caprolactone modified hydroxy acrylate(CHA)를 합성한 후, hexamethylene diisocyanate trimer(HDT)와 축중합을 통해 카프로락톤 변성 우레탄 아크릴레이트(UA) 올리고머를 합성하였다. 카프로락톤과 2-HEA의 몰비에 따른 CHA의 분자량은 수산가를 이용하여 계산되었으며, 계산된 분자량은 이론분자량과 거의 일치하였다. UA 올리고머의 점도는 2-HEA 대한 CHA의 함량이 증가할수록 감소하는 경향을 보였다. UA 올리고머와 반응형 희석제를 광개시제와 함께 광경화한 후, 형성된 경화필름의 내열성 및 내열 변색성을 측정하였다. 경화필름의 가교밀도가 증가할수록 내열성 및 내열변색성이 우수하였으나 가교밀도가 증가할수록 경도는 증가하지만, 신율은 상대적으로 감소하였다.

• 한국방사성폐기물학회:학술대회논문집
• /
• 한국방사성폐기물학회 2004년도 Proceedings of the 4th Korea-China Joint Workshop on Nuclear Waste Management
• /
• pp.245-256
• /
• 2004

The extraction of three kinds of amido podands, N,N,N'N'-tetrabutyl-3-oxa-pentanedi- amide (TBDGA), N,N,N'N'-tetra-isobutyl-3-oxa-pentanediamide(TiBDGA) and N,N,N'N'-tetra- butyl-3,6-dioxa-oct-anediam- ide(TBDOODA) on U(VI),Pu(IV), Am(III), Eu(III) and other metal ions is studied in nitric acid solutions. 40%octanol-kerosene is chosen as diluents to eliminate third phase and emulsion. TBDGA and TiBDGA show extraction selectivity to An(III) and Ln(III) much higher than to U(VI) and Pu(IV). Fe, Ru and Mo is poorly extracted by the three kinds of amid podands in 2~3mol/L $HNO_3$ solutions. Aiming to eliminate interface crude when using simulated HLLW solution in the system of 0.2mol/L TBDGA/Octanol＋kerosene, acetohydroxyamic acid was adapted. Distribution ratio of zirconium was decreased when adding acetohydroxyamic acid in aqueous solution, and interface crude disappeared as mixing extractant with HLLW. The counter-current extraction test is carried out in a set of miniature mixer-settler, with 0.2mol/L TBDGA/ 40% octanol-kerosene as extractant to separate U(VI), Pu(IV), Am(III) and Eu(III) from simulated high level liquid waste(HLLW) solution. In battery A, lanthanides and actinides are coextracted into organic phase with the recovery of 99.98% for U(Ⅵ), >99.99% for Pu(IV), and >99.99% for Am(III) and Eu(III) respectively. In battery R1, 99.99% U, 86.2% Pu and a part of Am or Eu are stripped into aqueous phase by 0.2mol/L acetohydroxyamic acid (AHA) in 0.01mol/L $HNO_3$ solution. In battery $R_2$, Am, Eu and remained Pu are completely back-extracted by 0.2mol/L AHA. This separation process contains no salt reagent, and it is not necessary to dilute HLLW feed.