• 제목/요약/키워드: Critical mixing rate

검색결과 32건 처리시간 0.022초

폴리에틸렌 글리콜 내에서의 흄드 실리카 현탁액의 전단농화 거동연구 (Shear Thickening Behavior of Fumed Silica Suspension in Polyethylene Glycol)

  • 박혜수;조봉상;유의상;안재범;노시태
    • 공업화학
    • /
    • 제22권4호
    • /
    • pp.384-389
    • /
    • 2011
  • 폴리에틸렌 글리콜(PEG) 내에 흄드 실리카를 분산시켜 현탁액을 제조하고, 실리카의 함량과 분산조건, 폴리에틸렌 글리콜 분자량, 온도 및 수분함량에 따른 유변학적 거동을 연구하였다. 현탁액의 유변학적 거동은 레오미터를 이용하여 전단농화 현상을 일으키는 임계전단속도와 전단점도 상승폭을 측정하였다. 분산매는 PEG 200, 400 및 600을 사용하였다. 실리카의 함량을 5, 7, 9, 13, 그리고 18 wt%으로 한 흄드 실리카 현탁액은 단순교반, 균질교반, 비드밀링의 세 가지 분산 방법을 사용하여 제조하였다. 10, 20, 30 그리고 $40^{\circ}C$에서 유변학적 거동을 측정하였다. 현탁액 내의 실리카의 함량이 증가할수록 그리고 분산매의 분자량이 커질수록 임계전단속도는 낮아지는 경향을 나타냈다. 측정온도의 영향에서도 온도가 증가할수록 임계전단속도가 높아지는 경향을 보였다. 수분의 함량에 따른 영향은 나타나지 않으나, 분산공정의 영향은 크게 나타났다. 단순교반 방법으로 제조한 현탁액의 임계 전단속도가 가장 낮았으며 비드밀링공정으로 제조한 현택액의 임계전단속도가 가장 높게 나타났다. 전단점도의 상승폭은 단순교반으로 제조한 현탁액이 비드밀링 공정의 현탁액 보다 높게 나타났다. 이는 분산 공정에 따른 실리카 입자의 분산상태에 기인되고 있음을 알 수 있었다.

미소채널 내 회전교반기와 진동교반기에 의한 혼합향상의 연구 (A Study on Mixing Enhancement by Rotating and Oscillating Stirrers in the Micro Channel)

  • 김용대;맹주성;안상준
    • 대한기계학회논문집B
    • /
    • 제30권5호
    • /
    • pp.430-437
    • /
    • 2006
  • The mixing effect is studied by comparing rotating and oscillating stirrers in the micro channel. The cases of Re=10 to 80 with various stirring speeds are considered to analysis the effect of Re and stirrer speed for the mixing. Under Re=20, the oscillating stirrer represents better mixing rate than the rotating stirrer up to the critical stirrer speed which has a maximum efficiency. Over Re=30, the results of oscillating and rotating stirrer show that the faster the stirrer speed, the higher the mixing effect within the concerned stirrer speed range and the oscillating stirrer keeps the higher mixing rate. It was found that the mixing effect is a function which has an optimum of the Reynolds number and the stirrer speed. The D2Q9 Lattice Boltzmann Method is used due to the merits of calculation for the unsteady flow with moving boundary.

시간 분해 직렬 펨토초 결정학을 위한 3차원 프린팅 기반의 초고속 믹싱 및 인젝팅 시스템 (3D Printing-Based Ultrafast Mixing and Injecting Systems for Time-Resolved Serial Femtosecond Crystallography)

  • 지인서;강전웅;김태영;강민서;권순범;홍지우
    • Korean Chemical Engineering Research
    • /
    • 제60권2호
    • /
    • pp.300-307
    • /
    • 2022
  • 매우 짧은 펄스 폭의 X선 자유전자 레이저(XFEL)를 이용한 시간 분해능 연속 펨토초 결정학(time-resolved serial femtosecond crystallography, TR-SFX)기법에서 반응 물질과 생체분자 결정 샘플간의 혼합률(mixing rate)과 결정 샘플과 X선 레이저 간의 충돌률(hit rate)은 생체분자의 시분해 구조 변화에 대한 정확한 이미지 획득 및 효율적인 샘플소비와 같은 TR-SFX의 분석 성능을 결정짓는 핵심인자이다. 본 연구에서는 극초단 내 일어나는 생체분자의 시분해 구조 변화 해석을 위해 초고속 믹싱 기능을 가짐과 동시에 공압 기반의 주문형 액적 젯팅이 가능한 두 가지 다른 방식의 샘플 전달시스템을 고안하였다. 한 방식은 이중 노즐을 통해 토출된 액적의 고속 충돌에 유발된 관성 믹싱을 기반으로 하고 있으며, 다른 방식은 마이크로믹서가 내장된 공압 젯팅을 기반으로 하고 있다. 먼저, 이중 노즐을 통해 토출된 액적의 충돌에 대한 동적 거동 및 액적 내부 관성 유동에 대한 믹싱에 대한 실험 및 수치해석적 연구를 수행하였다. 다음으로 마이크로믹서가 내장된 공압 젯팅 시스템의 성능을 유사한 방법을 통해 평가하였다. 본 연구에서 개발한 샘플 전달시스템은 질환을 유발하는 특정 단백질들의 기작을 규명하거나, 항체 의약품과 신약 후보 물질 탐색하는 데 있어 필수적인 3차원 생체 분자 구조분석 연구에 매우 유용하게 활용될 수 있을 것이다.

Grit와 Air의 혼합비 최적화를 통한 블라스팅 효율 향상 (Improvement of the Blasting Productivity by Optimizing the Abrasive-to-Air Mixing Ratio)

  • 배한진;백재진;김을현;정몽규;신칠석;백광기
    • 대한기계학회:학술대회논문집
    • /
    • 대한기계학회 2004년도 추계학술대회
    • /
    • pp.1436-1441
    • /
    • 2004
  • Achieving the maximum blasting efficiency with minimum abrasive consumption is a critical concern in surface preparation stage of shipbuilding and offshore industry. Increasing the abrasive flow rate beyond the optimum point results in a major reduction in productivity even though the amount of abrasive used is larger. So, this study is intend to find out the optimum abrasive-to-air mixing ratio which can make a significant improvement in blasting efficiency and remarkably reduce the amount of abrasive used. From the test results, it can be identified that as the abrasive feeding rate is increased linearly, blasting efficiency is increased to a maximum point and then gradually decreased in the form of a bell-shaped.

  • PDF

Reactor Agitator 의 진동분석 및 진단사례 (Vibration Analysis and Diagnosis for Reactor Agitator)

  • 유주형;정구충;이선휘
    • 한국소음진동공학회:학술대회논문집
    • /
    • 한국소음진동공학회 2012년도 춘계학술대회 논문집
    • /
    • pp.107-112
    • /
    • 2012
  • All chemical processes are centered in the chemical reactor. Chemical reactions are often accompanied by mixing. Mixing can influence not just reaction rate but also product distribution if more than one product is possible. So, reactor agitator is more critical in industrial reactions. High vibration was occurred on reactor agitator which is critical equipment in HDPE plant. This paper describes analysis and diagnosis for agitator vibration throughout some tests. High vibration has been occurred by misalignment and resonance. Through the correction it could be stable.

  • PDF

이중확산의 영향을 받는 염수침입의 혼합과정 연구 (Mixing Process of Double Diffusive Salt Wedge)

  • 황진환
    • 한국해양환경ㆍ에너지학회지
    • /
    • 제11권2호
    • /
    • pp.92-97
    • /
    • 2008
  • 일반적으로 해수가 강으로 침입하거나 담수가 해양으로 유입을 하면 두 유체간의 밀도차에 의한 밀도류의 성질을 가진다. 하지만, 염분과 온도가 동시에 밀도의 차를 결정하는 경우, 특히 이 중 하나가 중력과 불안정한 수직 분포를 갖게되면 이중확산이 혼합을 결정하는 중요한 요인이 된다. 본 연구에서는 고온, 고염의 수괴가 저온, 저염의 수괴로 진입할 때 기계적 혼합과 이중확산에 의한 대류가 혼합에 미치는 상대적 영향을 비교 연구하였다. 실험실에서 차갑고 염도가 없는 주 흐름에 온도가 높고 염분이 높은 밀도류를 조심스럽게 방류시켜 정상상태의 염수침입 형태를 유지하였다. 수평방향으로 따라 밀도율(Turner 1979)이 15정도 되면 온도와 염분의 유출입량비율이 가파르게 변화하였고, 전체적으로 방출구 부분에서 이중확산의 영향이 강하게 나타나게 되며 이 경우에는 총 방출량도 함께 증가하였다. 아울러 밀도율이 낮은 경우 밀도율이 높은 경우에 비해서 약 $6{\times}10$배의 높은 혼합율을 보였다.

  • PDF

특수교반날개를 사용한 DCM 공법의 지반 관입 특성에 대한 사례연구 (Case Studies of Penetration Characteristics of DCM Wall Using Spiral Mixing Blades in Soil Layers)

  • 정두회;정경환;양태선
    • 한국지반공학회논문집
    • /
    • 제23권3호
    • /
    • pp.133-140
    • /
    • 2007
  • DCM공법(심층혼합처리 공법)은 흙막이 벽체 등 구조물 조성에 적용하였다. 이러한 DCM 벽체는 경질층에서 관입능력이 있어야 한다. DCM 장비에 부착된 교반날개에 의해 경질지반의 관입능력이 증가되는 알아보기 위해 특수교반날개가 고안되었다. 경질점토층에 관입되는 특수교반날개의 관입특성은 김해와 인천현장에서 조사하였다. 고안한 특수교반날개는 관입속도가 다소 느려도 N=30 이상 되는 지반까지 관입되었고 관입시 효율이 경질지반에서 낮아질 수 있으므로 경제적인 교반날개의 관입깊이를 분석하였다.

에폭시 수지 모르터의 특성에 관한 실험적 연구 (Experimental Studies on the Properties of Epoxy Resin Mortars)

  • 연규석;강신업
    • 한국농공학회지
    • /
    • 제26권1호
    • /
    • pp.52-72
    • /
    • 1984
  • This study was performed to obtain the basic data which can be applied to the use of epoxy resin mortars. The data was based on the properties of epoxy resin mortars depending upon various mixing ratios to compare those of cement mortar. The resin which was used at this experiment was Epi-Bis type epoxy resin which is extensively being used as concrete structures. In the case of epoxy resin mortar, mixing ratios of resin to fine aggregate were 1: 2, 1: 4, 1: 6, 1: 8, 1:10, 1 :12 and 1:14, but the ratio of cement to fine aggregate in cement mortar was 1 : 2.5. The results obtained are summarized as follows; 1.When the mixing ratio was 1: 6, the highest density was 2.01 g/cm$^3$, being lower than 2.13 g/cm$^3$ of that of cement mortar. 2.According to the water absorption and water permeability test, the watertightness was shown very high at the mixing ratios of 1: 2, 1: 4 and 1: 6. But then the mixing ratio was less than 1 : 6, the watertightness considerably decreased. By this result, it was regarded that optimum mixing ratio of epoxy resin mortar for watertight structures should be richer mixing ratio than 1: 6. 3.The hardening shrinkage was large as the mixing ratio became leaner, but the values were remarkably small as compared with cement mortar. And the influence of dryness and moisture was exerted little at richer mixing ratio than 1: 6, but its effect was obvious at the lean mixing ratio, 1: 8, 1:10,1:12 and 1:14. It was confirmed that the optimum mixing ratio for concrete structures which would be influenced by the repeated dryness and moisture should be rich mixing ratio higher than 1: 6. 4.The compressive, bending and splitting tensile strenghs were observed very high, even the value at the mixing ratio of 1:14 was higher than that of cement mortar. It showed that epoxy resin mortar especially was to have high strength in bending and splitting tensile strength. Also, the initial strength within 24 hours gave rise to high value. Thus it was clear that epoxy resin was rapid hardening material. The multiple regression equations of strength were computed depending on a function of mixing ratios and curing times. 5.The elastic moduli derived from the compressive stress-strain curve were slightly smaller than the value of cement mortar, and the toughness of epoxy resin mortar was larger than that of cement mortar. 6.The impact resistance was strong compared with cement mortar at all mixing ratios. Especially, bending impact strength by the square pillar specimens was higher than the impact resistance of flat specimens or cylinderic specimens. 7.The Brinell hardness was relatively larger than that of cement mortar, but it gradually decreased with the decline of mixing ratio, and Brinell hardness at mixing ratio of 1 :14 was much the same as cement mortar. 8.The abrasion rate of epoxy resin mortar at all mixing ratio, when Losangeles abation testing machine revolved 500 times, was very low. Even mixing ratio of 1 :14 was no more than 31.41%, which was less than critical abrasion rate 40% of coarse aggregate for cement concrete. Consequently, the abrasion rate of epoxy resin mortar was superior to cement mortar, and the relation between abrasion rate and Brinell hardness was highly significant as exponential curve. 9.The highest bond strength of epoxy resin mortar was 12.9 kg/cm$^2$ at the mixing ratio of 1:2. The failure of bonded flat steel specimens occurred on the part of epoxy resin mortar at the mixing ratio of 1: 2 and 1: 4, and that of bonded cement concrete specimens was fond on the part of combained concrete at the mixing ratio of 1 : 2 ,1: 4 and 1: 6. It was confirmed that the optimum mixing ratio for bonding of steel plate, and of cement concrete should be rich mixing ratio above 1 : 4 and 1 : 6 respectively. 10.The variations of color tone by heating began to take place at about 60˚C, and the ultimate change occurred at 120˚C. The compressive, bending and splitting tensile strengths increased with rising temperature up to 80˚ C, but these rapidly decreased when temperature was above 800 C. Accordingly, it was evident that the resistance temperature of epoxy resin mortar was about 80˚C which was generally considered lower than that of the other concrete materials. But it is likely that there is no problem in epoxy resin mortar when used for unnecessary materials of high temperature resistance. The multiple regression equations of strength were computed depending on a function of mixing ratios and heating temperatures. 11.The susceptibility to chemical attack of cement mortar was easily affected by inorganic and organic acid. and that of epoxy resin mortar with mixing ratio of 1: 4 was of great resistance. On the other hand, when mixing ratio was lower than 1 : 8 epoxy resin mortar had very poor resistance, especially being poor resistant to organicacid. Therefore, for the structures requiring chemical resistance optimum mixing of epoxy resin mortar should be rich mixing ratio higher than 1: 4.

  • PDF

방파제 기초에 적용된 고품질 DCM공법의 설계 및 시공 사례 (A Case Study on the High-quality DCM applied to the Foundation of Breakwater)

  • 강연익;심민보;심성현;김하영;심재범;천윤철;윤종익
    • 한국지반공학회:학술대회논문집
    • /
    • 한국지반공학회 2009년도 세계 도시지반공학 심포지엄
    • /
    • pp.815-826
    • /
    • 2009
  • The paper presents a case study addressing the design and construction aspects for DCM(Deep Cement Mixing) method employed as the foundation of a caisson type breakwater with heavy weight(10,700 ton/EA) and a high design wave height($H_{1/3}$=8.7m). The DCM was designed for the project(Ulsan New Port North Breakwater Phase 1) by optimizing the pattern of DCM columns with a combination of short and long columns (i.e., block type(upper 3m)+wall type(lower)) and considering overlapped section between columns as a critical section against shear force where the coefficient of effective width of treated column($\alpha$) was estimated with caution. It was shown that the value can be 0.9 under the condition with the overlapped width of 30cm. In addition to that, a field trial test was performed after improving conventional DCM equipment (e.g., mixing blades, cement paste supplying pipes, multi auger motor, etc.) to establish a standardized DCM construction cycle (withdrawal rate of mixing blades) which can provide the prescribed strength. The result of the field strength test for cored DCM specimens shows that the averaged strength is larger than the target strength and the distribution of the strength(with a defect rate of 7%) also satisfies with the quality control normal distribution curve which allows defect rate of 15.9%.

  • PDF

고형물함량 및 혼합강도가 생물반응기를 이용한 석유계탄화수소 오염토양의 처리에 미치는 영향 (Effects of Solids Content and Mixing Speed in Treatment of Petroleum Hydrocarbon Contaminated Soils using a Bioreactor)

  • 김수철;남궁완;박대원
    • 한국토양환경학회지
    • /
    • 제2권3호
    • /
    • pp.23-30
    • /
    • 1997
  • 본 연구의 목적은 슬러리상 생물반응기를 이용한 석유계탄화수소 오염토양의 처리에 있어서 고형물함량 및 혼합강도의 영향을 평가하는 것이다. 디이젤오염토양의 슬러리상 생물학적 처리에 대한 수행결과는 실험실규모에서 얻어졌고 TPH(총 석유계탄화수소)는 생물학적 처리와 연관하여 평가되었다. TPH의 생물학적 및 비생물학적 거동은 디이젤내의 화합물에 의해 이전에 노출되지 않은 토양을 이용하여 결정되었다. 투입량에 대한 반응기부피는 고형물함량을 최대화함으로써 줄여질 수 있다. 고형물함량 50% 및 20%를 적용한 결과 생물학적 TPH 제거율에 있어서 약간의 차이(57.5%:61.6%)를 보여주었다. 혼합과 토양입자의 부유는 오염물의 탈착 및 생물학적 분해에 있어서 매우 중요하다. 이러한 관점에서 본 연구는 두가지 혼합강도를 이용하여 수행되었다. 70rpm을 이용한 반응기의 경우 20rpm을 적용한 반응기에 비하여 토양입자의 부유 및 TPH의 제거율에 있어서 더 좋은 결과를 나타내었다. 20rpm을 적용한 반응기의 경우 토양입자의 완전한 부유가 일어나지 않았다.

  • PDF