• Transactions of the Korean Society of Mechanical Engineers B
• /
• v.26 no.12
• /
• pp.1722-1728
• /
• 2002

Most researches regarding emulsified fuel were in the areas of emulsifier, emulsified fuel manufacturing and emulsified fuel droplet combustion, but there were little papers published regarding emulsified fuel combustion and boiler efficiency in an industrial boiler. The main purpose of this study is to clarify whether improvements in the boiler efficiency and the reduction of pollutants such as CO, NOx, SOx and smoke exist or not when emulsified fuels are combusted in the commercial boiler. Main experimental parameters were water content in heavy oil , excess $O_2$, and boiler load. The fuels used in this experiment were 0.5 B-C, and 5 kinds of 0.5 B-C/water emulsified fuels. The combustion characteristics of heavy oil and its emulsions with water were investigated in an industrial boiler. The combustion stability was monitored and exhaust gases such as CO, NOx, SOx and smoke were measured with excess $O_2$ and combustion load. In case of emulsified fuel combustion, flame stability was poor and boiler efficiency was lowered by 1.6~5.7%, but emission levels of CO and smoke were improved.

• Journal of the Korean Institute of Electrical and Electronic Material Engineers
• /
• v.19 no.1
• /
• pp.46-51
• /
• 2006

This paper reports on the effects of silicone oils, used as processing agents, on the recovery of hydrophobicity of silicone rubber. The recovery of hydrophobicity was evaluated by the measuring the contact angle, the surface electrical resistance and SEM. Here, we formed artificial contamination on the surface of samples, which scratched by sand papers and alumina powders. There was small recovery of hydrophobicity on the surface of SIR-A that silicone oil was not added. In both oil-added samples, SIR-B and SIR-C, recovery of hydrophobicity was achieved greatly. The surface of SIR-C showed that a lot of silicone oil was observed due to migration of oil, relatively in comparison with SIR-B. The tendency of recovery of hydrophobicity expressed by contact angle was in a good agreement with electrical property as determined by surface resistivity.

• Carbon letters
• /
• v.7 no.4
• /
• pp.245-248
• /
• 2006

Thin films of carbon-nano materials (CNMs) of different morphology have been successfully deposited on ceramic substrate by CVD at temperatures $800^{\circ}C$, $850^{\circ}C$ and $900^{\circ}C$ using plant based oils in the presence of transition metal catalysts (Ni, Co and Ni/Co alloys). Based on the return and insertion loss, microwave absorption properties of thin film of nanocarbon material are measured using passive micro-Strip line components. The result indicates that amongst CNMs synthesized from oil of natural precursors (mustered oil - Brassica napus, Karanja oil - Pongamia glabra, Cotton oil - Gossipium hirsuta and Neem oil - Azadirachta indica) carbon nano fibers obtained from neem's seed oil showed better microwave absorption (~20dB) in the range of 8.0 GHz to 17.90 GHz.

• Food Science and Preservation
• /
• v.15 no.4
• /
• pp.556-561
• /
• 2008

This study was carried out to identify the cause of benzo(a)pyrene[B(a)P] production during the manufacture of sesame oil and perilla oil, and to minimize such B(a)P synthesis. The distribution of B(a)P in sesame seed and perilla seed differed with seed-growing district, the range was $0.06{\sim}0.31{\mu}g/kg$ in domestic seed and $0.12{\sim}0.47{\mu}g/kg$ in imported seed. B(a)P contents after roasting at $220^{\circ}C$ for 20 min in sesame seed and perilla seed were $1.87{\sim}2.47{\mu}g/kg$ and $2.12{\sim}2.43{\mu}g/kg$, respectively, and levels in oils obtained from the roasted seeds were $3.68{\mu}g/kg$ and $4.64{\mu}g/kg$, respectively. These data refer to seeds subjected to codsed roasting. With open roasting, the levels were $0.63{\mu}g/kg$ and $0.56{\mu}g/kg$, respectively. Closed roasting resulted in absorption of B(a)P, with consequent high levels in oils. We introduced forced ventilation during closed roasting. We tested various methods to remove B(a)P from sesame oil and perilla oil. Neither centrifugation nor filtering with diatomite and diatomiteactive carbon removed B(a)P. A filtering method using active carbon was effective. But this method adversely affected the color and flavor of sesame oil and perilla oil.

• Biomolecules & Therapeutics
• /
• v.31 no.3
• /
• pp.298-305
• /
• 2023

This study aimed to examine the effects of several essential oils on insomnia in dementia patients following transdermal treatment (aromatherapy). The mean change rates (%) of sleep biomarkers were compared between the single essential and jojoba (vehicle) oil massage groups in this study. The lavender (L) essential oil massage group demonstrated a significant decrease in the mean change rate (%) of 24-h urinary free cortisol, whereas the valerian (V) essential oil massage group demonstrated a significant increase in the mean change rate (%) of serum 5-hydroxytryptamine. In addition, a significant increase in the mean change rate (%) of 24-h urinary norepinephrine was observed in the chamomile (C) essential oil massage group only. Based on these results, valerian, lavender, and chamomile oils were mixed in different ratios to produce blending oils A (L:C:V=2:2:1), B (L:C:V=3:1:1) and C (L:C:V=1:3:1). The highest level of serum 5-hydroxytryptamine was observed after administering blending oil A. These results suggest that blending oil A might possess therapeutic effects against insomnia. Overall, it is hypothesized that the optimally blended essential oil will produce synergic effects when combined with hypnotic drugs.

• Korean Journal of Poultry Science
• /
• v.33 no.1
• /
• pp.1-6
• /
• 2006

This study was conducted to investigate the influence of dietary mugwort (0, 1, 2, 4%) and sardline oil(1%) on weight gain, pH, volatile basic nitrogen (VBN), thiobarbituric acid reactive substance (TBARS), and meat color in meat-type chickens. Birds were randomly assigned to the four dietary treatments: control (commercial feed), control plus 1% mugwort and sardine oil (T1), 2% mugwort and 1% sardine oil(T2), or 4% mugwort and 1% sardine oil (T3). Birds were sacrificed and meat samples were taken and stored for either 0, 3, 7 or 10 days at $4^{\circ}C$. Weight gain in T3 was lowest than other treatment groups (P<0.05). pH of dietary mugwort and sardine oil treatments increased significantly compared to that of control during storage periods (P<0.05). VBN and TBARS of all treatment groups were significantly increased as storage period extended (P<0.05). Meat color $(L^*,\;b^*)$ significantly increased during storage periods. $L^*\;and\;b^*$ values were higher in treatment groups than in control (P<0.05). These results indicate that the mugwort and fish oil may improve quality and self-life of meat-type chickens during storage.

• Journal of the Korean Society of Clothing and Textiles
• /
• v.18 no.5
• /
• pp.661-673
• /
• 1994

We have gathered a fatty acid to recycle the waste oil of food manufacturing process, and then made a soap from the waste oil by alkali saponification. Effects of the washing elements such as the concentration of the soap, temperature and time were evaluated to find out the optimum washing conditions, and results are as follows. 1. We could find soaps made from the soybean oil (A), corn oil (B), rape seed salad oil (C), cotton seed oil (D) and a soap consisting of the each oil 25% respectively (I) had the lowest surface tension at the concentration of 0.225% -0.25%. Compared with the single fatty-acid soap, the multi-component soap I showed the lower surface tension at the cmc. 2. All the samples of A-I showed the lowest contact angle for the solid material at the concentration of 0.25%. The multi-component soap of I showed higher contact angle than the single.component soaps of A, B, C and D. 3. The soap G, made from the waste oil, show lower surface tension than 5, made from the complex raw fats of the eatable fatty oil acid and H, commercial soap. 4. The washing efficiency depends on the washing time. Especially the 25-minute was found to be the optimum washing time. 5. The highest washing efficiency was found at the 0.25% cont. reagardless of the washing temperature. At 0.15% concentration level the washing efficiency reduces as washing tem- perature increases. At 0.3% concentration level the highest washing efficiency was found between $50^{\circ}$-$60^{\circ}$. 6. The soap made from the waste oil showed the highest washing efficiency in terms of concentration, temperature, and time. 7. The soap made from the waste oil showed the similiar concentration of hydrogen ion to the synthetic detergent. 8. The hand value of the fabric washed by the soap made from the waste oil was a little lower value than those washed by the synthetic detergent.

• Food Science and Biotechnology
• /
• v.15 no.2
• /
• pp.202-206
• /
• 2006

The oxidation stability of fish oil containing omega-3 polyunsaturated fatty acids (PUFAs), which is very susceptible to oxidative deterioration, needs to be improved before it can be successfully applied to functional foods. The antioxidant activities of 17 species of materials in anchovy oil (AO) were compared and a potent antioxidant was determined to improve the shelf-life of refined AO. Antioxidant activities of the 0.05% (w/w) materials in AO were compared against control during storage at $30^{\circ}C$ for 10 days. While no antioxidant effect was shown in alpha tocopherol against control, 3 species of grapefruit seed extracts (GSEs), astaxanthin (AX), soybean lecithin, and green tea extract showed good antioxidant activities. Especially, GSE B, GSE C, and AX showed significantly high peroxide inhibitory activities (PIAs) of $16.2{\pm}2.1$, $20.{\pm}3.5$, and $17.7{\pm}3.5%$, respectively, after the 4th day (p<0.01). Radical scavenging activities (RSAs) of GSE B, GSE C, and AX were $85.1{\pm}0.8$, $95.3{\pm}0.3$, and $85.9{\pm}0.8%$, respectively. Correlation between PIAs and RSAs was high ($R^2=0.926$) in GSE B, GSE C, and AX. Therefore, we concluded that one of the main antioxidative mechanisms of GSEs and AX must operate through an RSA pathway. The $RC_{50}$ (concentration required for 50% reduction of 1,1-diphenyl-2-picryl-hydrazyl, DPPH) of GSE C was $258\;{\mu}g/mL$.

• Proceedings of the Korean Society of Crop Science Conference
• /
• 2017.06a
• /
• pp.255-255
• /
• 2017

Sesame has been consumed for centuries as flavoring ingredient in eastern Asian countries, especially Korea. Sesame seeds have been used as health food for traditional medicine to prevent disease in Asian countries for several thousand years. Sesame seed has higher oil content (around 50%) than most of the known oilseeds. Sesame oil is rich in monounsaturated and polyunsaturated fatty acids. Extraction of sesame has developed significantly over the years. The mechanical method was an early means of separation which was physical pressure to squeeze the oil out. Nowadays, solvent extraction becomes the commonly used commercial technique to recover oil from oilseeds. In this study, we investigated extraction efficiency and quality of oil affected by cultivars and extraction methods of sesame seed. Different variables were investigated; roasting temperature ($170{\sim}220^{\circ}C$), extraction methods (solvent and physical pressure), forced ventilation system and cultivars. The Contents of B(a)P in sesame oil after roasting at $170{\sim}220^{\circ}C$ were 0.30~2.53 ppm. When we introduced forced ventilation system during roasting, B(a)P Contents were decreased up to 36%. The Oil extraction efficiency on sesame seed was statistically depending on the cultivars and extraction methods. The oil extraction yields of solvent and physical pressure extraction were 56.3% and 44.6%, respectively. Many of sesame cultivars and genetic resources are linolenic acid content of less than 0.5%. The results supported that we have developed a safe and high quality sesame oil processing methods for small and medium-sized companies.

• Asian-Australasian Journal of Animal Sciences
• /
• v.21 no.12
• /
• pp.1728-1735
• /
• 2008

The present study was conducted with four ruminally canulated Holstein cows to observe the effects of monensin or fish oil on diet fermentation and production of conjugated linoleic acids (CLAs) in the rumen when fed diets supplemented with soybean oil and sodium bicarbonate. Cows of the control treatment were fed a basal diet (CON) consisting of 60% commercial concentrate and 40% chopped rye grass hay. Cows of other treatments were fed the same diet as CON, but the concentrate was supplemented with 7% of soybean oil and 0.5% of sodium bicarbonate (SO-B), SO-B supplemented with monensin (30 ppm, SO-BM) or concentrate supplemented with 6.3% of soybean oil, 0.5% of sodium-bicarbonate, 30 ppm of monensin and 0.7% of fish oil (SO-BMF). Dry matter (DM) intake of the cows was significantly (p<0.011) reduced by feeding the SO-BMF diet compared to the other diets which did not differ in DM intake. Whole tract digestibility of major dietary components was significantly (p<0.004-0.027) higher for SO-BMF than the other supplement-containing diets. Dietary supplements did not clearly affect rumen pH and ammonia concentrations compared to the CON diet. Significantly reduced (p<0.05) total VFA concentration was obtained by the addition of fish oil to the diet (SO-BMF) compared to other diets. No differences, however, were obtained in major VFA proportions as well as in total VFA between the supplemented diets. The SO-BM diet increased (p<0.01-0.05) the concentrations of trans-11 $C_{18:1}$ and linoleic acid in rumen fluid. Total CLA concentration was also increased by the feeding of SO-B and SO-BM diets during early fermentation times (up to 3 h) post-feeding. Cis-9, trans-11 CLA concentration in rumen fluid was highest (p<0.05) for SO-B up to 1 h while the highest (p<0.01) value for SO-BM occurred at 3 h post-feeding. An increased trans-10, cis-12 CLA concentration was obtained from the SO-B and SO-BM diets at 1 and 3 h post feeding compared to the other diets. Supplementation of oils with monensin and sodium bicarbonate increased (p<0.05) the proportions of $C_{18:1}$ and CLA in the plasma of cows, but the effect of monensin and/or fish oil was limited to trans-10, cis-12 CLA.