• Korean Journal of Air-Conditioning and Refrigeration Engineering
• /
• v.16 no.12
• /
• pp.1117-1125
• /
• 2004

In this study, in order to utilize the waste heat of industrial wastewater in the range of the relatively low temperature of 40～5$0^{\circ}C$ as a heat source, a hybrid heat pump system was considered by computer simulation method. In the simulation, an absorber, desorber and solution heat exchanger were modelled by UA values while a compressor and pump performance were specified by an isentropic efficiency. Simulation results show that the performance of hybrid heat pump can be up to 80% higher than that of conventional R134a heat pump when it makes a process hot water of 9$0^{\circ}C$ while the wastewater is cooled down to 2$0^{\circ}C$. As the absorber pressure increases, the system performance and deserter pressure increase with a favorable effect of a compressor discharge gas temperature drop.

• Korean Chemical Engineering Research
• /
• v.57 no.4
• /
• pp.469-474
• /
• 2019

Fermentation of palm oil mill effluent (POME) produces biohydrogen in a mixture at a specific set condition. This research was conducted to purify the produced mixed biohydrogen via absorption and membrane techniques. Three different solvents, methyl ethanolamine (MEA), ammonia ($NH_3$) and potassium hydroxide (KOH) solutions, were used in absorption technique. The highest $H_2$ purity was found using 1M MEA solution with 5.0 ml/s feed mixed gas flow rate at 60 minutes absorption time. Meanwhile, the purified biohydrogen using a polysulfone membrane had the highest $H_2$ purity at 2~3 bar operating pressure. Upon testing with proton exchange membrane fuel cell (PEMFC), the highest current and power produced at 100% $H_2$ were 1.66 A and 8.1 W, while the lowest were produced at 50/50 vol% $H_2/CO_2$ (0.32 A and 0.49 W). These results proved that both purification techniques have significant potential for $H_2$ purification efficiency.

• Korean Journal of Materials Research
• /
• v.29 no.3
• /
• pp.143-149
• /
• 2019

To develop flexible adsorbents for compact volatile organic compound (VOC) air purifiers, flexible as-spun zeolite fibers are prepared by an electrospinning method, and then zeolite particles are exposed as active sites for VOC (toluene) adsorption on the surface of the fibers by a thermal surface partial etching process. The breakthrough curves for the adsorption and temperature programmed desorption (TPD) curves of toluene over the flexible zeolite fibers is investigated as a function of the thermal etching temperature by gas chromatography (GC), and the adsorption/desorption characteristics improves with an increase in the thermal surface etching temperature. The effect of acidity on the flexible zeolite fibers for the removal of toluene is investigated as a function of the $SiO_2/Al_2O_3$ ratios of zeolites. The acidity of the flexible zeolite fibers with different $SiO_2/Al_2O_3$ ratios is measured by ammonia-temperature-programmed desorption ($NH_3-TPD$), and the adsorption/desorption characteristics are investigated by GC. The results of the toluene adsorption/desorption experiments confirm that a higher $SiO_2/Al_2O_3$ ratio of the flexible zeolite fibers creates a better toluene adsorption/desorption performance.

• Journal of the Korean Wood Science and Technology
• /
• v.49 no.2
• /
• pp.134-141
• /
• 2021

This study was conducted to investigate the potential of the neutral extract (NE) prepared by treating P. radiata bark with aqueous NaHCO3 solution as a natural dyestuff. Silk and cotton fabrics were dyed at four different NE concentrations, 0.5%, 1.0%, 1.5%, and 2.0% o.w.b. (on the weight of bath). The fabric to liquid ratio of 1 : 50, dyeing temperature of 90℃, and dyeing time of 90 min were used as the fixed condition. The appropriate NE dyeing concentration of silk and cotton fabrics was 1.5% o.w.b. Colors of the dyed silk and cotton fabrics were brown and light brown, respectively. From colorfastness assessment, both dyed silk and cotton showed good washing and rubbing fastness, but poor light fastness. NE dyed fabrics exhibited excellent ammonia deodorization property and antibacterial activity against Staphylococcus aureus and Klebsiella pneumoniae. Therefore, NE of P. radiata bark could have the potential for use as a functional brown dyestuff.

• Journal of Sensor Science and Technology
• /
• v.30 no.6
• /
• pp.451-455
• /
• 2021

Porous copper bromide (CuBr) films are highly advantageous for detecting ammonia (NH₃). The fabrication of porous CuBr films requires complex high-temperature processes or multistep processes. Herein, we report the uncomplicated preparation of porous CuBr films by a spin-coating method and the films' excellent NH₃ sensing properties. The porous films were prepared by spin-coating 100, 150, and 200 mM CuBr solutions, and then dried in a vacuum oven for 2 h. All the films showed a high NH₃ response; in particular, the film prepared using a 100 mM CuBr solution showed an extremely high response (resistance ratio = 852) to 5 ppm NH₃. The film also showed fast response and recovery times, 272 s and 10 s respectively, even at room temperature. The outstanding NH₃ sensing characteristics were explained in relation to the porosity and thickness of the prepared films. The high-performance NH₃ sensors used in this study can be used for both indoor air quality and environmental monitoring applications.

• Elastomers and Composites
• /
• v.57 no.4
• /
• pp.181-187
• /
• 2022

CdSe-Mn nanocomposites were synthesized using a microwave method with sodium sulfite (Na₂SO₃), selenium (Se), cadmium sulfate octahydrate (3CdSO₄·8H₂O), ammonia solution (NH₃·H₂O), and manganese (II) sulfate monohydrate (MnSO₄·H₂O). We obtained CdSe-Mn-C₆₀ nanocomposites by calcining CdSe-Mn nanocomposites and fullerene (C₆₀) in an electric furnace at 700 ℃ for 2 h. X-ray diffraction, Raman spectroscopy, and scanning electron microscopy were used to characterize the crystal structures, lattice vibrations, and surface morphologies of the products, respectively. The photocatalytic activities of the CdSe-Mn-C₆₀ nanocomposites were investigated based on the photocatalytic degradations of organic dyes such as BG, MB, MO, and RhB under ultraviolet (UV) irradiation at 254 nm. UV-visible spectrophotometry was used to confirm the degradation process.

• Journal of Sensor Science and Technology
• /
• v.33 no.5
• /
• pp.237-241
• /
• 2024

ZnWO₄-WO₃ hetero-composite microspheres were prepared by ultrasonic spray pyrolysis of a solution containing Zn and W cations, followed by heat treatment at 600℃. The gas-sensing characteristics of 5 at% of Zn-added WO₃ (5Zn-WO₃; ZnWO₄-WO₃ hetero-composite) microspheres to 1 ppm acetone, ethanol, 20 ppm hydrogen (H₂), 5 ppm carbon monoxide (CO), 25 ppb toluene, and 5 ppm ammonia (NH₃) were measured at 325-400℃ under 80% relative humidity (RH). The sensor using 5Zn-WO₃ microspheres exhibited highly selective and sensitive gas-sensing properties to acetone at 375℃ even under high humidity conditions. These superior gas-sensing properties were attributed to the increased resistance (electronic sensitization) through n-n heterojunction formation between WO₃ and ZnWO₄ phases and the acidic property of WO₃, which exhibited a low gas response to interfering ethanol gas. The superior acetone gas-sensing characteristics of the 5Zn-WO₃ sensor can be utilized in breath acetone analyzers for rapid, real-time ketogenic diet monitoring.

• Journal of Animal Environmental Science
• /
• v.13 no.2
• /
• pp.129-138
• /
• 2007

A natural deodorizing agent (NDA) was made using pine cone byproduct, and its effects on malodor emission and composting were analyzed in this study. NDA was manufactured by mixing pine cone byproduct with three species of microorganisms and water containing mineral nutrients and molasses, and then by incubating for 48 hours at $30^{\circ}C$. Lab scale experiments were done with three treatment groups, T1 (control, sawdust treatment), T2 (microorganisms and sawdust treatment group), and T3 (NDA and sawdust treatment group). During composting, temperatures reached over $55^{\circ}C$, a minimum temperature for the inactivation of pathogenic microorganisms. No differences were found in physicochemical composition of compost among treatments. However, it was observed that over usage of NDA could obstruct temperature increase, since the biodegradation rate of organic matter of NDA was relatively low, Nitrogen loss due to ammonia gas emission, which normally happens during composting, was reduced by using NDA, and hence the nitrogen level of final compost was higher in T3 than in others. During experiment, it was found that ammonia gas emission was entirely lasted through compositing duration, but the $CH_3SH$ and $H_2S$ gases were produced only at early stage of composting. The ammonia concentration trapped in $H_2SO_4$ solution during 31 days of composting in T1, T2 and T3 was 12,660mg/L, 11,598mg/L and 7,367mg/L, respectively, showing distinguishable reduction of ammonia gas emission in T3. The emissions of $CH_3SH$ and $H_2S$ gases were also remarkably reduced in T3. Based on these obtained results, usage of the deodorizing agent made with pine cone byproduct could reduce the emission of malodor during composting, without any deterioration of compost quality.

• Asian-Australasian Journal of Animal Sciences
• /
• v.24 no.12
• /
• pp.1718-1728
• /
• 2011

Two experiments were conducted to investigate the in vitro ability of keratinase to hydrolyze soybean glycinin and ${\beta}$-conglycinin and to evaluate the in vivo effects of keratinase when included in corn-soybean diets with different levels of crude protein and fed to nursery pigs. In experiment 1, a saturated keratinase solution (1 ml) was added to two blank controls of either glycinin or ${\beta}$-conglycinin resulting in the hydrolysis of 94.74% glycinin and 88.89% ${\beta}$-conglycinin. In experiment 2, 190 pigs (8.3${\pm}$0.63 kg BW) were allotted to one of four treatments in a 2${\times}$2 factorial arrangement on the basis of body weight, and sex was balanced among the pens. The effects of crude protein (19 vs. 22%) and keratinase (0 vs. 0.05%) were studied. Each treatment was applied to six pens with seven (two pens) or eight pigs per pen. Pigs were fed the experimental diets for 21 d. Weight gain and feed conversion ratio were improved (p<0.05) with keratinase supplementation while feed intake was reduced (p<0.05). Keratinase supplementation increased (p<0.05) the apparent total tract digestibility of dry matter, energy, crude protein and phosphorus. Keratinase supplementation also increased n-butyric acid in the cecum and colon, lactobacilli and total anaerobe counts in the colon as well as the ratio of villus height to crypt depth in the ileum. Additionally, fecal score, ammonia nitrogen and branch chain volatile fatty acids in the colon, E. coli and total aerobe counts in the colon, crypt depth in the jejunum and ileum as well as serum interleukin-1 and interleukin-6 concentrations were also decreased (p<0.05) by keratinase supplementation. A reduction in dietary crude protein decreased (p<0.05) colon ammonia nitrogen concentration and cecal propionic acid and branch chain volatile fatty acid concentrations. In addition, cecal E. coli counts, colon total anaerobe counts, ileal crypt depth, and serum interleukin-1 and interleukin-6 concentrations were also decreased (p<0.05) with the reduction of dietary crude protein. With the exception of fecal scores, there were no significant interactions between crude protein and keratinase. This study provides evidence that dietary keratinase supplementation improved nursery pig performance by improving intestinal morphology and ecology, thus improving nutrient digestibility and alleviating the inflammatory response.

• Korean Journal of Microbiology
• /
• v.1 no.1
• /
• pp.38-44
• /
• 1963

According to the experiment on pure-isolation and the related contaminants of Chlorella, the phenomena of the ecological distributions of Chlorella in Korea have been manifested in several areas and also the aim that in going to do culture, biological and physiological study of Chlorella is carried out. Contaminants very oftenly occupied on the colony of the strains taken in order to fulfil pure-isolation of Chlorella, but in accordance with being piled up the minute research on this subject, I can obtain the desirable results as follows: 1. For the pure-isolation, the duration chose the time from May to September 1957 so that may easily isolate from contaminant water with utilizing the antibiotic substances. 2. To take long time, 36-48 hours until growth of nascent through the non-sporulated, it originates from the difference of the cultured media. In addition to the above mention, the mechanism of growth until nascent through the sporulated must not always require the ligh. However the supply of metabolic energy depend upon its nutritional conditions per phase. 3. The culture of Chlorella should be based on the lower culturing except adding especial conditions such as reagent concentration of media, artifical shake of media and other facts due to the natural conditions. And also these strains grew not only in distilled water but 2% NaCl solution without any abnormality in cell it self. I, therefore, guess it is possible to culture in sea-water under phasic environment. 4. In the experiment of ammonia detection, it is caused by the sampling surroundings to contain the minute quantity of ammonia in strain No. M 918; that is the place to be plenty of Carbohydrate on behalf of protein. 5. To compare the absorption curve of chlorophyll of higher plant with that of Chlorella, the absorption zone made mostly the Same ones each other but a little absorption grade dose not clearly appear. The colony which formed giant type grows with intensive colour and green band on surrounding of the colony and after that it was changed into all the green colour and developed up to end. 6. At first phase for a week, the development of Chlorella suspends the normal condition as in vivo but after a few days, the colour of chlorophyll gradually changed into blue-yellow which secrete the mucous substances on the agar media. The cell was flew out the contained substances itself on leaving the cell wall only, or the various micro-organism diffused on the outer-region of the cell.