• Clean Technology
• /
• v.8 no.3
• /
• pp.119-128
• /
• 2002

In the present study the membrane filtration characteristics of a commercially available synthetic water-based cutting oil through two kinds of ultrafiltration membranes (HF1-45-CM50 and HF1-43-CM100) with molecular weight cut-offs of 50,000 and 100,000, respectively, have been investigated in detail. Among these membranes, the hydrophilic one (HF1-45-CM50) was found to show a satisfactory result for both the permeate flux and the permeability of oil components, whereas the permeate flux obtained with the hydrophobic membrane (HF1-43-CM100) appears to be significantly low, indicating that synthetic cutting oil was easily wetted on the hydrophobic membrane surface and induced more membrane fouling. The effect of material characteristics of the membrane on the filtration characteristics was found to be much more significant compared with the mean pore size of the membrane. Backflushing by nitrogen gas was applied to reduce the formation of a gel layer and membrane fouling. With the hydrophilic membrane, the backflushing was found to increase the permeate flux, whereas the backflushing resulted in a decrease in flux for the hydrophobic membrane. The flux recovery was observed to be highest when the membranes fouled with waste synthetic cutting oil were immersed into a cleaning solution for more than 72 hours and then backflushed by nitrogen gas.

• Korean Journal of Agricultural Science
• /
• v.20 no.1
• /
• pp.34-42
• /
• 1993

Effects of salt concentrations on the cell growth and the pigment accumulation were investigated in cell suspension culture of Vitis vinifera and Phytolacca americana L.. The growth pattern of vine cell in control was showed the normal exponential growth pattern, but in the dilution media delay the exponential growth pattern from 4 to 8 days after culture. Maximal accumulation of anthocyanin was observed at 12 days after culture in all treatments. In cell suspension culture of Phytolacca, accumulation of betacyanin occurred in parallel with the cell growth pattern and maximal accumulation of betacyanin was observed after 8 days of culture. In the vine cell culture, the cell growth was showed the peak at 87.6mM of sucrose in the medium and reduced at over this concentration. Maximal anthocyanin accumulation was showed at 146mM of sucrose. In the higher concentrations of sucrose, the cell growth was rapidly decreased, but the accumulation of anthocyanin was not. Otherwise, in case of Phytolacca cell culture, betacyanin accumulation was showed in parallel with the cell growth increased with sucrose concentration. It was suggested that the anthocyanin of vine and the betacyanin of Phytolacca were controlled by different mechanisms.

• Proceedings of the Membrane Society of Korea Conference
• /
• 1996.06a
• /
• pp.91-120
• /
• 1996

경제발전과 더불어 산업의 많은 분야에서 순수 및 초순순의 사용이 증가하고 있으나, 환경오염에 의한 원수의 오염에 따라 순수 및 초순순제조의 장치비와 처리비용의 증가가 야기되고 있다. 현재 국내에는 화력, 원자력발전소를 비롯하여 열병합발전소, 석유화학공장, 제약회사, 전기 전자부품회사, 반도체회사 및 철강회사 등 많은 분야에서 순수 및 초순수 제조장치의 구성과 성능이 많은 차이를 나타내고 있다. 국내의 초순수 제조장치는 90% 이상이 이온교환수지를 사용하는 이온교환법과 UF, R/O System과 같은 Membrane을 사용하는 Membrane System을 병행하여 적용하고 있다. 국내 초순수처리 Plant에서는 통상 전처리 System과 1차 순수제조 System 및 초순수 System이 상호 연결되어 Plant가 구성 운영되고 있다. 전처리 System에는 응집침전, 여과 흡착, 살균 등이 적용되고 있으며 여과 System에 Membrane을 적용할 수 있으나 국내에서는 특별한 경우를 제외하고 대부분 전처리 여과 System에 Media Filter를 사용한다. 전처리 System도 순수처리 장치의 전처리로는 없어서는 안되는 System이지만 여기에는 전처리 System을 제외하고 국내에서 적용하고 있는 초순수처리 System의 공정현황과 각 System별 특징을 설명하고 있다. 초순순 System에는 요구 수질에 따라 다소 차이가 있지만 반도체 공업에서 사용되는 초순수 System이 이중 최고의 Grade로 반도체공업에서 적용되고 있는 System을 기준하였다. 특히 Membrane을 적용한 초순수제조 System이 증가하고 있어 R/O, ED, EDR, CDI, (EDI)와 같은 Membrane System의 특성과 원리를 검토하였다.대적으로 높은 산소확산계수와 물에 대해서는 낮은 투과도를 가져야 한다. 높은 산소확산계수는 반응을 빠르게 하는 잇점이 있으며 물에 대한 낮은 투과도는 센서내의 전해질 물질을 유지보호하는 역할을 한다. 분리막이 산소전극에 이용될 경우 높은 산소 확산계수 이외에도 적절한 기계적 강도, 열적 안정성 등이 요구된다. 몰입이 가능하여 임계치가 저하된 것으로 여겨진다. 또한 광학적 이득의 존재는 이 구조에 의한 극단파장 반도체 레이저다이오드의 실현 가능성을 나타내는 것이다.548 mL에 비해 통계학적으로 의의 있게 적었다(p<0.05). 결론: 관상동맥우회로 조성수술에서 전방온혈심정지액을 사용할 때 희석되지 많은 고농도 포타슘은 fliud overload와 수혈을 피하고 delivery kit를 사용하지 않음으로써 효과적이고 만족할 만한 심근보호 효과를 보였다.를 보였다.4주까지에서는 비교적 폐포는 정상적 구조를 유지하면서 부분적으로 소폐동맥 중막의 비후와 간질에 호산구 침윤의 소견이 특징적으로 관찰되었다. 결론: 분리 폐 관류는 정맥주입 방법에 비해 고농도의 cisplatin 투여로 인한 다른 장기에서의 농도 증가 없이 폐 조직에 약 50배 정도의 고농도 cisplatin을 투여할 수 있었으며, 또한 분리 폐 관류 시 cisplatin에 의한 직접적 폐 독성은 발견되지 않았다이 낮았으나 통계학적 의의는 없었다[10.0%(4/40) : 8.2%(20/244), p>0.05]. 결론: 비디오흉강경술에서 재발을 낮추기 위해 수술시 폐야 전체를 관찰하여 존재하는 폐기포를 놓치지 않는 것이 중요하며, 폐기포를 확인하지 못한 경우와 이차성 자연기흉에 대해서는 흉막유착술에 더 세심한 주의가 필요하다는 것을 확인하였다. 비디오흉강경수술은 통증이 적고, 입원기간이 짧고, 사회

• Food Science and Preservation
• /
• v.9 no.1
• /
• pp.85-91
• /
• 2002

Quality changes of over-wintering satsuma mandarin (Citrus unshiu Marc. var. miyagawa) during storage by chitosan and calcium treatment and type of storage warehouse were investigated. Citrus were treated with 2000-folds diluted iminoctadime-triacetate solution and 1.5% chitosan with 0.5% CaCl$_2$ solutions and were at 30$\^{C}$ far 24 h before storage. The citrus of about 12 kg/26 L plastic container were stored at room temperature, and at 4$\^{C}$ with 87% relative humidity. Chitosan and CaCl$_2$ solution treated citrus fruits were showed lower in decay ratio than the ones without treatment. Also, these chitosan and calcium treated citrus fruits skewed less in weight loss, that seems it also has restraining effect of fruits' transpiration. Decay ratio of citrus with precise temperature and humidity control were lower than the others during storage. Weight loss, moisture content of peel and flesh were decreased slowly during storage. 0.84 ∼0.90% of acid content were decreased on 120 days' storage. Reducing sugar of citrus was decreased rapidly after 90 days, and vitamin C content were also decreased rapidly after 60 days during storage.

• Korean Journal of Food Science and Technology
• /
• v.37 no.6
• /
• pp.1018-1023
• /
• 2005

Simplified procedure was developed for concentrating and detecting poliovirus and norovirus in oysters. Viruses were seeded into oyster tissue homogenates and concentrated through polyethylene glycol (PEG) precipitation, chloroform or Freon extraction, with additional PEG precipitation. Amount of viruses was evaluated using poliovirus plaque assay. Virus recovery during concentration procedure was approximately 16.4-26.0%. For defection, viral RNAs in oysters were examined using one-step RT-PCR after extraction with Trizol. Dilution or capturing of viral RNA using silica gel membrane allowed viruses to be detected by RT-PCR, whereas viruses could not be removed using $QIAshredder^{TM}$ Homogenizer, which is effective in removing RT-PCR inhibitors in lettuce and hamburgers. Freon extraction, generally used to concentrate viruses found in food, could be substituted with chloroform extraction using this procedure; no difference could be observed between detection limits of whole oyster extracts and digestive organ extracts indicating that RT-PCR inhibitors were distributed evenly throughout whole tissues. Nested PCR greatly improved efficiency of this procedure. Overall, this procedure could remove sufficient amount of inhibitors to allow detection of norovirus in oysters.

• Korean Journal of Materials Research
• /
• v.8 no.6
• /
• pp.513-519
• /
• 1998

Zr-Si binary alloys containing 0.01 to O.lwt.%Si were prepared to investigate the effect of Si on the corrosion behavior of Zr. Corrosion test was performed in pure water at 36$0^{\circ}C$ under a pressure of 2660psi for 100days. The alloys containing 0.01 wt. % and 0.05wt. %Si had the black and uniform oxide film and didn't show the transition of corrosion rate. However. the alloys containing O.lwt.%Si had white oxide film and showed the trasition of corrosion rate at 70 days corrosion test. The weight gain increased with the increasing Si content from 0.01 to 0.1 wt.%. The variation of Si contents had no effect on changing the oxide structure but had significant effect on the electrical resistivity of oxide. The electrical resistivity decreased with increasing Si content. The fraction of precipitates in the Zr-Si binary alloys. identified as tetragonal $Zr_{3}$Si increased with increasing Si content. The increase of the volume fraction of precipitates is thought to be responsible for the increase of weight gain due to short circuit effect of precipitate.

• Journal of the Korea Organic Resources Recycling Association
• /
• v.9 no.3
• /
• pp.127-135
• /
• 2001

Achieved to grasp possibility to use compost that make food waste and sawdust (bulking agent) by raw material in this research droopingly to bulking agent calamity. To be kept by aerobic experiment method to 4 composting device that air is supplied Food Waste + Sawdust, Livestock Feces + Sawdust, Food Waste + Compost, Livestock Feces + Compost free medical care and investigated composting sledding and temperature, pH, the moisture rate, heavy metals item etc. Judged that food waste of the moisture rate mix experiment result food waste input (food waste and sawdust composting done material mean) compost happened after resources anger as bulking agent food waste and Livestock Feces quantity is 72~77%, because axis dries to promote optimum composting progress appearing by 64~65%, thing which use need and was difficult to set salt 1% that is by-product compost standard when use compost as bulking agent of food waste but by dilution effect of Livestock Feces quantity using compost being expose that preservation is available by standard low because salt content density of done compost becomes found possibility that can solve salt content problem.

• Journal of Korean Society of Forest Science
• /
• v.99 no.3
• /
• pp.432-438
• /
• 2010

This study was carried out to understand the effect on soil chemical property, ion contents, and growth of Lonicera japonica by treatment of simulated acid rain and wood vinegar. It was treated total 30 times by one time per 2 weeks during 150 days from June to October dividing to various pH level of simulated acid rain (each pH 5.6, 4.5, 3.5 and 2.5) and the control site (pH 6.3). The wood vinegar diluted with 500 times was also treated total 10 times by one time per 2 weeks at the experimental sites. The soil pH was reduced as pH level of simulated acid rain was decreased. The organic content, total nitrogen, and Av. $P_2O_5$ in soil showed a tendency to increment. However, the soil improvement effect was exposed to be insufficient when a wood vinegar was treated. In the component of the plant body, $SO_4{^2}$ and $NO_3{^-}$ increased due to the simulated acid rain treatment and the increment ratio was reduced in the wood vinegar treatment plot. In addition, the cation contents showed a tendency to variation due to pH of simulated acid rain. And it showed more increment in the leaves than the root. The early fallen leaves and growth inhibition of L. japonica showed up after the simulated acid rain treatment but the growth of L. japonica increased after the wood vinegar treatment.

• Korean Journal of Agricultural Science
• /
• v.38 no.4
• /
• pp.785-791
• /
• 2011

This study was carried out to analyze the effect of the farm management and productivity increase of cabbages growing in the plastic house based on application of green manure crops such as silage corn, haussolgo (Sorghum bicolar L. Moench), hairy vetch, etc. According to the effect of green manure crop grown in summer season, the biomass amount of the silage corn was the highest; 7,630 kg per 10a, the next was haussolgo, 5,620 kg per 10a. In terms of the fertilizer ingredients, the first of forage soybean was 3.84% of nitrogen, whereas hairy vetch was 1.74% of phosphate and kalium, 4.74%. Productivity increase of cabbages was the highest in the haussolgo plot of which the yield of showed 10,090 kg per 10a and the farm household income would be worth 8,053 thousand won. By growing forage crops in the winter season, the biomass amount was the highest in the mixed sowing plot with rye (50%) and hairy vetch (50%) of 3,590 kg per 10a, whereas the productivity in the mixed seeding with rye (70%) and hairy vetch (30%) was highest, 6,249 kg per 10a and the farm household income would be worth 7,387 thousand won. Judging from these results, more practical on-farm research on applying different green manure crops as a basal fertilizer with cabbage in the plastic house should be considered to analyze the farm management and the farm household income at different sites.

• Journal of Mushroom
• /
• v.9 no.3
• /
• pp.110-115
• /
• 2011

Trichoderma disease of oyster mushroom has not been effectively detected in the field for testing its resistance against the disease with its varieties. In this study, we investigated the methods to detect its resistance in the laboratory by using media, which enables us to understand the relevant characteristics (e.g., lysis, toxin enzyme, mycelial growth rate). In coculturing with strains of Trichoderma and oyster mushroom, it is possible to observe the difference in the resistance of oyster mushroom against Trichoderma with the phenomena of barrage reaction, overgrowth and lysis. We also observed the inhibition of mycelial growth of oyster mushroom using the dilution method with 48-well plate, but could not observed the inhibition of mycelial growth using the filter paper method of cultural supernatant. In simultaneously culturing both Trichoderma and oyster mushroom, it was possible to detect the inhibition of the mycelial growth of oyster mushroom, but Trichoderma mycelium did not overgrow against oyster mushroom. We found that the pathogenicity was efficient in using solid medium with the phenomena of overgrowth and lysis by inoculating Trichoderma on top of mycelia of oyster mushroom. In conclusion, the methods (e.g., coculture method, dilution method with 48-well plate, post-inoculation method) are recommended to detect the resistance of oyster mushroom against Trichoderma disease.