• 한국수소및신에너지학회논문집
• /
• 제17권1호
• /
• pp.75-81
• /
• 2006

Lean premixed combustion is a well known method for low $NO_x$ gas turbine combustor. But lean combustion is usually accompanied by flame instability. To overcome this problem, the hydrogen ($H_2$) was added to main fuel methane to increase flammable limit. In this paper, the effects of hydrogen addition on lean premixed combustion of methane ($CH_4$) were investigated numerically. Results showed that the extinction stretch rate increases and the extinction temperature constant with relatively small amount of $H_2$ addition. The flame temperature and NO emission increase with $H_2$ addition at the same stretch rate and equivalence ratio but it could increase the range of lean extinction and extinction equivalence ratio limit. Eventually, the $H_2$ addition case showed almost same or lower NO emission than no addictive $CH_4$ case in the extinction condition.

• 대한기계학회논문집B
• /
• 제35권8호
• /
• pp.839-845
• /
• 2011

산소부화 조건의 $CH_4/O_2/N_2$ 화염에서 트리플루오르메탄의 영향을 조사하기 위해 1기압에서 자유롭게 전파하는 예혼합 화염에 대한 수치해석을 수행하였다. 트리플루오르메탄은 화염속도 감소에 기여하며, 감소의 크기는 화학적 효과보다 물리적 효과에 의해 더 크다. 트리플루오르메탄은 산소부화된 $CH_4/O_2/N_2$ 화염에서 더 많이 첨가되고 소비될 수 있다. 트리플루오르메탄은 주로 $CF_3{\rightarrow}CF_2{\rightarrow}CF{\rightarrow}CF:O{\rightarrow}CO$을 통해 분해되고, 산소부화 화염에서 $CHF_3+M{\rightarrow}CF_2+HF+M$이 중요한 역할을 한다. 억제제가 산소 부화 화염에 첨가함에 따라 활성기 최대 농도의 위치는 상대적으로 낮은 온도로 이동하고, OH의 순생성률은 H의 순생성률보다 높다.

• 대한기계학회논문집B
• /
• 제29권9호
• /
• pp.979-987
• /
• 2005

Numerical simulations were performed at atmospheric pressure in order to understand the effect of additives on flame speed, flame temperature, radical concentrations, $NO_x$ formation, and heat flux in freely propagating $CH_4-Air$ flames. The additives were both carbon dioxide and hydrogen chloride which had a combination of physical and chemical behavior on hydrocarbon flame. In the flame established with the same mole of methane and additive, hydrogen chloride significantly contributed toward the reduction of flame speed, flame temperature, $NO_x$ formation and heat flux by the chemical effect, whereas carbon dioxide mainly did so by the physical effect. The impact of hydrogen chloride on the decrease of the radical concentration was about $1.4\~3.0$ times as large as that of carbon dioxide. Hydrogen chloride had higher effect on the reduction of $EI_{NO}$ than carbon dioxide because of the chemical effect of hydrogen chloride. The reaction, $OH+HCl{\rightarrow}Cl+H_2O$, played an important role in the heat flux from flames added by hydrogen chloride instead of the reaction, $OH+H_2{\rightarrow}H+H_2O$ which was an important reaction in hydrocarbon flames.

• 한국화재소방학회논문지
• /
• 제28권3호
• /
• pp.34-42
• /
• 2014

본 연구에서는 $CH_4$ 및 $C_3H_8$ 연료의 컵버너 비예혼합화염에서 Swing, Rotation, Lifted 및 Blow-out과 같은 화염 불안정성을 발생시키는 불활성기체($N_2$, Ar, $CO_2$ 및 He)의 농도를 측정하였으며, 소화기준(즉, 화염날림 또는 화염불안정성 개시)에 따른 소화농도의 정량적 차이를 검토하였다. 소화농도의 차이는 부상화염의 발생 그리고 낮은 소화성능의 불활성기체일수록 증가됨을 확인하였다. 소화기준에 따른 소화농도의 최대 차이는 $C_3H_8$-air 비예혼합화염의 최대 연료유속의 조건(1.3 cm/s)에서 약 35%이다. 또한 화염 불안정성의 개시를 기준으로 측정된 소화농도는 정확한 그리고 경제적 설계 농도의 관점에서 유용한 정보를 제공할 것으로 기대된다.

• 한국광학회지
• /
• 제9권4호
• /
• pp.264-269
• /
• 1998

분젠버너에서 당량비에 따른 연료부족, 적정, 과잉의 경우로 예혼합된 프로판-공기 화염에서 발생된 C2, CH, OH 라디칼의 농도형태 측정을 영상처리법을 이용하여 가시화하였다. 영상처리 시스템에서 협대역 통과필터, 영상증폭장치, CCD 및 PC를 사용하여 라디칼의 발광 파장대의 영상을 처리하였다. 영상처리 시스템을 통하여 화염에서 라디칼의 반응영역을 관찰하고, 라디칼의 농도분도를 예측할 수 있었다. 반응영역에서 각각의 라디칼의 공간적 분포는 CmHn 계열 화염의 반응 메카니즘을 이해할 수 있는 충분한 정보를 제공하였다. 이 정보로부터 C2 라디칼의 형광은 반응영역 앞부분에 먼저 나타나며 CH와 OH 라디칼의 형광은 화염의 하류부분에 분포함을 알 수 있었다.

• 청정기술
• /
• 제14권2호
• /
• pp.117-122
• /
• 2008

중발열량 석탄 합성가스의 연소 및 NOx 발생 특성에 대한 이론적 해석을 수행하였다. 석탄 합성가스는 CO, $H_2,\;CO_2,\;N_2$가 주성분이고, 미량의 $CH_4$ 및 $NH_3$를 함유하는 것으로 가정하였다. 열화학적 해석을 통해 합성가스 연소 시의 화염 온도, 배기가스의 주요 및 부차적 화학종들의 조성, 열 및 연료 NOx 발생량을 계산하였다. 또한 합성가스 중의 $CH_4$ 및 $NH_3$ 성분이 연소 및 NOx 발생에 미치는 영향을 검토하였다. 본 석탄 합성가스들의 계산결과들을 토대로 가스터빈 연소기의 NOx 저감 설계에 필요한 기본 방향과 기준을 제시하였다.

• 한국수소및신에너지학회논문집
• /
• 제18권3호
• /
• pp.265-274
• /
• 2007

A study has been conducted to clarify NO emission behavior through preferential diffusion effects of $H_2$ and H in methane-hydrogen diffusion flames. A comparison is made by employing three species diffusion models. Special concerns are focused on what is the deterministic role of the preferential diffusion effects in flame structure and NO emission. The behavior of maximum flame temperatures with three species diffusion models is not explained by scalar dissipation rate but the nature of chemical kinetics. The preferential diffusion of H into reaction zone suppresses the populations of the chain carrier radicals and then flame temperature while that of $H_2$ produces the increase of flame temperature. These preferential diffusion effects of $H_2$ and H are also discussed about NO emissions through the three species diffusion models.

• 한국연소학회지
• /
• 제15권4호
• /
• pp.29-36
• /
• 2010

An experimental study was conducted for three different fuels($CH_4$, $C_2H_4$ and $C_3H_8$) to investigate the combustion characteristics and the local reaction intensity with combustor pressure(-30kpa~30kpa). Regardless of fuel composition, EINOx decreased with reducing pressure decreased. Structure and combustion characteristics were also largely affected by the combustor pressure. In addition, reaction intensity in terms of the changing combustor pressure and equivalence ratio was investigated. Combustion reaction in higher than atmospheric pressure was very active than the lower combustor pressure. When the combustor pressure is lower than the atmospheric pressure, the overall reactivity is noticeably enhanced due to the elevated diffusion process of unburned mixture. It was found that the combustion characteristics of the methane and propane flames are considerably influenced by the pressure while those of ethylene flame are less sensitive to the combustor pressure.

• 한국마린엔지니어링학회:학술대회논문집
• /
• 한국마린엔지니어링학회 2011년도 후기공동학술대회 논문집
• /
• pp.88-89
• /
• 2011

The study on synthesis of carbon nanomaterials by H2 mixing in counterflow methane diffusion flames has been experimentally conducted. We have also investigated on effect of catalyst and temperature in flame. The counterflow flame was formed by many kind of gas (fuel side using $CH_4-H_2-N_2$ and oxidizer side $N_2-O_2$) and nitrogen shields discharge on each other side to cut off oxidizer of the atmosphere. Ferrocene was used as a metal catalyst for CNTs synthesis. substrate was used to deposit carbon nanomaterials and these were analyzed by FE-SEM. We could find that carbon nanotubes and many kind of carbon nano materials were formed in Cu wire substrate, through this experiment.

• 한국연소학회:학술대회논문집
• /
• 한국연소학회 2001년도 제22회 KOSCI SYMPOSIUM 논문집
• /
• pp.133-138
• /
• 2001

In this study, quantitative nitric oxide concentration distributions are investigated in the laminar nonpremixed $H_2/N_2$ flames by laser-induced fluorescence (LIF). The measurements are taken in flames for different $N_2$ dilution ratios varying from 20${\sim}$80%, and fuel now rate is fixed as lslpm. The NO A-X (0,0) vibrational band around 226 nm is excited using a XeCl excimer-pumped dye laser. We applied same excitation line used in $CH_4$ premixed flame. Overall, NO concentration was rapidly decreased with $N_2$ addition and we could not measure the concentration any longer for $N_2$ dilution above 80%.