Advances in concrete construction

  • 제14권2호
  • /
  • Pages.93-102
  • /
  • 2022
  • /
  • 2287-5301(pISSN)
  • /
  • 2287-531X(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

The effects of limestone powder and fly ash as an addition on fresh, elastic, inelastic and strength properties of self-compacting concrete

  • Hilmioglu, Hayati (Istanbul Technical University, Faculty of Civil Engineering) ;
  • Sengul, Cengiz (Istanbul Technical University, Faculty of Civil Engineering) ;
  • Ozkul, M. Hulusi (Istanbul Technical University, Faculty of Civil Engineering)
  • 투고 : 2021.02.04
  • 심사 : 2022.08.14
  • 발행 : 2022.08.25
⟨ 이전 논문 다음 논문 ⟩

초록

In this study, limestone powder (LS) and fly ash (FA) were used as powder materials in self-compacting concrete (SCC) in increasing quantities in addition to cement, so that the two powders commonly used in the production of SCC could be compared in the same study. Considering the reduction of the maximum aggregate size in SCC, 10 mm or 16 mm was selected as the coarse aggregate size. The properties of fresh concrete were determined by slump flow (including T500 time), V-funnel and J-ring experiments. The experimental results showed that as the amount of both LS and FA increased, the slump flow also increased. The increase in powder material had a negative effect on V-funnel flow times, causing it to increase; however, the increase in FA concretes was smaller compared to LS ones. The increase in the powder content reduced the amount of blockage in the J-ring test for both aggregate sizes. As the hardened concrete properties, the compressive and splitting strengths as well as the modulus of elasticity were determined. Longitudinal and transverse deformations were measured by attaching a special frame to the cylindrical specimens and the values of Poisson's ratio, initiation and critical stresses were obtained. Despite having a similar W/C ratio, all SCC exhibited higher compressive strength than NVC. Compressive strength increased with increasing powder content for both LS and FA; however, the increase of the FA was higher than the LS due to the pozzolanic effect. SCC with a coarse aggregate size of 16 mm showed higher strength than 10 mm for both powders. Similarly, the modulus of elasticity increased with the amount of powder material. Inelastic properties, which are rarely found in the literature for SCC, were determined by measuring the initial and critical stresses. Crack formation in SCC begins under lower stresses (corresponding to lower initial stresses) than in normal concretes, while critical stresses indicate a more brittle behavior by taking higher values.

키워드

과제정보

The authors wish to thank the Scientific and Technological Research Council of Turkey (TUBITAK) for providing funding for this study (MAG-115M483). The authors also thank ITU. BAP (Project No. 39476) for their support.

참고문헌

  1. Abd Elrahman, M. and Hillemeier, B. (2014), "Combined effect of fine fly ash and packing density on the properties of high performance concrete: an experimental approach", Constr. Build. Mater., 58, 225-233. https://doi.org/10.1016/j.conbuildmat.2014.02.024.
  2. ACI 211.1-91 (2009), Standard Practice for Selecting Proportions for Normal, Heavyweight, and Mass Concrete; American Concrete Institute, Farmington Hills, MI, USA.
  3. Akcaoglu, T., Tokyay, M. and Celik, T. (2005), "Assessing the ITZ microcracking via scanning electron microscope and its effect on the failure behavior of concrete", Cement Concrete Res., 35, 358-363. https://doi.org/10.1016/j.cemconres.2004.05.042
  4. Alqadi, A.N., Mustapha, K.N.B., Naganathan, S. and Al-Kadi, Q.N. (2012), "Uses of central composite design and surface response to evaluate the influence of constituent materials on fresh and hardened properties of self-compacting concrete", KSCE J. Civil Eng., 16(3), 407-416. https://doi.org/10.1007/s12205-012-1308-z
  5. Amparanoa, F.E., Xib, Y. and Roh, Y.-S. (2000), "Experimental study on the effect of aggregate content on fracture behavior of concrete", Eng. Fract. Mech., 67, 65-84. https://doi.org/10.1016/S0013-7944(00)00036-9
  6. ASTM C39 (2018), Standard Test Method for Compressive Strength of Cylindrical Concrete Specimens; ASTM, West Conshohocken, PA, USA.
  7. Barbhuiya, S. (2011), "Effects of fly ash and dolomite powder on the properties of self-compacting concrete", Constr. Build. Mater., 25, 3301-3305. https://doi.org/10.1016/j.conbuildmat.2011.03.018
  8. Bauchkar, S.D. and Chore, H.S. (2018), "Effect of PCE superplasticizers on rheological and strength properties of high strength self-consolidating concrete", Adv. Concrete Constr., Int. J., 6(6), 561-583. https://doi.org/10.12989/acc.2018.6.6.561
  9. Collepardi, M., Collepardi, S. and Troli, R. (2007), "Properties of SCC and flowing concrete", Proceedings of the International Conference of Sustainable Construction Materials and Technologies, Coventry, UK, June, pp. 25-31.
  10. Das, D. and Chatterjee, A. (2012), "A comparison of hardened properties of fly-ash-based self-compacting concrete and normally compacted concrete under different curing conditions", Mag. Concrete Res., 64(2), 129-141. https://doi.org/10.1680/macr.10.00118
  11. Diamantonis, N., Marinos, I., Katsiotis, M.S., Sakellariou, A., Papathanasiou, A., Kaloidas, V. and Katsioti, M. (2010), "Investigations about the influence of fine additives on the viscosity of cement paste for self-compacting concrete", Constr. Build. Mater., 24, 1518-1522. https://doi.org/10.1016/j.conbuildmat.2010.02.005
  12. Dinakar, P., Reddy, M.K. and Sharma, M. (2013), "Behaviour of self-compacting concrete using Portland pozzolana cement with different levels of fly ash", Mater. Des., 46, 609-616. https://doi.org/10.1016/j.matdes.2012.11.015
  13. Djamila, B., Othmane, B., Said, K. and El-Hadj, K. (2018), "Combined effect of mineral admixture and curing temperature on mechanical behavior and porosity of SCC", Adv. Concrete Constr., Int. J., 6(1), 69-85. https://doi.org/10.12989/acc.2018.6.1.069
  14. Domone, P.L. (2006), "Self-compacting concrete: An analysis of 11 years of case studies", Cement Concrete Compos., 28(2), 197-208. https://doi:10.1016/j.cemconcomp.2005.10.003
  15. EFNARC (2005), The European Guidelines for Self-Compacting Concrete: Specification, Production and Use; The Self-Compacting Concrete European Project Group, UK.
  16. EN 197-1 (2011), Cement - Part1: Composition, Specifications and Conformity Criteria for Common Cements, CEN (European Committee for Standardization), Brussels, Belgium.
  17. EN 12350-8 (2010), Testing fresh concrete - Part 8: Selfcompacting concrete - Slump-flow test, CEN (European Committee for Standardization), Brussels, Belgium.
  18. EN 12350-9 (2010), Testing fresh concrete - Part 9: Selfcompacting concrete - V-funnel test, CEN (European Committee for Standardization), Brussels, Belgium.
  19. EN 12350-12 (2010), Testing fresh concrete - Part 12: Selfcompacting concrete - J-ring test, CEN (European Committee for Standardization), Brussels, Belgium.
  20. EN 12390-6 (2010), Testing hardened concrete: Tensile splitting strength of test specimens, CEN (European Committee for Standardization), Brussels, Belgium.
  21. Giaccio, G., Sensale, G.R. and Zerbino, R. (2007), "Failure mechanism of normal and high-strength concrete with rice-husk ash", Cement Concrete Compos., 29, 566-574. https://doi.org/10.1016/j.cemconcomp.2007.04.005
  22. Girish, S., Ranganath, R.V. and Vengala, J. (2010), "Influence of powder and paste on flow properties of SCC", Constr. Build. Mater., 24, 2481-2488. https://doi.org/10.1016/j.conbuildmat.2010.06.008
  23. Gorzelanczyk, T. (2011), "The effect of moisture content on the failure of self-compacting concrete under compression, as assessed by means of acoustic methods", Archiv. Civil Mech. Eng., 11(1), 45-60. https://doi.org/10.1016/S1644-9665(12)60173-3
  24. Gorzelanczyk, T. (2012), "Acoustically Assessed Influence of Air Pore Structure on Failure of Self-Compacting Concretes Under Compression", J. Civil Eng. Manage., 18(1), 60-70. https://doi.org/10.3846/13923730.2011.652982
  25. Gorzelanczyk, T. and Hola, J. (2011), "Pore structure of selfcompacting concretes made using different superplasticizers", Archiv. Civil Mech. Eng., 11, 611-621. https://doi.org/10.1016/S1644-9665(12)60104-6
  26. Gorzelanczyk, T. and Hola, J. (2015), "Stress failure of cement concretes under compression - Synthesis, of Knowledge, Conclusions", J. Civil Eng. Manage., 21(1), 1-10. https://doi.org/10.3846/13923730.2014.929024
  27. Guo, L.-P., Carpinteri, A., Spagnoli, A. and Wei, S. (2010), "Effects of mechanical properties of concrete constituents including active mineral admixtures on fatigue behaviours of high performance concrete", Fatigue Fract. Eng. Mater. Struct., 33(1), 66-75. https://doi.org/10.1111/j.1460-2695.2009.01416.x
  28. Hu, J. and Wang, K. (2011), "Effect of coarse aggregate characteristics on concrete rheology", Constr. Build. Mater., 25(3), 1196-1204. https://doi.org/10.1016/j.conbuildmat.2010.09.035
  29. Jain, A., Gupta, R. and Chaudhary, S. (2020), "Sustainable development of self-compacting concrete by using granite waste and fly ash", Constr. Build. Mater., 262, 120516. https://doi.org/10.1016/j.conbuildmat.2020.120516
  30. Jalal, M., Fathi, M. and Farzad, M. (2013), "Effects of fly ash and TiO2 nanoparticles on rheological, mechanical, microstructural and thermal properties of high strength self-compacting concrete", Mech. Mater., 61, 11-27. https://doi.org/10.1016/j.mechmat.2013.01.010
  31. Jiao, D., Shi, C., Yuan, Q., An, X., Liu, Y. and Li, H. (2017), "Effect of constituents on rheological properties of fresh concrete-A review", Cement Concrete Compos., 83, 146-159. https://doi.org/10.1016/j.cemconcomp.2017.07.016
  32. Khaleel, O.R., Al-Mishhadani, S.A. and Abdul Razak, H. (2011), "The effect of coarse aggregate on fresh and hardened properties of self-compacting concrete (SCC)", Procedia Eng., 14, 805-813. https://doi.org/10.1016/j.proeng.2011.07.102
  33. Khatib, J.M. (2008), "Performance of self-compacting concrete containing fly ash", Constr. Build. Mater., 22, 1963-1971. https://doi.org/10.1016/j.conbuildmat.2007.07.011
  34. Koehler, E.P. and Fowler, D.W. (2007a), "Aggregate in selfconsolidating concrete", ICAR Project 108; The University of Texas at Austin, p. 362. http://hdl.handle.net/2152/35362
  35. Koehler, E.P. and Fowler, D.W. (2007b), "Proportioning SCC based on aggregate characteristics", Proceedings of 5th International RILEM Symposium on Self-Compacting Concrete, Gent, Belgium, September, pp. 67-72.
  36. Kuder, K., Lehman, D., Berman, J., Hannesson, G. and Shogren, R. (2012), "Mechanical properties of self-consolidating concrete blended with high volumes of fly ash and slag", Constr. Build. Mater., 34, 285-295. https://doi.org/10.1016/j.conbuildmat.2012.02.034
  37. Laskar, A.I. and Talukdar, S. (2008), "Rheological behavior of high performance concrete with mineral admixtures and their blending", Constr. Build. Mater., 22(12), 2345-2354. https://doi.org/10.1016/j.conbuildmat.2007.10.004
  38. Liu, M. (2010), "Self-compacting concrete with different levels of pulverized fuel ash", Constr. Build. Mater., 24, 1245-1252. https://doi.org/10.1016/j.conbuildmat.2009.12.012
  39. Lothenbach, B., Scrivener, K. and Hooton, R.D. (2011), "Supplementary cementitious materials", Cement Concrete Res., 41, 1244-1256. https://doi.org/10.1016/j.cemconres.2010.12.001
  40. Mohamed, S. and Tayeb, B. (2019), "Effect of coarse aggregates and sand contents on workability and static stability of selfcompacting concrete", Adv. Concrete Constr., Int. J., 7(2), 97-105. https://doi.org/10.12989/acc.2019.7.2.097
  41. Mueller, F.V., Wallevik, O.H. and Khayat, K.H. (2014), "Linking solid particle packing of Eco-SCC to material performance", Cement Concrete Compos., 54, 117-125. https://doi.org/10.1016/j.cemconcomp.2014.04.001
  42. Nanthagopalan, P. and Santhanam, M. (2009), "Experimental investigations on the influence of paste composition and content on the properties of self-compacting concrete", Constr. Build. Mater., 23, 3443-3449. https://doi.org/10.1016/S0008-8846(01)00566-X
  43. Nikbin, I.M., Beygi, M.H.A., Kazemi, M.T., Vaseghi Amiri, J., Rahmani, E., Rabbanifar, S. and Eslami, M. (2014a), "A comprehensive investigation into the effect of aging and coarse aggregate size and volume on mechanical properties of selfcompacting concrete", Mater. Des., 59, 199-210. https://doi.org/10.1016/j.matdes.2014.02.054
  44. Nikbin, I.M., Beygi, M.H.A., Kazemi, M.T., Vaseghi Amiri, J. Rabbanifar, S., Rahmani, E. and Rahimi, S. (2014b), "A comprehensive investigation into the effect of water to cement ratio and powder content on mechanical properties of selfcompacting concrete", Constr. Build. Mater., 57, 69-80. https://doi.org/10.1016/j.conbuildmat.2014.01.098
  45. Okamura, H. and Ouchi, M. (2003), "Self-compacting concrete", J. Adv. Concrete Technol., 1(1), 5-15. https://doi.org/10.3151/jact.1.5
  46. Pandurangan, K., Ramakrishna, G. and Kothandaraman, S. (2012), "Effect of coarse aggregate size and shape on the strength and flow characteristics of self-compacting concrete", ICI J., 13(2), 1-7.
  47. Parra, C., Valcuende, M. and Gomez, F. (2011), "Splitting tensile strength and modulus of elasticity of self-compacting concrete", Constr. Build. Mater., 25, 201-207. https://doi.org/10.1016/j.conbuildmat.2010.06.037
  48. Roziere, E., Granger, S., Turcry, Ph, and Loukili, A. (2007), "Influence of paste volume on shrinkage cracking and fracture properties of self-compacting concrete", Cement Concrete Compos., 29, 626-636. https://doi.org/10.1016/j.cemconcomp.2007.03.010
  49. Shah, S.P. and Chandra, S. (1968), "Critical stress, volume change, and microcracking of concrete", ACI J., 65(9), 770-781.
  50. Shindoh, T. and Matsuoka, Y. (2003), "Development of combination-type self-compacting concrete and evaluation test methods", J. Adv. Concrete Technol., 1(1), 26-36. https://doi.org/10.3151/jact.1.26
  51. Siddique, S. (2011), "Properties of self-compacting concrete containing class F fly ash", Mater. Des., 32, 1501-1507. https://doi.org/10.1016/j.matdes.2010.08.043
  52. Skender, Z., Bali, A. and Kettab, R. (2021), "Self-compacting concrete (SCC) behaviour incorporating limestone fines as cement and sand replacement", Eur. J. Environ. Civil Eng., 25(10), 1852-1873. https://doi.org/10.1080/19648189.2019.1607564
  53. Su, N., Hsu, K.-C. and Chai, H.-W. (2001), "A simple mix design method for self-compacting concrete", Cement Concrete Res., 31, 1799-1807. https://doi.org/10.1016/S0008-8846(01)00566-X
  54. Varhen, C., Dilonardo, I., de Oliveira Romano, R.C., Pileggi, R.G. and de Figueiredo, A.D. (2016), "Effect of the substitution of cement by limestone filler on the rheological behaviour and shrinkage of microconcretes", Constr. Build. Mater., 125, 375-386. https://doi.org/10.1016/j.conbuildmat.2016.08.062
  55. Zhang, J., Han, G., Shen, D., An, X. and Meye, S.M. (2022), "A new model to predict the optimal mix design of self-compacting concrete considering powder properties and superplasticizer type", J. Mater. Res. Technol., 19, 3980-3993. https://doi.org/10.1016/j.jmrt.2022.06.130
  56. Zhu, W. and Gibbs, J.C. (2005), "Use of different limestone and chalk powders in self-compacting concrete", Cement Concrete Res., 35, 1457-1462. https://doi.org/10.1016/j.cemconres.2004.07.001