Advances in environmental research

  • 제10권1호
  • /
  • Pages.87-103
  • /
  • 2021
  • /
  • 2234-1722(pISSN)
  • /
  • 2234-1730(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Sustainable anaerobic digestion of euphorbiaceae waste for biogas production: Effects of feedstock variation

  • Kamaruddin, Mohamad Anuar (Environmental Technology Division, School of Industrial Technology, Universiti Sains Malaysia) ;
  • Ismail, Norli (Environmental Technology Division, School of Industrial Technology, Universiti Sains Malaysia) ;
  • Fauzi, Noor Fadhilah (Environmental Technology Division, School of Industrial Technology, Universiti Sains Malaysia) ;
  • Alrozi, Rasyidah (Faculty of Chemical Engineering, Universiti Teknologi MARA, Cawangan Pulau Pinang) ;
  • Hanif, Mohamad Haziq (Environmental Technology Division, School of Industrial Technology, Universiti Sains Malaysia) ;
  • Norashiddin, Faris Aiman (Environmental Technology Division, School of Industrial Technology, Universiti Sains Malaysia)
  • 투고 : 2021.01.18
  • 심사 : 2021.03.11
  • 발행 : 2021.03.25
⟨ 이전 논문 다음 논문 ⟩

초록

Anaerobic digestion (AD) refers to the biological process which can convert organic substrates to biogas in the absence of oxygen. The aim of this study was to determine the capability of feedstock to produce biogas and to quantify the biogas yield from different feedstocks. A co-digestion approach was carried out in a continuous stirred tank reactor operated under mesophilic conditions and at a constant organic loading rate of 0.0756 g COD/ L.day, with a hydraulic retention time of 25 days. For comparison, mono-digestion was also included in the experimental work. 2 L working volumes were used throughout the experimental work. The seed culture was obtained from composting as substrate digestion. When the feedstock was added to seeding, the biogas started to emit after three days of retention time. The highest volume of biogas was observed when the seeding volume used for 1000mL. However, the lowest volume of biogas yield was obtained from both co-digestion reactors, with a value of 340 mL. For methane yield, the highest methane production rate was 0.16 L CH4/mg. The COD with yield was at 8.6% and the lowest was at 0.5%. The highest quantity of methane was obtained from a reactor of Euphorbiaceae peel with added seeding, while the lowest methane yield came from a reactor of Euphorbiaceae stems with added seeding. In this study, sodium bicarbonate (NaHCO3) was used as a buffering solution to correct the pH in the reactor if the reactor condition was found to be in a souring or acidic condition.

키워드

참고문헌

  1. Amin, F.R., Khalid, H., Zhang, H., Rahman, S., Zhang, R., Liu, G. and Chen, C. (2017), "Pretreatment methods of lignocellulosic biomass for anaerobic digestion", AMB Express, 7(1), 1-12. https://doi.org/10.1186/s13568-017-0375-4.
  2. Anunputtikul, W. and Rodtong, S. (2004), "Laboratory scale experiments for biogas production from Euphorbiaceae tubers", Proceedings of the Joint International Conference on "Sustainable Energy and Environment (SEE), Hua Hin, Thailand, December.
  3. Bayitse, R.N.L.G., Selormey, G., Oduro, W.O., Aggey, M., Mensah, B., Gustavsson, M. and Bjerre, A.B. (2014), "Anaerobic co-digestion of cassava peels and manure: A technological approach for biogas generation and bio-fertilizer production", J. Appl. Sci. Technol., 19(1/2), 10-17.
  4. Bjornsson, L., Murto, M. and Mattiasson, B. (2000), "Evaluation of parameters for monitoring an anaerobic co-digestion process", Appl. Microbiol. Biotechnol., 54(6), 844-849. https://doi.org/10.1007/s002530000471.
  5. Demirel, B. and Yenigun, O. (2004), "Anaerobic acidogenesis of dairy wastewater: The effects of variations in hydraulic retention time with no pH control", J. Chem. Technol. Biotechnol., 79(7), 755-760. https://doi.org/10.1002/JCTB.1052.
  6. Deublein, D. and Steinhauser, A. (2011), Biogas from Waste and Renewable Resources: An Introduction, Wiley.
  7. Dioha, I.J., Ikeme, C.H., Nafi'u, T., Soba, N.I. and Yusuf, M.B.S. (2013), "Effect of carbon to nitrogen ratio on biogas production", Int. Res. J. Nat. Sci., 1(3), 1-10. https://doi.org/10.5296/ijssr.v1i1.3588
  8. Franke-Whittle, I.H., Walter, A., Ebner, C. and Insam, H. (2014), "Investigation into the effect of high concentrations of volatile fatty acids in anaerobic digestion on methanogenic communities", Waste Manage., 34(11), 2080-2089. https://doi.org/10.1016/J.WASMAN.2014.07.020.
  9. Hagos, K., Zong, J., Li, D., Liu, C. and Lu, X. (2017), "Anaerobic co-digestion process for biogas production: Progress, challenges and perspectives", Renew. Sust. Energ. Rev., 76, 1485-1496. https://doi.org/10.1016/j.rser.2016.11.184.
  10. Jekayinfa, S. and V. S. (2013), "Laboratory scale preparation of biogas from Euphorbiaceae tubers, Euphorbiaceae peels, and palm kernel oil residues", Energy Sources Part A Recovery Utilization Environ. Effects, 35(21), 2022-2032. https://doi.org/10.1080/15567036.2010.532190
  11. Kamaruddin, M.A., Yusoff, M.S., Aziz, H.A. and Hung, Y.T. (2015), "Sustainable treatment of landfill leachate", Appl. Water Sci., 5(2), 113-126. https://doi.org/10.1007/s13201-014-0177-7.
  12. Kamaruddin, M.A., Yusoff, M.S., Rui, L.M., Isa, A.M., Zawawi, M.H. and Alrozi, R. (2017), "An overview of municipal solid waste management and landfill leachate treatment: Malaysia and Asian perspectives", Environ. Sci. Pollut. Res., 24(35), 26988-27020. https://doi.org/10.1007/s11356-017-0303-9.
  13. Kim, J., Park, C., Kim, T.H., Lee, M., Kim, S., Kim, S.W. and Lee, J. (2003), "Effects of various pretreatments for enhanced anaerobic digestion with waste activated sludge", J. Biosci. Bioeng., 95(3), 271-275. https://doi.org/10.1016/s1389-1723(03)80028-2.
  14. Komemoto, K., Lim, Y.G., Nagao, N., Onoue, Y., Niwa, C. and Toda, T. (2009), "Effect of temperature on VFA's and biogas production in anaerobic solubilization of food waste", Waste Manage., 29(12), 2950-2955. https://doi.org/10.1016/j.wasman.2009.07.011.
  15. Kwietniewska, E. and Tys, J. (2014), "Process characteristics, inhibition factors and methane yields of anaerobic digestion process, with particular focus on microalgal biomass fermentation", Renew. Sust. Energ. Rev., 34, 491-500. https://doi.org/10.1016/j.rser.2014.03.041.
  16. Maharaj, I. and Elefsiniotis, P. (2001), "The role of HRT and low temperature on the acid-phase anaerobic digestion of municipal and industrial wastewaters", Bioresource Technol., 76(3), 191-197. https://doi.org/10.1016/S0960-8524(00)00128-0.
  17. Mao, C., Feng, Y., Wang, X. and Ren, G. (2015), "Review on research achievements of biogas from anaerobic digestion", Renew. Sust. Energ. Rev., 45, 540-555. https://doi.org/10.1016/j.rser.2015.02.032.
  18. Montanes, R., Solera, R. and Perez, M. (2015), "Anaerobic co-digestion of sewage sludge and sugar beet pulp lixiviation in batch reactors: Effect of temperature", Bioresource Technol., 180, 177-184. https://doi.org/10.1016/j.biortech.2014.12.056.
  19. Okudoh, V., Trois, C., Workneh, T. and Schmidt, S. (2014), "The potential of cassava biomass and applicable technologies for sustainable biogas production in South Africa: A review", Renew. Sust. Energ. Rev., 39, 1035-1052. https://doi.org/10.1016/J.RSER.2014.07.142.
  20. Oslaj, M., Mursec, B. and Vindis, P. (2010), "Biogas production from maize hybrids", Biomass Bioenergy, 34(11), 1538-1545. https://doi.org/10.1016/j.biombioe.2010.04.016.
  21. Panichnumsin, P., Nopharatana, A., Ahring, B. and Chaiprasert, P. (2010), "Production of methane by co-digestion of cassava pulp with various concentrations of pig manure", Biomass Bioenergy, 34(8), 1117-1124. https://doi.org/10.1016/j.biombioe.2010.02.018.
  22. Sawatdeenarunat, C., Surendra, K.C., Takara, D., Oechsner, H. and Khanal, S.K. (2015), "Anaerobic digestion of lignocellulosic biomass: Challenges and opportunities", Bioresource Technol., 178, 178-186. https://doi.org/10.1016/j.biortech.2014.09.103
  23. Singhal, Y., Bansal, S.K. and Singh, R. (2012), "Evaluation of biogas production from solid waste using pretreatment method in anaerobic condition", Int. J. Emerg. Sci., 2(3), 405-414.
  24. Tan, C.S., Maragatham, K. and Leong, Y.P. (2013), "Electricity energy outlook in Malaysia", IOP Conf. Ser. Earth Environ. Sci., 16(1), 012126. https://doi.org/10.1088/1755-1315/16/1/012126.
  25. Wang, Y., Zhang, Y., Wang, J. and Meng, L. (2009), "Effects of volatile fatty acid concentrations on methane yield and methanogenic bacteria", Biomass Bioenergy, 33(5), 848-853. https://doi.org/10.1016/j.biombioe.2009.01.007.
  26. Ward, A.J., Hobbs, P.J., Holliman, P.J. and Jones, D.L. (2008), "Optimisation of the anaerobic digestion of agricultural resources", Bioresource Technol., 99(17), 7928-7940. https://doi.org/10.1016/j.biortech.2008.02.044.
  27. Weiland, P. (2010), "Biogas production: Current state and perspectives", Appl. Microbiol. Biotechnol., 85(4), 849-860. https://doi.org/10.1007/s00253-009-2246-7.