Earthquakes and Structures

  • 제15권2호
  • /
  • Pages.165-178
  • /
  • 2018
  • /
  • 2092-7614(pISSN)
  • /
  • 2092-7622(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

A new method for repair of fiber reinforced concrete corbels using steel threaded rods

  • Gulsan, Mehmet Eren (Department of Civil Engineering, Gaziantep University, University Avenue, Central Campus) ;
  • Shaikhan, Mustafa A. (Department of Civil Engineering, Gaziantep University, University Avenue, Central Campus)
  • 투고 : 2017.06.22
  • 심사 : 2018.05.02
  • 발행 : 2018.08.25
⟨ 이전 논문 다음 논문 ⟩

초록

The aim of this study is to investigate the efficiency of using threaded rods and steel profiles to produce a steel confining system for rehabilitation of damaged concrete corbels for the first time in literature. Some of the specimens were repaired by crack repair epoxy before being confined for further enhancement. A total of 19 two sided damaged corbels were used in the study with different mechanical properties and parameters but similar dimensions. The differences were in rehabilitation style, shear span, fiber percentage, reinforcement steel diameter, and concrete strength. The rehabilitated specimens were loaded with vertical load until failure. Four different configurations were used in the investigation. Test results show that the proposed rehabilitation technique is effective to enhance the load capacity of the corbels and to improve their ductility. Moreover, new formulations were proposed to calculate the load capacity of the rehabilitated corbels. A good fit was observed between numerical and experimental results.

키워드

참고문헌

  1. ACI Committee E706 (2003), Structural Crack Repair by Epoxy Injection (ACI RAP bulletin 1), American Concrete Institute, Farmington Hills.
  2. Ahmad, S., Elahi, A., Kundi, S. and Haq, W. (2013), "Investigation of shear behavior of corbel beams strengthened with CFRP", Life Sci. J., 10(12), 961-965.
  3. Ahmad, S., Shah, A., Nawaz, A. and Salimullah, K. (2010), "Shear strengthening of corbels with carbon fibre reinforced polymers (CFRP)", Mater. Constr., 60(299), 79-97. https://doi.org/10.3989/mc.2010.50009
  4. Al-Fadhli, S.K.I. (2017), "Ultimate strength of concrete corbels with hybrid reinforcement and strengthened externally by carbon fiber", J. Eng. Sustain. Develop., 21(1), 89-103
  5. Belal, M.F., Mohamed, H.M. and Morad, S.A. (2015), "Behavior of reinforced concrete columns strengthened by steel jacket", HBRC J., 11(2), 201-212. https://doi.org/10.1016/j.hbrcj.2014.05.002
  6. Bournas, D.A. and Triantafillou, T.C. (2009), "Flexural strengthening of reinforced concrete columns with near-surface-mounted FRP or stainless steel", ACI Struct. J., 106(4), 495.
  7. British Standards Institution (2005), Eurocode 3: Design of Steel Structures - Part 1-1: General Rules and Rules for Buildings, London: BSI.
  8. Chalioris, C.E. (2008), "Torsional strengthening of rectangular and flanged beams using carbon fibre-reinforced-polymers-Experimental study", Constr. Build. Mater., 22(1), 21-29. https://doi.org/10.1016/j.conbuildmat.2006.09.003
  9. Dandapat, R., Deb, A. and Bhattacharyya, S.K. (2012), "Localized failure in fiber-reinforced polymer-wrapped cylindrical concrete columns", ACI Struct. J., 109(4), 445-456.
  10. Di Sarno, L., Elnashai, A.S. and Nethercot, D.A. (2006), "Seismic retrofitting of framed structures with stainless steel", J. Constr. Steel Res., 62(1), 93-104. https://doi.org/10.1016/j.jcsr.2005.05.007
  11. El-Maaddawy, T.A. and Sherif, E.A.I. (2013), "Response of concrete corbels reinforced with internal steel rebars and external composite sheets: Experimental testing and finite element modeling", J. Compos. Constr., ASCE, 18(1), 1-11.
  12. Elgwady, M.A., Rabie, M. and Mostafa, M.T. (2005), "Strengthening of corbels using CFRP: An experimental program", Cairo University, Giza, Egypt.
  13. Erfan, A.M. (2010), "Behavior of reinforced concrete corbels strengthened with CFRP fabric", M.Sc. Dissertation, Benha University, Egypt.
  14. Fattuhi, N.I. (1990), "Strength of SFRC corbels subjected to vertical load", J. Struct. Eng., 116(3), 701-718. https://doi.org/10.1061/(ASCE)0733-9445(1990)116:3(701)
  15. Fattuhi, N.I. (1994), "Strength of FRC corbels in flexure", J. Struct. Eng., 120(2), 360-377. https://doi.org/10.1061/(ASCE)0733-9445(1994)120:2(360)
  16. Gu, D.S., Wu, G., Wu, Z.S. and Wu, Y.F. (2010), "Confinement effectiveness of FRP in retrofitting circular concrete columns under simulated seismic load", J. Compos. Constr., 14(5), 531-540. https://doi.org/10.1061/(ASCE)CC.1943-5614.0000105
  17. Gulsan, M.E. (2015), "Stochastic finite element based reliability analysis of Steel Fiber Reinforced Concrete (SFRC) corbels", Ph.D. Dissertation, Gaziantep University, Gaziantep, Turkey.
  18. Hagberg, T. (1983), "Design of concrete brackets: On the application of truss analogy", ACI J., 80(1-2), 3-12
  19. Harrison, D.M. (2013), The Grouting Handbook: A Step-by-step Guide for Foundation Design and Machinery Installation, Elsevier.
  20. Hussein, A.A. (2016), "Glass fiber reinforced concrete corbels", M.Sc. Dissertation, Hasan Kalyoncu University, Gaziantep.
  21. Iacobucci, R.D., Sheikh, S.A. and Bayrak, O. (2003), "Retrofit of square concrete columns with carbon fiber-reinforced polymer for seismic resistance", ACI Struct. J., 100(6), 785-794.
  22. Issa, C.A. and Debs, P. (2007), "Experimental study of epoxy repairing of cracks in concrete", Constr. Build. Mater., 21(1), 157-163. https://doi.org/10.1016/j.conbuildmat.2005.06.030
  23. Ivanona, I. and Assih, J. (2015), "Experimental study of local behavior of strengthened reinforced concrete short corbel by bonding carbon fiber fabrics", Int. J. Struct. Civil Eng. Res., 4(1), 148-158
  24. Ivanova, I., Assih, J., Li, A., Dontchev, D. and Delmas, Y. (2015), "Experimental investigation into strengthened short reinforced concrete corbels by bonding carbon fiber fabrics", J. Adhes. Sci. Technol., 29(20), 2176-2189. https://doi.org/10.1080/01694243.2015.1060060
  25. Julio, E.N., Branco, F.A. and Silva, V.D. (2005), "Reinforced concrete jacketing-interface influence on monotonic loading response", ACI Struct. J., 102(2), 252-257.
  26. Julio, E.S., Branco, F. and Silva, V.D. (2003), "Structural rehabilitation of columns with reinforced concrete jacketing", Prog. Struct. Eng. Mater., 5(1), 29-37. https://doi.org/10.1002/pse.140
  27. Kaish, A.B.M.A., Alam, M.R., Jamil, M., Zain, M.F.M. and Wahed, M.A. (2012), "Improved ferrocement jacketing for restrengthening of square RC short column", Constr. Build. Mater., 36, 228-237. https://doi.org/10.1016/j.conbuildmat.2012.04.083
  28. Kakaletsis, D.J. (2016), "Comparative experimental assessment of seismic rehabilitation with CFRP strips and sheets on RC frames", Earthq. Struct., 10(3), 613-628. https://doi.org/10.12989/eas.2016.10.3.613
  29. Kamil, M.A. (2016), "High strength glass fiber reinforced concrete (GFRC) corbels", M.Sc. Dissertation, Gaziantep University, Gaziantep.
  30. Karayannis, C.G., Chalioris, C.E. and Sirkelis, G.M. (2008), "Local retrofit of exterior RC beam-column joints using thin RC jackets-An experimental study", Earthq. Eng. Struct. Dyn., 37(5), 727-746. https://doi.org/10.1002/eqe.783
  31. Kriz, L.B. and Raths, C.H. (1965), "Connections in precast concrete structures-strength of corbels", J. Prestress. Concrete Inst., 10, 16-61.
  32. Lehman, D.E., Gookin, S.E., Nacamuli, A.M. and Moehle, J.P. (2001), "Repair of earthquake-damaged bridge columns", ACI Struct. J., 98(3), 233-238.
  33. Ma, C.K., Apandi, N.M., Sofrie, C.S.Y., Ng, J.H., Lo, W.H., Awang, A.Z. and Omar, W. (2017), "Repair and rehabilitation of concrete structures using confinement: A review", Constr Build. Mater., 133, 502-515. https://doi.org/10.1016/j.conbuildmat.2016.12.100
  34. Macdonald, S. (2008), Concrete: Building Pathology, John Wiley and Sons.
  35. Marthong, C., Deb, S.K. and Dutta, A. (2016), "Experimental fragility functions for exterior deficient RC beam-column connections before and after rehabilitation", Earthq. Struct., 10(6), 1291-1314. https://doi.org/10.12989/eas.2016.10.6.1291
  36. Mattock, A.H., Chen, K.C. and Soongswang, K. (1976), "The behavior of reinforced concrete corbels", PCI J., 21(2), 52-77. https://doi.org/10.15554/pcij.03011976.52.77
  37. Neupane, R.C., Eddy, L. Nagai, K. (2017), "Investigation on strengthening approaches adopted for poorly detailed RC corbels", Fiber., 5(16), 1-15. https://doi.org/10.3390/fib5010001
  38. Panjehpour, M., Farzadnia, N., Demirboga, R. and Ali, A.A.A. (2016), "Behavior of high-strength concrete cylinders repaired with CFRP sheets", J. Civil Eng. Manage., 22(1), 56-64.
  39. Paulay, T., Park, R. and Phillips, M.H. (1974), "Horizontal construction joints in cast-in-place reinforced concrete", Special Publ., 42, 599-616.
  40. Peled, A. (2007), "Confinement of damaged and nondamaged structural concrete with FRP and TRC sleeves", J. Compos. Constr., 11(5), 514-522. https://doi.org/10.1061/(ASCE)1090-0268(2007)11:5(514)
  41. Shadhan, K.K. and Kadhim, M.M. (2015), "Use of CFRP laminates for strengthening of reinforced concrete corbels", Int. J. Civil Eng. Tech., 6(11), 11-20.
  42. Stoppenhagen, D.R., Jirsa, J.O. and Wyllie, L.A. (1995), "Seismic repair and strengthening of a severely damaged concrete frame", ACI Struct. . 92(2), 177-187.
  43. Urban, T. and Krawczyk, L. (2017), "Strengthening corbels using post-installed threaded rods", Struct. Concrete, 18, 303-315. https://doi.org/10.1002/suco.201500215
  44. Wu, Y.F., Yun, Y., Wei, Y. and Zhou, Y. (2014), "Effect of predamage on the stress-strain relationship of confined concrete under monotonic loading", J. Struct. Eng., 140(12), 04014093. https://doi.org/10.1061/(ASCE)ST.1943-541X.0001015
  45. Yassin, L.A.G., Sayhood, E.K. and Hasan, Q.A.M. (2015), "Reinforced concrete corbels-state of the art", J. Mater. Eng. Struct., JMES, 2(4), 180-205.
  46. Yuce, S.Z., Yuksel, E., Bingol, Y., Taskin, K. and Karadogan, H.F. (2007), "Local thin jacketing for the retrofitting of reinforced concrete columns", Struct. Eng. Mech., 27(5), 589-607. https://doi.org/10.12989/sem.2007.27.5.589
  47. Zhou, Y.W., Liu, X.M., Sui, L.L., Xing, F. and Zhou, H.J. (2015), "Stress-strain model for fibre reinforced polymer confined loadinduced damaged concrete", Mater. Res. Innov., 19(sup6), S6-125.

피인용 문헌

  1. Influence of Precast Member Corbels on Seismic Performance of Precast Beam-Slab-Column Joints vol.2021, pp.None, 2018, https://doi.org/10.1155/2021/7107569