Geomechanics and Engineering

  • 제15권2호
  • /
  • Pages.729-738
  • /
  • 2018
  • /
  • 2005-307X(pISSN)
  • /
  • 2092-6219(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Effect of clay mineral types on the strength and microstructure properties of soft clay soils stabilized by epoxy resin

  • 투고 : 2017.07.11
  • 심사 : 2017.11.27
  • 발행 : 2018.06.10
⟨ 이전 논문 다음 논문 ⟩

초록

Soft clay soils due to their various geotechnical problems, stabilized with different additives. Traditional additives such as cement and lime will not able to increase the soil strength properties significantly. So, it seems necessary to use new additives for increasing strength parameters of soft clay soils significantly. Among the new additives, epoxy resins have excellent physical and mechanical properties, low shrinkage, excellent resistance to chemicals and corrosive materials, etc. So, in this research, epoxy resin used for stabilization of soft clay soils. For comprehensive study, three clay soil samples with different PI and various clay mineral types were studied. A series of uniaxial tests, SEM and XRD analysis conducted on the samples. The results show that using epoxy resin increases the strength parameters such as UCS, elastic modulus and material toughness about 100 to 500 times which the increase was dependent on the type of clay minerals type in the soil. Also, In addition to water conservation, the best efficiency in the weakest and most sensitive soils is the prominent results of stabilization by epoxy resin which can be used in different climatic zones, especially in hot and dry and equatorial climate which will be faced with water scarcity.

키워드

참고문헌

  1. Ahmed, A. (2015), "Compressive strength and microstructure of soft clay soil stabilized with recycled bassanite", Appl. Clay Sci., 104, 27-35. https://doi.org/10.1016/j.clay.2014.11.031
  2. Ajayi, M.A., Grissom, W.A., Smith, L.S. and Jones, E.E. (1991), Epoxy-Resin-Based Chemical Stabilization of a Fine, Poorly, Graded Soil System, Transportation Research Record 1295, National Research Council, Washington, D.C., U.S.A.
  3. Al-Bayati, G., Al-Mahaidi, R. and Kalfat, R. (2017), "Torsional strengthening of reinforced concrete beams using different configurations of NSM FRP with epoxy resins and cement-based adhesives", Compos. Struct., 168, 569-581. https://doi.org/10.1016/j.compstruct.2016.12.045
  4. Al-Khanbashi, A. and Abdalla, S.W. (2006), "Evaluation of three waterborne polymers as stabilizers for sandy soil", Geotech. Geol. Eng., 24(6), 1603-1625. https://doi.org/10.1007/s10706-005-4895-3
  5. Anagnostopoulos, C.A. (2015), "Strength properties of an epoxy resin and cement-stabilized silty clay soil", Appl. Clay Sci., 114, 517-529. https://doi.org/10.1016/j.clay.2015.07.007
  6. Anagnostopoulos, C.A. and Hadjispyrou, S. (2004), "Laboratory study of an epoxy resin grouted sand", Proc. Inst. Civ. Eng. Ground Improv., 8(1), 39-45.
  7. Anagnostopoulos, C.A. and Papaliangas, T.T. (2012), "Experimental investigation of epoxy resin and sand mixes", J. Geotech. Geoenviron. Eng., 138(7), 841-849. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000648
  8. Anagnostopoulos, C.A., Stavridakis, E. and Grammatikopoulos, I. (2003), "Engineering behavior of cement acrylic resin treated soft clay", Proceedings of the International Conference on Problematic Soils, Nottingham, U.K., July.
  9. Benmokranea, B., Alia, A.H., Mohameda, H.M., ElSaftyb, A. and Manaloc, A. (2017), "Laboratory assessment and durability performance of vinyl-ester, polyester, and epoxy glass-FRP bars for concrete structures", Compos. Part B Eng., 114, 163-174. https://doi.org/10.1016/j.compositesb.2017.02.002
  10. Dash, S.K. and Bora, M.C. (2013), "Improved performance of soft clay foundations using stone columns and geocell-sand mattress", Geotext. Geomembr., 41, 26-35. https://doi.org/10.1016/j.geotexmem.2013.09.001
  11. Estabragh, A.R., Beytolahpour, I. and Javadi, A.A. (2011), "Effect of resin on the strength of soil-cement mixture", J. Mater. Civ. Eng., 23(7), 969-976. https://doi.org/10.1061/(ASCE)MT.1943-5533.0000252
  12. Ferdous, W., Manalo, A., Aravinthan, T. and Van Erp, G. (2016), "Properties of epoxy polymer concrete matrix: Effect of resin-to-filler ratio and determination of optimal mix for composite railway sleepers", Construct. Build. Mater., 124, 287-300. https://doi.org/10.1016/j.conbuildmat.2016.07.111
  13. Horpibiulsuk, S., Miura, N., Nagaraj, T.S. and Koga, H. (2002), "Improvement of soft marine clays by deep mixing technique", Proceedings of the 12th International Offshore and Polar Engineering Conference, Kitakyushu, Japan, May.
  14. Horpibulsk, S., Rachan, R., Suddeepong, A. and Chinkulkijniwat, A. (2011), "Strength development in cement admixed Bangkok clay: Laboratory and field investigations", Soil. Found., 51(2), 239-251. https://doi.org/10.3208/sandf.51.239
  15. Huat, B.B.K. (1994), "Behaviour of soft clay foundation beneath an embankment", Pertanika J. Sci. Technol., 2(2), 215-235.
  16. Impe, W.F.V. and Flores, R.D.V. (2006), "Deep mixing in underwater conditions: A laboratory and field investigation", Proc. Inst. Civ. Eng. Ground Improv., 10(1), 15-22.
  17. Kamruzzaman, A.H.M., Chew, S.H. and Lee, F.H. (2000), "Engineering behavior of cement treated Singapore marine clay", Proceedings of the GeoEng 2000: International Conference on Geotechnical and Geological Engineering, Melbourne, Australia, November.
  18. Kasama, K., Whittleb, A.J. and Zen, K. (2012), "Effect of spatial variability on the bearing capacity of cement-treated ground", Soil. Found., 52(4), 600-619. https://doi.org/10.1016/j.sandf.2012.07.003
  19. Khemissa, M. and Mahamedi, A. (2014), "Cement and lime mixture stabilization of an expansive overconsolidated clay", Appl. Clay Sci., 95, 104-110. https://doi.org/10.1016/j.clay.2014.03.017
  20. McSwiggan, C. and Fam, A. (2017), "Bio-based resins for flexural strengthening of reinforced concrete beams with FRP sheets", Construct. Build. Mater., 131, 618-629. https://doi.org/10.1016/j.conbuildmat.2016.11.110
  21. Modarres, A. and Nosoudy, Y.M. (2015), "Clay stabilization using coal waste and lime-Technical and environmental impacts", Appl. Clay Sci., 116, 281-288.
  22. Ouhadi, V.R. (1997), "The role of marl components and ettringite on the stability of stabilized marl", Ph.D. Dissertation, McGill University, Montreal, Canada.
  23. Ouhadi, V.R. and Goodarzi, A.R. (2006), "Assessment of the stability of a dispersive soil treated by alum", Eng. Geol., 85(1-2), 91-101. https://doi.org/10.1016/j.enggeo.2005.09.042
  24. Ouhadi, V.R. and Yong, R.N. (2003), "Experimental and theoretical evaluation of impact of clay microstructure on the quantitative mineral evaluation by XRD analysis", Appl. Clay Sci., 23(1-4), 141-148. https://doi.org/10.1016/S0169-1317(03)00096-6
  25. Ouhadi, V.R. and Yong, R.N. (2003a), "The role of clay fractions of marly soils on their post stabilization failure", Eng. Geol., 70(3-4), 365-375. https://doi.org/10.1016/S0013-7952(03)00104-2
  26. Ouhadi, V.R. and Yong, R.N. (2003b), "Impact of clay microstructure and mass absorption coefficient on the quantitative mineral identification by XRD analysis", Appl. Clay Sci., 23(1-4), 141-148. https://doi.org/10.1016/S0169-1317(03)00096-6
  27. Ouhadi, V.R., Yong, R.N., Amiri, M. and Ouhadi, M.H. (2014), "Pozzolanic consolidation of stabilized soft clays", Appl. Clay Sci., 95, 111-118. https://doi.org/10.1016/j.clay.2014.03.020
  28. Pakbaz, M.S. and Alipour, R. (2012), "Influence of cement addition on the geotechnical properties of an Iranian clay", Appl. Clay Sci., 67, 1-4.
  29. Petchgate, K., Jongpradist, P. and Jamsawang, P. (2004), "Field flexural behavior of soil-cement column", Proceedings of the 5th Symposium on Soil/Ground Improvement and Geosynthetics, Thonburi, Thailand,
  30. Petchgate, K., Jongpradist, P. and Panmanajareonphol, S. (2003), "Field pile load test of soil-cement column in soft clay", Proceedings of the International Symposium 2003 on Soil/Ground Improvement and Geosynthetics in Waste Containment and Erosion Control Applications, Khlong Luang, Thailand, December.
  31. Porbaha, A. (1998), "State of the art in deep mixing technology, part I: basic concepts and overview of technology", Proc. Inst. Civ. Eng. Ground Improv., 2(2), 81-92.
  32. Porbaha, A. (2002), "State of the art in quality assessment of deep mixing technology", Proc. Inst. Civ. Eng. Ground Improv., 6(3), 95-120.
  33. Sadowski, L., Czarnecki, S. and Hola, J. (2016), "Evaluation of the height 3D roughness parameters of concrete substrate and the adhesion to epoxy resin", J. Adhes. Adhes., 67, 3-13. https://doi.org/10.1016/j.ijadhadh.2015.12.019
  34. Saride, S., Puppala, A.J. and Chikyala, S.R. (2013), "Swell-shrink and strength behaviors of lime and cement stabilized expansive organic clays", Appl. Clay Sci., 85, 39-45. https://doi.org/10.1016/j.clay.2013.09.008
  35. Sasanian, S. (2011), "The behaviour of cement stabilized clay at high water contents", Ph.D. Dissertation, University of Western Ontario, London, Canada.
  36. Sukontasukkul, P. and Jamsawang, P. (2012), "Use of steel and polypropylene fibers to improve flexural performance of deep soil-cement column", Constr. Build. Mater., 29, 201-205. https://doi.org/10.1016/j.conbuildmat.2011.10.040
  37. Sukpunya, A. and Jotisankasa, A. (2016), "Large simple shear testing of soft Bangkok clay stabilized with soil-cement-columns and its application", Soil. Found., 56(4), 640-651. https://doi.org/10.1016/j.sandf.2016.07.005
  38. Tabbaa, A.A. (2003), "Soil mixing in the UK 1991-2001: State of practice report", Proc. Inst. Civ. Eng. Ground Improv., 7(3), 117-126
  39. Vichan, S. and Rachan, R. (2013), "Chemical stabilization of soft Bangkok clay using the blend of calcium carbide residue and biomass ash", Soil. Found., 53(2), 272-281. https://doi.org/10.1016/j.sandf.2013.02.007
  40. Voottipruex, P. and Jamsawang, P. (2014), "Characteristics of expansive soils improved with cement and fly ash in Northern Thailand", Geomech. Eng., 6(5), 437-453. https://doi.org/10.12989/gae.2014.6.5.437
  41. Yang, Y., Wang, G., Xie, S., Tu, X. and Huang, X. (2013), "Effect of mechanical property of cemented soil under the different pH value", Appl. Clay Sci., 79, 19-24. https://doi.org/10.1016/j.clay.2013.02.014
  42. Yi, Y., Gu, L., Liu, S. and Jin, F. (2016), "Magnesia reactivity on activating efficacy for ground granulated blast furnace slag for soft clay stabilization", Appl. Clay Sci., 126, 57-62. https://doi.org/10.1016/j.clay.2016.02.033
  43. Yilmaz, I. and Civelekoglu, B. (2009), "Gypsum: An additive for stabilization of swelling clay soils", Appl. Clay Sci., 44(1-2), 166-172. https://doi.org/10.1016/j.clay.2009.01.020

피인용 문헌

  1. Investigation on the macro- and microdeformation characteristics of silty clay under different shield construction stress paths vol.80, pp.12, 2018, https://doi.org/10.1007/s10064-021-02475-0