• Journal of Nuclear Fuel Cycle and Waste Technology(JNFCWT)
• /
• v.5 no.1
• /
• pp.39-52
• /
• 2007

Quantitative analysis on release behavior of the $^{85}Kr\;and\;^{14}C$ fission gases from the spent fuel material during the voloxidation and OREOX process has been performed. This thermal treatment step in a remote fabrication process to fabricate the dry-processed fuel from spent fuel has been used to obtain a fine powder The fractional release percent of fission gases from spent fuel materials with burn-up ranges from 27,000 MWd/tU to 65,000 MWd/tU have been evaluated by comparing the measured data with these initial inventories calculated by ORIGEN code. The release characteristics of $^{85}Kr\;and\;^{14}C$ fission gases during the voloxidation process at $500^{\circ}C$ seem to be closely linked to the degree of conversion efficiency of $UO_2\;to\;U_3O_8$ powder, and it is thus interpreted that the release from grain-boundary would be dominated during this step. The high release fraction of the fission gas from an oxidized powder during the OREOX process would be due to increase both in the gas diffusion at a temperature of $500^{\circ}C$ in a reduction step and in U atom mobility by the reduction. Therefore, it is believed that the fission gases release inventories in the OREOX step come from the inter-grain and inter-grain on $UO_2$ matrix. It is shown that the release fraction of $^{85}Kr\;and\;^{14}C$ fission gases during the voloxidation step would be increased as fuel burn-up increases, ranging from 6 to 12%, and a residual fission gas would completely be removed during the OREOX step. It seems that more effective treatment conditions for a removal of volatile fission gas are of powder formation by the oxidation in advance than the reduction of spent fuel at the higher temperature.

• Korean Journal of Food Science and Technology
• /
• v.46 no.1
• /
• pp.25-32
• /
• 2014

This study aimed to analyze the general ingredients and volatile compounds of ipguk (koji) and nuruk soju distilled under reduced pressure (RP) or atmospheric pressure (AP) conditions. After the secondary brewing process, soju made using ipguk had a final fermentation alcohol content of $18.0{\pm}0.6%$, whereas soju made using nuruk reached $14.3{\pm}1.7%$. The level of succinic acid was the highest in ipguk soju ($7,685.33{\pm}34.97$ ppm), but nuruk soju also showed a high level of succinic acid ($5,945.79{\pm}76.30$ ppm) after its final fermentation. In an analysis of fusel alcohol content, the level of n-propanol in ipguk soju (389.10-397.27 ppm) was similar under different RP (50 cm Hg and 60 cm Hg) and AP conditions ($80^{\circ}C$ and $90^{\circ}C$). Under RP and AP conditions, the isoamyl alcohol/isobutanol (A/B) ratio was similar, ranging from 1.32-1.35. In ipguk soju distilled under RP conditions of 50 cm Hg and 60 cm Hg, the amount of the toxic component, acetaldehyde, was 8.59 and 9.27 ppm, respectively. Under AP conditions, the amount of acetaldehyde in ipguk soju distilled at 80 and $90^{\circ}C$ was 9.80 and 10.63 ppm, respectively, indicating that the amount of acetaldehyde did not differ depending on the distilling method used. These results suggest that the liquor distilled from the mash produced using ipguk under RP conditions may be of a higher quality.

• Korean Journal of Food Science and Technology
• /
• v.41 no.5
• /
• pp.541-546
• /
• 2009

The objectives of this study were to evaluate the physico-chemical and sensory characteristics of a Korean traditional alcoholic beverage (yakju) prepared using different nuruk (Korean-style koji) concentrations and yeasts such as the fusant FA776 and Saccharomyces cerevisiae KOY-1, respectively. The fusant FA776, which has alcohol-fermenting and starch-utilizing properties, was formed by Saccharomyces cerevisiae KOY-1 and Saccharomyces diastaticus KCTC1804. The fermentation trial was conducted in a 5 L lab-scale jar at $25^{\circ}C$. The maximum alcohol production of the K-100 and F-50 reached levels of 135.0 mg/mL and 119.4 mg/mL, respectively. The pH values were in a range of 4.3-4.5. Total acidity was in a range of 0.47-0.60%. Organic acids and amino acids were analyzed in order to evaluate variations in its composition and content via HPLC analysis. Organic acids including lactic acid, citric acid, malic acid, and pyruvic acid, and 16 kinds of amino acids, including aspartic acid, were detected in all treatments. K-100 showed the highest amino acid contents, whereas F-50 exhibited the lowest amino acid contents. Volatile flavor components such as phenylethyl alcohol, isoamyl alcohol, 2-methylthiophane, isobutyl alcohol, and ethyl succinate were detected as a major component in all treatments, as determined via gas chromatography. The results of our sensory evaluation demonstrated that Yakju fermented by the FA776 fusant yielded more favorable results than S. cerevisiae KOY-1.

• Journal of the Korea Organic Resources Recycling Association
• /
• v.8 no.2
• /
• pp.130-139
• /
• 2000

Serial basic tests were conducted for the determination of fundamental kinetics and for the actual application of kinetic parameter to food waste digestion with precise measurement of methane production under a thermophilic condition. The effects of food particle size, sodium ion concentration, and volatile solid (VS) loading rate on the anaerobic thermophilic food waste digestion process were investigated. Results of serial test for the determination of fundamental kinetic coefficients showed the value of k (maximum substrate utilization rate coefficient) and KS (half-saturation coefficient) as $0.24hr^{-1}$ and $700mg/{\ell}$, respectively, for non-inhibiting organic loading range. No inhibition effect was shown until $5g/{\ell}$ of sodium ion concentration was applied to a serum bottle reactor. However, the volume of methane gas was decreased gradually when the concentrations of more than $5g/{\ell}$ of sodium ion applied. All sizes of food waste particle showed the same constants (A : 0.45) but the maximum substrate utilization rate constant ($k_{HA}$) was inversely proportional to particle size. As an average particle size increased from 1.02 mm to 2.14 mm, $k_{HA}$ decreased from $0.0033hr^{-1}$ to $0.0015hr^{-1}$. The result reveals that particle size is one of the most important factors in anaerobic food waste digestion. There was no inhibition effect of sodium ion when VS loading rate was $30g/{\ell}$. And maximum injection concentration of VS loading rate was determined about $40g/{\ell}$.

• Applied Biological Chemistry
• /
• v.45 no.1
• /
• pp.11-17
• /
• 2002

Fermentation characteristics with/without nitrogen source and quality of the fruit distillate of Opuntia ficus-indica var. saboten were investigated during the manufacturing process of a Korean traditional liquor. As the fermentation period increased, acidity, brix degree, and alcohol concentration increased, whereas pH and contents of reducing sugar decreased. Acidity, pH, and brix degree were higher, whereas the content of reducing sugar lower, in the nitrogen source-added distillate than in the distillate without nitrogen source. The growth of yeast increased, while that of bacteria decreased; this trend was more prominent with the addition of a nitrogen source. Sojues, distilled from two types of mashes and diluted with $H_2O$ and tails of distillate into 22% alcohol concentration, showed pH $3.7{\sim}4.0$, acidity $0.02{\sim}0.10$, and $5.4{\sim}6.1$ $^{\circ}Brix$. Analysis through GC using direct injection methods revealed common volatile flavor compounds in sojues, including acetaldehyde, acetyl acetone, acetic acid ethyl ester, ethyl alcohol, 2-propyl alcohol, acetone, n-propyl alcohol, butanoic acid methyl ester, 2-phenyl ethanol, thymol, acetic acid phenyl ester, and vanillic aldehyde. As revealed through the sensory evaluation, no significant difference (p>0.05) in overall acceptability was shown among four experimental groups, while color and flavor showed significant differences(p<0.05).

• Korean Journal of Fisheries and Aquatic Sciences
• /
• v.16 no.4
• /
• pp.363-367
• /
• 1983

Low salt fermented products of anchovy, Engraulis japonica, caught in the coasts of East Sea of Korea, were prepared tentatively and also discussed the retarding effect of rancidity of the product by the addition of BHA or red pepper. Fresh anchovies were purchased from Kichang fish market. The raw samples were mixed with $8\%$ table salt, $0.5\%$ lactic acid, $6\%$ sorbitol, $4\%$ ethyl alcohol and $0.02\%$ BHA or $0.5\%$ red pepper and filled in the glass bottles and sealed with the cap. Conventional fermented product of anchovy as a control was prepared from fresh anchovy and $20\%$ salt only. After preparation, the products were fermented for 90 days at room temperature. Amino-nitrogen, TBA value, peroxide value and viable counts of bacteria of these products were determined and also evaluation of their qualify was compared with control product by sensory evaluation during fermentation. Amino-nitrogen contents of the low salt products reached a peak in 55 days of fermentation, and the volatile basic nitrogen contents ranged $100\;mg\%$ even after 90 days of fermentation. Thiobarbituric acid value of the product with $0.02\%$ BHA showed a little increase up to 65 days of fermentation regardless of salt contents, while that of the control product increased sharply up to 65 days and then decreased gradually. BHA was effective on retarding rancidity of fermented products of anchovy and red pepper was also slightly effective. All the products showed the highest cell population in about 55 days of fermentation. Judging from the results of analysis and sensory evaluation, the low salt fermented product of anchovy could be prepared with $8\%$ salt, $0.5\%$ lactic acid, $6\%$ sorbitol, $4\%$ ethyl alcohol and $0.02\%$ BHA or $0.5\%$ red pepper to the fresh round anchovy.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.18 no.2
• /
• pp.181-188
• /
• 1989

The present study has been carried out to investigate the effect of Bactokil(made from didecyldimethyl ammonium chloride isopropanol and water) and Taipet-F (made from natural vitamin E, L-ascorbic acid, glyceride and gallic acid) on retarding lipid oxidation in boiled-dried anchovy. To process boiled-dried anchovy, boiled anchovy dried in cabinet drier $(dry-bulb\;temperature\;40^{\circ}C)$ for 1 hour were fronted with the Bactokil, the Taipet-F and mixture of Bactokil and Taipet-F, respectively. Anchovy fronted with chemicals were redried for 8 hours, packed in polyethylene film bag, and then stored at room temperature $(24{\pm}3^{\circ}C)$. These products were compared with control(untreated with chemicals) during storage. The changes in volatile basic nitrogen of each product was negligible during storage. The thiobarbituric acid and peroxide values of each product increased up to 10 days of storage, and then decreased. In color value of each product, L value increased, while n, b and ${\bigtriangleup}E$ values decreased during storage. The changes in brown pigment formation of each product increased up to final stage of storage. From the results of chemical analysis and sensory evaluation, the product treated with Taipet-F(0.5%, v/v) was the most effective on retarding lipid oxidation of the boiled -dried anchovy, followed by the product treated withthe mixture of Bactokil (0.04%, v/v) and Taipet-F (0.5%, v/v), the product treated with Bactokil(0.04%, v/v) and control, in the order named.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.43 no.10
• /
• pp.1579-1587
• /
• 2014

This study aimed to determine the quality characteristics of fermented wine using Nuruk according to the type of aging container (jar or stainless container) and aging time. Alcohol analysis was initiated at 40.4~39.3%, and alcohol contents in the jar and stainless container decreased as aging time increased. Volatile acid content slightly increased in the reduced pressure (RP) jar and stainless container and showed a different result in the atmospheric pressure (AP) container. Amount of acetic acid did not change either in the jar or stainless container as aging time increased. In the case of 2-thiobarbituric acid (TBA), RP was lower than AP after distillation, and TBA value did not change much either in the jar or stainless container. In the case of fusel alcohol by aging time, n-propanol content did not increase either in the jar or stainless container as aging time increased. Iso-butanol content was reduced in the jar but did not change in the stainless container. In the AP container, more aromatic components were measured on the 180th day of aging time than after distillation. High boiling point aromatic components increased in particular. In the stainless container, more aromatic components were generated on the 180th day of aging, but their amount was relatively lower than in the jar. In the jar aging sensory test, the sensory score at RP 50 cmHg was highest on the 180th day of aging. In the case of AP $80^{\circ}C$ liquor, sensory score on the 180th day was the most improved.

• Journal of Bio-Environment Control
• /
• v.24 no.1
• /
• pp.21-26
• /
• 2015

This study was conducted to compare the aromatic compounds and the internal quality such as total phenolic contents, DPPH activity, and vitamin C contents in two new forma (red type and dalgom) and gom-chwi (Ligularia fischeri). Total phenolic contents were indicated 137.29mg/100g fresh wt. in gom-chwi, 158.40mg/100g fresh wt. in red type, and 180.82mg/100g fresh wt. in dalgom, red type and dalgom had higher contents than gom-chwi. DPPH activities were appeared similar result in gom-chwi (74.45%) and red type (75.59%), and dalgom (86.26%) had better than others. In vitamin C contents, gom-chwi and red variety had shown very closed results but dalgom had best result (1.81mg/100g fresh wt.). Essential oil contents of red type (0.164% of fresh wt.) and dalgom (0.290% of fresh wt.) had higher contents than gom-chwi (0.060%). Analysis of major components of essential oil by GC/MSD, identified 43 compounds in gom-chwi, 44 compounds in red type, and 31 compounds in dalgom. N-containing compound only detected in dalgom. Comparison of six aromatic compounds for fragrance (a-pinene, ${\beta}$-pinene, ${\beta}$-phellandrene, a-phellandrene, 3-carene, and limonene) was indicated red type had higher contents and dalgom had lower contents than gom-chwi. Dalgom had higher contents of total phenolic, DPPH activity, vitamin C, and essential oil than red type and gom-chwi. This result had shown the dalgom had better characters for new cultivar.

• Korean Journal of Food Science and Technology
• /
• v.28 no.4
• /
• pp.762-771
• /
• 1996

Chemical and sensory characteristics of kakdugi which was prepared with various radish cultivars and harvesting seasons were analyzed during 7-day storage. Average pH of small radish cultivar kakdugi was higher than that of large ones, and total acidity was lower in small ones. Reducing sugar content was the highest in kakdugi of autumn radish. Organic acids such as lactic, succinic and fumaric acid analyzed by GC increased until the third day of fermentation, whereas volatile isothiocyanates analyzed by GC/MS continued to decline. There was a significant difference in flavor characteristics of large radish kakdugi across seasons, in contrast to no significant difference in those of small radish kakdugi except sweet taste and reducing sugar content in which interaction existed between season and cultivar. Score of overall acceptability was higher in small radish than large ones with Dongja showing the highest score of overall acceptability. Overall acceptability of autumn Dongja kakdugi was positively correlated with radish kakdugi odor and sour odor, respectively, but negatively with total acidity, lactic acid content, sweet taste and pungency, respectively. By multiple regression analysis, overall acceptability in spring Dongja kakdugi is expressed as a function of overall acceptability = -0.1115 + 1.2519 savory taste + 1.5159 malic acid -0.0054 total isothiocyanate + ${\varepsilon}$.