• Proceedings of the Korean Institute of Surface Engineering Conference
• /
• 2015.11a
• /
• pp.148-150
• /
• 2015

최근 가압경수로 핵연료는 다양한 형태의 원자로의 개발 및 다양한 운전 방식을 요구한다. 장주기 운전이 가능한 고연소도 핵연료의 지속적인 성능 개선이 필요하다. 핵연료에서 가연성 중성자 흡수체(Burnable absorber-BA) 역할은 매우 중요하다. 다양한 원자로 및 다양한 운전방식을 대비하여 BA 제조에 유연성을 고려하면 핵연료 피복관 내부에 직접 코팅하는 것이 바람직하다. 이에 피복관 내부표면에 직접 금속도금이 가능 여부와 기존에 많이 사용하던 전해도금에서 발생되는 기포에 의한 불균질한 도금(핀홀) 문제점 해결 방안을 고안하였다. 본 연구에서는 초임계 이산화탄소와 전해도금액간의 초음파 교반을 통한 강한 진동에 의해 매크로 에멀젼을 형성시켜 피 도금 물질 표면에 얇은 막을 얻는 도금 방법을 적용하였다. 초임계 유체를 이용한 전해도금을 적용한 결과 균질한 얇은 도금 막을 증착 시켰으며, 기포에 의한 핀홀 현상을 억제하였다. 또한 전해도금액의 사용량을 최소화 하여 폐수 발생 문제를 개선하였다.

• Tribology and Lubricants
• /
• v.34 no.2
• /
• pp.43-48
• /
• 2018

This paper presents the thermohydrodynamic analysis of tilting journal pad bearings supporting a power turbine rotor applied to a 250 kW super-critical $CO_2$ cycle. In the analysis, the generalized Reynolds equation and 3D energy equation are solved to predict oil film temperature and the 3D heat conduction equation is solved for pad temperature. The power turbine rotor is supported by two tilting pad bearings consisting of five pads with an oil supply block between the pads. Copper backing pads with higher thermal conductivity compared to steel backing pads are adopted to improve thermal management. The predicted maximum pad temperature is around $55^{\circ}C$ which is approximately $15^{\circ}C$ higher than oil supply temperature. In addition, the predicted minimum film thickness is 50 mm at a rotating speed of 5,000 rpm. These results indicate that there is no issue in the thermal behavior of the bearing. An operation test is performed with a power turbine module consisting of a power turbine, a reduction gear and a generator. Thermocouples are installed at the 75% position from the leading edge of the pad to monitor pad temperature. The power turbine uses compressed air at a temperature of $250^{\circ}C$ in its operation. The steady state pad temperatures measured in the test show good agreement with the predicted temperatures.

• Journal of the Korean Institute of Gas
• /
• v.18 no.5
• /
• pp.26-32
• /
• 2014

CCS(Carbon Capture and Storage) which is technic to capture and storage the carbon-dioxide is the method that reduces the carbon-dioxide from the industries to prevent earth from the global warming. In order to apply to the practical site, it is inevitable to investigate the possibility of damage in the pipe or components by carbon-dioxide. In this paper, the immersion test is performed to estimate the suitability of the rubber which is used to seal or connect the pipelines because the rubber has not been validated. Also, the immersion test is carried out in a certain condition(pre- and supercritical state).

• Applied Chemistry for Engineering
• /
• v.33 no.1
• /
• pp.44-49
• /
• 2022

Essential oil was separated from Dendropanax morbiferus (DM) by means of hot water extraction and supercritical extraction, respectively, and the separated essential oil was analyzed qualitatively and quantitatively, and the antioxidant effect of essential oil was investigated. In addition, yields of essential oil and Caryophyllene according to the drying and extraction methods for each part of DM were obtained and compared, respectively. The yield of essential oil was found to be high in the order of bark > leaves > twigs > limb. When the freeze-dried DM leaves were supercritically extracted, the yields of essential oil and Caryophyllene were 23.2 g/kg DM and 429.6 mg Caryophyllene/kg DM, respectively. The essential oil of DM showed an antioxidant effect even at a low concentration, and the concentration of the essential oil of SC₅₀, which means 50% of 2,2-diphenyl-1-picrylhydrazyl (DPPH) radical scavenging activity, was about 0.34%.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.38 no.4
• /
• pp.423-429
• /
• 2009

This study was conducted to investigate the effects of pine (Pinus densiflora) needle extracts on hepatic antioxidative system in rats fed high-cholesterol diet. Eight-week old Sprague Dawley rats were divided into four groups; normal diet group (CON), 0.5% cholesterol diet group (0.5% CHOL), 0.5% cholesterol diet and pine needle extracts prepared by using hot water group (HOT water), and 0.5% cholesterol diet and pine needle extracts prepared by using sub-supercritical $CO_2$ group (Sub-supercritical). The serum ALP, AST, and ALT activities were increased by 0.5% cholesterol diet supplementation, but treatment with pine needle extracts showed decrease compared with 0.5% CHOL group. The SOD activity in liver at 0.5% cholesterol diet group was more decreased than control group while Sub-supercritical group had significantly higher SOD activity than 0.5% CHOL group. Moreover, groups with pine needle extracts supplementation had higher level of GPx in liver than 0.5% cholesterol diet group. These results suggest that pine needle extracts increased antioxidative activities.

• Journal of the Korea Institute of Building Construction
• /
• v.17 no.3
• /
• pp.253-260
• /
• 2017

As global warming became a worldwide issue, a significant effort has been made on the development of technology related to $CO_2$ capture and storage. Geologic sequestration of $CO_2$ is one of those technologies for safe disposal of $CO_2$. Geologic sequestration stores $CO_2$ in the form of supercritical fluid into the underground site surrounded by solid rock, and concrete is used for prevention of $CO_2$ leakage into the atmosphere. In such case, concrete may experience severe damage by attack of supercritical $CO_2$, and especially in contact with underground water, very aggressive form of carbonation can occur. In this work, to prevent such deterioration in concrete, calcium phosphates were added to the portland cement to produce hydroxyapatite, one of the most stable mineral in the world. Temperature rise, viscosity, set and stiffening, and strength development of cement paste incorporating three different types of calcium phosphates were investigated. According to the results, it was found that the addition of calcium phosphate increased apparent viscosity, but decreased maximum temperature rise and 28 day compressive strength. It was found that monocalcium phosphate was found to be inappropriate for portland cement based material. Applicability of dicalcium and tricalcium phosphates for portland cement needs to be evaluated with further investigation, including the long term compressive strength development.

• Journal of Physiology & Pathology in Korean Medicine
• /
• v.36 no.2
• /
• pp.54-58
• /
• 2022

This study aimed to investigate the anti-stress function of Aucklandiae Radix (AR) and Cyperi Rhizoma (CR). The essential oils used in the experiment were extracted from AR and CR using Steam Distillation Extraction and Super critical CO₂ extraction. To observe the effects of sample administration, we measured feed intake, leukocytes, red blood cells, hemoglobin, platelets, serum serotonin content, immobility time, climbing time, and swimming time in mice subjected to chronic restraint stress as behavioral changes. The average body weight of all experimental groups increased than the average body weight of the control group. The immobility and climbing times of experimental groups A and B administered with supercritical extraction samples were shorter than those of the other experimental groups and the control group, and the swimming time was longer. The serotonin content in the blood of all experimental groups decreased compared to the normal group, and the serotonin content of the control group was increased. The authors suggest that Korean herbal medicines AR and CR may be utilized as anti-stress flavoring agents based on the above results.

• Tunnel and Underground Space
• /
• v.22 no.4
• /
• pp.266-275
• /
• 2012

In this study, a method is devised to implement a supercritical $CO_2$ ($scCO_2$) injection environment on a laboratory scale and to investigate the effects of $scCO_2$ on the properties of rock specimens. Specimens of shale and sandstone normally constituting the cap rock and reservoir rock, respectively, were kept in a laboratory reactor chamber with $scCO_2$ for two weeks. From this stage, a chemical reaction between rock surface and the $scCO_2$ was induced. The effect of saline water was also investigated by comparing three conditions ($scCO_2$-rock, $scCO_2-H_2O$-rock and $scCO_2$-brine(1M)-rock). Finally, we checked the changes in the properties before and after the reaction by destructive and nondestructive testing procedures. The swelling of shale was a main concern in this case. The experimental results suggested that $scCO_2$ has a greater effect on the swelling of the shale than pure water and brine. It was also observed that the largest swelling displacement of shale occurred after a reaction with the $H_2O-scCO_2$ solution. The results of a series of the destructive and nondestructive tests indicate that although each of the property changes of the rock differed depending on the reaction conditions, the $H_2O-scCO_2$ solution had the greatest effect. In this study, shale was highly sensitive to the reaction conditions. These results provide fundamental information pertaining to the stability of $CO_2$ storage sites due to physical and chemical reactions between the rocks in these sites and $scCO_2$.

• Bulletin of the Korean Chemical Society
• /
• v.32 no.9
• /
• pp.3348-3354
• /
• 2011

Oleanolic acid (OA) as template molecule, polyamide-6 (PA6) as basement membrane and poly(styrene-comaleic acid) (PSMA) were used to prepare PA6/PSMA-OA molecularly imprinted composite membranes by phase inversion method in supercritical $CO_2$ ($ScCO_2$). The template molecule (OA), [poly(styrene-co-maleic anhydride) (PSMAH), PSMA, molecularly imprinted membranes (MIMs) imprinting OA and MIMs after elution were all characterized by Fourier transform infrared spectroscopy (FTIR). The conditions that were the mass ratio between PSMA and OA from 3:1 to 8:1, temperature of $ScCO_2$ from $35^{\circ}C$ to $50^{\circ}C$ and pressure of $ScCO_2$ 12 MPa to 17 MPa were studied. It was obtained the largest adsorption rate and purity of OA after adsorption of the resultant MIMs, 50.41% and 96.15% respectively. After using PA6 film and non-woven fabrics as basement membrane respectively, it was found that smaller aperture of PA6 was used as basement membrane, a higher adsorption rate and a higher purity of OA after adsorption of the MIMs were obtained, and so were the stability and reproducibility of the resultant MIMs. After template molecules being removed, the MIMs had effective selectivity hydrogen bonding to separately bind in the binary components to the template molecules-oleanolic acid.

• Food Engineering Progress
• /
• v.15 no.2
• /
• pp.175-181
• /
• 2011

By using supercritical carbon dioxide fluid, an attempt was made to extract surface-active substances from defatted rice bran. Extraction was carried out according to D-optimal design and results were analyzed by response surface methodology to establish optimum condition. It was found that pressure, temperature and co-solvent (ethanol) influenced in a different extent on the extraction efficiency (i.e., yield and interfacial tension) of surface-active substances. Among them, co-solvent was found to be a major influencing factor, where maximum yield (2.62%) was observed at the highest content (250 g). In addition, it also affected most on the interfacial tension at the oil-water interface but in this case the lowest interfacial tension value (9.51 mN/m) was found when added lowest (50 g). In conclusion, it was estimated that the optimum extraction condition was to be pressure 350bar, temperature $62^{\circ}C$ and co-solvent content 50 g in this study, where extraction yield was 0.69% and interfacial tension to be 10.1 mN/m.