• Journal of the Korean Wood Science and Technology
• /
• v.50 no.3
• /
• pp.179-185
• /
• 2022

This study investigated the prospect of using peanut shells as an alternative and green sound-absorbing material. The sound-absorption coefficients were determined after filling impedance tubes of 30, 60, and 90 mm in height with peanut shells. The sound-absorption ability increased as the filling height increased, showing noise reduction coefficient (NRCs) of 0.23, 0.43, and 0.54 for the 30-, 60-, and 90-mm heights, respectively. In addition, for sounds greater than 2,000 Hz, the average sound-absorption coefficient of peanut shells in the 60- and 90-mm heights was 0.9. In summary, peanut shells were found to have good sound-absorption properties comparable to or better than those of bamboo, sisal, jute, and wool, and this research suggests that peanut shells may be useful as an environmentally friendly sound-absorbing material.

• Korean Journal of Food Science and Technology
• /
• v.36 no.4
• /
• pp.643-647
• /
• 2004

Natural antimicrobial substance from peanut (Arachis hypogaea) shells was isolated and structurally elucidated. Peanut shells were extracted with methanol (MeOH) and concentrated in vacuo, MeOH extract was solvent-fractionated with ethyl acetate (EtOAc) and various buffer to obtain EtOAc acidic, neutral, and phenolic fractions. EtOAc neutral fraction, which showed antimicrobial activity, was purified through silica gel adsorption column, Sephadex LH-20 column, ODS column, and high performance liquid chromatographies, and its active substance was isolated and identified as pratensein (3',5,7-trihydroxy-4'-methoxyisoflavone) by spectroscopic methods of proton-nuclear magnetic resonance, mass spectrometry, and nuclear overhauser enhancement spectroscopy.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.34 no.7
• /
• pp.1114-1117
• /
• 2005

The effects of far-infrared (FIR) irradiation and heat treatment on the antioxidant activity of extracts from peanut shells was evaluated. Peanut shells were placed in pyrex petri dishes (8.0cm diameter) and irradiated at $150^{\circ}C$ for 5, 10, 15, 20, 40 or 60min with a FIR heater. After FIR irradiation or simple heat treatment at same conditions, methanol extracts of peanut shells were prepared and total phenol contents (TPC), radical scavenging activities (RSA) and reducing powers of the extracts were determined. The antioxidant activities of the extracts increased as the time of heating or FIR-irradiation increased. When peanut shells were FIR­irradiated at $150^{\circ}C$ for 5 min, the values of TPC, RSA, and reducing power of the extracts increased from 40.17mg/mL to 42.30mg/mL, $67.7\%\;to\;76.3\%$, and 0.569 to 0.639, respectively, compared to the untreated controls. Simple heat treatment of peanut shell under the same conditions $(150^{\circ}C\;for\;5min)$ also increased the TPC, RSA, and reducing power of the extracts from 40.17mg/mL to 43.52mg/mL, 67.7\%\;to\;79.3\%$ and from 0.569 to 0.623, respectively. The results indicate that appropriate FIR-irradiation or heat treatment on peanut shells could increase the antioxidant activities of methanolic extracts.

• Food Science and Biotechnology
• /
• v.16 no.1
• /
• pp.116-122
• /
• 2007

Four compounds with antioxidant activity were isolated from the MeOH extract of peanut shells (pod) and identified as 5,7-dihydroxychromone (1), eriodictyol (2), 3',4',7-trihydroxyflavanone (3), and luteolin (4) by electron impact-mass spectrometry (EI-MS) and nuclear magnetic resonance (NMR) analyses. The relationship between antioxidant activity and chemical structure of the isolated compounds with their analogues [(-)-epicatechin, quercetin, taxifolin] was examined by measuring 1,1-diphenyl-2-picrylhydrazyl (DPPH) radical-scavenging activity and using the 2-deoxy-D-ribose degradation system. The order of antioxidant activity on the basis of DPPH radical-scavenging was quercetin = (-)-epicatechin (6.0 molecules) > taxifolin (4,5 molecules) > 4 (luteolin; 4.0 molecules) > 2 (eriodictyol; 2.5 molecules) > 3 (3',4',7-trihydroxy-flavanone; 2.0 molecules) > 1 (5,7-dihydroxychromone; 0.5 molecules). On the other hand, using the 2-deoxy-D-ribose degradation system, the order of antioxidant activity was quercetin > 4 >> (-)-epicatechin ${\geq}\;2\;{\geq}$ taxifolin > 3 > 1. These compounds from peanut shells may provide defensive measures against oxidative stress and insects in the soil.

• Journal of Nutrition and Health
• /
• v.54 no.1
• /
• pp.116-128
• /
• 2021

Purpose: The extraction conditions for bioactive components from peanut shells, which is a byproduct of peanut processing, were optimized to enhance the total phenolic content (TPC, Y1), total flavonoid content (TFC, Y2), and 2,2-diphenyl-1-picrylhydrazyl radical scavenging activity (RSA, Y3). In addition, this study evaluated the anti-obesity effect of peanut shell extract. Methods: Optimization of ultrasonic-assisted extraction (UAE) was performed using a response surface methodology. The independent variables applied for extraction were time (X1: 5.0-55.0), temperature (X2: 26.0-94.0), and ethanol concentration (X3: 0.0%-99.5%). Quadratic regression models were derived based on the results of 17 experimental sets, and an analysis of the variance was performed to verify its accuracy and precision of the regression equations. Results: When evaluating the effects of independent variables on responses using statistically-based optimization, the independent variable with the most significant effect on the TPC, TFC, and RSA was the ethanol concentration (p = 0.0008). The optimal extraction conditions to satisfy all three responses were 35.8 minutes, 82.7℃, and 96.0% ethanol. Under these conditions, the inhibitory activities of α-glucosidase and pancreatic lipase by the extract were 86.4% and 78.5%, respectively. Conclusion: In this study, UAE showed superior extraction efficiency compared to conventional hot-water extraction in the extraction of polyphenols and bioactive materials. In addition, α-glucosidase and pancreatic lipase inhibitory effects were identified, suggesting that peanut shells can be used as effective antioxidants and anti-obesity agents in functional foods and medicines.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.46 no.4
• /
• pp.279-283
• /
• 2001

The content and composition of tocopherol were analyzed in peanuts produced in Korea. The tocopherol assay was consisted of an extraction with n-hex-ane:isopropanol mixture followed by high pressure liquid chromatography with fluorescence detection. Tocopherol content was higher in leaves and seeds but lower in seed coats and shells. $\alpha$-/${\gamma}$- Tocopherol ratio was as low as 0.53 in seeds and as high as 22.5 in shells. Tocopherol content in seeds of nine varieties ranged from 142 to 220 ng/mg dry weight, and the $\alpha$-/${\gamma}$-tocopherol ratio from 0.40 to 0.75. Tocopherol content decreased by 18% but $\alpha$-/${\gamma}$-tocopherol ratio increased by 44% in roasted seeds. The results indicate that the level of tocopherol in Korean peanut varieties is moderate and the ratio of $\alpha$- to ${\gamma}$-tocopherol is low.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.28 no.2
• /
• pp.240-247
• /
• 1983

Heritability of flowering date, length of main stem, weight of 100 grains and number of shells per square meter in peanut were high with low local variation. There was positive genotypic correlation between length of main stem and yield, No. of shells per square meter and matured seed ratio, No of shells per square meter and yield 100 grain weight and yield but was negative genotypic correlation between flowering date and yield. With the view of path-coefficients, length of main stem, number of shells per square meter showed highly direct effects at.. all locations.

• Proceedings of the Korean Society of Crop Science Conference
• /
• 2018.04a
• /
• pp.70-70
• /
• 2018

• Journal of the Korean Wood Science and Technology
• /
• v.26 no.3
• /
• pp.48-52
• /
• 1998

Residues such as walnut, pinenut and peanut shells were used as a filler in adhesive for bonding radiata pine plywood. The nutshell residues were prepared by simply drying to 8% moisture content and grinding the dry material using a laboratory Wiley mill with a $75{\mu}m$ (200 mesh) screen. The nutshells residues were compared to a commercial filler commonly used in adhesives by the structural plywood and laminated veneer lumber industry in the United States. The adhesive mixes were made by following the recommended procedure of Georgia-Pacific Resins, Inc., using phenol-formaldehyde resin. For each filler type, three-ply plywoods, 6 mm nominal thickness and 30 by 30 cm in size, were fabricated at two press times (4 and 5 min) and around 30 minute assembly time. Evaluations of the nutshell residues were carried out by tension shear tests after cyclic boil tests on plywood. The results of the performance test included tension shear strength and wood failure. All plywoods made with the nutshell fillers were comparable to those made with the control filler. These results indicate that nutshell residues would be suitable as filler for plywood adhesives.

• Korean Journal of Plant Resources
• /
• v.1 no.1
• /
• pp.1-7
• /
• 1988

This experiment were carried out to study the heritability, genotypic, pheno-typic and environmental correlation in four edible oil crops. Heritabilities of flowering date, maturing date, plant height and weight of 1, 000 grains in rape were high. A highly significant positive correlation was found between flowering date and maturing date, plant hight and ear length, number of pods per ear and flowering date, maturing date and plant hight, The number of seed per pod showed also significant positive correlation with flowering or maturing date as well as with the relationship between weight of 1, 000 grains and plant height or ear length inrapeseed, respectively. Heritabilities of maturing date, length of stem with eapsule and number of seed per capsule were high, in sesame. Genotypic correlation between plant height and length of stem with capsule, length of stem with capsule and number of capsule per plant, number of capsule per plant and weight of 1, 000 grains, weight of 1, 000 grains and yield were highy positive in sesame. Heritabilities of flowering date, length of main stem, weight of 100 grains and number of shells per square meter in peanut were high, There was positive genotypic correlation between length of main stem and yield, number of shells per quare meter and matured seed ratio, number of shells per square meter and yield, 100 grains weight and yield. On the other hand, a significant negative correlation appeared between flowering date and yield. Heritabilities of days to flowering, stem length, stem diameter and weight of 1, 000 grains in perila were high. There was positive genotypic correlation between stem length and stem diameter, number of pods per plant, stem weight etc, between number of internodes and number of pods per plant, stem weight, number of valid branches and number of pods plant as well, respectively. While, a significant negative correlation was observed between number of valid branches and weight of 1, 000 grains, between number of pods per plant and weight of 1, 000 grains.