• Journal of Environmental Health Sciences
• /
• v.13 no.1
• /
• pp.17-33
• /
• 1987

As a result of technical advances and industrialization, the characteristics of domestic and industrial wastes are becoming more complex. Accordingly, improved treatment and disposal systems are being continuously sought to take account of complex characteristics and to comply with economic restrictions. In this study, an application of pyrolysis to the treatment of industrial wastes, including waste scrap rubber, waste raw material used in making the slipper bottom and waste PVC pipe, and the effectiveness of pyrolysis in resource recovery from these wastes were investigated. Batches of wastes were pyrolysed by external heating to a temperature of 400-800$\circ$C in a 32 mm diameter x 0.9 m long silica tube to produce combustible gases, oils and chars. Before the start of pyrolysis runs, the entire system was purged with nitrogen gas to exclude the air. The temperature inside the retort was controlled by the thermocouple in the gas stream, and referred to as the pyrolysis temperature. Under these conditions three products were separately collected and further analyzed. The results were summarized as follows. 1. More gases and less chars were produced with higher pyrolyzing temperature and with higher rates of heating, but the yields of oils tended downwards at temperatures above 700$\circ$C. Accordingly, operating conditions of pyrolysis should be varied with desired material. 2. Calorific values and sulfur contents of produced oils were sufficient and suitable for fuel use. Chars from waste rubber had high heating values with low sulfur contents, but calorific values of chars from waste PVC and waste slipper were as low as 3, 065-4, 273 kcal/kg and 942-2, 545 kcal/kg, respectively. Therefore, char from these wastes are inappropriate for fuel. 3. Soluble contents of Pb, Cd, Cu and Zn in chars from waste rubber and waste slipper were below the Specific Hazardous Waste Treatment Standards. However soluble contents of Pb and Cd in chars from waste PVC were one or two times and five or seven times exceedingly the Specific Hazardous Waste Treatment Standards, respectively. 4. Post high heating is desirable for treatment method of waste PVC which generates toxic hydrogen chloride. 5. The proportions of hydrogen, methane and ethane in produced gases were in the range of 3.99-35.61% V/V, 18.22-32.50% V/V and 5.17-5.87% V/V, respectively. 6. Pyrolysis is a useful disposal method in case of waste slipper, which was hardly combustible, and thus investigations of this kind of materials are required for effective management of industrial waste. 7. Based upon the possible market development for products, overall pyroly economics to take account of treatment values of noncombustible or hazardous materials should be evaluated.

• Korean Journal of Soil Science and Fertilizer
• /
• v.11 no.3
• /
• pp.195-206
• /
• 1979

Where the industrial waste is increasing in number of kind and in quantities by the industrialization and population increases, the pollution problem is not only national but grobal question of the day. This paper is trying to invite attentions by the people who are working in both sector-natural sciences and industries in reviewing limited reports and materials. 1. By the chemical evaluation of over 20 industrial waste produced in Korea, potential wastes for commercial fertilizer would be wastes from alcohol fermantation, beer brewery, leather processing, synthetic fiber, and coffee grounds. 2. The composition of city waste is differ from other countries and sludge cake from human feces processing is promising one in the organic matter and phosphate content particularly. However, the content of heavy matals, specific order, and availability of phosphate are the bottle-neck for the development. 3. There is one commercial fertilizer from industrial waste in the market. It is very reasonable in the content of nitrogen and organic matter, and its formulation and responeses on crops. 4. Discussions were also given on the general problems in processing and marketing of fertilizers from industrial waste, however, scientists and industrial owners have to pay more attention on the development of fertilizers from tire industrial wastes because of vital environmental protection view-point.

• 수도
• /
• s.64
• /
• pp.34-41
• /
• 1993

• Magazine of the Korea Concrete Institute
• /
• v.13 no.4
• /
• pp.118-125
• /
• 2001

• 보일러설비
• /
• s.67
• /
• pp.114-115
• /
• 1999

• Applied Chemistry for Engineering
• /
• v.4 no.3
• /
• pp.576-582
• /
• 1993

In order to investigate the inhibition of anaerobic digestion with alcohol-distillery wastes, batch anaerobic digestion experiments were conducted. Both naked-barley based and rice based alcohol-distillery wastes were separated into soluble organic fractions and suspended solids fraction using diafiltration with ceramic membranes. Each fraction of retentates and permeates, and the raw alcohol-distillery wastes were used as feeds for the anaerobic digestion study. The suspended solids fraction from the naked-barley stillages had produced much more propionic acid than the soluble organic fractions or raw alcohol-distillery wastes. The inhibition of anaerobic digestion for naked-barley alcohol-distillery wastes may be due to the higher productions of propionic acid with solids fraction of the wastes.

• Journal of the East Asian Society of Dietary Life
• /
• v.9 no.1
• /
• pp.55-63
• /
• 1999

This research was conducted to estimate waste rates of 69 food items after pre-preparation and amounts of food wastes disposed and it's reduction effect by education in some institutional foodservices for reduction of the food wastes. The result are as follows: 1. The waste rates were 55.40% for sweet corn, 5.73% for potatoes, 19.14% for sweet potatoes, and 33.47% for chestnuts. 2. The waste rates of fruits were 0.21-49.36%. Food items with over 40% waste rate were banana, watermelon, and pineapple. 3. The waste rates of vegetables were 1.14-52.90%. The number of foods with under 10% waste rate were 14 items(red pepper, green pepper, chard, and so on), 10-20% was 9 items(perilla leaf, chinese cabbage, ginger root, and so on), 20-30% was 5 items(root of chinese bellflower, garlic, radish-leaves, burdock, welsh onion-large type), 30-40% was 3 items(shepherd's purse, head lettuce, kale) and over 40% was 3 items(water dropwort, crown daisy, mallow). 4. The waste rates were 24.30% in chicken, 9.53-13.79% in eggs, and 9.30-55.32% in fishes. The waste rates of vegetables and fishes were higher than those of other food groups. 5. There were significantly different in amount of food wastes disposed (g/person/day) to institutional foodservices (hospital＞industrial institution＞ Korean restaurant＞elementary school). The amount of food wastes disposed, especially amount in pre-preparation phase, after education for reduction of food wastes was significantly reduced. Since these study results show significant deviations in food waste rates and education effect, there should be more studies for standard waste rates of each food and systematic education method for reduction of food wastes.

• Journal of environmental and Sanitary engineering
• /
• v.13 no.3
• /
• pp.9-18
• /
• 1998

An experimental research was conducted to establish primary data for the stabilization assessment of industrial wastes landfill with analysis of waste components and investigation of leachate and gas generation, using three sets of lysimeter as experimental apparatus. Comparing results of lysimeter from data of landfill, it is suggested that lysimeter of this study can be used to accomplish the stabilization assessment of the real landfill site. Moisture content was lower as landfill period was older and combustible component was the highest in lysimeter C. The C/N ratio of waste was 7.4~14.4 and, with the elemental analysis, the theoretical gas generation rate based on the modified Buswell equation was 0.47~0.49 $m^3/kg-dry$ waste in lysimeter C. Considering the C/N ratio of leachate, it is concluded that the addition of carbon source is needed to biodegrade leachate hereafter. Gas generation rate($m^3/kg-dry$ waste) from lysimeter A, B and C was 0.0009, 0.014 and 0.0067, respectively, and different from each other according to the landfill period of wastes. The results in this study show that the biodegradation of microorganism for stabilization of landfill was inhibited and more activated in acidogenic step than in methanogenic of anaerobic degradation.

• Resources Recycling
• /
• v.9 no.1
• /
• pp.3-14
• /
• 2000

In order to prospect current recycling status in Korea, wastes generation and recycling rate were reviewed. Approximately 188,600 ton/day of wastes was generated in 1998; 44,600 ton/day of domestic waste and 144,000 ton/day of industrial waste. During the last five years, waste management laws such as recycling law and environment friendly industry law were prepared. In this article, concerning over waste generation and recycling, the problems and technological developments associated with recycling were summarized.

• Proceedings of the Korea Society for Energy Engineering kosee Conference
• /
• 1993.05a
• /
• pp.20-32
• /
• 1993

Although the importance of agricultural sector decreased over the last several decades because of the economic growth in Korea led by the development of manufacturing sector, the biomass energy resources such as urban wastes, industrial wastes including agricultural residues emerged recently as a major target of development mainly because of environmental issues. (omitted)