• Journal of Biosystems Engineering
• /
• v.9 no.2
• /
• pp.65-73
• /
• 1984

While most of researches on the performance of high temperature grain dryer have dealt mainly with improving dryer capacity and drying speed during the last twenty years, energy efficiency, in fact, has not been emphasized. Current fuel supplies and energy cost have shifted the emphasis to reducing the energy consumption for grain drying while maintaining dryer capacity and grain quality. Since the energy input for drying is relatively large, the recovery and reuse of at least part of the exhaust energy can significantly reduce the total energy consumption in existing drying systems. Unilization of exhaust heat in grain dryer either through direct recycling or by a thermal coupling in heat exchanger have been subject of a number of investigators. However, very seldom research in Korea has been done in this area. Three drying tests(non-recycling, 0.22 recycle ratio, and 0.76 recycle ratio)were performed to investigate the thermal efficiency and heat loss factors of continuous flow type dryer, and to analyze the effect of recycle ratio (weight of exhaust air recycled/total weight of input air) on the energy requriements for rough rice drying. The test results showed that when the exhaust air was not recycled, the energy lost from furnace was 15.3 percent of input fuel energy, and latent and sensible heat of exhaust air were 61.4 percent and 11.2 percent respectively. The heat which was required in raising grain temperature and stored in dryer was relatively small. As the recycle ratio of exhaust air was increased, the drying rate was suddenly decreased, and thermal efficiency of the kerosene burner was also decreased. Drying test with 0.76 recycle ratio resulted in 12.4% increase in fuel consumption, and 38.4% increase in electric power consumption as compared to the non-recycled drying test. Drying test of 0.22 recycle ratio resulted in 6.8% saving in total energy consumption, 8.0% reduction in fuel consumption, and 2.5% increase in electric power consumption as compared to the non-recycled drying test.

• Korean Journal of Agricultural Science
• /
• v.48 no.1
• /
• pp.103-117
• /
• 2021

The severe effects of climate change, such as global warming and the El Niño phenomenon, have become more prevalent. In recent years, natural disasters such as drought, heavy rain, and typhoons have taken place, resulting in noticeable damage. Korea is affected by droughts that cause damage to rice fields and crops. Societal interest in droughts is growing, and measures are urgently needed to address their impacts. As the demand for high-quality agricultural products expands, farmers have become more interested in water management, and the demand for field irrigation is increasing. Therefore, we investigated water demand in the irrigation of drought-vulnerable crops. Specifically, we determined the water requirements for crops including cabbage, red pepper, apple, and bean in four regions by calculating the consumptive water use (evapotranspiration), effective rainfall, and irrigation capacity. The total consumptive water use (crop evapotranspiration) estimates for Dangjin-si (cabbage), Yesan-gun (apple), Cheongyang-gun (pepper) in Chungnam, and Goesan-gun (bean) in Chungbuk were 33.5, 206.4, 86.1, and 204.5 mm, respectively. The volumes of groundwater available in the four regions were determined to be the following: Dangjin-si, 4,968,000 m³; Yesan-gun, 4,300,000 m³; Cheongyang-gun, 1,114,000 m³, and Goesan-gun, 3,794,000 m³. The annual amounts available for the representative crops, compared to the amount of evapotranspiration, were 313.9% in Dangjin-si, 29.5% in Yesan-gun, 56.1% in Cheongyang-gun, and 20.1% in Goesan-gun.

• Journal of the FoodService Safety
• /
• v.2 no.1
• /
• pp.44-50
• /
• 2021

Physicochemical and antioxidant properties of the three different calorie types of HMR curry rice using fermented turmeric were analyzed in this study. The general tumeric added sample groups showed significantly higher carbohydrate content than the fermented turmeric sample group. In all sample groups, the ratio of protein, fat, and carbohydrate was found to be appropriate according to the nutritional composition ratio as one meal recommended by the Ministry of Health and Welfare. The brightness L value of the general turmeric-added sample group was measured to be significantly brighter than the fermented turmeric-added sample group. The fermented turmeric sample group showed a slightly lower pH value than the general sample group due to organic acids generated during fermentation. As a result of analyzing the radical scavenging activity of ABTS, LFTC, MFTC, and HFTC of the fermented turmeric group were 40.20, 40.46, and 36.16%, respectively, compared to those 32.41, 37.75, and 36.16% of LNTC, MNTC and FNTC of the general sample groups, respectively, consistently indicating that more free radicals were generated in the fermented sample group (p<0.01). Relatively unstable to heat and acid, DPPH scavenged radicals showed similar results to those of ABTS radical scavenging activity in terms of activity. Similar results were also shown in the measurement of total flavonoid and phenol content, which are known to have antioxidant antiviral and anticancer effects. Thus we could conclude that pilot products of the high quality varied calorie levels of HMR Bibimbap set with tumeric, which is helpful for antioxidant action have been developed to meet various customer needs.

• Journal of Mushroom
• /
• v.20 no.3
• /
• pp.183-185
• /
• 2022

High-income mushroom crops require complex farming. Therefore, we conducted a test to identify the optimum temperature for the production of antler-shaped Ganoderma lucidum using the King Oyster mushroom cultivation facility. T-N showed 0.28% of oak sawdust and 2.2% of nutritional source. The pH of oak sawdust was 6.0, indicating weak acidity, and that of rice steel was 6.6, indicating neutrality in nutrition source. Study on the quality characteristics of mushrooms showed that the number of days at 25℃ were 5~6 and those at 30℃ were 3~5; the representative length at 25℃ was 57.5 mm and that at 30℃ was 92.2 mm; the biological weight at 25 ℃ was 43 g, which was greater than that at 30℃.

• KOREAN JOURNAL OF CROP SCIENCE
• /
• v.52 no.2
• /
• pp.146-152
• /
• 2007

The present study was carried out to investigate the potential acute toxicity of ethanol extracts of the aleurone layer of Oryza sativa cvs. Obongbyeo, Ilpumbyeo, and Aranghyangchalbyeo by a single oral dose in ICR mice. The test article was orally administered once by gavage to male and female mice at dose levels of 0, 2.5, 5.0, and 10.0 g/kg body weight (n=10 for male and female mice for each dose). We examined numbers of deaths, general signs, weight measurement and biochemical analysis for sexes and doses of mice control and experimental groups. All mice were alive during the experimental period so can not yield death rate and $LD_{50}$. Any significant clinical symptom was not observed in all treated groups. No significant body weight changes in treatment groups in comparison with those of control groups was observed at any dose levels in experimental groups. Plasma glucose levels were valued both control and treated groups and there were no significant differences between groups. The activities of ALT and AST were not increase in all sample treated groups when compared with the control groups. The results suggest that the toxicity of Oryza sativa cvs. Obongbyeo, Ilpumbyeo, and Aranghyangchalbyeo are low and its $LD_{50}$ is over 10.0 g/kg body weight in both male and female mice.

• Microbiology and Biotechnology Letters
• /
• v.39 no.1
• /
• pp.56-62
• /
• 2011

We investigated quality characteristics of Seoktanju (one of the Korean traditional rice wine) which was fermented using five kinds of Korean commercial Nuruks. The purpose of this study was to research what effects on the quality of Seoktanju by using different Nuruks. We analyzed general component such as each mash's temperature change patterns, pH, titrable acidities, reducing sugar contents, volatile acids, and sugar contents during fermentation periods and studied sensory evaluation of produced Seoktanju (10 days). On the whole, temperature change patterns in the each mashes were depend on room temperature. All Seoktanju's pH was reduced rapidly up to three days after first mashing (pH 3.13-3.57) and after that was increased gradually. The end of fermentation pH was pH 3.6-4.05. Mostly, acidities were indicated high(0.59%) and Nuruk-B was showed highest acid value. These results seems to be different as occasion organic acids producing activity depend on the number of yeast, material contents, optimal temperature in the each mashes by fungi and lactic acid bacteria in Nuruks. In reducing sugar contents and sugar contents, Nuruk-C treatment were showed the highest value with 5.36%, $23^{\circ}brix$, respectively and alcohol content was lowest with 8.6%. In the five kinds of reproduced Seoktanju, alcohol content was the highest in the treated Nuruk-A group. Volatile acid value was the highest with 132.6~263.7 ppm at the 3 day after first mashing day but as the fermentation time goes on, it was reduced sharply by 5.25~5.94 ppm. Sensory evaluation was performed with 5 point scale, the Seoktanju using Nuruk-D was presented by 4 point, while Nuruk-A was presented lowest by 2.77 point on overall acceptability.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.46 no.1
• /
• pp.61-67
• /
• 2017

Chia seed (Salvia hispanica L.) originated from Central America is a highly nutritious food containing large amounts of linolenic acid, dietary fiber, and protein. This study investigated the quality properties and antioxidant activities of Sulgidduk prepared with chia seed powder as a functional material. Freeze-dried chia seed powder was replaced with 0, 1, 3, 5, and 7% of rice flour. The addition of chia seed powder did not affect water content, whereas the pH value of the chia seed group decreased as compared to the control. For color measurements, a and b values increased as the amount of chia seed powder increased, whereas L value decreased. Hardness and chewiness of Sulgidduk with chia seed powder were lower than those of the control, whereas springiness of the chia seed group was higher than that of the control. Cohesiveness was not significantly different in all samples. According to retrogradation analysis based on changes in hardness during storage, it was confirmed that addition of chia seed powder inhibited aging of Sulgidduk. Retrogradation of CSP5 was the slowest. Consumer acceptability analysis did not show significant differences in all samples. Total polyphenol and flavonoid contents tended to significantly increase as chia seed content increased. DPPH and ABTS radical scavenging activities of Sulgidduk were also elevated due to addition of chia seeds. From the results, addition of chia seed softened texture, inhibited aging, and enhanced antioxidant activities of Sulgidduk. It is concluded that addition of 5% chia seed powder, which showed high effectiveness for aging, is the most suitable for commercialization.

• Journal of Animal Science and Technology
• /
• v.47 no.5
• /
• pp.769-782
• /
• 2005

Twenty four Holstein steers fed commercial concentrates with rice straw(T1), mixed grass hay(T2), or wet brewer’s grains based TMR ad libitum(T3) were used to investigate the effects of roughage feeding type during the growing and early-fattening periods on growth performance, feed efficiency and carcass characteristics. Growth performance and feed efficiency were investigated during the feeding trial conducted from 6 to 23 mo of age, and carcass characteristics were investigated after slaughter. Body weight at slaughter and daily gains were 751 to 802 kg(mean 782 kg) and 1.064 to 1.159 kg/d(mean 1.122 kg/d), respectively, showing that those for T2 were highest followed by T3. Compared with T1, the daily gain for T2 was improved by 8.9%. The TDN intakes per kg gain were 6.87, 7.17 and 7.15 kg for T1, T3 and T2, respectively, indicating that feed efficiency for T2 was improved(approx. 5%) compared with T1. The feeding treatments did not change dressing percentage(mean 60.8%), back fat thickness(6.68 mm) and rib-eye area(84.0$cm^2$). Neither meat quality characteristics nor physicochemical properties were significantly different among the treatments. However, economic analysis accounting for 882.8, 991.7 and 943.8 thousand won per head for T1, T2 and T3, respectively, indicated that T2 and T3 increased(7-12%) total net income compared with T1. Therefore, it may be concluded that high quality meat of Holstein steers can be produced if they are fattened until 23 mo of age and that feeding mixed grass hay as roughage or TMR containing mainly wet brewer's grains during the growing and early-fattening periods can improve growth performance compared with feeding rice straw.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.42 no.2
• /
• pp.212-222
• /
• 2013

We studied the eating habits and sleeping patterns of 682 middle and high school students in their third year in Gwangju. According to the body mass index (BMI) of the subjects, obesity (over weight) was significantly higher in the third graders of high school students ($20.8{\pm}4.0$, 32.9%) than middle school students ($19.4{\pm}3.8$, 14.2%) (p<0.001). In addition, 71.1% of high school students experienced a lack of sleep compared to 48.8% of middle school students (p<0.001). There was a difference between good and bad sleepers in the number of times they ate snacks and the quantity of their snacks. Good sleepers had more fruit and dairy products (e.g. fruit juice 2~4 times (p<0.05), milk 2~4 times (p<0.001), apples 2~4 times, strawberries 2~4 times (p<0.01), and bananas 2~4 times a week), while bad sleepers consumed more beverages, frozen desserts, flour-based foods, fast food, bread, and rice cake. Bad sleepers clearly consumed snacks more frequently. From analyzing the correlations between sleep quality and snack intake, eating fruits 2~4 times a week (30 g~200 g/once) and drinking dairy products 2~4 times a week (120 mL~400 mL/once) appears to promote better sleeping habits.

• Journal of Nutrition and Health
• /
• v.9 no.1
• /
• pp.43-50
• /
• 1976

This is the report of a food consumption survey of 193 members of 30 farm families in three rural villages of Korea. From a total of 188 households of the three villages, namely Wolgok in Kyunggi Do Province, Wachon in Kangwon Do Province, and Sobong in Cholla Namdo Province, 30 households were chosen for the survey. Four consecutive seasonal surveys, beginning in the autumn, November 1974 and finishing with the summer, August 1975, were made and each survey covered three consecutive days. The Precise Weighing Method was used in evaluating the kinds of food and nutrient intakes of the subjects. This method entails the accurate weighing of all foods by the investigator just prior to their consumption by the subjects under investigation. This survey was male to determine the actual food eaten by the members of these farm families at each season of the year, and to note any special differences in the foods consumed. The results obtained are summarized as follows: Food Intake The traditional ordinary diet of Korean farmers consists mainly of rice and other cereals as staple foods, and simple subsidary foods. The nutritional shortcomings of rice as a staple food are evident in the subclinical status of nutritional deficiencies. The mean consumption of cereals and their products was very high and it was more than half of the daily total food intake throughout all the seasons. The consumption of animal food, fruits, and fat by the farmers was very low. Fruit intake during winter and spring was almost nil. One of the special foods in the Korean dietary pattern is Kim-chi, a variety of pickled and fermented vegetables. The mean intake of Kim-chi during autumn and winter was very much higher than the other seasons. Korean farmers have difficulties in balanced year-round supply of food due to seasonality of food production and lack of food preservation. As nutrition problems of Korean farmers are highly influenced by seasonal variations, the expansion of an appropriate food preservation and storage programme should be encouraged. Special consideration should be given to new methods of preservation, the types of foods preserved, and production and consumption of nutritionally valuable foods for the improvement of the nutritional status in rural communities. Nutrient Intake Average adult rates for calorie and protein in the three study areas were 0.80 and 0.87 respectively, with little variations by villages. The adult caloric intake in averaged 2,928 kcal for autumn, 2,662 for winter, 2,673 for spring, and 2,760 for summer. Cereals contributed most of the total calories. In terms of the recommended daily dietary allowances for the Korean given by the Korea FAO Association, the diets in this survey were adequate except in the winter and spring. The protein intake averaged from 76.4 grams in autumn to 83.4 grams in summer and was near the recommended allowance, but a relatively large proportion of the total protein came from cereals and their products. The fat intake was unsatisfactory, ranging from 19.2 grams to 29.3 grams for the four seasons, and the consumption during farming season was higher than other seasons. It is apparent that the diet of the Korean farmers should be supplemented by calcium during autumn and winter. The highest calcium intake, with a mean of 583.5 milligrams, was recorded in summer. The mean intake of iron ranged from a low of 9.2 milligrams in the autumn to a high of 15.0 milligrams in the spring and it was satisfactory for all seasons. Among the vitamin group, the daily average intakes of vitamin A, thiamine, riboflavin, and ascorbic acid were lower than the desired intake throughout all the seasons. The mean vitamin A intake as ${\beta}-carotene$ ranged from a low of 2,807.8 IU to a high of 5,221.0 IU. The thiamine intake ranged from 0.98 milligrams to 1.19 milligrams, while mean riboflavin intake ranged from 0.92 milligrams to 1.13 milligrams. Ascorbic acid intake was 37.3 milligrams, the lowest, and the highest 47.8 milligrams. Niacin intake among Korean farmers was higher than the recommended allowance throughout all the seasons, and the mean intake ranged from 18.3 milligrams to 25.8 milligrams. The main character of the Korean farmers' diet has been found low in quality of protein and high in carbohydrate. Attention should be paid to the low intake of vitamin A, thiamine, riboflavin, and ascorbic acid among Korean farmers.