• 한국식품과학회지
• /
• 제31권2호
• /
• pp.285-292
• /
• 1999

시판 된장중에 보존제로 사용되는 소르빈산과 안식향산 측정방법을 품질관리에 응용할 수 있도록 신속하고 실용적인 분석방법을 검토한 결과는 다음과 같다. 소르빈산과 안식향산을 기체크로마토그래피로 분석할 때, HP-FFAP(acid modified polyethylene) wide bore 모세관 칼럼을 사용하여 분리능을 크게 개선할 수 있었으며, 전체 분리에 소요되는 분석시간은 기체크로마토그래피의 오븐 온도를 $200^{\circ}C$로 조절하면 충진칼럼에서와 비슷한 시간대에서 정량분석이 가능하였다. 된장중에 함유된 소르빈산과 안식향산을 자동 수증기 증류장치를 이용하여 추출하면 분석에 소요되는 시간을 기존의 수증기 증류에 소요되는 시간보다 약 80% 정도 단축시킬 수 있었다. 표준물질 첨가법에 따라 회수율을 측정한 결과 자동수증기 추출장치에서 소르빈산은 98.1%, 안식향산은 99.9%이었다. 시판 된장중의 소르빈산 함량을 측정한 결과 14개의 검체중에서 3개의 시료에서 $466{\sim}530ppm$ 범위의 농도를 갖고 있었으며, 안식향산은 모든 시료에서 $0.3{\sim}4.4ppm$ 정도로 검출되었다.

• 분석과학
• /
• 제34권1호
• /
• pp.23-35
• /
• 2021

In order to measure the volatile organic compounds (VOCs) of a sample which is too large to use commercially available chamber, a stainless steel vacuum chamber (VC) (with an internal diameter of 205 mm and a height of 50 mm) was manufactured and the temperature of the chamber was controlled using an oven. After concentrating the volatiles of the sample in the chamber by helium gas, it was made possible to remove residual volatile substances present in the chamber under reduced pressure ((2 ± 1) × 10-2 mmHg). The chamber was connected to a purge & trap (P&T) using a 6 port valve to concentrate the VOCs, which were analyzed by gas chromatography-mass spectrometry (GC-MS) after thermal desorption (VC-P&T-GC-MS). Using toluene, the toluene recovery rate of this device was 85 ± 2 %, reproducibility was 5 ± 2 %, and the detection limit was 0.01 ng L-1. The method of removing VOCs remaining in the chamber with helium and the method of removing those with reduced pressure was compared using Korean drinking water regulation (KDWR) VOC Mix A (5 μL of 100 ㎍ mL-1) and butylated hydroxytoluene (BHT, 2 μL of 500 ㎍ mL-1). In case of using helium, which requires a large amount of gas and time, reduced pressure ((2 ± 1) × 10-2 mmHg) only during the GC-MS running time, could remove VOCs and BHT to less than 0.1 % of the original injection concentration. As a result of analyzing volatile substances using VC-P&T-GC-MS of six types of cell phone case, BHT was detected in four types and quantitatively analyzed. Maintaining the chamber at reduced pressure during the GC-MS analysis time eliminated memory effect and did not affect the next sample analysis. The volatile substances in a cell phone case were also analyzed by dynamic headspace (HT3) and GC-MS, and the results of the analysis were compared with those of VC-P&T-GC-MS. Considering the chamber volume and sample weight, the VC-P&T configuration was able to collect volatile substances more efficiently than the HT3. The VC-P&T-GC-MS system is believed to be useful for VOCs measurement of inhomogeneous large sample or devices used inside clean rooms.

• 생명과학회지
• /
• 제15권5호
• /
• pp.840-846
• /
• 2005

본 연구는 식품의 안전성에 대한 관심이 고조되면서 위생적인 식육생산을 위한 방법으로 전자선을 조사하여 이화학적 특성 및 지방산화에 미치는 영향을 조사하고자 실시하였다. 공시재료는 한우암소 지육중 육질등급 1+판정(근내지방도 No.7. 육색 No.4, 성숙도 No.1, 조직감 No.1)을 받은 지육($280\∼300kg$) 6두를 구매하였다. 구매한 원료지육을 1차 수도물로 고압수세하고 2차 $ 50\% $에틸알콜로 소독한 후 발골 정형하여 실험재료로 사용하였다. 모든 처리에서 가열온도가 높아갈수록 포화지방산의 함량이 높아갔다. PBS는 가열온도에 따른 지방산패에서 전자선 비조사구와 조사구 모두 가열온도가 높을수록 높은 지방산 패도를 나타내 었고(P<0.05), OBS 또한 malonsldehyde양이 증가하였다(p<0.05). 가열온도별로는 $ 60^{\circ}C $에 비하여 $ 80^{\circ}C $가 비조사구와 3, 6 kCy 조사구는 약 2배정도의 MA량이 생성되었다(p<0.05). OBS가 PBS보다 많은 양의 malonaldehyde가 생성되었으며, 전자선 조사 수준의 차이에는 수준에 따라 비조사구와 약간의 차이만 나타내었다. 전자선조사수준과 가열온도가 증가함에 따라 콜레스테롤 산화물의 발생량이 증가하였으며, 또한 가열방법 중 PBS가 OBS에 비하여 산화의 정도가 유의적으로 증가하였다(p<0.05).

• 한국식품조리과학회지
• /
• 제16권6호
• /
• pp.652-662
• /
• 2000

섭취 빈도가 높은 어류중 붉은 살 생선인 고등어(Mackerel), 삼치(Saury pike), 방어(Yellowtail), 연어(Salmon), 흰 살 생선인 조기 및 염장조기(Croaker, Salted Croaker), 및 갈치(Trichiurus)를 시료로 하여 , 가스그릴, 전기그릴과 microwave oven으로 가열 조리한 후 일정기간 동안 냉장 및 냉동 보존한 시료와 보존한 시료를 microwave로 재가열하였을 때 변이원성을 in vitro test로 Ames/salmonella assay를, in vivo test 로 Micronucleous test를 실시하여 검색하고, 그 제어방법으로 항암성분을 많이 함유하고 있는 녹황색 채소즙으로 전처리하여 돌연변이 억제능을 검토하고자 한다. 또한, 지질의 과산화도를 측정하여 변이원 생성과 과산화 지질간의 상관성을 검토한 결과는 다음과 같다. 1.어류의 가열조리에 의해 대조군(생시료)보다 변이원성이 유의적으로 증가되었는데 , 생성된 변이원은 모두 농도 의존성을 나타내었으며, 5 mg/plate인 농도구간에서 돌연변이원성이 유의적으로 높게 나타났다(p<0.05). 2. 조리온도가 높아질수록 변이원성이 유의적으로 높아졌으며 대사활성물질을 첨가했을 경우 무첨가시보다 2-4 배정도 돌연변이원성이 높게 나타났다. 3. 조리기기에 따른 복귀 돌연변이 균수는 가스그릴과 전기그릴군 간에는 유의적인 차이가 없었으나 MW에서 조리한 시료의 경우에는 유의적으로 낮게 나타났다(p<0.05). 4. 생선 종류별 변이원성을 검색한 결과 흰살 생선이 붉은 살 생선에 비해 유의적으로 낮은 변이원성을 나타내었으며, 붉은 살 생선간에 유의적인 차이는 나타나지 않았으나 고등어가 약간 높은 변이원성을 나타내었고, 흰살 생선중에서도 유의차는 없었으나 염장조기가 가장 낮은 변이원성을 나타내었다. 5. 채소즙 및 녹차 추출물로 처리 후 가열조리을 한 시료의 경우 모두 대조군에 비해 유의적으로 변이원성이 억제되었으며, 녹차>생강＞무순으로 변이원성 억제효과가 나타났다. 6. 저장에 의해 돌연변이원성이 유의적으로 증가하였는데, 냉장 저장시 저장 3일째부터, 냉동저장시에는 저장 7일째부터 변이원성이 유의적으로 증가하였다. 냉동저장보다 냉장저장시 더 높은 변이원성을 나타내었고 MW에 의한 재가열에 의해 변이원성이 증가되었다. 7. Micronucleus test 결과, 조리온도가 증가할수록 골수 소핵 형성이 유의적으로 증가되었고, 채소즙 처리군의경우 생강>녹차＞무순으로 골수 소핵 형성 억제효과를 보였다. 8. 조리, 재가열 및 저장 조건에 따른 산패도(TBA value)를 측정한 결과 저장기간이 길어질수록 산패도가 증가하였고 냉장 저장시료의 경우 저장 3일째부터 유의 적으로 산패도가 증가되었으며 냉동 저장 시료의 경우에 는 저장 7일째부터 유의적으로 높은 산패도를 나타내었다. 냉장저장 시료가 냉동저장 시료보다 더 높은 산패도를 나타내었으며, microwave에 의한 재가열에 의해 산패도가 증가되었다. 9. 채소즙 및 녹차 추출물로 처리 한 고등어의 DPPH에 대한 전자공여능(%EDA)측정 결과는 양파>녹차＞생강>양배추 순으로 양파의 전자공여능이 가장 높게 나타났다. 10.전기그릴 26$0^{\circ}C$에서 조리한 시료의 냉장저장 및 냉동저장에 따른 변이원성과 과산화지질 생성간의 상관관계는 냉장 저장했을 때 0.93으로 높은 상관관계를 나타내었고 재가열했을 경우 0.98로 상관관계가 더 높게 나타났다. 냉동저장 역시 0.92를 나타내어 상당히 높은 상관관계를 나타내었으나 재가열했을 경우에는 0.89로 오히려 낮은 상관관계를 보였다.

• 한국축산식품학회지
• /
• 제30권1호
• /
• pp.73-86
• /
• 2010

The current study was designed to optimize solid phase microextraction (SPME)-GC-MS conditions for extraction and analysis of volatile components for Hanwoo beef and to establish a tentative database of flavor components. Samples were taken from Hanwoo longissimus muscle (30 mon old steer, $1^+B$ carcass grade) at 24 h postmortem. Results indicated that the optimum adsorption time for $75{\mu}m$ CAR/PDMS fiber was 60 min at $60^{\circ}C$. Thermal cleaning at $250^{\circ}C$ for 60 min was the best practice for decontamination of the fiber. A short analysis program with a sharp oven temperature ramp resulted in a better resolution and higher number of measurable volatile components. With these conditions, 96 volatile compounds were identified with little variation including 22 aldehydes, 8 ketones, 31 hydrocarbons, 12 alcohols, 8 nitrogen- and sulfurcontaining compounds, 5 pyrazines and 10 furans. A noticeable observation was the high number of hydrocarbons, aldehydes, ketones, alcohols and 2-alkylfurans which were generated from lipid decomposition especially the oxidation and degradation of unsaturated and saturate fatty acids. This implies that these compounds can be candidates for flavor specification of highly marbled beef such as Hanwoo flavor.

• 한국환경과학회지
• /
• 제17권5호
• /
• pp.479-484
• /
• 2008

The application of microwave technology has been investigated in the remediation of diesel-contaminated soil. The paper deals with economic assessment by means of cost analysis and degradation characteristics at different microwave powers for total petroleum hydrocarbon (TPH) in diesel contaminated soils. The soils from S Mountain around the D University were sampled. The samples were screened with 2.0 mm mesh and dried for 6 hours before the diesel was added into the dried soils. The diesel-contaminated soil (3,300 mg THP/kg soil) was prepared with diesel (S Co.). The drying process was carried out in a microwave oven, a standard household appliance with a 2,450 MHz frequency and 700 W of power. The experiments were conducted from 0 to 20 minutes as the microwave powers increased from 350W to 500W to 700W. The concentrations of TPH were analysed using a gas chromatography/mass spectrometer (GC/MS). The initial concentration of TPH was 3,300 mg TPH/kg soil. The weight of contaminated soil was 200g. The concentration of TPH was decreased to 1,828 mg TPH/kg soil (44.7%), 1,347 mg TPH/kg soil (59.2%) and 1,014 mg TPH/kg soil (69.3%) at 350W, 500W and 700W for 15 minutes respectively. In addition, the curve was best fit with first order kinetics using the least-square method. The ranges of a first order rate constant k and r-square were $0.0298{\sim}0.0375min^{-1}$ and $0.9373{\sim}0.9541$ respectively.

• 가정과삶의질연구
• /
• 제24권5호
• /
• pp.89-99
• /
• 2006

The purpose of this study was to devise guidelines for the kitchen workspace of the aged by examining current usage. To achieve this objective, surveys were conducted and measurement were taken between June 15 and lune 30, 2005. The data were gathered from 50 women over 65- years-old who live in the downtown and suburbs of Seoul, Korea. The collected data were processed using SPSS 12.0 for Microsoft Windows and resulted in the following conclusions: The kitchen for the aged needs to be laid out in ㄱ-shape and the refrigerator needs to be positioned prominently. The height of the work counter is relative to the user's height (${\times}0.49{\sim}056$). and the length varies depending on the available space of the house and the type of work counter needed: however it was found that it should be at least 270cm Concerning the depth of the work counter, the standard sizes (60cm) currently on the market did not cause any inconvenience. It was found that the sink must be designed to allow for some space at the bottom so as to ensure comfortable sedentary work. Also, an electrical oven was preferred over a gas-fuelled one. Finally, the height of the upper cabinet should be relative to the user's height at ${\times}0.85{\sim}1.0$ from the floor to the bottom of the cabinet.

• 에너지공학
• /
• 제19권3호
• /
• pp.163-170
• /
• 2010

소결버너를 이용한 표면점화는 제철공정에서 철광석의 소결을 위한 중요한 공정 중 하나이다. 본 연구에서는 듀얼 타입 소결 버너의 연소 특성을 분석하기 위하여 실험실적 규모의 실험과 전산 해석을 수행하였다. 라디칼 측정을 통해 연소특성을 파악하였으며, 열전대를 이용한 실험과 전산 해석 결과를 검증하였다. 검증된 전산 해석 모델을 바탕으로 싱글타입 소결 버너와 듀얼 타입 소결버너의 연소를 비교하였으며, 노즐 간격과 각도가 연소에 미치는 영향을 분석하기 위하여 3가지 노즐 간격 및 4개의 노즐 각도에 대한 전산해석을 수행하였다. 듀얼 타입이 싱글 타입 소결 버너보다 넓고 균일한 화염 폭을 형성함을 확인하였으며, 45도 비대칭 노즐 간격이 소결 베드 표면 점화를 위한 최적의 화염 폭을 형성함을 확인할 수 있었다.

• 한국산업보건학회지
• /
• 제5권2호
• /
• pp.172-183
• /
• 1995

The airborne concentrations of the welding fumes produced during $CO_2$ arcwelding process at shipbuilding, shiprepairing, container manufacturing and car accessary manufacturing industry were investigated. The effects how much reduced the welding fume were checked when the portable fan was used. The results were as follows; 1.The geometric mean of welding fume concentration in shipbuilding factory was $10.05mg/m^3$. This exposure concentration was higher than other 3 manufacturing industries at 95% confidence level. 2. The sampling filters for welding fume could be digested with acid within 1 hour by microwave oven. The recoveries for investigated metal elements were all over 95%. 3. The optimal wavelength could be selected for the simultaneous analysis of 8 metal elements by ICP(Inductively Coupled Plasma). 4. Noxious gases($O_1,NO_2$) produced during $CO_1$ gas arc welding process were detected that the concentration of ozone($O_1$) was less than 0.01 ppm and that of nitrogen dioxide($NO_2$) was 0.01-0.03 ppm. 5. The geometric mean of welding fume particle diameter was $1.26{\mu}m$ and geometric standard deviation was 1.51 for the counts when particle an analyzer(ELZONE) had been used. 6. When the portable fan had been used,the reduced percent of total welding fume for workers was about 47.8% when portable fan was applied to blow and 71.7% when to exhaust.

• Advances in environmental research
• /
• 제4권3호
• /
• pp.143-153
• /
• 2015

The ventilation system is a key device to ensure both healthful indoor air quality (IAQ) and thermal comfort in buildings. The ventilation system should make the IAQ meet the standards such as ASHRAE 62. This study deals with a new approach to modeling the ventilation and IAQ requirement in residential buildings. In that approach, Elite software is used to calculate the air supply volume, and CONTAM model as a multi-zone and contaminant dispersal model is employed to estimate the contaminants' concentrations. Amongst various contaminants existing in the residential buildings, two main contaminates of carbon dioxide ($CO_2$) and carbon monoxide (CO) were considered. CO and $CO_2$ are generated mainly from combustion sources such as gas cooking and heating oven. In addition to the mentioned sources, $CO_2$ is generated from occupants' respirations. To show how that approach works, a sample house with the area of $80m^2$ located in Tehran was considered as an illustrative case study. The results showed that $CO_2$ concentration in the winter was higher than the acceptable level. Therefore, the air change rate (ACH) of 4.2 was required to lower the $CO_2$ concentration below the air quality threshold in the living room, and in the bedrooms, the rate of ventilation volume should be 11.2 ACH.