This research was carried out to obtain the fundamental data for the development of the technology and practical use of far-infrared radiation(IR) drying of quarter-sliced decorative veneers of walnut and red oak. The average drying rates of IR drying were about one and half to four times those of kiln drying and this tendency was prominent in thin veneer. The end wavinesses of the IR-dried veneers were smaller than those of kiln-dried veneers. These were largely recovered by the cold treatments after drying. The consumed electric power for IR drying was about one-fifth to two-fifthes compared to that for kiln drying.
This study was carried out to investigate the effect of grain and veneer thickness on drying rate, required energy consumption, and drying defects such as checking, end waving, and burning during a far-infrared radiation drying process of decorative veneers of hard maple and beech. Most of the veneer could be dried from green to in-use moisture content within 30 to 360 seconds. The drying rates were significantly affected by veneer thickness, but there was little difference between edge-and flat-sliced veneers. The formation of checking during drying test was none or very slight. The percentages of the veneers defected by checks were higher in the flat-sliced veneers than in the edge-sliced veneers. The maximum end wavinesses in the flat-sliced veneers were almost 1.6 to 3 times larger than that in the edge-sliced veneers. All veneers were fee from burned marks during drying test.
본 시험은 우리나라에서 원적외선을 이용한 이탈리안 라이그라스 인공건초 조제 가능성을 확인하기 위해 수행되었다. 본 시험에 사용된 기계는 온도, 송풍량, 원적외선 방사량을 조절할 수 있는 원적외선 건조기로 5월에 수확한 이탈리안 라이그라스를 대상으로 실시하였다. 건조를 위한 조건은 전체 9개의 조건을 선택하여 수행하였으며 각각의 조건은 방사율 42~45 %로 설정을 하였으며 내부 온도는 65℃로 설정하였다. 기기내의 기류의 속도는 40~60m/s로 하였으며, 전체적인 건조시간은 방사량 42%는 30분, 43%는 25분 그리고 45%는 20분으로 하여 수행하였다. 각각의 건조조건에 따른 최종 건물함량은 평균 88.5%로 나타났으며 전처리에서 건초에 적합한 건물함량을 나타내었다. 건조 조건에 따른 전력 소비량을 보면 45% 방사량에서 20분간을 건조한 처리구에서 가장 낮게 나타났다. 건조율에 있어서는 1~5번 건조 조건에서는 차이가 없었으나 6~7조건에서는 유의적으로 낮은 경향을 보였다. 사료가치에 있어서는 대부분의 건조조건에서 원물보다 CP, IVDMD는 높았고 ADF, NDF 함량은 낮게 나타났으며 대체적으로 4, 7 및 8번 건조 조건에서 높은 경향을 보였다. 이상의 결과를 통하여 건조속도, 전력량, 품질 등을 고려할 때 7 및 8번 건조조건이 가장 유리한 것으로 판단되었다.
In this study, the antibacterial effect was evaluated to determine the benefits of high speed drying (HSD) and far-infrared radiation drying (FIR) compared to the freeze drying (FD) method. Citrus press-cakes (CPCs) are released as a by-product in the citrus processing industry. Previous studies have shown that the HSD and FIR drying methods are much more economical for drying time and mass drying than those of FD, even though FD is the most qualified drying method. The disk diffusion assay was conducted, and the minimum inhibitory concentration (MIC) and minimum bactericidal concentration (MBC) were determined with methanol extracts of the dried CPCs against 11 fish and five food-related pathogenic bacteria. The disk diffusion results indicated that the CPCs dried by HSD, FIR, and FD prevented growth of all tested bacteria almost identically. The MIC and MBC results showed a range from 0.5-8.0 mg/mL and 1.0-16.0 mg/mL respectively. Scanning electron microscopy indicated that the extracts changed the morphology of the bacteria cell wall, leading to destruction. These results suggest that CPCs dried by HSD and FIR showed strong antibacterial activity against pathogenic bacteria and are more useful drying methods than that of the classic FD method in CPCs utilization.
In the present study, a suitable drying method was developed for citrus press cakes (CPCs), which are produced as a by-product in citrus juice plants, and the protective effect of methanol extract of CPCs prepared by far-infrared radiation (FIR) drying against $H_2O_2$-induced DNA damage was evaluated versus that of freeze-dried CPCs. Methanol extract of FIR-dried CPCs exhibited comparatively good ROS scavenging activity versus the freeze-dried CPCs at the concentration of 100 ${\mu}g$/mL. The extract strongly enhanced the cell viability against $H_2O_2$-induced oxidative damage in Vero cells. Lipid peroxidation inhibitory activity of the extract from FIR-dried CPCs was comparable to that of the extract from freeze-dried CPCs. This sample also exhibited good protective effects against $H_2O_2$-mediated cell apoptosis as demonstrated by decreased apoptotic body formation in the nuclear staining with Hoechst 33342. In the comet assay, the CPC extracts exhibited strong inhibitory effects against $H_2O_2$-mediated DNA damage in a dose-dependent manner. Thus, this study demonstrated that FIR drying effectively preserves CPC as a functionally important natural antioxidant source and the FIR drying can be adapted for drying CPCs and is more economical for massive production than freeze drying.
Efficiency of a far-infrared radiation (FIR) dryer for drying of citrus by-products (CBPs) was evaluated through their antioxidant activities. The CBPs dried through FIR were enzymatically digested by six carbohydrases (AMG, Celluclast, Pectinase, Termamyl, Ultraflo and Viscozyme) to prepare digests for evaluation of the activities. The total polyphenolic and total flavonoid contents of the digests were determined by colorimetric assays. The AMG digest was selected for the further experiments. The antioxidant potential of the digests were evaluated by DPPH, superoxide, hydroxyl and alkyl radical scavenging activities, $H_2O_2$ scavenging activity, metal chelating, lipid peroxidation inhibition and the reduction of DNA damage. The AMG digest from CBPs dried through FIR at $50^{\circ}C$ showed strong antioxidant activities in DPPH, superoxide, hydrogen peroxide, alkyl and metal chelating assays while all the digests showed strong lipid peroxidation activities. Further, enzymatic digests showed remarkable inhibitory activities against $H_2O_2$-induced DNA damage. Hence, the data obtained using different in vitro models clearly established the antioxidant potential of enzymatic digests from CBPs dried through FIR. Furthermore, they can be used as a source of natural antioxidants; hence, far-infrared radiation drying is a viable method for transforming wet CBPs into a dried form without destroying the bioactive components.
Infrared heating has been traditionally used in industrial applications for processes such as dehydration of food industrial. This heating method involves the application of radiation in the wavelength range of 2 to 50 micrometers. In this work, simultaneous heat balance equations were developed to simulate the infrared radiation heating of agricultural products. The equations assume that moisture diffuses to the outer boundaries of the material in liquid form and evaporation occurs at the surface of the agricultural products. Energy for moisture evaporation is supplied by the infrared radiant energy. The optimum temperature and drying time for the best drying conditions of changing the red peppers with the moisture content of 18% and the restore rate of 80~85% are $80^{\circ}C$ and 44 hours. The performance of radiation tubes coating with the radiation paint developed in this research has the energy of $2.27{\times}103W/m^2{\mu}m$, $150^{\circ}C$ within the scope of radiation wave length of $2{\sim}30{\mu}m$ and has the radiation 0.92~0.93, which is superior to the general radiation tubes. The extinction coefficient according to the band pass filter using the 4 flux theory ha higher dependability on wave length, accounting for $2{\sim}17{\mu}m$ and $5{\times}105{\sim}106m-1$. A comparison between the theoretical energy transfer whose figures are interpreted according to 4 flux theory and the experimental energy transfer of far infrared dryer leads to the findings of the agreement less than 5%.
본 연구에서는 원적외선 이용하여 단풍취를 박층 건조할 경우 건조온도와 송풍속도에 따른 건조특성과 건조제품의 색도 변화를 조사하였고, 건조 전후 취나물의 항산화 성분과 항산화력 변화를 분석함으로써 고품질의 원적외선 건조 취나물 제품 생산을 위한 기초 자료를 제시하고자 하였다. 단풍취의 건조속도는 원적외선 박층 건조온도와 송풍속도가 증가할수록 빨라지고, 건조시간이 단축되는 것으로 나타났다. 특히 원적외선 박층 건조온도 $50^{\circ}C$의 송풍속도 0.8m/sec에서 건조속도가 가장 빠른 것으로 나타났다. 본 연구에서 검증한 건조모델 중 Thompson 모델은 결정계수가 0.9826 이상, RMSE는 0.1277 이하로 나타나, Lewis, Page, Henderson 모델보다 단풍취의 원적외선 박층 건조 시 함수율비 예측 정밀도가 높은 것으로 나타났다. 원적외선 박층건조 후 단풍취의 ${\Delta}L$(명도)값은 원적외선 건조온도와 송풍속도가 빠를수록 증가하는 경향을 보였고, ${\Delta}a$(적색도/녹색도)와 ${\Delta}b$(황색도) 값은 원적외선 건조온도가 낮고, 송풍속도가 느릴수록 갈변하는 현상이 심화되는 것으로 나타났다. 원적외선 박층 건조 후 단풍취의 ${\Delta}E$(색차)값도 원적외선 건조온도가 낮고, 송풍속도가 느릴수록 증가하는 경향을 보였다. 항산화 성분인 폴리페놀 함량의 경우 원적외선 건조온도가 높을수록 감소량이 증가하였고 원적외선 박층 건조 후 37.36~55.21% 감소하는 경향을 보였으며, 원적외선 박층건조조건 중 원적외선 건조온도 $40^{\circ}C$의 송풍속도 0.8m/sec와 $45^{\circ}C$의 송풍속도 0.6 m/sec 조건에서 감소율이 낮은 것으로 나타났다. 플라보노이드 함량의 경우에도 원적외선 박층 건조 후 32.24~44.18% 감소하는 것으로 나타났고, 원적외선 건조온도 $40^{\circ}C$의 송풍속도 0.8 m/sec와 $45^{\circ}C$의 송풍속도 0.8 m/sec 조건에서 감소율이 낮은 것으로 나타났다. 항산화력의 경우에도 원적외선 건조온도가 높을수록 감소하는 경향을 보였고, 원적외선 건조조건 중 $40^{\circ}C$의 송풍속도 0.8 m/sec와 $45^{\circ}C$의 송풍속도 0.6 m/sec 조건에서 항산화력 감소율이 다른 건조조건보다 낮은 것으로 나타났다. 따라서 단풍취의 건조시간, 건조 중 변색, 항산화 성분 및 항산화력 등을 고려하면 단풍취 건조제품의 고품질화를 위해서는 원적외선 박층 건조온도 $45^{\circ}C$의 송풍속도 0.6, 0.8 m/sec가 적절한 건조조건으로 판단된다.
본 연구에서는 건조방법(열풍건조, 원적외선건조, 진공동결건조)을 달리한 오미자의 품질 특성 및 항산화 효과를 비교 검토하여 고품질의 건조 오미자를 얻기 위한 기초자료를 제시하고자 하였다. 수분 함량 및 수분활성도(Aw)는 열풍건조 > 원적외선건조 > 진공동결건조 순으로 나타났다. pH는 건조방법에 따른 차이는 없었고, 당도는 $6.60^{\circ}Brix$로 진공동결건조 오미자가 가장 높은 값을 나타내었다. 탁도는 열풍건조 8.24 T%, 원적외선건조 0.32 T%, 진공동결건조 71.85 T%를 나타내었으며, 색도 L, a, b는 진공동결건조가 다른 건조방법에 비해 높게 나타났다. 유리당 함량은 glucose > fructose > sucrose 순으로 나타내었고, 총 유리당 함량은 진공동결건조 오미자가 5.01 g/100 g으로 가장 높은 값을 나타내었다. 항산화 활성에서 DPPH radical 소거능, ABTS radical 소거능에서는 각각 진공동결건조 오미자가 88.68%, 93.85%로 가장 높은 활성을 나타내었다. 반면 아질산염 소거능은 원적외선건조 오미자가 90.04%로 가장 높은 값을 나타내었고, 열풍건조 오미자는 88.78%, 진공동결건조 오미자가 82.58%의 순으로 활성을 나타내었다. 총페놀, 총 플라보노이드, 총 탄닌 함량에서 진공동결건조 오미자가 1633.70 mg/100 g, 351.35 mg/100 g, 514.04 mg/100 g으로 가장 높은 값을 나타내었다. 이상의 결과에서 건조방법은 오미자의 품질특성 및 항산화 효과에 유의적인 영향을 주는 것으로 나타났으며, 진공동결건조 오미자는 다른 건조방법에 비해 높은 품질 특성과 항산화 효과를 나타내었다.
복령은 온도와 풍속, 온도와 방사거리를 변화시켜 열풍건조와 원적외선건조방법으로 건조함으로써 건조조건에 따른 색도, 갈변도, 총페놀함량, 전자공여능 등의 품질변화에 미치는 영향을 조사하였다. 색도는 열풍건조시료에서 건조온도와 풍속이 증가할수록, 원적외선건조시료에서 건조온도는 증가하고 방사거리가 짧아질수록 ${\Delta}L$, ${\Delta}a$, ${\Delta}E\;value$는 증가하였고, ${\Delta}b\;value$는 감소하였으며 그 변화폭도 커졌다. 그리고, 갈변된 정도를 알 수 있는 추출물의 흡광도는 색도 변화와 같은 양상을 보였다. 복령의 총페놀함량은 원적외선 시료가 열풍건조시료보다 낮은 함량을 나타냈지만 전체적으로 시판품의 함량보다는 높은 함량을 보였다. 전자공여능은 온도, 풍속과 방사거리에 따른 각 구간별 차이는 거의 없었다. 따라서 원적외선건조보다는 열풍건조로, $50^{\circ}C$의 낮은 건조온도와 0.5 m/s의 느린 풍속으로 건조할 때 품질에 영향을 주는 색도변화와 화학성분함량의 손실을 최소화할 수 있는 것으로 사료되며, 원적외선 열원을 고온, 장시간 사용할 경우 품질손실은 매우 크게 나타났다.
본 웹사이트에 게시된 이메일 주소가 전자우편 수집 프로그램이나
그 밖의 기술적 장치를 이용하여 무단으로 수집되는 것을 거부하며,
이를 위반시 정보통신망법에 의해 형사 처벌됨을 유념하시기 바랍니다.
[게시일 2004년 10월 1일]
이용약관
제 1 장 총칙
제 1 조 (목적)
이 이용약관은 KoreaScience 홈페이지(이하 “당 사이트”)에서 제공하는 인터넷 서비스(이하 '서비스')의 가입조건 및 이용에 관한 제반 사항과 기타 필요한 사항을 구체적으로 규정함을 목적으로 합니다.
제 2 조 (용어의 정의)
① "이용자"라 함은 당 사이트에 접속하여 이 약관에 따라 당 사이트가 제공하는 서비스를 받는 회원 및 비회원을
말합니다.
② "회원"이라 함은 서비스를 이용하기 위하여 당 사이트에 개인정보를 제공하여 아이디(ID)와 비밀번호를 부여
받은 자를 말합니다.
③ "회원 아이디(ID)"라 함은 회원의 식별 및 서비스 이용을 위하여 자신이 선정한 문자 및 숫자의 조합을
말합니다.
④ "비밀번호(패스워드)"라 함은 회원이 자신의 비밀보호를 위하여 선정한 문자 및 숫자의 조합을 말합니다.
제 3 조 (이용약관의 효력 및 변경)
① 이 약관은 당 사이트에 게시하거나 기타의 방법으로 회원에게 공지함으로써 효력이 발생합니다.
② 당 사이트는 이 약관을 개정할 경우에 적용일자 및 개정사유를 명시하여 현행 약관과 함께 당 사이트의
초기화면에 그 적용일자 7일 이전부터 적용일자 전일까지 공지합니다. 다만, 회원에게 불리하게 약관내용을
변경하는 경우에는 최소한 30일 이상의 사전 유예기간을 두고 공지합니다. 이 경우 당 사이트는 개정 전
내용과 개정 후 내용을 명확하게 비교하여 이용자가 알기 쉽도록 표시합니다.
제 4 조(약관 외 준칙)
① 이 약관은 당 사이트가 제공하는 서비스에 관한 이용안내와 함께 적용됩니다.
② 이 약관에 명시되지 아니한 사항은 관계법령의 규정이 적용됩니다.
제 2 장 이용계약의 체결
제 5 조 (이용계약의 성립 등)
① 이용계약은 이용고객이 당 사이트가 정한 약관에 「동의합니다」를 선택하고, 당 사이트가 정한
온라인신청양식을 작성하여 서비스 이용을 신청한 후, 당 사이트가 이를 승낙함으로써 성립합니다.
② 제1항의 승낙은 당 사이트가 제공하는 과학기술정보검색, 맞춤정보, 서지정보 등 다른 서비스의 이용승낙을
포함합니다.
제 6 조 (회원가입)
서비스를 이용하고자 하는 고객은 당 사이트에서 정한 회원가입양식에 개인정보를 기재하여 가입을 하여야 합니다.
제 7 조 (개인정보의 보호 및 사용)
당 사이트는 관계법령이 정하는 바에 따라 회원 등록정보를 포함한 회원의 개인정보를 보호하기 위해 노력합니다. 회원 개인정보의 보호 및 사용에 대해서는 관련법령 및 당 사이트의 개인정보 보호정책이 적용됩니다.
제 8 조 (이용 신청의 승낙과 제한)
① 당 사이트는 제6조의 규정에 의한 이용신청고객에 대하여 서비스 이용을 승낙합니다.
② 당 사이트는 아래사항에 해당하는 경우에 대해서 승낙하지 아니 합니다.
- 이용계약 신청서의 내용을 허위로 기재한 경우
- 기타 규정한 제반사항을 위반하며 신청하는 경우
제 9 조 (회원 ID 부여 및 변경 등)
① 당 사이트는 이용고객에 대하여 약관에 정하는 바에 따라 자신이 선정한 회원 ID를 부여합니다.
② 회원 ID는 원칙적으로 변경이 불가하며 부득이한 사유로 인하여 변경 하고자 하는 경우에는 해당 ID를
해지하고 재가입해야 합니다.
③ 기타 회원 개인정보 관리 및 변경 등에 관한 사항은 서비스별 안내에 정하는 바에 의합니다.
제 3 장 계약 당사자의 의무
제 10 조 (KISTI의 의무)
① 당 사이트는 이용고객이 희망한 서비스 제공 개시일에 특별한 사정이 없는 한 서비스를 이용할 수 있도록
하여야 합니다.
② 당 사이트는 개인정보 보호를 위해 보안시스템을 구축하며 개인정보 보호정책을 공시하고 준수합니다.
③ 당 사이트는 회원으로부터 제기되는 의견이나 불만이 정당하다고 객관적으로 인정될 경우에는 적절한 절차를
거쳐 즉시 처리하여야 합니다. 다만, 즉시 처리가 곤란한 경우는 회원에게 그 사유와 처리일정을 통보하여야
합니다.
제 11 조 (회원의 의무)
① 이용자는 회원가입 신청 또는 회원정보 변경 시 실명으로 모든 사항을 사실에 근거하여 작성하여야 하며,
허위 또는 타인의 정보를 등록할 경우 일체의 권리를 주장할 수 없습니다.
② 당 사이트가 관계법령 및 개인정보 보호정책에 의거하여 그 책임을 지는 경우를 제외하고 회원에게 부여된
ID의 비밀번호 관리소홀, 부정사용에 의하여 발생하는 모든 결과에 대한 책임은 회원에게 있습니다.
③ 회원은 당 사이트 및 제 3자의 지적 재산권을 침해해서는 안 됩니다.
제 4 장 서비스의 이용
제 12 조 (서비스 이용 시간)
① 서비스 이용은 당 사이트의 업무상 또는 기술상 특별한 지장이 없는 한 연중무휴, 1일 24시간 운영을
원칙으로 합니다. 단, 당 사이트는 시스템 정기점검, 증설 및 교체를 위해 당 사이트가 정한 날이나 시간에
서비스를 일시 중단할 수 있으며, 예정되어 있는 작업으로 인한 서비스 일시중단은 당 사이트 홈페이지를
통해 사전에 공지합니다.
② 당 사이트는 서비스를 특정범위로 분할하여 각 범위별로 이용가능시간을 별도로 지정할 수 있습니다. 다만
이 경우 그 내용을 공지합니다.
제 13 조 (홈페이지 저작권)
① NDSL에서 제공하는 모든 저작물의 저작권은 원저작자에게 있으며, KISTI는 복제/배포/전송권을 확보하고
있습니다.
② NDSL에서 제공하는 콘텐츠를 상업적 및 기타 영리목적으로 복제/배포/전송할 경우 사전에 KISTI의 허락을
받아야 합니다.
③ NDSL에서 제공하는 콘텐츠를 보도, 비평, 교육, 연구 등을 위하여 정당한 범위 안에서 공정한 관행에
합치되게 인용할 수 있습니다.
④ NDSL에서 제공하는 콘텐츠를 무단 복제, 전송, 배포 기타 저작권법에 위반되는 방법으로 이용할 경우
저작권법 제136조에 따라 5년 이하의 징역 또는 5천만 원 이하의 벌금에 처해질 수 있습니다.
제 14 조 (유료서비스)
① 당 사이트 및 협력기관이 정한 유료서비스(원문복사 등)는 별도로 정해진 바에 따르며, 변경사항은 시행 전에
당 사이트 홈페이지를 통하여 회원에게 공지합니다.
② 유료서비스를 이용하려는 회원은 정해진 요금체계에 따라 요금을 납부해야 합니다.
제 5 장 계약 해지 및 이용 제한
제 15 조 (계약 해지)
회원이 이용계약을 해지하고자 하는 때에는 [가입해지] 메뉴를 이용해 직접 해지해야 합니다.
제 16 조 (서비스 이용제한)
① 당 사이트는 회원이 서비스 이용내용에 있어서 본 약관 제 11조 내용을 위반하거나, 다음 각 호에 해당하는
경우 서비스 이용을 제한할 수 있습니다.
- 2년 이상 서비스를 이용한 적이 없는 경우
- 기타 정상적인 서비스 운영에 방해가 될 경우
② 상기 이용제한 규정에 따라 서비스를 이용하는 회원에게 서비스 이용에 대하여 별도 공지 없이 서비스 이용의
일시정지, 이용계약 해지 할 수 있습니다.
제 17 조 (전자우편주소 수집 금지)
회원은 전자우편주소 추출기 등을 이용하여 전자우편주소를 수집 또는 제3자에게 제공할 수 없습니다.
제 6 장 손해배상 및 기타사항
제 18 조 (손해배상)
당 사이트는 무료로 제공되는 서비스와 관련하여 회원에게 어떠한 손해가 발생하더라도 당 사이트가 고의 또는 과실로 인한 손해발생을 제외하고는 이에 대하여 책임을 부담하지 아니합니다.
제 19 조 (관할 법원)
서비스 이용으로 발생한 분쟁에 대해 소송이 제기되는 경우 민사 소송법상의 관할 법원에 제기합니다.
[부 칙]
1. (시행일) 이 약관은 2016년 9월 5일부터 적용되며, 종전 약관은 본 약관으로 대체되며, 개정된 약관의 적용일 이전 가입자도 개정된 약관의 적용을 받습니다.