• 제목/요약/키워드: design error

검색결과 5,360건 처리시간 0.034초

부스바 접촉 상태 및 온도 감지 시스템 설계 및 구현 (A Design and Implementation of Busbar Joint and Temperature Measurement System)

  • 이영동;정성학
    • 한국정보통신학회논문지
    • /
    • 제21권2호
    • /
    • pp.379-385
    • /
    • 2017
  • 일반적으로 배전반, 분전반, 전동기제어반(Motor Control Center; MCC)은 집단거주지역, 빌딩, 학교, 공장, 항만, 공항, 상하수 처리장, 변전소, 중공업 플랜트 등의 광범위한 전력 수용가에 설치되어 특고압의 전력을 해당 설비들에 요구되는 전압으로 변환하여 공급하는데 사용된다. 이와 같은 배전반, 분전반, MCC에 포함되는 전기설비의 사고는 부스바 접촉부의 열화에 의한 사고, 부스바의 접점 및 연결 부위에서의 접촉 불량에 의한 사고, 부스바 접촉부의 과열현상에 의한 사고로 구분된다. 본 논문에서는 부스바 접촉부의 볼트 및 너트의 풀림상태, 접촉부 열화 측정이 가능하며, 정밀 가변저항을 이용하여 저항값의 변화에 따라 볼트 체결상태 감지 및 비접촉식 적외선 센서를 사용하여 부스바 접촉부 온도 감지 시스템을 설계하고 구현하였다. 부스바 접촉부 체결상태 감지를 위한 가변저항을 이용한 실험을 수행한 결과 볼트와 너트를 완전히 체결시키면 가변저항 값은 감소하였으며, 최대 오차범위는 0.1mm의 결과를 보였다. 또한, 부스바 접촉 저항값 변화에 따라 접촉부 온도가 $27.3^{\circ}C$에서 $69.3^{\circ}C$로 상승하는 결과를 확인하였다.

전원전압 1.0V 산소 및 과산화수소 기반의 정전압분극장치 설계 (Design of 1.0V O2 and H2O2 based Potentiostat)

  • 김재덕;;최성열;김영석
    • 한국정보통신학회논문지
    • /
    • 제21권2호
    • /
    • pp.345-352
    • /
    • 2017
  • 본 논문에서는 전원전압 1V에서 동작하는 산소 및 과산화수소 기반의 혈당전류를 측정할 수 있는 통합형 정전압분극장치를 설계하고 제작하였다. 정전압분극장치는 저전압 OTA, 캐스코드 전류거울 그리고 모드 선택회로로 구성되어 있다. 정전압분극장치는 산소 및 과산화수소 기반에서 혈당의 화학반응으로 발생하는 전류를 측정할 수 있다. OTA의 PMOS 차동 입력단의 바디에는 순방향전압을 인가하여 문턱전압을 낮추어 낮은 전원전압이 가능하도록 하였다. 또한 채널길이변조효과로 인한 전류의 오차를 줄이기 위해 캐스코드 전류거울이 사용되었다. 제안한 저전압 정전압분극장치는 Cadence SPECTRE를 이용하여 설계하였으며, 매그나칩 $0.18{\mu}m$ CMOS 공정을 이용하여 제작되었으며 회로의 크기는 $110{\mu}m{\times}60{\mu}m$이다. 전원전압 1.0V에서 소모전류는 최대 $46{\mu}A$이다. 페리시안화칼륨($K_3Fe(CN)_6$)을 사용하여 제작된 정전압분극장치의 성능을 확인하였다.

MATLAB/Simulink를 이용한 화력발전소 복수펌프 순환기동로직 시뮬레이션 구현 (Simulation Implementation of Fossil Power Plant Condensate Pumps' Rotation Operation Logic Using MATLAB/Simulink)

  • 윤창선;홍연찬
    • 한국산학기술학회논문지
    • /
    • 제17권1호
    • /
    • pp.693-699
    • /
    • 2016
  • 기존 국내 외 연구를 통해 개발된 펌프 운전 시뮬레이터는 대부분 동역학적 해석을 목적으로 하거나 운전자 교육용을 목적으로 개발되어 왔다. 그런데 기존 시뮬레이터는 운전자 위주로 구성되어 있어서 로직 설계자나 시운전 참여자들이 다양한 운전조건 또는 로직을 임의로 변경하기에는 적절하지 않다. 더욱이 최근 발전소에서 사용되는 두 개 이상의 복수펌프 운전에 대해 설계자나 운전자가 쉽게 활용할 수 있는 시뮬레이터는 개발되어 있지 않다. 그래서 본 논문에서는 MATLAB Simulink를 사용하여 일반적인 화력발전소에 주로 사용되는 복수펌프 3대에 대한 순환운전 로직에 대해 설계자나 운전원이 쉽게 사용할 수 있도록 시뮬레이션을 할 수 있는 방법을 제안 한다. 이 제안은 MATLAB을 사용할 수 있는 사용자가 발전소 DCS(Distributed Control System) 로직에 주로 사용되는 ANSI/ISA S5.2를 Simulink를 통해 구현할 수 있도록 도움을 준다. 또한 코드에 명시된 로직을 구현하기 위해 블록에 대한 Sub-System을 만들고 이를 시뮬레이터 내에서 적용이 가능한지를 검증한다. 제안된 방법을 이용한 실무 검증 단계에서는 로직 내에서 발생한 기동신호를 구현된 펌프 모델에 적용하여 3대 펌프 순환운전 시 발생할 수 있는 모든 오류 가능성을 제안된 시뮬레이터를 사용하여 설계 단계 및 운전 전에 검증할 수 있음을 실험을 통해 확인하였다.

GPS Galileo Time Offset (GGTO)의 항법해 영향 분석 (Analysis of GPS Galileo Time Offset Effects on Positioning)

  • 주정민;조정호;허문범
    • 한국통신학회논문지
    • /
    • 제37C권12호
    • /
    • pp.1310-1317
    • /
    • 2012
  • 미국의 GPS와 유럽연합의 Galileo 시스템과 같은 위성항법시스템(Global Navigation Satellite System, GNSS)은 정확한 시각과 주파수로 동기화된 항법신호를 지상의 사용자에게 제공하는 전 지구 측위시스템으로 이를 기반으로 넓은 범위에 걸쳐 항법 및 시각동기 서비스를 제공하고 있다. 이와 더불어 다중위성항법신호를 활용하여 측위를 할 경우 단독위성항법신호를 사용할 때 보다 가용 항법신호의 수가 증가하고 이에 따라 측위 정확도를 향상시킬 수 있다는 장점이 있는 것으로 알려져 있다. 하지만 현재의 GPS와 Galileo 시스템은 각기 다른 기준 시각체계를 사용하고 있기 때문에 항법해 계산 시 시각 편이가 발생하며 이를 적절히 보정하지 못할 경우 통합 항법 측위 성능을 저하시킬 수 있다. 본 논문에서는 이러한 미국의 GPS와 유럽의 Galileo 시스템에 대한 기준 시각체계에 대한 차이점을 분석하고 시각체계 불일치에 따른 항법해 영향을 시뮬레이션을 통하여 분석하였다. 또한, 현재 알려진 대표적 보정기법을 적용하였을 경우의 측위 정확도의 향상과 기법별 문제점에 대해서도 분석하였으며 기법별 문제점을 보완할 수 있는 새로운 기법에 대한 개념을 함께 제시한다.

FirmOS를 이용한 HDD 무결성 검사 시스템 개발에 관한 연구 (Study on Development of HDD Integrity Verification System using FirmOS)

  • 염재환;오세진;노덕규;정동규;황주연;오충식;김효령;신재식
    • 융합신호처리학회논문지
    • /
    • 제18권2호
    • /
    • pp.55-61
    • /
    • 2017
  • 전파천문분야에서 관측데이터의 저장을 위해 대용량 HDD를 RAID로 연결한 디스크 팩을 활용하고 있다. VLBI 관측의 경우 관측속도가 빨라지고 광대역으로 확장되면서 많은 양의 관측데이터를 저장해야 한다. HDD는 사용회수가 많아질수록 고장이 많이 발생하고 있으며, 이것을 찾아서 복구하는데 많은 시간이 소요된다. 또한 고장난 HDD를 계속 사용할 경우 관측데이터의 손실이 발생한다. 그리고 새 HDD를 구입하여 많은 비용도 필요하게 된다. 본 연구에서는 FirmOS를 이용하여 SATA HDD의 무결성 검사 시스템을 개발하였다. FirmOS는 일반 서버보드와 CPU를 갖는 시스템에서 특정목적에만 동작하도록 개발한 OS이다. 개발한 시스템은 FirmOS 기반에서 SATA HDD의 물리적인 영역에 특정 패턴의 데이터를 쓰고 읽는 과정을 수행한다. 그리고 HDD 제어기의 메모리 영역에서 HDD로부터 읽어들인 저장된 패턴 데이터와 비교를 수행하는 방식으로 HDD의 무결성 검사를 확인하는 방법을 채용하였다. 개발한 시스템을 활용하여 VLBI 관측에서 활용하고 있는 디스크 팩의 고장여부를 쉽게 확인할 수 있었으며, 관측효율을 향상시킬 수 있는데 많은 도움이 되고 있다. 본 논문에서는 개발한 SATA HDD 무결성 확인 시스템의 설계, 구성, 시험 등에 대해 자세히 기술한다.

  • PDF

패치형 무선 피부 온도 측정 시스템의 설계 및 구현 (Design and implement of patch type wireless skin temperature measuring system)

  • 우상효;박수영;지아 모이 우딘;원철호;이정현;박희준;이정우;홍영진;서진호;염영일;조진호
    • 센서학회지
    • /
    • 제17권5호
    • /
    • pp.350-360
    • /
    • 2008
  • In every large hospital, nurses must perform simple repetitive tasks such as measuring body temperature. Such tedious work reduces nurses' motivation to provide quality medical care, which is an important element of the medical services provided by a hospital. If a device were available to measure body temperature, nurses could focus on the more important aspects of providing quality medical care to the patients. However, body temperature is generally measured from the throat, anus, tympanum or armpit, where it is difficult to affix a patch type device. In addition, general body temperature measuring points shows moving artifact error; therefore, it is not good point to continually measure the temperature. In this paper, a patch type skin temperature measuring system was developed. To appropriately measure the skin temperature, a thermal transducer was implemented with a thin (0.5 mm) temperature sensor. The system is small and thin ($H6.6{\sim}5.3{\times}L35{\times}W24\;mm$), and weighs only 5 g including a battery, case and circuit; therefore, it is small and light enough to function as a patch type device. Moreover, the system worked for 5 days. To investigate differences between the experimental and conventional thermometer, simple clinical experiments were performed with 17 volunteers, and the result showed some correlation between the implemented system and conventional thermometer (Correlation coefficient = 0.647, P<0.1).

Thin Layer Drying Model of Sorghum

  • Kim, Hong-Sik;Kim, Oui-Woung;Kim, Hoon;Lee, Hyo-Jai;Han, Jae-Woong
    • Journal of Biosystems Engineering
    • /
    • 제41권4호
    • /
    • pp.357-364
    • /
    • 2016
  • Purpose: This study was performed to define the drying characteristics of sorghum by developing thin layer drying equations and evaluating various grain drying equations. Thin layer drying equations lay the foundation characteristics to establish the thick layer drying equations, which can be adopted to determine the design conditions for an agricultural dryer. Methods: The drying rate of sorghum was measured under three levels of drying temperature ($40^{\circ}C$, $50^{\circ}C$, and $60^{\circ}C$) and relative humidity (30%, 40%, and 50%) to analyze the drying process and investigate the drying conditions. The drying experiment was performed until the weight of sorghum became constant. The experimental constants of four thin layer drying models were determined by developing a non-linear regression model along with the drying experiment results. Result: The half response time (moisture ratio = 0.5) of drying, which is an index of the drying rate, was increased as the drying temperature was high and relative humidity was low. When the drying temperature was $40^{\circ}C$ at a relative humidity (RH) of 50%, the maximum half response time of drying was 2.8 h. Contrastingly, the maximum half response time of drying was 1.2 h when the drying temperature was $60^{\circ}C$ at 30% RH. The coefficient of determination for the Lewis model, simplified diffusion model, Page model, and Thompson model was respectively 0.9976, 0.9977, 0.9340, and 0.9783. The Lewis model and the simplified diffusion model satisfied the drying conditions by showing the average coefficient of determination of the experimental constants and predicted values of the model as 0.9976 and Root Mean Square Error (RMSE) of 0.0236. Conclusion: The simplified diffusion model was the most suitable for every drying condition of drying temperature and relative humidity, and the model for the thin layer drying is expected to be useful to develop the thick layer drying model.

유역 특성과 유출추적에 의한 단위도 해석에 관한 고찰 (A Study on the Interpretalion of the Synthetic Unit Hydrograph According to the Characteristics of catchment Area and Runoff Routing)

  • 서승덕
    • 한국농공학회지
    • /
    • 제8권1호
    • /
    • pp.1088-1096
    • /
    • 1966
  • The following is a method of synthetic unitgraph derivation based on the routing of a time area diagram through channel storage, studied by Clark-Jonstone and Laurenson. Unithy drograph (or unitgraph) is the hydrograph that would result from unit rainfall\ulcorner excess occuring uniformly with respect to both time and area over a catchment in unit time. By thus standarzing rainfall characteristics and ignoring loss, the unitgraph represents only the effects of catchment characteristics on the time distribution of runoff from a catchment The situation abten arises where it is desirable to derive a unitgraph for the design of dams, large bridge, and flood mitigation works such as levees, floodways and other flood control structures, and are also used in flood forecasting, and the necessary hydrologie records are not available. In such cases, if time and funds permit, it may be desirable to install the necessary raingauges, pruviometers, and stream gaging stations, and collect the necessary data over a period of years. On the otherhand, this procedure may be found either uneconomic or impossible on the grounds of time required, and it then becomes necessary to synthesise a unitgraph from a knowledge of the physical charcteristics of the catchment. In the preparing the approach to the solution of the problem we must select a number of catchment characteristic(shape, stream pattern, surface slope, and stream slope, etc.), a number of parameters that will define the magnitude and shape of the unit graph (e.g. peak discharge, time to peak, and base length, etc.), evaluate the catch-ment characteristics and unitgraph parameters selected, for a number of catchments having adequate rainfall and stream data and obtain Correlations between the two classes of data, and assume the relationships derived in just above question apply to other, ungaged, Catchments in the same region and, knowing the physical characteritics of these catchments, substitute for them in the relation\ulcorner ships to determine the corresponding unitgraph parameters. This method described in this note, based on the routing of a time area diagram through channel storage, appears to provide a logical line of research and they allow a readier correlation of unitgraph parameters with catchment characteristics. The main disadvantage of this method appears to be the error in routing all elements of rainfall excess through the same amount of storage. evertheless, it should be noted that the synthetic unitgraph method is more accurate than the rational method since it takes account of the shape and tophography of the catchment, channel storage, and temporal variation of rainfall excess, all of which are neglected in rational method.

  • PDF

엔트로피 개념을 활용한 개수로 마찰속도 산정 (The Estimation of Friction Velocity in an Open Channel by the Entropy Concept)

  • 추태호;손희삼;윤관선;노현석;고현수
    • 한국산학기술학회논문지
    • /
    • 제16권2호
    • /
    • pp.1533-1540
    • /
    • 2015
  • 수공구조물 설계 또는 하상의 유동 특징을 나타내기 위해선 마찰속도 산정이 필수적이다. 하지만 기존의 개수로 내의 마찰속도 공식인 Log 방법이나 Power방법은 벽면 근처에서 경계층 조건 혹은 다양한 수리적 특성이 지속적으로 변화하기 때문에 마찰속도의 산정에 어려움이 있다. 따라서 본 연구에서는 매개변수를 최소화하고 오차를 줄일 수 있는 새로운 마찰속도 공식을 제안하였다. 제안한 공식에 대한 신뢰성과 정확성을 검증하기 위하여 엔트로피매개변수M을 각각의 수로마다 산정을 하여 Dr.Song이 산정한 3가지 방법(Clauser 방법, $\sqrt{gRI}$ 방법, 레이놀즈 응력법)으로 산정한 마찰속도와 비교하였다. 그 결과 가속부등류 조건의 경우 $R^2=0.9621$ 감속부등류 조건의 경우 $R^2=0.9274$ 등류흐름 조건의 경우 $R^2=0.8865$로 매우 높은 정확성으로 등류조건뿐만 아니라 부등류 조건에서도 거의 일치하였다.

낮은 샘플링 주파수에서 임계 함수를 사용한 개선된 걸음 검출 알고리즘 (An Enhanced Step Detection Algorithm with Threshold Function under Low Sampling Rate)

  • 김보연;장윤석
    • 정보처리학회논문지:컴퓨터 및 통신 시스템
    • /
    • 제4권2호
    • /
    • pp.57-64
    • /
    • 2015
  • 피크 임계값을 사용하는 걸음 검출 알고리즘에서 충분한 정확도로 걸음을 검출하기 위해서는 3축 가속도 센서가 20Hz 이상의 주파수로 샘플링을 수행하여야 한다. 그러나 $I^2C$나 SPI를 통하여 데이터를 전송받는 상용의 통합 MPU와 연결되는 디지털 센서 장치들의 샘플링 주파수는 아날로그 방식의 샘플링 회로들에 비하여 매우 낮은 경향이 있다. 센서의 샘플링 주파수가 낮게 되면 충분한 데이터를 확보할 수 없기 때문에 측정 결과의 정확도가 떨어지게 된다. 본 연구에서는 피크 임계값 방식의 피크 검출 알고리즘에서 데이터가 20Hz 이하의 낮은 주파수로 샘플링될 경우에 샘플링 주파수와 피크 임계값 사이에 함수관계가 있음을 발견하였으며, 실험을 통하여 임계 함수를 도출하였다. 고정 임계값 대신에 샘플링 주파수에 따른 임계 함수를 적용하고, 테스트 프로토콜에 의하여 실험을 수행한 결과, 각 걸음 유형에 대하여 평균적으로 1.2% 미만의 걸음 검출 오차율을 얻을 수 있었다. 그러므로 걸음 검출 알고리즘이 걸음 모드에 따라서 적절히 결정된 임계 함수로부터 샘플링 주파수에 적합한 임계값을 사용하여 걸음을 검출한다면, 걸음 검출 및 걸음수 측정의 정확도는 매우 높아질 수 있다. 이러한 결과는 걸음수 측정 장치에만 적용되는 것이 아니라, 샘플링 주파수가 낮게 설계될 수밖에 없는 소형, 저가의 유비쿼터스 기기에도 적용해 정확도를 효과적으로 향상시킬 수 있다.