• Proceedings of the Materials Research Society of Korea Conference
• /
• 2011.10a
• /
• pp.17.2-17.2
• /
• 2011

Double-walled carbon nanotubes (DWCNTs) were grown with vertical alignment on a Si wafer by using catalytic thermal chemical vapor deposition. This study investigated the effect of pre-annealing time of catalyst on the types of CNTs grown on the substrate. The catalyst layer is usually evolved into discretely distributed nanoparticles during the annealing and initial growth of CNTs. The 0.5-nm-thick Fe served as a catalyst, underneath which Al was coated as a catalyst support as well as a diffusion barrier on the Si substrate. Both the catalyst and support layers were coated by using thermal evaporation. CNTs were synthesized for 10 min by flowing 60 sccm of Ar and 60 sccm of H2 as a carrier gas and 20 sccm of C2H2 as a feedstock at 95 torr and $750^{\circ}C$. In this study, the catalyst and support layers were subject to annealing for 0~420 sec. As-grown CNTs were characterized by using field emission scanning electron microscopy, high resolution transmission electron microscopy, Raman spectroscopy, and atomic force microscopy. The annealing for 90~300 sec caused the growth of DWCNTs as high as ~670 ${\mu}m$ for 10 min while below 90 sec and over 420 sec 300~830 ${\mu}m$-thick triple and multiwalled CNTs occurred, respectively. Several radial breathing mode (RBM) peaks in the Raman spectra were observed at the Raman shifts of 112~191 cm-1, implying the presence of DWCNTs, TWCNTs, MWCNTs with the tube diameters 3.4, 4.0, 6.5 nm, respectively. The maximum ratio of DWCNTs was observed to be ~85% at the annealing time of 180 sec. The Raman spectra of the as-grown DWCNTs showed low G/D peak intensity ratios, indicating their low defect concentrations. As increasing the annealing time, the catalyst layer seemed to be granulated, and then grown to particles with larger sizes but fewer numbers by Ostwald ripening.

• Korean Journal of Materials Research
• /
• v.21 no.2
• /
• pp.78-82
• /
• 2011

Mono- and few-layer graphenes were grown on Ni thin films by rapid-thermal pulse chemical vapor deposition technique. In the growth steps, the exposure step for 60 s in $H_2$ (a flow rate of 10 sccm (standard cubic centimeters per minute)) atmosphere after graphene growth was specially established to improve the quality of the graphenes. The graphene films grown by exposure alone without $H_2$ showed an intensity ratio of $I_G/I_{2D}$ = 0.47, compared with a value of 0.38 in the films grown by exposure in H2 ambient. The quality of the graphenes can be improved by exposure for 60 s in $H_2$ ambient after the growth of the graphene films. The physical properties of the graphene films were investigated for the graphene films grown on various Ni film thicknesses and on 260-nm thick Ni films annealed at 500 and $700^{\circ}C$. The graphene films grown on 260-nm thick Ni films at $900^{\circ}C$ showed the lowest $I_G/I_{2D}$ ratio, resulting in the fewest layers. The graphene films grown on Ni films annealed at $700^{\circ}C$ for 2 h showed a decrease of the number of layers. The graphene films were dependent on the thickness and the grain size of the Ni films.

• Journal of Korean Society for Atmospheric Environment
• /
• v.18 no.E1
• /
• pp.29-36
• /
• 2002

The selective catalytic reduction (SCR) reaction of promoter catalysts was investigated in this study. A pure anatase type of TiO$_2$ was used as support. Activation measurement of prepared catalysts was practiced on a fixed reactor packing by the glass bead after filling up catalysts in 1/4 inch stainless tube. The reaction temperature was measured by K-type thermocouple and catalyst was heated by electric furnace. The standard compositions of the simulated flue gas mixture in this study were as follows: NO 1,780ppm, NH$_3$1,780ppm, $O_2$1% and $N_2$ as balance gas. In this study, gas analyzer was used to measure the outgassing gas. Catalyst bed was handled for 1hr at 45$0^{\circ}C$, and the reactivity of the various catalyst was determined in a wide temperature range. Conversion of NH$_3$/NO ratio and of $O_2$ concentration was practiced at 1,1.5 and 2, respectively. The respective space velocity were as follows . 10,000, 15,000 and 17,000 hr-1. It was found that the maximum conversion temperature range was in a 5$0^{\circ}C$. It was also found toi be very sensitive at space velocity, $O_2$ concentration, and NH$_3$/NO ratio. We also noticed that the maximum conversion temperature of (W, Mo, Sn) -V$_2$O$_{5}$/TiO$_2$ catalysts was broad. Specially WO$_3$-V$_2$O$_{5}$TiO$_2$2 catalyst appeared nearly 100% conversion at not only above 30$0^{\circ}C$ ut also below 25$0^{\circ}C$. At over 30$0^{\circ}C$, NH$_3$ oxidation decreased with decrease of surface excess oxygen. In addition, WO$_3$-V$_2$O$_{5}$TiO$_2$ catalyst did not appear to affect space velocity, $O_2$ concentration, and NH$_3$/NO ratio.ratio.

• Analytical Science and Technology
• /
• v.10 no.5
• /
• pp.378-385
• /
• 1997

In order to clarify the functional role of Tyr7 in human glutathione S-transferase P1-1, we extensively investigated the effect of mutation of Tyr7 on the substrate specificity and inhibition characteristics. The mutational replacement of Tyr7 with phenylalanine lowered the specific activities with 1,2-dichloro-4-nitrobenzene and 1,2-epoxy-3-(p-nitrophenoxy) propane for GSH-conjugation reaction to 3~5% of the values for the wild-type enzyme. The pKa of the thiol group of GSH bound in Y7F was about 2.4 pK units higher than that in the wild-type enzyme. The $I_{50}$ of hematin for Y7F was similar to that for the wild-type enzyme and those of benastatin A and S-(2,4-dinitrophenyl)glutathione were only moderately decreased. These results suggest that Tyr7 is considered to be important the catalytic activities not only for GSH-chloronitrobenzene derivatives but also for GSH-epoxide conjugation reaction, rather than to binding of the substrates.

• Environmental Analysis Health and Toxicology
• /
• v.16 no.2
• /
• pp.97-102
• /
• 2001

The flavin-containing monooxygenases(FMOs) (EC1.14.13.8) are NADPH0dependent flavoenzymes that catalyze oxidation of soft nucleophilic heteroatom centers in a range of structurally diverse compounds, including foods, drugs, pesticides, and other xenobiotics. In humans, FMO3 is quantitatively a major human liver monooxygenase. In the present study, the baculovirus expression vector system was used to overexpress human FMO3 in sect cells for stalytic studies. Microsomes isolated from Spodoptera frugiperda(Sf)9 cells infected with human FMO3 recombinant baculovirus catalyzed the NADPH-and O$_2$-dependent oxidation of methimazole, thiourea, and phenylthiourea. However there was no detectable activity with 1, 3-diphenylthiourea or larger thiocarbamides. Microsomes from control Sf9 cells were devoid of methimazole or thiourea S-oxygenase activity. 1, 3-diphenylthiourea is apparently completely excluded from the catalytic site, these amines drugs are probably approaching the upper size limits of xenobiotics accepted by human FMO3. The substrate specificity of this iosform in humans appears considerably more restriceted than that of pig, guinea pig, rat or rabbit FMO3.

• Journal of Korean Society for Atmospheric Environment
• /
• v.26 no.1
• /
• pp.1-9
• /
• 2010

In this study, the selective catalytic reduction of $NO_x$ with ammonia was carried out in a filter bag support reactor. The experiments were performed by powder type $MnO_x$ and $V_2O_5$/$TiO_2$ catalyst at low temperature between 130 and $250^{\circ}C$. Also, the effect of $SO_2$ and $H_2O$ on the NO conversion was investigated under our test conditions. The powder type catalysts were analyzed by X-ray photoelectron spectrum (XPS), X-ray diffraction(XRD), scanning electron microscopy (SEM) and thermal gravimetric analysis (TGA). It was observed that NO removal efficiency of the powder type $V_2O_5$/$TiO_2$ catalyst was 85% at low temperature($200^{\circ}C$) under presence of oxygen and that of $MnO_x$ was 50% at the same condition. The powder type $V_2O_5$/$TiO_2$ catalyst, in conclusion, was found to be available for SCR reaction in a filter bag support system.

• Journal of Microbiology and Biotechnology
• /
• v.25 no.2
• /
• pp.296-301
• /
• 2015

Chronic kidney diseases are based on uncontrolled immunological and inflammatory responses to pathophysiological renal circumstances such as glomerulonephritis, which is caused by immunological mechanisms of glomerular inflammation with increased production of renal pro-inflammatory cytokines. Pentoxifylline (PTX) exhibits anti-inflammatory properties by inhibiting cytokine and chemokine production through aggregation of erythrocytes and thrombocytes. We synthesized a series of 1,7-substituted methylxanthine derivatives by the Traube purine reaction, and the formation of purine ring was completed through nitrosation, a reduction of the nitroso to the amine by catalytic hydrogenation as derivatives of PTX. Then we studied biological activities such as renal anti-inflammatory effects of the synthesized compounds in the production of cytokines such as nitric oxide (NO), interleukin (IL)-1β, IL-6, and tumor necrosis factor-α (TNF-α) and of chemokines such as monocyte chemoattractant protein-1 and IL-8 in Raw 264.7 and HK-2 cells. Renal antiinflammatory activities of this novel series of N-1 and N-7-substituted methylxanthine showed that the N-7 methyl-group-substituted analogs (S7b) showed selective 61% and 77% inhibition of the production of NO and IL-8. The other replacement of the N-1-(CH₂)₄COCH₃ roup, as in the case of compound S6c, also showed an effective 50% and 77% inhibition of TNF-α and IL-8 production in LPS-stimulated Raw 264.7 and HK-2 cells.

• Journal of Microbiology and Biotechnology
• /
• v.19 no.7
• /
• pp.713-717
• /
• 2009

The dependence of the catalytic properties of horseradish peroxidase on the structural changes of ionic liquids was investigated with two water-miscible ionic liquids, N-butyl-3methypyridinium tetraftuoroborate ([$BMP_y$][$BF_4$]) and 1-butyl-3-methylimidazolium methylsulfate ([BMIM][$MeSO_4$]), each of which shares an anion ($BF_4^-$) or a cation ($BMIM^+$) with 1-butyl-3-methylimidazolium tetraftuoroborate ([BMIM][$BF_4$]), respectively. The oxidation of guaiacol (2-methoxyphenol) with $H_2O_2$was used as a model reaction. In order to minimize the effect of solution viscosity on the kinetic constants of the enzymatic catalysis, the enzymatic reactions for the kinetic study were performed in water-ionic liquid mixtures containing 25% (v/v) ionic liquid at maximum. Similarly to the previously reported results for [BMIM][$BF_4$], as the concentration of [$BMP_y$][$BF_4$] increased, the $K_m$value increased with a decrease in the $k_{cat}$value: the $K_m$value increased markedly from 2.8 mM in 100% water to 12.6 mM in 25% (v/v) ionic liquid, indicating that ionic liquid significantly weakens the binding affinity of guaiacol to the enzyme. On the contrary, [BMIM][$MeSO_4$] decreased the Km value to 1.4 mM in 25% (v/v) ionic liquid. [BMIM][$MeSO_4$] also decreased $k_{cat}$more than 3-folds [from 13.8 $s^{-1}$in 100% water to 4.1 $s^{-1}$in 25% (v/v) ionic liquid]. These results indicate that the ionic liquids interact with the enzyme at the molecular level as well as at a macroscopic thermodynamic scale. Specifically, the anionic component of the ionic liquids influenced the catalysis of horseradish peroxidase in different ways.

• Journal of Korean Society of Environmental Engineers
• /
• v.39 no.10
• /
• pp.575-580
• /
• 2017

Chlorinated hydrocarbons (TCE and PCE), petroleum hydrocarbons (BTEX, PAHs, and TPH), and explosive compounds (TNT, RDX, and HMX) have been detected in underground water countrywide. The overall objective of this study is to evaluate sono-catalytic degradation coupled with the use of PUV in order to understand the fate and transport of a representative selection of non-biodegradable contaminants (i.e., TCE, PCE, BTEX, PAHs, TPH, TNT, RDX, and HMX) in groundwater. Both ultraviolet (UV) and ultrasound (US) systems are used in degrading of organic contaminants and they can thus be applicable simultaneously as an UV/US hybrid system in attempts further to increase the degradation efficiency. Results indicate that synergistic effect of UV/US hybrid system is closely correlated to the enhancement of sono-chemical reactivity with the UV-US interaction of increasing the formation rate of OH by providing additional $H_2O_2$ production through the pyrolysis of water molecules during UV/US hybrid irradiation.

• Korean Chemical Engineering Research
• /
• v.44 no.3
• /
• pp.319-322
• /
• 2006

In this paper, the methodology of life-cycle assessment was applied to an ethanol production process based on fermentation. The purpose of the assessment was to quantify environmental performance of the process and to prepare a basis for environmental comparisons with the ethanol production process based on catalytic reaction. The assessment was carried only on the stages of raw material acquisition through ethanol manufacture since it was assumed that ethanol from both processes had the same environmental impacts through its use and discard. The assessment results showed that the major environmental impact came from the sub-process of producing starch from corn and the most severe burden was generated in the form of acidification and greenhouse effect.