• Journal of Animal Environmental Science
• /
• v.1 no.1
• /
• pp.9-19
• /
• 1995

This study was carried out to investigate the effect of sawdust bedding barn on manure handing, management labour and physiological aspect of dairy cows, and then to establish the criteria on the optimum utilization method of sawdust bedding barn. 46 tie stall barns and 49 sawdust bedding barns were surveyed to cmopare the milk productivity between two different barns, and also 5 tie stall barns, 15 sawdust bedding barns and 1 rice hull bedding barn were selected to study the utilization situation of sawdust barn in Kyung-Ki province area. The major results obtained were as follows; 1. The roof material of sawdust barn were consisted of 66% vinyl house, 23% PVC light and 11% slate and galvanum coated tin. Most of the floor structure was earth ground with the rate of the approximately 82%. 2. The average occupied area of sawdust bed per cow was 15.2 $m^2$, depth that 30 cm and the utilization period was 12 months. 3. Milk Yield was significantly higher at sawdust barn than at tie stall barn(P<0.01). Bacterial and somatic cell count in raw milk were less at the sawdust barn than in tie stall barn. However, there was not significance difference between two barns. 4. The labour hour needed to cow management in the sawdust barn was approximately 48% of that of tie stall barn. 5. The temperature and moisture content measured in sawdust bed were closely affected by seasonal ambient temperature. The skin and hair of cow were much cleaner at the PVC light roofed sawdust barn than any other roof materials. 6. The additives used for improving of fermentation did not show any effect on temperature and moisture content in sawdust bed. When the ambient temperature was $30.4^{\circ}C$, the surface temperature of measured 1 cm above the sawdust bed was $12.2^{\circ}C$ lower and the temperature of 100 cm above the sawdust bed was $2.4^{\circ}C lower under shading net facility than that of vinyl roofed one.7. The hoof length of miking cow was 7.95 cm in tie stall and 9.19 cm in sawdust barn with high significance (P<0.01). And disease occurence such as mastitis and foot-rot tended to decrease in the sawdust barn. 8. The number of total bacteria and coliform bacteria were less in the sawdust bed compared with earth ground resting area. And a parasite strongyloides papillosus was detected but without any infected cow. 9. The nitrate($NO_3N$) content in non-roofed earth ground resting area and earth ground under the sawdust bed was likely to pollute the ground water. 10. In economic point of view, rice hull bedding barn was the cheapest among different systems. And in the sawdust bedding barn PVC light + slate roofed barn was most desirable, and vinyl roofed one the least.

• Journal of Food Hygiene and Safety
• /
• v.31 no.4
• /
• pp.250-257
• /
• 2016

This study was conducted to extract the factors affecting the microbial safety of leaf and stem vegetables in the high school foodservice and to provide information for supplying the safe foodservice menu. The lunch and dinner menu (1,945 data) of the total 6 high schools at the Central and the South Region in March, June, September, and December were collected. The frequency analysis and the multiple correspondence analysis (MCA) based on the 3 factors (potentially hazardous food (PHF), leafy and stem vegetables in the menu, the cooking methods) were conducted. The most frequent PHF was the menu of blanched vegetables, salads, seaweeds and fried chicken. The most frequent consumed leaf and stem vegetables were spinach, chive, lettuce, Western cabbage, perilla leaf, iceberg lettuce, chicory, leek and broccoli. MCA based on the leaf and stem vegetables, the region, and the cooking method (cooked/non-cooked) showed that garlic stem and spinach were more used in the Central Region, while water drop-wort were more used in the South Region. Iceberg lettuce, Bok choy and leek were included frequently in the PHF menu. Plant products frequently used in PHF menu requires the food safety system such as Good Agricultural Practice (GAP) to reduce the microbial risk. The menu database according to raw materials based on cooking methods (heating or mixing) as well as the development and verification of menu based on the microbial safety will be contributed to provide the safer foodservice menu.

• Journal of Food Hygiene and Safety
• /
• v.27 no.3
• /
• pp.215-223
• /
• 2012

This study was performed to investigate hygienic behavior of food workers on the awareness of hand-washing, and the microbial load of their hands. This study focused on the comparison of fast food restaurant workers and full-service restaurant workers. A questionnaire survey and microbiological analysis were carried out for thirty fast food restaurant workers and forty full-service restaurant workers. Samples for microbiological analysis were collected through the glove-juice method from the hands of the food workers, and were analyzed for the presence of aerobic plate counts, total coliforms, fecal coliforms, Escherichia coli, Staphylococcus aureus, and Salmonella spp. Microbiological analysis was done according to the Food Code of Korea. In the survey, significant differences (p < 0.05) were found between the fast food restaurant workers and full-service restaurant workers in the use of hand washing tools and method of turning off water. More full-service restaurant workers responded to wash their hands after touching face, hair, or clothes; after handling raw food materials, and more fast food restaurant workers periodically (p < 0.05). Aerobic plate counts were higher in fast food restaurant workers while total coliforms were higher in full-service restaurant workers (p < 0.05). No remarkable difference was found between the two groups in the load of fecal coliforms, E. coli, S. aureus, and Salmonella spp. Poor hand hygiene practices were indicated by the positive results for E. coli, S. aureus, and Salmonella spp. on the hands of some food workers in both groups. The findings of this study emphasize the need for strict adherence to hand hygiene compliance among the food workers.

• The Korean Journal of Food And Nutrition
• /
• v.23 no.3
• /
• pp.352-360
• /
• 2010

This study was performed to develop a Korean natural cheese with traditional medical wine, making it different from foreign natural cheese. The effects of cheese with Sasam(Codonopsis lanceolate) wine(CLW) on the quality properties during the ripening period of natural cheese were investigated. The properties investigated were growth of lactic acid bacteria, characteristics of ripening, and sensory characteristics. Four vats of cheese were made on the same day from the same tank of fresh milk. Cheese samples were prepared with CLW at 2.0%, 4.0% and 6.0% of raw milk. Changes in gross composition, viable cell counts, pH, water soluble nitrogen(WSN), non casein nitrogen(NCN), non protein nitrogen(NPN), and proteolysis during maturation were measured. Polyacrylamide gel electrophoresis(PAGE) patterns were determined with control cheese. Viable cell counts of control and CLW cheese were not significantly different. The pH of CLW cheese increased gradually during maturation, and saponin levels and levels of NPN, NCN, and WSN were higher in CLW cheeses than control cheese. For most compositional data, the 4.0% CLW cheese was most similar to the control cheese. The PAGE pattern of cheese caseins indicated that the CLW cheeses degraded more rapidly than the control cheese. Control and 2.0% CLW cheese had good sensory scores, while scores for 4.0% and 6.0% CLW cheese were lower. However, sensory data depreciated with added levels of CLW, especially at a level of 4.0% or more. Further studies on levels of CLW and processing methods are required to improve sensory quality.

• Journal of Life Science
• /
• v.30 no.7
• /
• pp.606-613
• /
• 2020

This study investigated the effect of olive oil substitution ratio on physicochemical quality of pork patty. Five treatments were performed as follows: control (T0, 20% pork fat), T1 (pork fat 15% and olive oil gel 5%), T2 (pork fat 10% and olive oil gel 10%), T3 (pork fat 5% and olive oil gel 15%), and T4 (olive oil gel 20%). The moisture increased and fat amount was decreased in proportion to olive oil substitution ratio. The L^* and a^* values were highest levels in raw and cooked pork patty of T0, and the b^* value was highly enhanced in of cooked pork patty of T4. The water holding capacity, moisture and fat retention were significantly increased, and the cooking loss, diameter reduction and shrinkage ratio were decreased by olive oil substitution ratio. The hardness, springiness and chewiness showed the highest level in T4, and the cohesiveness and gumminess were highest in T0. The reduction ratio of cholesterol in T1, T2, T3 and T4 were 13.8%, 21.6%, 34.5% and 49.0%, respectively, indicating that the content was lowest level in T4. The palmitic acid was the most abundant saturated fatty acid, and the oleic acid was the most abundant unsaturated fatty acid. The unsaturated fatty acid of pork patty was increased in proportion to olive oil substitution ratio. Therefore, the olive oil gel substitution of low-fat pork patty results in a positive effect on the physicochemical qualities due to reduced cholesterol and saturated fatty acids.

• Journal of the East Asian Society of Dietary Life
• /
• v.21 no.3
• /
• pp.345-352
• /
• 2011

TMR feed was developed by adding mugwort (Artemisia capillaris), and was fed to Hanwoo cattle to investigate the effects of feeding mugwort on the physicochemical and sensory characteristics of rump meat, and to determine the feasibility of producing Hanwoo beef with high quality and functionality. The experimental samples consisted of the Hanwoo rump from cattle fed with fattening TMR feed without mugwort (T0), and those fed with fattening cattle TMR feed supplemented with mugwort (T1). T1 was significantly higher than T0 for Hanwoo rump characteristics of Hunter's $L^*$, $a^*$, $b^*$ values (p<0.05). VBN content for T0 was significantly higher than for T1, and EDA for T1 was significantly higher than for T0 (p<0.05). There was no significant difference between T0 and T1 in terms of pH, TBARS, and total bacterial numbers. Water holding capacity for T1 was significantly higher than for T0 (p<0.05), but there was no significant difference between T0 and T1 in terms of freezing loss, thawing loss, and cooking loss. Springiness for T1 was significantly higher than for T0 (p<0.05), and there was no significant difference between T0 and T1 in terms of hardness, cohesiveness, gumminess, chewiness, and shear force. There was no significant difference between T0 and T1 in terms of acid value, peroxide value, and iodine value. However, the melting point for T1 was significantly lower than for T0 (p<0.05). Aroma of raw meat for T1 was significantly superior to aroma for T0 (p<0.05). Taste, palatability of boiled meat, and juiciness of roasted meat for T1 were significantly superior to those parameters for T0 (p<0.05). These results suggest that the feed containing mugwort can be used to improve color and sensory characteristics, inhibit VBN formation, and also to increase antioxidant ability as a functional feed.

• Journal of the East Asian Society of Dietary Life
• /
• v.22 no.4
• /
• pp.497-505
• /
• 2012

The nutritional, physicochemical and sensory quality characteristics of chilled loins of Jeju Black Cattle, Hanwoo and imported Australian beef were compared. For nutritional properties, moisture and crude protein contents of Jeju Black Cattle beef were 65.91% and 17.39% respectively, the lowest among the comparison groups. On the other hand, their crude fat and crude ash contents were 15.89% and 0.79%, respectively, the highest among the comparison groups. There was a significant difference in crude ash content, but there was no significant difference in the other properties. The Fe and Zn contents of Jeju Black Cattle beef were 29.85 and 48.13 ppm, respectively, lower than those of Hanwoo beef, although the difference was not significant. These values were higher than those of Australian beef (p<0.05). There was no significant difference among the samples in contents of Ca, P, Na and Cu. The total amino acid and essential amino acid contents of Jeju Black Cattle beef were 16.81% and 9.08%, respectively, the lowest among the samples, although the difference was not significant. The ratio of essential amino acids to total amino acids of Jeju Black Cattle beef was 54.01%, the highest among the samples. The saturated fatty acid (43.25%), stearic acid (13.51%), linoleic acid (2.39%) and essential fatty acid (2.47%) contents of Jeju Black Cattle beef were the lowest. However, their unsaturated fatty acid (56.69%), oleic acid (47.80%) and MUFA/SFA ratios were the highest, and there were significant differences compared with Australian beef. There was no significant difference in the PUFA/SFA ratio. Among physicochemical properties, redness ($a^*$) of Jeju Black Cattle beef was the highest while melting point was the lowest (p<0.05). There were no significant differences in lightness ($L^*$), yellowness ($b^*$), pH, water holding capacity, cooking loss or shear force value. For sensory properties, raw meat aroma, cooked meat aroma and palatability of Jeju Black Cattle beef were superior compared to other comparison groups, with significant differences in comparison with Australian beef (p<0.05). However, there were no significant differences in taste, juiciness, or tenderness of cooked meat.

• Food Science of Animal Resources
• /
• v.22 no.3
• /
• pp.240-246
• /
• 2002

The seasoned pork with soy sauce(SS) or Kochujang(SK) was manufactured using hind and fore leg as main raw material and the quality characteristics and shelf-life were investigated during storage at 5$\^{C}$ and 10$\^{C}$ after having packaged with air. The initial total aerobic plate counts(APC) of SS and SK were 5.24 and 5.75 log10 CFU/㎠, respectively. APC exceeded 7 log10CFU/cm2 after 10 days at 5$\^{C}$ and 6 days at 10$\^{C}$ far SS, and after 6 days at 5$\^{C}$ and 4 days at 10$\^{C}$ for SK, respectively. In the sensory test, the SS samples stored at 5$\^{C}$ and 10$\^{C}$ were assessed as lower than 3.0 points, the criterium of consumer acceptability, after 10 and 8 days, respectively. In the case of SK samples, the point of this time was at day 10 and 6, respectively when they were stored at 5$\^{C}$ and 10$\^{C}$. As storage time extended, pH and water content tended to decrease. Contrarily, the increase of TBA and VBN values was observed during storage and this was more pronounced at 10$\^{C}$ than at 5$\^{C}$ . The oxygen concentration in the package was 19.8 and 19.9% each for 55 and SK samples at the beginning but it was gradually decreased thereafter. On the other hand, the concentration of carbon dioxide was increased with the extension of storage. Based on the above results, the shelf-lives of seasoned pork were estimated to be 8 days for SS and SK stored at 5$\^{C}$ and 6 days for SS and 4 days for SK stored at 10$\^{C}$.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.23 no.2
• /
• pp.232-237
• /
• 1994

Changes of volatile components in modified oleoresin red pepper during cooking at high temperature were investigated. Dried red pepper was milled to 100mesh of size particle and oily compounds were extracted by reduced pressure steam distrillation. The rest part was reextracted and concentrated. The extracts were combined. The same volume of water and 4% of polyglycerol condensed ricinoleate (PGDR) were added to the combined extract, and emulsified to make oleoresin red pepper 119 volatile compounds were separated from the dried red pepper and oleoresin and 35 components were identified in both samples. The major flavor compounds were identified to be 2-methoxy-phenol, 2, 6-bis(1, 1-dimethylethyl)-4-methyl-phenol, 1, 4-dimethylbenzene, thylbenzene, 1, 2-benzenedicarboxylic acid, 2-methoxyl-4-methylphenol, 4-ethyl-2-methoxy-phenol, and 5- methyl-2-furancarboxyaldehyde, and their transferal from raw red pepper to oleresin was low. 93 voltilie compounds were isolated after 3 hours cooking at 100 and 82 volitile compounds were separated after that at $150^{\circ}C$. Degeneration of volatile compounds was peculiarly proportional to the temperature of cooling. Capsaicin was relatively stable during cooking and remaining ratio after cooking at 100 and $150^{\circ}C$ was 84.7% and 73.3%. respectively. Oleoresin from red pepper had a little antioxidation effect at $100^{\circ}C$ cooking, but, antioxidation effect at $150^{\circ}C$ cooking was not shown due to degradation of capsaicin.

• Clean Technology
• /
• v.18 no.1
• /
• pp.102-110
• /
• 2012

In this study, the production of bio-diesel from animal oil by esterification and trans-esterification was investigated. There were three different extraction methods for oil extraction from raw animal fat. Heterogeneous catalysts such as Amberlyst-15 and Amberlyst BD-20 and a homogeneous catalyst such as sulfuric acid were used for esterification. Among three catalysts, the removal efficiency of Free Fatty Acid (FFA) was the highest in sulfuric acid. Response surface method was carried out to find the optimal esterification condition of sulfuric acid and methanol. After the esterification under the optimal condition, this animal fat was used for the trans-esterification. Animal oil used for trans-esterification was below 1% of FFA content and 0.09% of water content. The catalysts for trans-esterification were KOH, NaOH and $NaOCH_3$. To investigate the effects of catalyst type and amount on trans-esterification, The amount of catalyst were changed with 0.3, 0.6 and 0.9 wt%. The molar ratio of methanol/oil was changed with 4, 6, 9 and 12. The amount of catalyst was fixed to 0.8 wt%. The KOH catalyst showed the highest FAME conversion for trans- esterification, and the optimal methanol/oil weight ratio was 6. In the experiments of various catalysts and methanol molar ratios, the highest content of FAME is 96%. However, this FAME content was below Korean bio-diesel standard which is 96.5% of FAME content. After distillation, FAME content increased to 98%.