• Journal of Environmental Health Sciences
• /
• v.23 no.3
• /
• pp.80-84
• /
• 1997

This study was conducted from April 11, 1996 to May 12, 1996 in Taegu and its vicinities. The purpose of this study was to determine storage conditions of pasteurized fluid milk at retail food establishments. The results are summarized as follows 1. 12(9.5%) out of 126 retail food establishments displayed out dated fluid milk. In a county, more out dated fluid milk(18.2%) were found in retail food establishments in town area eup than those (2.5%) in township area myeon.(P<0.05) 2. 47(37.3%) retail food establishments stored fluid milk below 10$\circ$C, and 79(62.7%) stored them above 10$\circ$C. 3. Only 18(14.3%) refrigerators out of 126 had thermometers to check temperature of a refrigerator. 4. Coliform bacteria were isolated from 3(2.4%) out of 126 fluid milk samples.

• Microbiology and Biotechnology Letters
• /
• v.16 no.6
• /
• pp.517-521
• /
• 1988

This study focused on the psychrotrophic post-pasteurization contamination of fluid milk pro-ducts which were processed by HTST system. Pasteurized line samples and container samples of each fluid milk product (whole milk and skim milk) were taken in a large fluid milk plant. tine samples were collected through nine and five different sampling locations for whole milk and skim milk products, respectively. Each sample was subjected to preliminary incubation (PI) at 21$^{\circ}C$ for 16h followed by standard plate count (SPC) and crystal violet tetrazolium agar count (CVT). Flavor, SPC, and psychrotrophic bacteria count (PBC) were determined after 7 d at 7.2$^{\circ}C$. In addition, ten sequential container samples (packaged in 1000ml paperboard containers) were taken from a filler at the beginning of each product run. These samples were used for PI followed by SPC and CVT. In addition, flavor evaluations, SPC and PBC tests were conducted after 7,10, and 14 d at 7.2$^{\circ}C$. The mean PI-CVT values for the line samples showed differences depending on the location. There was major contamination between pasteurized storage tank and the filler. The PI-CVT counts for each container sample were negatively correlated with flayer scores at 10 and 140. There were good correlations among PI-CVT values of line samples and the percentage of total container samples with acceptable flavor after 10d.

• Korean Journal of Food Science and Technology
• /
• v.31 no.6
• /
• pp.1518-1522
• /
• 1999

This work was to determine the quality changes of milk with respect to the chemical components when HTST pasteurized by microwave energy. Raw milk was HTST pasteurized $(at\;72^{\circ}C\;for\;15\;sec)$ by three methods; by heating in a stainless steel tube immersed in a hot water bath (MP0), by heating in a microwave cavity to a desired temperature and then holding in a hot water bath (MP1) and by both heating and holding in a microwave cavity (MP2). There were no significant differences in pH and titratable acidity before and after pasteurization and among the different pasteurization methods. MP1 or MP2 showed better retention or less destruction than MP0 with respect to vitamin A, vitamin $B_1$, ascorbic acid and lysine content. The higher retention of nutrients of the MP1 or MP2 supports the possibility of using microwave energy for the pasteurization of milk and other fluid food products.

• Korean Journal of Food Science and Technology
• /
• v.31 no.5
• /
• pp.1392-1396
• /
• 1999

This work was to apply the microwave energy to HTST pasteurization of milk in order to prevent undesirable quality changes due to the fouling and overheating on the surface of heat exchanger. A continuous tubulartype microwave pasteurization system was designed using a domestic microwave oven(800w and 2,450MHz). Raw milk was HTST pasteurized$(at\;72^{circ}C\;for\;15\;sec)$ by three methods; by heating in a stainless steel tube immersed in a hot water bath(MP0), by heating in a microwave cavity to a desired temperature and then holding in a hot water bath(MP1) and by both heating and holding in a microwave cavity(MP2). The microbial quality based on the total plate count and Psychotrophic bacterial count was in the order MP0, MP2 and MP1 ; however, the quality difference was not significant(p<0.05) when the initial microbial numbers were involved in the statistical analysis. In addition, the three samples pasteurized by different methods showed the similar microbial quality based on the coliform count and phosphatase activity. The similar microbial quality of the three samples supports the potential use of microwave energy for the pasteurization of milk and other fluid food products.