• Environmental Engineering Research
• /
• v.23 no.2
• /
• pp.159-163
• /
• 2018

The feasibility of applying coagulation-integrated microfiltration (MF) as a pretreatment for an ultrafiltration (UF) feed in oily wastewater treatment was investigated. The effects of different coagulants on oil removal rates from wastewater were studied. The maximum oil removal rate of 82% was obtained after coagulation with 130 mg/L of polyaluminium chloride (PAC). UF flux reached $95L/(m^2{\cdot}h)$ with coagulation-integrated MF as pretreatment. This value was 2.5 times higher than that flux obtained without pretreatment. The value of UF flux increased as the transmembrane pressure (TMP) and cross-flow velocity (CFV) of the UF module increased. UF flux gradually increased when TMP and CFV exceeded 0.4 MPa and 3 m/s, respectively, because of concentration polarization and membrane fouling stabilization. Chemical oxygen demand reduction and oil removal rate reached 95.2% and 98.5%, respectively, during integrated membrane processing with a PAC concentration of 130 mg/L, TMP of 0.4 MPa, and CFV of 3 m/s for UF. In addition, sequentially cleaning the fouling membrane with NaOH and $HNO_3$ aqueous solutions caused UF flux to recover to 90%. These encouraging results suggested that the hybrid integrated membrane process-based coagulation and MF + UF are effective approaches for oily wastewater treatment.

• Journal of Biosystems Engineering
• /
• v.43 no.1
• /
• pp.37-44
• /
• 2018

Purpose: The objective of this study was to investigate the high-efficiency anaerobic digestion of organic wastes with high fat content. Specifically, the analysis focused on biogas production performance with a focus on carbon number and the double bond count of the long-chain fatty acids (LCFAs), which are hydrolysis products of triglycerides. Methods: Experiments were performed under mesophilic anaerobic conditions with a feed-to-microorganism ratio (F/M) of 1.0. Biogas production performance was analyzed through biogas production patterns, lag-phase, and the time required for 90% biogas production (T90). Results: Biogas production increased when the content of unsaturated LCFAs (containing relatively large numbers of carbon atoms) increased. In substrate containing LCFAs with four or more double bonds, although the initial lag-phase in biogas production was shortened, development of a three-step lag-phase resulted in decreased biogas production. These results suggest that high rates of anaerobic digestion are possible when the LCFAs have high unsaturated fatty acid content with three or fewer double bonds. Conclusions: When various types of LCFAs are digested anaerobically, biogas production performance can be improved if the unsaturated fatty acid content and number of double bonds are optimized for maximum production.

• Asian-Australasian Journal of Animal Sciences
• /
• v.12 no.8
• /
• pp.1215-1221
• /
• 1999

Twelve rumen fistulated cross-bred calves were divided into three groups and fed wheat straw and concentrate mixture according to their maintenance requirement. Animals in group II and III were fed 50 and 100mg rumensin per day, in addition to basal feed. Supplementation of rumensin in the diet decreased the dry matter intake significantly (p<0.05) along with a significant decrease in the straw intake. Digestibility coefficients of all the nutrients were not affected significantly except that of CF digestibility which was lower (p<0.05) in groups II and III as compared to group I. Among N-parameters in the rumen fluid, mean $NH_3-N$ was significantly lower in groups II and III (19.13 and 18.63 mg N/100 ml respectively) than in group I (22.68); total-N and TCA-ppt-N did not differ among the three groups. Total VFA concentration did also not differ among the three groups, however, propionate increased from 24.33 molar % to 32.73 while acetate and butyrate decreased respectively from 65.85 to 58.81% and 9.79 to 8.46%. Total VFA, bacteria and protozoa production rates were not affected significantly due to rumensin in diet. Methane production per kg DDM as well as % of methane in total gas were reduced at both the levels of rumensin on different concentrate ratios with wheat straw as roughage. Similar trend was also observed with rice straw and concentrate mixture as substrate with rumensin addition.

• Asian-Australasian Journal of Animal Sciences
• /
• v.10 no.4
• /
• pp.371-377
• /
• 1997

Objective of the present study were to investigate effects of different levels of concentrate in complete rations on nutrient digestibilities and ruminal fermentation in sheep and growth performance in Korean native bulls. Increasing levels of concentrate (35, 50, 65, and 80% of complete rations) improved digestibilities of dry matter (DM), crude protein (CP) and ether extract (EE) without affecting digestibility of neutral detergent (NDF) and acid detergent fiber (ADF). Increasing levels of concentrate decreased ruminal fluid pH but increased concentrations of $NH_3-N$, propionic acid, and total volatile fatty acids (VFA). Both the disappearance rates of DM and nitrogen (N) in an in sacco study were linearly increased as the levels of concentrate in complete rations increased. Meanwhile, increasing levels of concentrate in complete rations improved growth rate and feed conversion ratio in Korean native bulls. In conclusion, the complete rations containing 80% concentrate showed better digestibility and energy supply than those of the lower levels (35, 50 and 65%) of concentrate of the rations, resulting in improved growth performance of Korean native bulls.

• Journal of Environmental Science International
• /
• v.16 no.1
• /
• pp.121-128
• /
• 2007

This study performed in order to evaluate the effects of pipe materials on corrosion and bacteria regrowth using a laboratory scale batch test. Two varieties of feed water with different microbial conditions were selected: tap water, surface river water (Han River water), and five pipe materials; carbon steel, copper, galvanized iron, stainless steel, and PVC, Carbon steel and galvanized iron pipes showed higher corrosion rates than other materials. In terms of attached bacterial growth, pipes with PVC and stainless steel showed higher bacteria concentration compared to other materials. Pseudomonas vesicularis was the predominant bacteria found on biofilm. The behavior of bacterial growth in the pipes was observed using a scanning electron microscope.

• Carbon letters
• /
• v.5 no.4
• /
• pp.170-179
• /
• 2004

The equilibrium and dynamic adsorption of methylene blue from aqueous solutions by activated carbons have been studied. The equilibrium studies have been carried out on two samples of activated carbon fibres and two samples of granulated activated carbons. These activated carbons have different BET surface areas and are associated with varying amounts of carbon oxygen surface groups. The amounts of these surface groups was enhanced by oxidation with $HNO_3$ and $O_2$ gas at $350^{\circ}C$ and decreased by degassing at increasing temperatures of $400^{\circ}$, $650^{\circ}$ and $950^{\circ}C$. The adsorption increases on oxidation of the carbon surface and decreases on degassing. The increase in adsorption has been attributed to the formation of acidic carbon-oxygen surface groups and the decrease in adsorption on degassing to their elimination. The dynamic adsorption studies have been carried out on the two granulated activated carbons using two 50 mm diameter glass columns at a feed concentration of 300 mg/L and at different hydraulic loading rates (HLR) and bed heights. The minimum achievable concentrations are comparatively lower while the adsorption capacities are higher for GAC-S under the same operating conditions. The adsorption capacity of a carbon increases with increase in HLR but the rate of increase decreases at higher HLR values.

• Particle and aerosol research
• /
• v.4 no.2
• /
• pp.37-50
• /
• 2008

Concerns on centrifugal classifiers, of which have cut sizes are below few micrometers, have been increased and it is prospected to be used in extensive industries, such as manufacturing the fine minerals, cosmetics, advanced electric materials, and life science. This paper reviews the recent progress of research and development on the centrifugal classifiers. General categorization of classifiers for feeds was assessed and separation mechanism of the classifiers was followed. History of centrifugal classifiers was explored and some points to be improved were briefly indicated. Fundamental theory of the classification by centrifugal classifiers was pearly studied, and advanced and further understandings on factors affecting the separation or grading efficiency are described. Factors determining the classification precision and efficiency of centrifugal classifiers, such as geometry, rotational speed and inclined angle of rotating vanes, feed and air flow rates, and rotor dimensions are reviewed.

• Korean Journal of Fisheries and Aquatic Sciences
• /
• v.1 no.2
• /
• pp.121-127
• /
• 1968

This research has been dealt with the nutritional component analysis of two kinds of non-edible marine algae, Sargassum herneri (Turner) C. Ag. and Zostera marina Linne which grow abundantly around the southern coast of Korea, These marine algae were mixed in several kinds of samples rates with the combined feed for poultry sold in the market. These were given to 35 chicken in seven test divisions respectively. We have experimented with 35 chicken grown up for two weeks after hatchout. The combined food for poultry obtained from the market was set up as control divisions. The experiments were as follows: 1) The average weight increase in each test division during feeding (Table 5, Fig.2). 2) Food conversion rate and food efficiency in each test division (Table 7). 3) The comparison of digestive rate of crude protein during feeding (Table 8), The results were as follows: 1) The weight increasing rate of the test animal stock fed the food containing $5\~10\%$ of Sargassum horneri (Turner) C. Ag. powder was higher than the rate of those fed only market food for poultry. 2) The stock given food containing $10\%$ Zostera marine powder showed lower growth than the control divison. 3) No apparent trouble owing to salt component involved in the marine algae was found. 4) The stock given food containing sodium glutaminate and Sargassum horneri (Turner) C. Ag. had better result than that without sodium glutaminate.

• Membrane and Water Treatment
• /
• v.1 no.2
• /
• pp.139-158
• /
• 2010

This work focuses on the application of nanofiltration (NF) to the concentration of a pharmaceutical product, Clavulanate ($CA^-$), from clarified fermentation broths, which show a complex composition with six main identified ions ($K^+$, $Cl^-$, ${NH_4}^+$, $H_2{PO_4}^-$, ${SO_4}^{2-}$ and $CA^-$), glucose and glycerol. The solutes transport through the NF membrane pores was investigated using the SEDE (Steric, Electric and Dielectric Exclusion) model. This model was applied to predict the rejection rates of the initial feed solution and the final concentrated solution (10-fold concentrated solution). The best results were achieved with a single fitted parameter, ${\varepsilon}_p$ (the dielectric constant of the solution inside pores) and considering that the membrane selectivity is governed by steric, electric (Donnan) and Born dielectric exclusion mechanisms. While the predicted intrinsic rejections of solutions comprising up to six ions and uncharged solutes were in good agreement with the experimental values, the deviations were much larger for the 10-fold concentrated solution.

• Asian-Australasian Journal of Animal Sciences
• /
• v.8 no.5
• /
• pp.443-447
• /
• 1995

Fifteen Karan-Swiss male calves of 9-12 months of age were divided into three groups of five each in a randomised block design. Animals in group I were fed wheat straw ad lib. and concentrate mixture according to their requirements, while in group II and III the animals were fed with 1/3 of the required concentrate mixture replaced by UMM licks 'Ex' and 'F', respectively. The DMI (kg/day as well as per 100 kg b.wt.) were similar (p > 0.05) among different groups of animals, however, the digestibility of DM as well as OM enhanced from $52.85{\pm}1.48$ to $58.36{\pm}1.89$ and $55.33{\pm}1.48$ to $60.12{\pm}1.75$, respectively. Growth rates of the calves were $533.8{\pm}27.25$, $532.3{\pm}42.24$ and $538.4{\pm}18.68$ g/d in groups I, II and ill (p > 0.05), respectively. Body composition and N balances of the animals were not affected by supplementation of UMM licks, however, protein retention efficiency was higher in group III ($82.57{\pm}2.54$) though nonsignificant. Feed cost/day was reduced from Rs. 7.92 (group I) to Rs. 4.62 (group II) and Rs. 3.44 (group III). Hence, partial replacement of concentrates by UMM licks reduced the cost of feeding of growing calves by 41.7 to 56.6% without affecting the growth performance.