본 연구는 잔골재 및 혼화재 종류, W/C에 따른 콘크리트의 폭열성상 및 압축강도 초음파속도 등의 공학적 특성을 검토함으로서 폭열 방지 및 화재 피해를 입은 콘크리트 구조물의 재사용과 보수보강, 안전도평가 등에 기초적인 자료를 제시하고자 한다. 폭열성상을 살펴보면, 잔골재에 따라서는 바다모래를 사용한 경우 폭열이 발생하지 않았거나 약간의 폭열이 나타나는 정도이나 재생잔골재나 부순모래를 사용한 경우에는 폭열이 심하게 나타났다. 또한 혼화재 종류에 따라서는 대체로 유사한 폭열성상을 나타내었다. 한편, W/C 30.5%의 고강도 영역에서는 대부분 폭열하였으나 W/C 55%의 보통강도 영역에서는 대부분 폭열하지 않았다. 잔존 압축강도는 W/C 55%의 경우 평균 45%로 나타났으며, W/C 30.5%의 경우에는 평균 64%로 나타났다. 초음파속도는 잔골재 종류 및 W/C, 가열시간에 따라 다르게 나타났으며, 가열 후 3개월이 가열 후 1개월보다 약 1.3∼8.4%의 초음파속도 회복을 보였다.
This research examines the eccentric compression performance of composite columns composed of recycled aggregate concrete (RAC)-filled square steel tube and profile steel. A total of 17 specimens on the composite columns with different recycled coarse aggregate (RCA) replacement percentage, RAC strength, width to thickness ratio of square steel tube, profile steel ratio, eccentricity and slenderness ratio were subjected to eccentric compression tests. The failure process and characteristic of specimens under eccentric compression loading were observed in detail. The load-lateral deflection curves, load-train curves and strain distribution on the cross section of the composite columns were also obtained and described on the basis of test data. Results corroborate that the failure characteristics and modes of the specimens with different design parameters were basically similar under eccentric compression loads. The compression side of square steel tube yields first, followed by the compression side of profile steel. Finally, the RAC in the columns was crushed and the apparent local bulging of square steel tube was also observed, which meant that the composite column was damaged and failed. The composite columns under eccentric compression loading suffered from typical bending failure. Moreover, the eccentric bearing capacity and deformation of the specimens decreased as the RCA replacement percentage and width to thickness ratio of square steel tube increased, respectively. Slenderness ratio and eccentricity had a significantly adverse effect on the eccentric compression performance of composite columns. But overall, the composite columns generally had high-bearing capacity and good deformation. Meanwhile, the mechanism of the composite columns under eccentric compression loads was also analysed in detail, and the calculation formulas on the eccentric compression capacity of composite columns were proposed via the limit equilibrium analysis method. The calculation results of the eccentric compression capacity of columns are consistent with the test results, which verify the validity of the formulas, and the conclusions can serve as references for the engineering application of this kind of composite columns.
본 연구에서는 압밀 배수를 촉진하기 위한 공법에서 사용되는 조립토나 골재로의 세립토 관입 정도를 다양한 조건에서 실험을 통해 확인하여 세립토의 조립토나 골재로의 관입특성을 규명하였다. 지중응력에 대응하는 압력의 크기나 세립토 함수비의 변화에 상관없이 해성점토가 해사나 표준사로는 관입되지 않아 모래 배수/말뚝 체에서의 배수저항 현상은 전혀 발생하지 않은 것으로 확인되었고, 오히려 물다짐에 의한 모래 배수/말뚝 체의 전단강도가 크게 증대한 것으로 보인다. 골재의 경우에는 골재의 입경이 클수록 해성점토의 관입깊이는 증대하고, 같은 골재라도 압력이나 함수비가 클수록 해성점토의 관입깊이는 증대함을 알 수 있었으며, 액성한계보다 작은 함수비를 갖는 해성점토는 입자가 작은 편인 13mm 골재로의 관입깊이가 현저하게 줄어들어 그 관입깊이가 상당히 적다 하더라도 일단 관입된 세립토에 의해 배수/말뚝 체에서의 배수저항 현상이 발생할 것으로 사료된다. 따라서 자연함수비가 액성한계보다 큰 매우 연약한 세립토층에서는 모래보다 큰 입경을 갖는 쇄석이나 자갈 등 골재를 사용하는 gravel drain 공법 및 gravel compaction pile 공법 등의 적용을 지양해야 하고, 자연함수비가 액성한계보다 작은 연약한 세립토 지반에서도 gravel drain 공법 및 gravel compaction pile 공법 등과 같은 연직배수공법을 적용할 경우 그 효용성은 크게 저하할 것으로 사료된다.
본 연구에서는 각종 건축물의 해체 공사에서 발생하는 다량의 폐콘크리트를 이용한 재생골재의 활용방안으로 유해폐기물 고형화 방법에 있어 요구되는 재생골재의 공학적 특성을 파악하고 그 적합성을 평가하기 위하여 실험하였다. 시멘트 모르타르에 재생골재를 기존 모래와 혼합하여 재생골재 5-15%일때 28일 양생 모르타르의 강도는 1급 콘크리트 벽돌 C종의 강도기준인 $163kg/cm^2$을 모두 상회하였다. 안정성 평가를 위한 용출실험 결과 Cu, Cd, Pb, Cr, As의 경우 법적기준치 보다 낮았으나, Hg의 경우 기준치보다 용출농도가 높게 나타내었는데 이는 Hg이 단순히 물리적으로 고정되기 때문인 것으로 판단된다. 시멘트의 모르타르의 결정구조를 파악하기 위한 XRD 분석결과 $Ca(OH)_2$, ettringite, CSH 피크가 나타났으며, 양생시간이 길어짐에 따라 나타나는 비교적 안정된 수화물인 CSH의 피크가 높게 나타났다. 위의 실험 결과 재생골재 치환량 5-10%일 때 혼화재인 비산회, 하수슬러지 소각재를 첨가한 경우 유해폐기물고형화 재료로써 활용가능성이 충분하나 압축강도를 좀 더 증진시킬 수 있는 다른 혼화재 및 첨가제 등에 관한 연구가 진행된다면 효과적인 재활용 방안이 될 것으로 판단된다.
이 연구는 현재 생산되고 있는 재생굵은골재와 재생잔골재를 폴리머 콘크리트 제조에 사용하기 위하여 불포화 폴리에스테르 수지, 개시제, 재생굵은골재, 쇄석, 재생잔골재, 규사, 탄산칼슘을 사용한 폴리머 콘크리트에 대한 물리 역학적 특성을 구명한 것으로서, 이 연구를 통해 얻어진 결과를 요약하면 다음과 같다. 1. 단위용적중량은 $2,127{\sim}2,239kg/m^3$의 범위로써 쇄석을 사용한 폴리머 콘크리트의 단위용적중량 $2,165{\sim}2,282kg/m^3$과 거의 유사하였고, 재생골재의 치환률이 증가할수록 감소하는 경향을 나타내었다. 2. 압축강도는 80.5~88.3 MPa의 범위로써, 쇄석을 사용한 폴리머 콘크리트의 압축강도 84.5~89.2 MPa에 비하여 1~2%정도 감소하였으며, 재생잔골재를 사용한 경우가 규사를 사용한 경우에 비하여 압축강도가 크게 나타나는 경향을 보였다. 3. 휨강도는 19.2~21.5 MPa의 범위로써, 쇄석을 사용한 폴리머 콘크리트의 휨강도 20.2~22.4 MPa에 비하여 4%정도 감소하였으며, 재생골재의 사용량이 증가할수록 휨강도는 감소하였다. 4. 동탄성계수는 $254{\times}10^2{\sim}288{\times}10^2MPa$의 범위로, 쇄석을 사용한 폴리머 콘크리트의 동탄성계수 $267{\times}10^2{\sim}294{\times}10^2MPa$보다 2~4%정도 감소되었으며, 재생골재의 사용량이 증가할수록 감소하였다. 5. 재생굵은골재와 재생잔골재를 사용한 폴리머 콘크리트를 개발하여 활용할 경우, 건설폐기물의 경제적이고 환경적인 처리가 가능할 것으로 기대되며, 고부가 가치의 환경친화적인 건설재료가 될 것으로 판단된다.
본 연구는 골재 생산과정에서 화감암 파쇄시 풍화정도가 골재의 입도분포 및 미석분 발생량에 미치는 영향을 평가하였다. 경북 거창의 골재 채석장에서 슈미스 햄머 측정값으로 강도 차가 있는 3개 지역에서 암석 시료를 채취하였다. 실내에서 동일 조건에서 죠크러셔로 파쇄를 한 후 입도분석, 광물 분석, 화학분석과 풍화지수를 산출했다. 슈미트 햄머 측정값은 56, 28, <10로 나타났고 풍화지수인 CIA 및 CIW 값도 차이가 나타나 시료들을 풍화도에 따라서 경암, 연암 및 풍화암으로 구분했다. 경하에서 풍화암으로 갈수록 작은 입도분포를 보이며, 변질광물로 견운모와 같은 점토광물의 비율이 높아졌다. 경암은 장석 및 석영 비율이 높았고 백운모 및 고령석(kaolinite)의 비가 작았다. 죠크러셔 파쇄 결과 경암은 굵은 파쇄물(13.2mm)을 많이 생산한 반면 풍화가 진행된 연암 및 풍화암은 가는 파쇄물(4.75mm)을 생산했다. 전자는 베타분포 곡선 특징을 보였고 후자는 쌍봉 분포 곡선을 보였다. 미석분(0.71mm 체 이하; 중량 %) 발생은 경암, 연암, 풍화암에서 13%<21%<22%로 증가하여 풍화도가 클수록 미석분이 많이 발생했다. 미석분은 습식 골재 생산 공정에서 샌드 유닛(모래탈수장치)의 운전으로 회수된다. 따라서 골재생산 공정에서 슬러지 발생량을 최소화하기 위해 사이클론의 최적 운전에 대한 연구가 필요할 것으로 판단되었다.
The generation of energy and the cooling of system using thermoelectric semiconductor material have been in spotlight. Thermoelectric effect increases with the decrease of the thermal conductivity. In the thermoelectric devices, thermal conductivity is related to phonon scattering. Therefore, few studies have been conducted in the thermoelectric materials dispersed nano oxide particle for increasing the phonon scattering. However, core-shell structure which nano particle disperses in solvents and then which thermoelectric materials coated on the nano oxide particles has not been reported. In this study, we selected commercial nano powder such as $Al_2O_3$. This nano particle was about 20nm and was crushed aggregate by mechanical treatment. We have developed the effect of the dispersant and the solvent. The properties of particles were evaluated by SEM, TEM, particle size analysis, and BET. Dispersion and dispersion stability were evaluated by electronic microscope and turbidity.
Recently, as industrialization is rapidly growing and the standard of life is rising, the quantities of waste glasses have been hastily increased and most of them are not recycled but abandoned. It cause some problems such as the waste of natural resources and environmental Pollution. Therefore, this study was conducted basic experimental research to analyze the possibilities of recycling of waste glasses(crushed waste glasses outbreaking from our county such as brown, green, colorlessness) as fine aggregates for concrete. Test results of fresh concrete, slump and compacting factors decrease because grain shape is angular and air content increase due to involving small size particles so much in waste glasses. Also compressive, tensile and flexural strengths decrease with increase of the content of waste glasses. In conclusion, the content of waste glasses below 30% is reasonable
This paper reports an experimental study into the rheological behaviour of Smart Dynamic Concrete (SDC). The investigation is aimed at quantifying the effect of the varying amount of mineral admixtures on the rheology, setting time and compressive strength of SDC containing natural sand and crushed sand. Ordinary Portland cement (OPC) in conjunction with the mineral admixtures was used in different replacement ratio keeping the mix paste volume (35%) and water binder ratio (0.4) constant at controlled laboratory atmospheric temperature ($33^{\circ}C$ to $35^{\circ}C$). The results show that the properties and amount of fine aggregate have a strong influence on the admixture demand for similar initial workability, i.e., flow. The large amounts of fines and lower value of fineness modulus (FM) of natural sand primarily increases the yield stress of the SDC. The mineral admixtures at various replacement ratios strongly contribute to the yield stress and plastic viscosity of SDC due to inter particle friction and cohesion.
As part of a fundamental study on the volume reduction of contaminated concrete wastes, the separation characteristics of the aggregates and the distribution of the radioactivity in the aggregates were investigated. Radioisotope $^{60}Co$ was artificially used as a model contaminant for non-radioactive crushed concrete waste. Volume reduction for radioactively contaminated dismantled concrete wastes was carried out using activated heavy weight concrete taken from the Korea Research Reactor 2 (KRR-2) and light weight concrete from the Uranium Conversion Plant (UCP). The results showed that most of the $^{60}Co$ nuclide was easily separated from the contaminated dismantled concrete waste and was concentrated mainly in the porous fine cement paste. The heating temperature was found to be one of the effective parameters in the removal of the radionuclide from concrete waste. The volume reduction rate achieved was above 80% for the KRR-2 concrete wastes and above 75% for the UCP concrete wastes by thermal and mechanical treatment.
본 웹사이트에 게시된 이메일 주소가 전자우편 수집 프로그램이나
그 밖의 기술적 장치를 이용하여 무단으로 수집되는 것을 거부하며,
이를 위반시 정보통신망법에 의해 형사 처벌됨을 유념하시기 바랍니다.
[게시일 2004년 10월 1일]
이용약관
제 1 장 총칙
제 1 조 (목적)
이 이용약관은 KoreaScience 홈페이지(이하 “당 사이트”)에서 제공하는 인터넷 서비스(이하 '서비스')의 가입조건 및 이용에 관한 제반 사항과 기타 필요한 사항을 구체적으로 규정함을 목적으로 합니다.
제 2 조 (용어의 정의)
① "이용자"라 함은 당 사이트에 접속하여 이 약관에 따라 당 사이트가 제공하는 서비스를 받는 회원 및 비회원을
말합니다.
② "회원"이라 함은 서비스를 이용하기 위하여 당 사이트에 개인정보를 제공하여 아이디(ID)와 비밀번호를 부여
받은 자를 말합니다.
③ "회원 아이디(ID)"라 함은 회원의 식별 및 서비스 이용을 위하여 자신이 선정한 문자 및 숫자의 조합을
말합니다.
④ "비밀번호(패스워드)"라 함은 회원이 자신의 비밀보호를 위하여 선정한 문자 및 숫자의 조합을 말합니다.
제 3 조 (이용약관의 효력 및 변경)
① 이 약관은 당 사이트에 게시하거나 기타의 방법으로 회원에게 공지함으로써 효력이 발생합니다.
② 당 사이트는 이 약관을 개정할 경우에 적용일자 및 개정사유를 명시하여 현행 약관과 함께 당 사이트의
초기화면에 그 적용일자 7일 이전부터 적용일자 전일까지 공지합니다. 다만, 회원에게 불리하게 약관내용을
변경하는 경우에는 최소한 30일 이상의 사전 유예기간을 두고 공지합니다. 이 경우 당 사이트는 개정 전
내용과 개정 후 내용을 명확하게 비교하여 이용자가 알기 쉽도록 표시합니다.
제 4 조(약관 외 준칙)
① 이 약관은 당 사이트가 제공하는 서비스에 관한 이용안내와 함께 적용됩니다.
② 이 약관에 명시되지 아니한 사항은 관계법령의 규정이 적용됩니다.
제 2 장 이용계약의 체결
제 5 조 (이용계약의 성립 등)
① 이용계약은 이용고객이 당 사이트가 정한 약관에 「동의합니다」를 선택하고, 당 사이트가 정한
온라인신청양식을 작성하여 서비스 이용을 신청한 후, 당 사이트가 이를 승낙함으로써 성립합니다.
② 제1항의 승낙은 당 사이트가 제공하는 과학기술정보검색, 맞춤정보, 서지정보 등 다른 서비스의 이용승낙을
포함합니다.
제 6 조 (회원가입)
서비스를 이용하고자 하는 고객은 당 사이트에서 정한 회원가입양식에 개인정보를 기재하여 가입을 하여야 합니다.
제 7 조 (개인정보의 보호 및 사용)
당 사이트는 관계법령이 정하는 바에 따라 회원 등록정보를 포함한 회원의 개인정보를 보호하기 위해 노력합니다. 회원 개인정보의 보호 및 사용에 대해서는 관련법령 및 당 사이트의 개인정보 보호정책이 적용됩니다.
제 8 조 (이용 신청의 승낙과 제한)
① 당 사이트는 제6조의 규정에 의한 이용신청고객에 대하여 서비스 이용을 승낙합니다.
② 당 사이트는 아래사항에 해당하는 경우에 대해서 승낙하지 아니 합니다.
- 이용계약 신청서의 내용을 허위로 기재한 경우
- 기타 규정한 제반사항을 위반하며 신청하는 경우
제 9 조 (회원 ID 부여 및 변경 등)
① 당 사이트는 이용고객에 대하여 약관에 정하는 바에 따라 자신이 선정한 회원 ID를 부여합니다.
② 회원 ID는 원칙적으로 변경이 불가하며 부득이한 사유로 인하여 변경 하고자 하는 경우에는 해당 ID를
해지하고 재가입해야 합니다.
③ 기타 회원 개인정보 관리 및 변경 등에 관한 사항은 서비스별 안내에 정하는 바에 의합니다.
제 3 장 계약 당사자의 의무
제 10 조 (KISTI의 의무)
① 당 사이트는 이용고객이 희망한 서비스 제공 개시일에 특별한 사정이 없는 한 서비스를 이용할 수 있도록
하여야 합니다.
② 당 사이트는 개인정보 보호를 위해 보안시스템을 구축하며 개인정보 보호정책을 공시하고 준수합니다.
③ 당 사이트는 회원으로부터 제기되는 의견이나 불만이 정당하다고 객관적으로 인정될 경우에는 적절한 절차를
거쳐 즉시 처리하여야 합니다. 다만, 즉시 처리가 곤란한 경우는 회원에게 그 사유와 처리일정을 통보하여야
합니다.
제 11 조 (회원의 의무)
① 이용자는 회원가입 신청 또는 회원정보 변경 시 실명으로 모든 사항을 사실에 근거하여 작성하여야 하며,
허위 또는 타인의 정보를 등록할 경우 일체의 권리를 주장할 수 없습니다.
② 당 사이트가 관계법령 및 개인정보 보호정책에 의거하여 그 책임을 지는 경우를 제외하고 회원에게 부여된
ID의 비밀번호 관리소홀, 부정사용에 의하여 발생하는 모든 결과에 대한 책임은 회원에게 있습니다.
③ 회원은 당 사이트 및 제 3자의 지적 재산권을 침해해서는 안 됩니다.
제 4 장 서비스의 이용
제 12 조 (서비스 이용 시간)
① 서비스 이용은 당 사이트의 업무상 또는 기술상 특별한 지장이 없는 한 연중무휴, 1일 24시간 운영을
원칙으로 합니다. 단, 당 사이트는 시스템 정기점검, 증설 및 교체를 위해 당 사이트가 정한 날이나 시간에
서비스를 일시 중단할 수 있으며, 예정되어 있는 작업으로 인한 서비스 일시중단은 당 사이트 홈페이지를
통해 사전에 공지합니다.
② 당 사이트는 서비스를 특정범위로 분할하여 각 범위별로 이용가능시간을 별도로 지정할 수 있습니다. 다만
이 경우 그 내용을 공지합니다.
제 13 조 (홈페이지 저작권)
① NDSL에서 제공하는 모든 저작물의 저작권은 원저작자에게 있으며, KISTI는 복제/배포/전송권을 확보하고
있습니다.
② NDSL에서 제공하는 콘텐츠를 상업적 및 기타 영리목적으로 복제/배포/전송할 경우 사전에 KISTI의 허락을
받아야 합니다.
③ NDSL에서 제공하는 콘텐츠를 보도, 비평, 교육, 연구 등을 위하여 정당한 범위 안에서 공정한 관행에
합치되게 인용할 수 있습니다.
④ NDSL에서 제공하는 콘텐츠를 무단 복제, 전송, 배포 기타 저작권법에 위반되는 방법으로 이용할 경우
저작권법 제136조에 따라 5년 이하의 징역 또는 5천만 원 이하의 벌금에 처해질 수 있습니다.
제 14 조 (유료서비스)
① 당 사이트 및 협력기관이 정한 유료서비스(원문복사 등)는 별도로 정해진 바에 따르며, 변경사항은 시행 전에
당 사이트 홈페이지를 통하여 회원에게 공지합니다.
② 유료서비스를 이용하려는 회원은 정해진 요금체계에 따라 요금을 납부해야 합니다.
제 5 장 계약 해지 및 이용 제한
제 15 조 (계약 해지)
회원이 이용계약을 해지하고자 하는 때에는 [가입해지] 메뉴를 이용해 직접 해지해야 합니다.
제 16 조 (서비스 이용제한)
① 당 사이트는 회원이 서비스 이용내용에 있어서 본 약관 제 11조 내용을 위반하거나, 다음 각 호에 해당하는
경우 서비스 이용을 제한할 수 있습니다.
- 2년 이상 서비스를 이용한 적이 없는 경우
- 기타 정상적인 서비스 운영에 방해가 될 경우
② 상기 이용제한 규정에 따라 서비스를 이용하는 회원에게 서비스 이용에 대하여 별도 공지 없이 서비스 이용의
일시정지, 이용계약 해지 할 수 있습니다.
제 17 조 (전자우편주소 수집 금지)
회원은 전자우편주소 추출기 등을 이용하여 전자우편주소를 수집 또는 제3자에게 제공할 수 없습니다.
제 6 장 손해배상 및 기타사항
제 18 조 (손해배상)
당 사이트는 무료로 제공되는 서비스와 관련하여 회원에게 어떠한 손해가 발생하더라도 당 사이트가 고의 또는 과실로 인한 손해발생을 제외하고는 이에 대하여 책임을 부담하지 아니합니다.
제 19 조 (관할 법원)
서비스 이용으로 발생한 분쟁에 대해 소송이 제기되는 경우 민사 소송법상의 관할 법원에 제기합니다.
[부 칙]
1. (시행일) 이 약관은 2016년 9월 5일부터 적용되며, 종전 약관은 본 약관으로 대체되며, 개정된 약관의 적용일 이전 가입자도 개정된 약관의 적용을 받습니다.