• Applied Biological Chemistry
• /
• v.37 no.4
• /
• pp.221-225
• /
• 1994

For producing single cell protein from the agricultural waste, heat treatment and antibiotics on the growth of Cellulomonas sp. KL-6, isolated in rotting leaf and the adjacent soil mixture, were examined. The organism was able to grow until 5 min. at $65^{\circ}C$, 1 min. at $75^{\circ}C$ and 1/4 min. at $85^{\circ}C$ in gradually rising temperatures. It can be Seen that preheating the suspension at $48^{\circ}C$ results in a marked decrease in heat resistance. On heating at temperature of $55^{\circ}C$ for 30 min., strain KL-6 was more resisted in the 0.1 M phosphate buffer when such substrates as casamino acid (1%), yeast extract (1%) or xylose (5%) were added to it whereas this organism was appeared weaker resistances in 0.1 M phosphate buffer when cysteine (0.03 M), sodium citrate (1%) or casein (1%) were in fused into it. Test strain was susceptible to penicillin-G $(1.563\;{\mu}g/ml)$ and ampicillin $(3.125\;{\mu}g/ml)$, but the organism was resisted to kanamycin $(>200\;{\mu}g/ml)$. The treatment of strain KL-6 with sodium dodecyl sulfate (SDS) resulted in the elimination of R-plasmid from the host strain and the elimination rate with SDS $(10{\sim}30\;{\mu}g/ml)$ was about $9.2{\sim}31.2%$, respectively.

• Journal of the Korean Society of Food Culture
• /
• v.8 no.3
• /
• pp.249-255
• /
• 1993

To minimize the waste amount of surface layer kochujang during aging, the effects of the three finishing methods(nothing, salt scatering and Polyethylene film on the kochujang surface) and sunning(conventional aging method) or nonsunning aging(cap covering) on water content, redness and spreadability, film forming yeast occurance and salinity of surface layer kochujang during 120 days aging were investigated. In the case of sunning aging, film forming yeast was not visually found on the surface. The surface layer kochujang was so low spreadability(zero) and very high salinity(18-30%) that could not eat. However, the aging method after PE-film covering on the kochujang surface, and then cap covering(nonsunning) was very effective in keeping of soundness of surface layer kochujang without film forming yeast growth on the surface kochujang, especially was greatly effective in keeping of redness, moderate moisture content and spreadability. The PE-film and cap covering aging were effective in prevention of water evaporation and $CO_2$ release, and in accumulation of ethanol and organic acids between the PE-film and surface layer of kochujang.

• Journal of Biosystems Engineering
• /
• v.9 no.1
• /
• pp.62-70
• /
• 1984

가축배설물(家畜排泄物)의 콤포스트화(化) 작업(作業)의 공학적(工學的)인 국면(局面)은 축산(畜産) 경영(經營)의 축산물(畜産物) 생산성(生産性), 에너지 보전(保全), 공해방지(公害防止)와 분뇨처리(糞尿處理)의 노력(勞力) 절약(節約)에 긴밀(緊密)한 관계(關係)가 있다. 그러나 우리나라에 있어서 축산업(畜産業)의 사양(飼養) 규모(規模)와 두수(頭數)는 매년(每年) 증가(增加)하고 있는 경향(傾向)인바 전통적(傳統的)인 가축(家畜) 배설물(排泄物) 처리(處理) 및 재이용(再利用) 과정(科程)에서 발생(發生)되는 문제점(問題點)에 대(對)한 연구(硏究) 자료(資料)가 없고 특(特)히 콤포스트화(化) 작업(作業)이 원시적(原始的)이므로 개선(改善) 확립(確立)이 절실(切實)히 요구(要求)되는 실정(實定)이다. 본(本) 연구(硏究)의 목적(目的)은 가축(家畜) 분뇨(糞尿)의 콤포스트화(化) 작업(作業) 과정(科程)에서 공학적(工學的)인 제(諸) 문제점(問題點)을 조사(調査) 분석(分析)하여 현상(現狀)을 평가(評價)하고 개선(改善) 방안(方案)을 모색(摸索)하기 위한 기본자료(基本資料)를 제공(提供)하고져 수행(遂行)하였다. 이에 관한 조사(調査)와 분석(分析) 결과(結果)를 요약(要約)하면 다음과 같다. 1. 축산농가(畜産農家)의 가축(家畜) 배설물(排泄物) 처분(處分) 방법(方法)은 대부분(大部分)이 자연건조(自然乾燥), 퇴적(堆積), 혐기적(嫌氣的)인 고형(固形) 또는 액상(液狀) 퇴비화(堆肥化)에 의하여 실시(實施)되고 있었으며 가축분뇨(家畜糞尿)로 인(因)한 공해(公害)는 심각(深刻)하다는 것을 알 수 있었다. 2. 호기성(好氣性) 야적(野積) 콤포스트의 통기작업(通氣作業)은 트랙터에 부착(附着)되어진 전후(前後) 작동식(作動式) 로우더가 바람직하다. 3. 농축산(農畜産) 폐기물(廢棄物)의 콤포스트화(化) 작업(作業)은 축산농가(畜産農家)를 중심(中心)으로 한 콤포스트 센타에서 전체 농가(農家)가 지방(地方) 증진(增進)과 오염(汚染) 방지(防止)를 하기 위해 참여(參與)하여 완전(完全) 공동(共同) 이용(利用) 체계에 따라 일관성(一貫性)있게 수행(遂行)되어야 한다. 4. 호기성(好氣性) 야적(野積) 콤포스트 작업(作業)은 다른 방법(方法)에 비하여 운영비(運營費)가 적게 들어 영세적(零細的)인 축산업(畜産業)의 경우(境遇)에 가장 적당(適當)하고 공해(公害)를 방지(防止)함으로서 한국(韓國) 축산농가(畜産農家)의 콤포스트화(化) 시설(施設)로 전망(展望)이 밝다고 판단(判斷)된다.

• Journal of Korean Society of Environmental Engineers
• /
• v.36 no.7
• /
• pp.461-468
• /
• 2014

Biochar is a carbon rich solid produced by the pyrolysis of biomass such as energy crops, forestry residues, and wood wastes. Biochar returned to soil is to mitigate climate change and the feedstock of wood wastes reduces fossil fuel consumption as well as disposal costs. This study was practiced to evaluate a biochar system by gasification in terms of global warming regarding the soil application of the produced biochar. Life cycle assessment methodology was used to analyze the environmental impacts of the system, and the functional unit was 1 tonne of wood wastes. The result shows that the biochar system by using wood wastes as feedstock produces 4.048E-01 $kgCO_2-eq$ from the pre-treatment process as chipping and drying, 4.579E-01 $kgCO_2-eq$ from the pyrolysis process, and 9.070E-02 $kgCO_2-eq$ from the spreading to agricultural land, therefore total 9.534E-01 $kgCO_2-eq$ are generated. About 252 kg of $CO_2$ is still stored in the produced biochar in soil after carbon offsetting of the system. Therefore, the net carbon of the system is -251 kg of $CO_2-eq$.

• Journal of Korean Society of Environmental Engineers
• /
• v.27 no.3
• /
• pp.316-322
• /
• 2005

In this study, the concentration of 17 dioxin congeners in the soil samples near a waste incinerator with respect to distance from incinerator and wind directions were investigated. The effect of PCB source was investigated using the cluster analysis method. The total concentration and I-TEQ concentration of dioxin ranged from 31.065 to 7,257.499 pg/g(dry weight) and from 0.099 to 35.191 pg I-TEQ/g(dry weight.), respectively. There was a weak correlation(not statistically significant) observed between soil concentration and wind direction, and the distance from the incinerator. The reason may be due to the presence of the local combustion sources other than the target incinerator. The fraction of PCDFs and PCDDs was also examined to study the effect of incinerator. The fraction of PCDFs was decreased with the distance from the incinerator. The influence of target incinerator was found within a 500-meter radius. The high concentration in the for site was due to small incinerators and the use of agricultural chemicals such as PCP. To investigate the relationship between soil near the incinerator and the sources, the cluster analysis was conducted using the congener pattern. As a result soil samples were divided into four groups and were qualitatively estimated the influence of sources such as incinerator and PCP by comparing the congener pattern of each roups. It was thought that a cluster analysis was a useful statistical method for the source estimation of dioxin.

• Journal of the Korean Society of Food Science and Nutrition
• /
• v.18 no.2
• /
• pp.160-166
• /
• 1989

This study was conducted to investigate whether egg-shell may be used as a mineral sourceor leavening agent in breadmaking. In Korea the waste volume of egg shell has been estimated at about 28,694 tons per year. Carbon dioxide generation maxima were established for barking powder$(153{\pm}3ml/g)$, egg-shell(205in reaction with lactic acid) and yeast$(115{\pm}3ml/sugar\;g)$. Gas release time required for each substance to reach $CO_2$ maximum was, for baking powder 7 minutes, for egg-shell 45 mins and for yeast 240 mins. Particle size of egg-shell in breadmaking was suitable more than 20 mesh (-). When egg-shell only was added to the basic formular without including lactic acid, no leavening effect was observed. However, when lactic acid and egg-shell were used together, the leavening effect was more or less equivalent to that of yeast(control). Addition of egg-shell was found to increase calcium content of bread products without noticeable altering flavor, as compared with control. Joint use of egg-shell was organic acids in breadmaking was shown to have potential in time saving, volume increase and yeast saving.

• The Journal of the Institute of Internet, Broadcasting and Communication
• /
• v.17 no.3
• /
• pp.267-274
• /
• 2017

Recently, several researches have been studied on agricultural automation system according to convergence of IT technology with agriculture. An automatic control system of the growth environment in crops is one of the these researches. The controls of damages caused by diseases and insects pest in crops are mainly carried out by manual mode or semi-automatic mode because of farmer's concerns for poor efficiency. But, this situation needs to be improved because it occurs various problems, such as human exposure to toxic pesticides, environmental pollution and waste due to drug overuse. In order to solve these problems, we developed an automatic quantity control system which based on the amount of pesticides for area under cultivation. The amount of pesticides is calculated according to the manufacturer's instruction for pesticides. To verify the effectiveness of our developed automatic system, we also compared with the systems of manual mode and the semi-automatic mode. The experimental results of a pest control performance of an automatic quantity control system showed that automatic system can reduce overuse of drugs. These results suggested that it can be expected to replace the existing system, with equivalent effectiveness to the manual mode.

• Korean Journal of Environmental Agriculture
• /
• v.33 no.2
• /
• pp.78-85
• /
• 2014

BACKGROUND: Recent studies using various industrial wastes for heavy metal stabilization in soil were conducted in order to find out new alternative amendments. The acid mine drainage sludge(AMDS) contains lots of metal oxides(hydroxides) that may be useful for heavy metal stabilization not only waste water treatment but also soil remediation. The aim of this study was to investigate the applicability of acid mine drainage sludge for heavy metals stabilization in soils METHODS AND RESULTS: Alkali soil contaminated with heavy metals was collected from the agricultural soils affected by the abandoned mine sites nearby. Three different amounts(1%, 3%, 5%) of AMDS were applied into control soil and contaminated soil. For determining the changes in the extractable heavy metals, $CaCl_2$ and Mehlich-3 were applied as chemical assessments for metal stabilization. For biological assessments, lettuce(Lactuca sativa L.) and chinese cabbage(Brassica rapa var. glabra) were cultivated and accumulation of heavy metals on each plant were determined. It was revealed that AMDS reduced heavy metal mobility and bioavailability in soil, which resulted in the decreases in the accumulation of As, Cd, Cu, Pb, and Zn in each plant. CONCLUSION: Though the high level of heavy metal concentrations in AMDS, any considerable increase in the heavy metal availability was not observed with control and contaminated soil. In conclusion, these results indicated that AMDS could be applied to heavy metal contaminated soil as an alternative amendments for reducing heavy metal mobility and bioavailability.

• Journal of the Korean earth science society
• /
• v.23 no.6
• /
• pp.474-485
• /
• 2002

The object of this study is to investigate the contamination degree and the interpretation of sea water intrusion phenomena with hydrogeochemical and hydrogen-oxygen stable isotope of coastal aquifer in the Gogum area, Korea. The physical characteristics of groundwaters is the neutral pH condition and transitional Redox environments, and groundwater is affected by sea water & surface water. The chemical properties of groundwaters are showing an increase in contamination owing to the sea water intrusion, waste water from the surface and agricultural chemicals. In the case of chloride, 6 samples of the groundwater in the study area are in excess of the drinking water standard. The Piper diagram shows the contamination in GG-4 and 14 by sea water intrusion. GG-3, 7 and 13 dominate the Na-HCO$_{3}$ type water and regional (GG-14) is indicated to dominate the Na-Cl type water such as sea water. According to the Sl (saturation index), sea water is oversaturated with respect to calcite and dolomite, GG-3, 14 and 18 are approaching the saturation state. The hydrogen-oxygen stable isotope ratio of groundwaters originates in the meteoric water, and groundwaters of GG-1, 5 and 14 display high oxygen isotope value due to surface water trespass and sea water intrusion. The result of this study, GG-14 is contaminated by sea water intrusion, groundwaters expected GG-3, 7 and 13 is in progress to artificial pollution and sea water intrusion.

• Journal of the Korea Organic Resources Recycling Association
• /
• v.8 no.4
• /
• pp.93-99
• /
• 2000

Treatment of shaving scrap, a chrome containing solid scrap generated by leather manufacturing process, has been so far depended on mainly incineration, soil landfill and ocean dumping, which give bad impact on environment and cause pollution. Shaving scrap generates from the mechanical work for controlling the final thickness of leather and its main components are collagen protein and pan of chromium compound. For the purpose of reusing this leather waste as resources, researches in connection with collagen fiber recovery, gelable protein recovery and liquid fertilizer is being speedily progressed. In the experiment, shaving scrap went through wet pulverizing treatment by physical and chemical methods. Then, making the leather sheet evenly, it is mixed with natural latex and every kind of binding materials in the container, and the mixtures were passed through experimental hydraulic press machine and applied to Fourdrinier machine respectively. Lastly, a test for fading out physical strength and properties of multiple-purpose of leather-like material was performed on a continuous leather sheet prepared by the experiment. In result, the physical strength and properties of leather-like material showed noticeable differences according to mixing ratio of binding materials, beating methods and the Ends of binding materials selected, and generally tear strength was the weakest property among others. Also, by the pilot scale experiment in sequence, it was possible to manufacture recycled goods made of soft and hard types of leather-like material with various performances.