• Journal of Energy Engineering
• /
• 제6권1호
• /
• pp.104-113
• /
• 1997

This study aims to develop an analysis model using a commercial process simulator-ASPEN PLUS for an IGCC (Integrated Gasification Combined Cycle) system consisting a dry coal feeding, oxygen-blown entrained gasification process by Shell, a low temperature gas clean up process, a General Electric MS7001FA gas turbine, a three pressure, natural recirculation heat recovery steam generator, a regenerative, condensing steam turbine and a cryogenic air separation unit. The comparison between those results of this study and reference one done by other engineer at design conditions shows consistency which means the soundness of this model. The greater moisture contents in Illinois#6 coal causes decreasing gasifier temperature and the greater ash and sulfur content hurt system efficiency due to increased heat loss. As the results of sensitivity analysis using developed model for the parameters of gasifier operating pressure, steam/coal ratio and oxygen/coal ratio, the gasifier temperature increases while combustible gases (CO＋H2) decreases throughout the pressure going up. In the steam/coal ratio analysis, when the feeding steam increases the maximum combustible gas generation point moves to lower oxygen/coal ratio feeding condition. Finally, for the oxygen/coal ratio analysis, it shows oxygen/coal ratio 0.77 as a optimum operating condition at steam/coal feeding ratio 0.2.

• Proceedings of the Korean Society of Organic Agriculture Conference
• /
• 한국유기농학회 2009년도 하반기 학술대회
• /
• pp.306-306
• /
• 2009

본 실험은 백세주 주정박이 벼의 생육과 토양 비옥도 개선에 미치는 영향을 조사하였다. 백세주 주정박은 압착된 주박을 재 발효시켜 단식증류기로 증류하여 알코올을 회수 후 발생된다. 실험 처리구는 무시용, 요소, 주정박 처리구로 하였고, 벼 질소비료 표준시비량 11kg N/10a를 기준으로 하여 전량 기비로 사용하였다. 백세주 주정박의 유효성분과 유해성분을 분석하였고, 토양에 주정박을 시용 전 후의 이화학적 분석을 하였다. 벼 실험 품종은 오대벼(Oryza sativa L.)이고, 벼의 생육과 수량 및 미질을 분석하였다. 백세주 주정박의 pH는 3.60, 유기물함량 90.12%, 염농도 0.72ds/cm, 수분함량 88%, 질소 0.21%, 인산 0.24%, 칼리 0.09%로 나타났다. 유해성분(중금속)분석결과 비소 0.03ppm, 크롬 0.09ppm, 구리0.91ppm, 납 0.05ppm, 니켈 0.05ppm, 아연 1.30ppm, 망간 3.28ppm, 철 34.86ppm로 나타났다. 토양이화학적 분석결과 주정박 시용처리구의 유기물함량과 질소 및 인산은 각각 23.0g/kg. 0.11%, 89mg/kg로 무시용과 요소처리구에 비해 유의한 차이를 보였다. 벼 이식 후 140일째 생육분석결과 초장 82.60cm, 옆폭 1.40cm, 옆장 37.70cm, 지상부건물중 59.21g로 다른 2개 처리구에 비해 유의한 차이를 보였다. 벼의 수량은 주정박 시용 처리구가 449.0kg/10a로 무시용 89.66kg/10a와 요소 401.66kg/10a에 비해 유의적인 차이를 보였다. 백세주 주정박 시용을 통해 토양 개량 효과를 기대할 수 있고, 공시 토양의 토양 개량 효과가 벼의 생육에 긍정적인 영향을 끼치는 것으로 나타남에 따라 백세주 주정박의 토양개량제로서의 활용 가능성을 확인하였다.

• Food Science of Animal Resources
• /
• 제25권3호
• /
• pp.265-270
• /
• 2005

This study was carried out to investigate the effects of washing times on quality characteristics of chicken breast surimi. The surimi was prepare after 2 (C), 4 (T1) and 6 (T2) times washed with a ratio 6 : 1 distilled water-chicken breast meat. The moisture and crude protein content of T1 and T2 were higher than that of C. The myofibrillay protein and yield of C was higher (p<0.05) than those of T1 and T2. The pH of C was higher (p<0.05) compare to other treatments. The WHC was no significant differences between the all treatments. The shear force of all treatments were tended to higher as washing times increased. The breaking force and deformation value of T2 were lower than other treatments. The $L^{*}$ values in C and $b^{\ast}$ values in T1 were significantly (p<0.05) lower among the treatments group. The hardness and gumminess of T1 was higher (p<0.05) compared to T2. The springiness of treatments increased as washing times increased. The sensory score of surimi made from chicken breast meat was not affected by the washing times.

• Proceedings of the Korean Society for Food Science of Animal Resources Conference
• /
• 한국축산식품학회 2005년도 정기총회 및 제35차 춘계 학술 발표대회
• /
• pp.231-234
• /
• 2005

본 실험은 돈육 후지 부위를 이용하여 육포 제조시 텀블링 시간에 따른 육포의, 이화학적 및 관능적 특성을 조사하여 표준화된 육포제조의 기초 자료를 제공하고자 실시하였다. 텀블링 시간에 따른 건조전 육포 양념육의 제품수율은 30분까지는 수율이 유의적으로 증가하는 경향을 보였으나, 60분 동안 텀블링을 실시하였을 때는 30분보다 낮은 값을 나타내었다. 텀블링 시간에 따라 pH는 차이가 없었으나, 보수력은 텀블링 30분까지 유의적으로 증가하였고 이후 부터는 차이가 없었다. 육색은 텀블링 시간이 경과함에 따라 $L^{\ast}-$값과 $b^{\ast}-$값은 감소하는 경향을 보였으나 반대로 $a^{\ast}-$값은 텀블링 시간이 증가함에 따라 점점 증가하는 경향을 보였다. 건조후 제조된 돈육육포의 수분함량은 $29{\sim}30%$ 정도를 유지하였으며, 건조수율은 모두 $48{\sim}49%$ 정도의 높은 수율을 보였다. 육포의 $L^{\ast}-$값은 30분 및 60분 동안 텀블링을 실시하였을 때 10분 동안 텀블링을 실시한 육포보다 낮게 나타났다. 60분 동안 텀블링한 육포의 $a^{\ast}-$값은 10분간 텀블링한 것보다 높았으며, $b^{\ast}-$값은 $a^{\ast}-$값과는 반대의 경향을 나타내었다. 탄력성(springiness)은 60분 동안 텀블링한 육포가 10분 동안 텀블링한 육포보다 높은 값을 보였으나, 탄력성을 제외한 모든 항목에서 유의차가 나타나지 않았다. 관능검사는 모든 항목에서 30분 이상 텀블링한 육포가 좋은 평가를 받았으나, 처리구간에 유의차는 나타나지 않았다.pm을 spiking한 후 SPE상에서 SCX(Strong cation exchange column)을 통한 clean-up과정을 거친 후의 STP의 limit of quantification(LOQ)는 약 0.44ppm이었으며, 이에 대한 회수율은 89.7${\pm}$2.3%(n=6)를 나타냈다. 실제 CODEX에서 권장한 우유의 MRL이 0.6ppm인 점을 감안하면 CODEX권고치에 도달할 수 있는 것으로 판단되었다. 따라서 본 연구에서 개발 된 시험법은 지금까지 국내적으로 STP에 대한 시험법이 확립되어 있지 않은 것으로 이와 아울러 간편한 parallux와 병용해 STP에 대한 정량 및 정성 분석을 유도체화 장치 및 형광검출기를 이용해 잔류항생물질 STP에 대한 분석시험법을 개발하였다.화와 네트워크 조직망 구축을 위한 지역중심의 복합 생활문화 공간이 필요할 것이며, 이를 촉진키 위한 mentor academy시스템 접근을 통해 점점 고령화되어 가고 있는 재래시장에 대해 차별적 특성이 반영된 종합적이고 체계적 접근 방법연구가 필요하다./TEX> 자체기술개발, 선진기술 도입, 산업간 및 산업내 기술확산, 국제기술협력 ${\rightarrow}$ 기술혁신의 촉진 ${\rightarrow}$ 총요소생산성과 기업경쟁력(자원 및 역량, 프로세스 경쟁력, 품질경쟁력, 시장경쟁력, 고객성과, 시장성과, 재무성과)의 제고 ${\rightarrow}$ 가격경쟁력(임금, 금리, 물류비용, 환율 등)과 비(非)가격경쟁력(디자인, 에프터서비스, 품질, 운송 등)의 제고 ${\rightarrow}$ 국가경쟁력의 제고 ${\rightarrow}$ 국제수지 흑자 ${\ri

• Korean Journal of Fisheries and Aquatic Sciences
• /
• 제35권4호
• /
• pp.309-314
• /
• 2002

Rhtological properties of surimi gel from white fishes by acid (acid surimi) and alkali (alkali surmi) process and effect of chemicals on gelation were investigated by punch and dynamic tests. The breaking force and deformation values of heat-induced gel of acid surimi were less than their values of alkali and conventional surimi gel, and whiteness was greatly decreased, Gel point of acid surimi was decreased but it of alkali surimi was increased with increasing moisture content in the range of 80 to $85\%$. Storage modulus of acid surimi was the highest vaule in pH 6.8, but that of alkali surimi showed high value at neutral and slightly alkali pH. Propylene glycol increased storage modulus in $20\~50^{\circ}C$, hut urea and 2-mercaptoethanol suppressed it. Potassium bromide improved storage modulus in $20~80^{\circ}C$, The results suggest that alkai process is used for making surimi instead of conventional method.

• Journal of the Korean Society of Food Science and Nutrition
• /
• 제35권10호
• /
• pp.1394-1398
• /
• 2006

Functionalities of drum-dried fish muscle protein from pH shifting process have been investigated by determining solubility, emulsion activity, rehydration, fat-adsorption capacity, viscosity, and color. Solubility was higher in recovered protein at pH 7.0 than that at pH 5.5, and not dependent on ionic strength. Solubility of the dried protein recovered at pH 7.0 depended on pH of solvent, and lowest in the range of pH 3 to pH 6. The dried protein showed relatively low emulsion capacity in all the samples. Emulsion stability, foam capacity and foam stability were not observed in the samples. Viscosity was in the range of $50,200\sim39,000cP$. Rehydration and fat-binding capacities were $2.63\sim2.89g$-water/g and $2.13\sim2.17g$-oil/g, respectively, and not dependent on particle size and pH. Drum-dried fish muscle protein has a potential application as an ingredient of meat patty products.

• Resources Recycling
• /
• 제5권4호
• /
• pp.25-31
• /
• 1996

The wastes ot l~mestone mines have been cause the extrar.ngance of the valuablz m e r a l s and destruction of the environment. Therefore, \\-c tied ta separation of calcite illid clay from the limestone mine wastes by rotntmg screen type separator made by ourselves in order to recyding such us a raw matcriala for cement maimfacture. CaO amtents in the separated coarse products increased from 37.36 wt% to 42+2 wt% at the condition ihat water content in wastes was lzss than 6wt%, the passing time of specimen in &amber was 15 semnds and the rotation speed was 6OLl qm. A process in order lo separate wastes effectively to having wide range aI part~dcs ize was cstablishcd and CaO contents of coarsc products through this process increased to 46.85 wt%. Tbis rcsult is insuEiicient to directly rcusing as a raw malerials for cement. However, it is supposed that coarse products would be able to be reuscd as a raw materials uf cement, if only it rs sclected dolomite in wastes, and really it may be possible in fields Othenvise, undcrsize products(less than 20 mm) would be able to recycling as a raw of cement bccause chcmicrl campasitions of thosc is kept almost constant v&cs on the overall process.

• The Korean Journal of Mycology
• /
• 제22권3호
• /
• pp.266-275
• /
• 1994

Brewer's yeast extract can be used as a good substrate for the culture of Lentinula edodes Mycelia(LEM). We found that it was better to filter the extract through three kinds of sieves and then to heat for hydrolysis and concentration at $90^{\circ}C$ prior to use. Also the maximum condition for the growth of LEM was investigated. We found that addition of inorganic salts such as calcium enhanced the growth of LEM. On the other hand, addition of carbon and nitrogen sources to the medium did not affect, and even inhibited under certain conditions, the growth of LEM. The maximum temperature for the growth of LEM was around $25^{\circ}C$. Also, it grows better when agitated by shaking at 100 rpm for airration. The appropriate concentration of the extract to use was 10%. Under these conditions, LEM could reach to the confluency after cultivation of 12 days. Our extract formula seems better than other available media for LEM growth, producing higher crude protein content and better taste.

• Microbiology and Biotechnology Letters
• /
• 제16권4호
• /
• pp.297-302
• /
• 1988

The protoplasts of Saccharomyces cerevisiae D-71, a thermophilic strain and Zygosaccharomyces rouxii SR-S, an osmotolerant strain were fused, and a fusant (FS-RN 1) was selected, then was characterized for its genetic stability, DNA content, cell capacity, growth rate, tolerance to salts and chemicals, $\beta$-fructofuranosidase level and ethanol fermenting activity. After 6 months of preservation, 5.8% of the fusant clones were segregated to parental types. The DNA content and cell capacity of the fusant were greater than those of the parental strains. Lag period of growth for the fusant was longer than those for the parents. The fusant colonies showed pink-color reaction to triphenyltetrazolium chloride(TTC) test. The fusant appeared to have resistances to NaCl at moderate levels between both parental strains, and resistances to KCI, sodium propionate and cycloheximide similar to either one of the parents. $\beta$-Fructofuranosidase activity of the fusant was 24.2$\times$10$^{-3}$/IU/g(dry wt) for 3 days culture. Ethanol yields ofter 4 days of fermentation by the fusant at 3$0^{\circ}C$ were : 6.0%(v/v) from 40% of glucose and 8.8%(v/v) from 20% of sucrose.

• Resources Recycling
• /
• 제18권1호
• /
• pp.38-43
• /
• 2009

In this study, binderless consolidation processes of ultra foe Si powder, by-products of making high purity poly-Si in the current method, were systematically investigated for use as economical solar-grade feedstock. The average diameter of the silicon powder was $7.8{\mu}m$. The main contaminants of the fine silicon powder were $SiO_2$ type oxide and humidity. The chemical pretreatment using the HF solution was observed to be effective for the improvement of the compactability of the silicon powder and the density ratio and the strength of the silicon powder compacts. The yield of the binder-free consolidation process increased by 20% under a vacuum condition. In as-received state, the silicon powder were not pure enough to be used as solar grade feed-stock material. After the dry chemical treatments, a sufficiently high purity above solar-grade was able to be achieved.