Advances in concrete construction

  • 제15권5호
  • /
  • Pages.333-348
  • /
  • 2023
  • /
  • 2287-5301(pISSN)
  • /
  • 2287-531X(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Develop a sustainable wet shotcrete for tunnel lining using industrial waste: a field experiment and simulation approach

  • Jinkun Sun (Civil and Architectural Engineering Institute, Panzhihua University) ;
  • Rita Yi Man Li (Sustainable Real Estate Research Center, Hong Kong Shue Yan University) ;
  • Lindong Li (Civil and Architectural Engineering Institute, Panzhihua University) ;
  • Chenxi Deng (School of Civil Engineering and Environment, Xihua University) ;
  • Shuangshi Ma (School of Civil Engineering and Environment, Xihua University) ;
  • Liyun Zeng (Civil and Architectural Engineering Institute, Panzhihua University)
  • 투고 : 2022.04.02
  • 심사 : 2023.05.25
  • 발행 : 2023.05.25
⟨ 이전 논문 다음 논문 ⟩

초록

Fast infrastructure development boosts the demand for shotcrete. Despite sand and stone being the most common coarse and fine aggregates for shotcrete, excessive exploration of these materials challenges the ecological environment. This study utilized an industrial solid waste, high-titanium heavy slag, blended with steel fibers to form Wet Shotcrete of Steel Fiber-reinforced High-Titanium Heavy Slag (WSSFHTHS). It investigated its workability, shotcrete performance and mechanical properties under different water-to-cement ratios, fly ash content, superplasticizer dosage, and steel fiber content. The tunnel excavation and support were investigated by conducting finite element numerical simulation analysis and was used in 3 tunnel lining pipes in Zhonggouwan tailing pond. The major findings are as follows: (1) The water-to-cement ratio (w/c ratio) significantly impacted the compressive strength of WSSFHTHS. The highest 28-day compressive strength of 60 MPa was achieved when the w/c ratio was 0.38; (2) Adding fly ash improved the workability and shotcrete performance and strength development of WSSFHTHS. The best anti-permeability performance was achieved when the fly ash constituted 15%, with the lowest permeability coefficient of 4.596 × 10-11 cm/s; (3) The optimum superplasticizer dosage for WSSFHTHS is 0.8%. It provided the best workability and shotcrete performance. Excessive dosage resulted in water bleeding and poor aggregate encapsulation, while insufficient dosage decreased flowability and adversely affected shotcrete performance; (4) The dosage of steel fibers significantly impacted the flexural and tensile strength of WSSFHTHS. When the steel fiber dosage was 45 kg/m3, the 28-day flexural and tensile strengths were 8.95 MPa and 6.15 MPa, respectively; (5) By integrating existing shotcrete techniques, the optimal lining thickness was 80 mm for WSSFHTHS per simulation. The results revealed that after using WSSFHTHS, the displacement of the tunnel surrounding the rock significantly improved, with no cracks or hollows, similar to the simulation results.

키워드

과제정보

This study was financially supported by "Research Fund of University Students' Innovation and Entrepreneurship Project": Research on Mechanical Properties of Wet Shotcreting Mixed with Steel Fibre and High Titanium Heavy Slag (S202011360019) and Ph.D. Starting Research Fund: Research on the Technology and Industry of a New Type of Prefabricated High-Titanium Heavy Slag Concrete Composite Board (no. 035200192).

참고문헌

  1. Ahmed, L. and Ansell, A. (2014), "Vibration vulnerability of shotcrete on tunnel walls during construction blasting", Tunnell. Undergr. Space Technol., 42, 105-111. https://doi.org/10.1016/j.tust.2014.02.008 
  2. Alawadhi, E.M. (2015), Finite Element Simulations Using ANSYS, Second Edition, CRC Press. https://doi.org/https://doi.org/10.1201/b18949 
  3. Chen, X. (2020), Face Stability and Reinforcement of the Tunnel in Weak Surrounding Rock, Geotechnical and Geological Engineering. 
  4. Dai, C., Jiang, K. and Wang, Q. (2020), "Recognition of Tunnel Lining Cracks Based on Digital Image Processing", Mathe. Probl. Eng., 2020, 5162583. https://doi.org/10.1155/2020/5162583 
  5. Ding, M.Q. et al. (2019), "Study on The Influence of Polycarboxylate Water-Reducing Agent Content on Concrete Performance", Fujian Transportation Technology, 6(1). [In Chinese] 
  6. Duarte, G., Bravo, M., de Brito, J. and Nobre, J. (2019), "Mechanical performance of shotcrete produced with recycled coarse aggregates from concrete", Constr. Build. Mater., 210, 696-708. https://doi.org/10.1016/j.conbuildmat.2019.03.156 
  7. Gao, X. (2021), "Tunnel lining crack detection technology under the background of artificial intelligence", Northern Commun., 92-94. https://doi.org/10.15996/j.cnki.bfjt.2021.11.023 
  8. Guler, S. and Akbulut, Z.F. (2022), "Residual strength and toughness properties of 3D, 4D and 5D steel fiber-reinforced concrete exposed to high temperatures", Constr. Build. Mater., 327, 126945. https://doi.org/10.1016/j.conbuildmat.2022.126945 
  9. He, W. (2013), Research For Testing The Properties Of Fresh Wet-Mix Shot Crete, Concrete. 
  10. Hemphill, G.B. (2013), Practical Tunnel Construction, Jone Wiley & Sons. 
  11. Huang, S. (2006), Application of high titanium blast furnace slag in concrete material, New Building Materials, November. 
  12. Jiang, F., He, P., Wang, G., Zheng, C., Xiao, Z., Wu, Y. and Lv, Z. (2022), "Q-method optimization of tunnel surrounding rock classification by fuzzy reasoning model and support vector machine", Soft Comput., 26, 1-14. https://doi.org/10.1007/s00500-021-06581-9 
  13. Jin, H., Xu, H., Yang, S., Xu, Z., Li, F. and Hu, Z. (2020), "Grey target decision analysis of optimum mixing ratio of LWAS based on the comprehensive performance", Constr. Build. Mater., 262, 120570. https://doi.org/10.1016/j.conbuildmat.2020.120570 
  14. Li, Q. (2012), Experimental Study of the Effect on the Performance of HPC with Different Mixture, Concrete. 
  15. Li, S. (2021), "On the Construction Technology of Sprayed Concrete in Highway Tunnels", China Build. Mater. Technol., 30(05), 154-156. 
  16. Liu, Z. (2015), Exploration and Application of Concrete Strength, Concrete. 
  17. Liu, F. (2019), "Experimental analysis of mechanical properties of steel fiber lightweight concrete", Chongqing Jiaotong University, China. 
  18. Liu, X. (2020), "Experimental analysis of mechanical properties of steel fiber lightweight concrete", Heilongjiang University, China. 
  19. Lu, L.H. (2018), "Application of Tailing Sand Steel Fiber Sprayed Concrete in Iron Mine Tunnel", J. Shenyang Univ. Technol., 1(1). [In Chinese] 
  20. Luo, F. (2018), "Research on tailings steel fiber shotcrete in iron mine roadways", Master Dissertation; Shenyang University of Technology, 5(1). [In Chinese] 
  21. Mansoor, Y. and Zhang, Z. (2012), "Development of Inspection System for Crack in R.C. Tunnel Lining by Using Knowledge-Based System (KBS)", Adv. Mater. Res., 622-623, 1415-1420. https://doi.org/10.4028/www.scientific.net/AMR.622-623.1415 
  22. Mingqiang, D. (2019), "Study on the Influence of Polycarboxylate Water-Reducing Agent Content on Concrete Performance", Fujian Transportation Technology. 
  23. Mou, T. (2014), Preparation and Application of High Performance Pumping Concrete using Heavy Titanium Slag Sand, Concrete. 
  24. Pisova, B. and Hilar, M. (2017), "Spray-applied waterproofing membranes: effective solution for safe and durable tunnel linings?", IOP Conference Series: Materials Science and Engineering, Vol. 236, p. 012087. https://doi.org/10.1088/1757-899X/236/1/012087 
  25. Sakoparnig, M., Galan, I., Kusterle, W., Lindlar, B., Koraimann, G., Angerer, T., Steindl, F., Briendl, L., Jehle, S., Flotzinger, J., Juhart, J. and Mittermayr, F. (2023), "On the significance of accelerator enriched layers in wet-mix shotcrete", Tunnell. Undergr. Space Technol., 131, 104764. https://doi.org/10.1016/j.tust.2022.104764 
  26. Shaposhnik, Y. (2018), "Selecting shotcrete composition for Vostoktsvetmet mines", IOP Conference Series: Earth and Environmental Science, Vol. 134, p. 012059. https://doi.org/10.1088/1755-1315/134/1/012059 
  27. Shuyuan, W. (2016), "Comparison between range analysis and variance analysis of concrete orthogonal test results", Development Guide to Building Materials. 
  28. Sun, J., Li, R.Y.M., Jiao, T., Wang, S., Deng, C. and Zeng, L. (2023), "Research on the Development and Joint Improvement of Ceramsite Lightweight High-Titanium Heavy Slag Concrete Precast Composite Slab", Buildings, 13(1), 3. https://doi.org/10.3390/buildings13010003 
  29. Thomas, A. (2009), Sprayed Concrete Lined Tunnels, CRC Press. https://doi.org/10.1201/9781482265682 
  30. Topcu, I. and Bilir, T. (2010), "Experimental investigation of drying shrinkage cracking of composite mortars incorporating crushed tile fine aggregate", Mater. Des., 31, 4088-4097. https://doi.org/10.1016/j.matdes.2010.04.047 
  31. Wang, Z.Q., Shi, Y., Li, J.Z. and Yan, X.H. (2012), "Study on indoor test methods and performance of shotcrete", J. Yangtze River Scientif. Res. Inst., 29(3), 59-61. https://doi.org/10.3969/j.issn.1001-5485.2012.03.012
  32. Xue, X., Su, Z., Sun, Z. and Song, F. (2014), "Instability Mechanism and Supporting Measure for Highway Tunnel with High Ground Stress and Soft Surrounding Rock", Advanced Materials Research, 1049-1050, 213-216. https://doi.org/10.4028/www.scientific.net/AMR.1049-1050.213 
  33. Yan, R. (2021), "Experimental Study on Preparation and Working Mechanical Properties of Steel Fiber Reinforced Concrete", Jiangxi Building Materials. 
  34. Yan, S., Jiao, H., Yang, X., Wang, J. and Chen, F. (2020), "Bending Properties of Short-Cut Basalt Fiber Shotcrete in Deep Soft Rock Roadway", Adv. Civil Eng., 2020, 1-9. https://doi.org/10.1155/2020/5749685 
  35. Yang, F. (2015), "Research on Application of High Strength Shotcrete in Railway Tunnels", Railway Engineering. 
  36. Yu, L. (2005), "Numerical analysis on tunnel excavation and support in soft rock", Dalian University of Technology, China. 
  37. Zhang, T. and Pan, D. (2021), "Mechanical properties of steel-polypropylene hybrid fiber reinforced concrete in building structure: steel-polypropylene hybrid fiber reinforced concrete in building structure", Stavebni obzor - Civil Eng. J., 30. https://doi.org/10.14311/CEJ.2021.02.0037 
  38. Zhen, H., Zhang, C., Ma, S., Chen, Y. and Liao, M. (2021), "Design and key technology analysis of integrated robot system for tunnel maintenance", J. Rail Way Sci. Eng., 18(3), 767-776. https://doi.org/10.19713/j.cnki.43-1423/u.T20200506 
  39. Zhu, Y. (2009), "Study on mechanical properties of steel fiber shotcrete and its application in tunnel single-layer lining", Chongqing University, China.