Membrane and Water Treatment

  • 제14권1호
  • /
  • Pages.27-33
  • /
  • 2023
  • /
  • 2005-8624(pISSN)
  • /
  • 2092-7037(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Phosphorus removal by lime-natural mineral dissolved solutions

  • Joohyun, Kim (Department of Civil and Environmental Engineering, Konkuk University) ;
  • Sunho, Yoon (Department of Civil and Environmental Engineering, Konkuk University) ;
  • Jueun, Jung (Department of Civil and Environmental Engineering, Konkuk University) ;
  • Sungjun, Bae (Department of Civil and Environmental Engineering, Konkuk University)
  • 투고 : 2022.10.12
  • 심사 : 2023.01.17
  • 발행 : 2023.01.25
⟨ 이전 논문 다음 논문 ⟩

초록

In previous studies, solely ferric (Fe3+) and calcium (Ca2+) ions were commonly used for removal of PO4-P (considered as T-P in this study) in wastewater via chemical precipitation. Herein, the removal of total phosphorus (T-P) in wastewater was performed using various mineral and lime dissolved solutions. The dissolution kinetics of different minerals (feldspar, olivine, elvan, illite, sericite, and zeolite) and lime was compared and used their solutions for T-P removal of real wastewater. The highest T-P removal (almost 90%) was obtained by the lime dissolved solution and followed by zeolite, illite, feldspar, and others. We observed a significant co-relationship (R of 0.96) between the amount of initial Ca2+ and T-P removal. This was induced by formation of hydroxyapatite-like mineral via Ca-P precipitation reaction at high pH solution. Furthermore, additional removal of suspended solid (SS) and chemical oxygen demand (COD) was achieved by only lime dissolved solution. Finally, the lime-feldspar dissolved solutions were prepared at different ratios (10-50%), which showed a successive T-P removal up to two times by samples of 40 and 50%.

키워드

과제정보

This work was supported by the Korea Environment Industry & Technology Institute (KEITI) through the Ecological Imitation-based Environmental Pollution Management Technology Development Project funded by the Korea Ministry of Environment (MOE) (2021002800007) and the Korea CCUS Association (K-CCUS) grant funded by the Korea Government (MOE, MOTIE). (KCCUS 20220001, Human Resources Program for Reduction of greenhouse gases), and Konkuk University Researcher Fund in 2022.

참고문헌

  1. Al-Shannag, M., Lafi, W., Bani-Melhem, K., Gharagheer, F. and Dhaimat, O. (2012), "Reduction of COD and TSS from paper industries wastewater using electro-coagulation and chemical coagulation", Sep. Sci. Technol., 47, 700-708. https://doi.org/10.1080/01496395.2011.634474
  2. Burakova, A. and Baksiene, E. (2021), "Leaching losses of main nutrients by incorporating organic fertilisers into light texture soils Haplic Luvisol", Environ. Eng. Res., 26(4), 200190. https://doi.org/10.4491/eer.2020.190
  3. Choi, Y.K., Jang, H.M., Kan, E., Wallace, A.R. and Sun, W. (2019), "Adsorption of phosphate in water on a novel calcium hydroxide-coated dairy manure-derived biochar", Environ. Eng. Res., 24, 434-442. https://doi.org/10.4491/eer.2018.296
  4. De Rooij, J.F., Heughebaert, J.C. and Nancollas, G.H. (1984), "A ph study of calcium phosphate seeded precipitation", J. Colloid Interface Sci., 100, 350-358. https://doi.org/10.1016/0021-9797(84)90440-5
  5. Desireddy, S., Madhavan, S. and P.C.S. (2022), "Development and long-term operation of aerobic granular system for simultaneous removal of COD, nitrogen, and phosphorous in a conical SBR", Environ. Eng. Res., 28, 220015-0. https://doi.org/10.4491/ee.r.2022.015
  6. Hong, S.H., Lee, C.G., Jeong, S. and Park, S.J. (2020), "Synthesis of polysulfone beads impregnated with Ca-sepiolite for phosphate removal", Membr. Water Treat., 11(1), 69-77. https://doi.org/10.12989/mwt.2020.11.1.069
  7. Hosni, K., Ben Moussa, S. and Ben Amor, M. (2007), "Conditions influencing the removal of phosphate from synthetic wastewater: Influence of the ionic composition", Desalination, 206, 279-285. https://doi.org/10.1016/j.desal.2006.03.570
  8. Hosni, K., Ben Moussa, S., Chachi, A. and Ben Amor, M. (2008), "The removal of PO23-- by calcium hydroxide from synthetic wastewater: Optimisation of the operating conditions", Desalination, 223, 337-343. https://doi.org/10.1016/j.desal.2007.01.213
  9. Kwak, S. and Yun, Z. (2020), "The control of point and non-point source nitrogen to prevent eutrophication of the Nakdong River basin, Korea", Membr. Water Treat., 11(5), 345-351. https://doi.org/10.12989/mwt.2020.11.5.345
  10. Li, R., Wang, J.J., Zhou, B., Awasthi, M.K., Ali, A., Zhang, Z., Lahori, A.H. and Mahar, A. (2016), "Recovery of phosphate from aqueous solution by magnesium oxide decorated magnetic biochar and its potential as phosphate-based fertilizer substitute", Bioresour. Technol., 215, 209-214. https://doi.org/10.1016/j.biortech.2016.02.125
  11. Li, S., Lei, T., Jiang, F., Liu, M., Wang, Y., Wang, S. and Yang, X. (2020), "Tuning the morphology and adsorption capacity of Al-MIL-101 analogues with Fe3+ for phosphorus removal from water", J. Colloid Interface Sci., 560, 321-329. https://doi.org/10.1016/j.jcis.2019.10.077
  12. Loganathan, P., Vigneswaran, S., Kandasamy, J. and Bolan, N.S. (2014), "Removal and recovery of phosphate from water using sorption", Crit. Rev. Environ. Sci. Technol., 44, 847-907. https://doi.org/10.1080/10643389.2012.741311
  13. Morse, G.K., Brett, S.W., Guy, J.A. and Lester, J.N. (1998), "Review: Phosphorus removal and recovery technologies", Sci. Total Environ., 212, 69-81. https://doi.org/10.1016/S0048-9697(97)00332-X
  14. Nikolenko, M. V, Vasylenko, K. V, Myrhorodska, V.D., Kostyniuk, A. and Likozar, B. (2020), "Synthesis of calcium orthophosphates by chemical precipitation in aqueous solutions : The effect of the acidity, ca/p molar ratio, and temperature on the phase composition and solubility of precipitates", Processes, 8(9), 1009. https://doi.org/10.3390/pr8091009
  15. Nir, O., Sengpiel, R. and Wessling, M. (2018), "Closing the cycle: Phosphorus removal and recovery from diluted effluents using acid resistive membranes", Chem. Eng. J., 346, 640-648. https://doi.org/10.1016/j.cej.2018.03.181
  16. Rumble, J. (2018), CRC Handbook of Chemistry and Physics, 99 ed, CRC Press.
  17. Shin, J., Kwak, J., Kim, S., Son, C., Lee, Y.G., Kim, J., Bae, S., Park, Y., Lee, S.H. and Chon, K. (2023), "Highly selective recovery of phosphate ions using a novel carbonaceous adsorbent synthesized via co-pyrolysis of spent coffee grounds and steel slags: A potential phosphatic fertilizer", Chem. Eng. J., 451, 138978. https://doi.org/10.1016/j.cej.2022.138978
  18. Shin, S.Y., Kim, J.H. and Ahn, J.H. (2016), "Phosphorus removal from municipal wastewater using ti-based coagulants", J. Korean Soc. Environ. Eng., 38, 428-434. https://doi.org/10.4491/ksee.2016.38.8.428
  19. Thistleton, J., Berry, T.A., Pearce, P. and Parsons, S.A. (2002), "Mechanisms of chemical phosphorus removal II. Iron (III) salts", Process Saf. Environ. Prot. Trans. Inst. Chem. Eng. Part B, 80, 265-269. https://doi.org/10.1205/095758202762277623
  20. Vaccari, D.A., Powers, S.M. and Liu, X. (2019), "Demand-driven model for global phosphate rock suggests paths for phosphorus sustainability", Environ. Sci. Technol., 53, 10417-10425. https://doi.org/10.1021/acs.est.9b02464
  21. Yoon, S., Choi, M., Hwang, Y. and Bae, S. (2021), "Upcycling of steel slag for manufacture of Prussian-blue-encapsulated pectin beads and its use for efficient removal of aqueous cesium." J. Clean. Prod., 319, 128786. https://doi.org/10.1016/j.jclepro.2021.128786