Structural Engineering and Mechanics

  • 제83권3호
  • /
  • Pages.305-326
  • /
  • 2022
  • /
  • 1225-4568(pISSN)
  • /
  • 1598-6217(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Hysteretic behaviors and calculation model of steel reinforced recycled concrete filled circular steel tube columns

  • Ma, Hui (State Key Laboratory of Eco-hydraulics in Northwest Arid Region, Xi'an University of Technology) ;
  • Zhang, Guoheng (State Key Laboratory of Eco-hydraulics in Northwest Arid Region, Xi'an University of Technology) ;
  • Xin, A. (Qinghai Building and Materials Research Co., Ltd.) ;
  • Bai, Hengyu (State Key Laboratory of Eco-hydraulics in Northwest Arid Region, Xi'an University of Technology)
  • 투고 : 2021.06.15
  • 심사 : 2022.03.15
  • 발행 : 2022.08.10
⟨ 이전 논문 다음 논문 ⟩

초록

To realize the recycling utilization of waste concrete and alleviate the shortage of resources, 11 specimens of steel reinforced recycled concrete (SRRC) filled circular steel tube columns were designed and manufactured in this study, and the cyclic loading tests on the specimens of columns were also carried out respectively. The hysteretic curves, skeleton curves and performance indicators of columns were obtained and analysed in detail. Besides, the finite element model of columns was established through OpenSees software, which considered the adverse effect of recycled coarse aggregate (RA) replacement rates and the constraint effect of circular steel tube on internal RAC. The numerical calculation curves of columns are in good agreement with the experimental curves, which shows that the numerical model is relatively reasonable. On this basis, a series of nonlinear parameters analysis on the hysteretic behaviors of columns were also investigated. The results are as follows: When the replacement rates of RA increases from 0 to 100%, the peak loads of columns decreases by 7.78% and the ductility decreases slightly. With the increase of axial compression ratio, the bearing capacity of columns increases first and then decreases, but the ductility of columns decreases rapidly. Increasing the wall thickness of circular steel tube is very profitable to improve the bearing capacity and ductility of columns. When the section steel ratio increases from 5.54% to 9.99%, although the bearing capacity of columns is improved, it has no obvious contribution to improve the ductility of columns. With the decrease of shear span ratio, the bearing capacity of columns increases obviously, but the ductility decreases, and the failure mode of columns develops into brittle shear failure. Therefore, in the engineering design of columns, the situation of small shear span ratio (i.e., short columns) should be avoided as far as possible. Based on this, the calculation model on the skeleton curves of columns was established by the theoretical analysis and fitting method, so as to determine the main characteristic points in the model. The effectiveness of skeleton curve model is verified by comparing with the test skeleton curves.

키워드

과제정보

The research was financially supported by National Natural Science Foundation of China P.R. (No.51408485), Project Supported by Natural Science Basic Research Plan in Shaanxi Province of China (No.2022JM-258 and No. 2021JM-332), the Open Fund Project of Qinghai Provincial Key Laboratory of Plateau Green Building and Ecocommunity (KLKF-2021-001), which is gratefully acknowledged.

참고문헌

  1. Bai, G., Ma, J., Liu, B. and Chen, X. (2020), "Study on the interfacial bond slip constitutive relation of I-section steel and fully recycled aggregate concrete", Constr. Build. Mater., 238(3), 117688. https://doi.org/10.1016/j.conbuildmat.2019.117688.
  2. Bhartiya, R., Oinam, R.M., Sahoo, D.R. and Utkarsh, K. (2021), "Modified confinement model for monotonic axial behavior of concrete-filled tubular columns", J. Constr. Steel Res., 180(5), 106570. https://doi.org/10.1016/j.jcsr.2021.106570.
  3. Braga, A.M., Silvestre, J.D. and de Brito, J. (2017), "Compared environmental and economic impact from cradle to gate of concrete with natural and recycled coarse aggregates", J. Clean. Prod., 162(9), 529-543. https://doi.org/10.1016/j.jclepro.2017.06.057.
  4. Dong, H.Y., Li, Y.N., Cao, W.L. and Guo, Y.L. (2021), "Seismic behavior of full-scale steel reinforced recycled concrete columns under high axial compression ratio", Struct., 29(2), 1882-1897. https://doi.org/10.1016/j.istruc.2020.12.037.
  5. Du, Y.B., Zhao, Z.Q., Xiao, Q., Shi, F.T., Yang, J.M. and Gao, P.W. (2021), "Experimental study on the mechanical properties and compression size effect of recycled aggregate concrete", Mater., 14(9), 2323. https://doi.org/10.3390/ma14092323.
  6. Duan, Z.H., Jiang, S.S., Xiao, J.Z. et al. (2020), "Effect of moisture content of recycled coarse aggregate on concrete properties", J. Build. Mater., 23(04), 1-11.
  7. Filippou, F.C. and Issa, A. (1988), "Nonlinear analysis of reinforced concrete frames under cyclic load reversals", Earthquake Engineering Research Center, EERC Report 88-12, Berkeley.
  8. GB/T50081 (2002), Test Method for Mechanical Properties of Ordinary Concrete, China Construction Industry Press, Beijing, China. (in Chinese)
  9. Han, L.H. (2007), Concrete Filled Steel Tubular Structure-Theory and Practice, Second Edition, Science Press, China. (in Chinese)
  10. He, A., Cai, J., Chen, Q.J., Liu, X., Xue, H. and Yu, C. (2017), "Axial compressive behaviour of steel-jacket retrofitted RC columns with recycled aggregate concrete", Constr. Build. Mater., 141(6), 501-516. https://doi.org/10.1016/j.conbuildmat.2017.03.013.
  11. Huda, S.B. and Alam, M.S. (2014), "Mechanical behavior of three generations of 100% repeated recycled coarse aggregate concrete", Constr. Build. Mater., 65(8), 574-582. https://doi.org/10.1016/j.conbuildmat.2014.05.010.
  12. Jia, P., Dong, J.F., Yuan, S.C. and Wang, Q.Y. (2018), "Experimental study of post-heated steel reinforced recycled concrete columns repaired with CFRP", J. Wuhan Univ. Technol.-Mater., 33(4), 901-907. https://doi.org/10.1007/s11595-018-1911-z.
  13. Kisku, N., Joshi, H., Ansari, M., Panda, S.K., Nayak, S. and Dutta, S.C. (2018), "A review of recycled aggregate in concrete applications (2000-2017)", Constr. Build. Mater., 172(5), 272-292. https://doi.org/10.1016/j.conbuildmat.2016.11.029.
  14. Kisku, N., Joshi, H., Ansari, M., Panda, S.K., Nayak, S. and Dutta, S.C. (2017), "A critical review and assessment for usage of recycled aggregate as sustainable construction material", Constr. Build. Mater., 131(1), 721-740. https://doi.org/10.1016/j.conbuildmat.2016.11.029.
  15. Liu, B., Bai, G.L., Xu, Z.H., Ma, J.F. and Han, Y.Y. (2019), "Experimental study and finite element modeling of bond behavior between recycled aggregate concrete and the shaped steel", Eng. Struct., 201(12), 109840. https://doi.org/10.1016/j.engstruct.2019.109840.
  16. Liu, Z.Q. (2012), "Research on seismic performance and design method of steel reinforced concrete special-shaped column frame", Xi'an University of Architecture and Technology, China. (in Chinese)
  17. Ma, H., Chen, Y., Bai, H. and Zhao, Y. (2019), "Eccentric compression performance of composite columns composed of RAC-filled circular steel tube and profile steel", Eng. Struct., 201(12), 109778. https://doi.org/10.1016/j.engstruct.2019.109778.
  18. Ma, H., Jia, C.J., Xi, J.C., Dong, J., Zhang, X.C. and Zhao, Y.L. (2021), "Cyclic loading test and nonlinear analysis on composite frame consisting of steel reinforced recycled concrete columns and steel beams", Eng. Struct., 241(8), 112480. https://doi.org/10.1016/j.engstruct.2021.112480.
  19. Ma, H., Xue, J., Liu, Y. and Zhang, X. (2015), "Cyclic loading tests and shear strength of steel reinforced recycled concrete short columns", Eng. Struct., 92(6), 55-68. https://doi.org/10.1016/j.engstruct.2015.03.009.
  20. Nour, A.I. and Guneyisi, E.M. (2019), "Prediction model on compressive strength of recycled aggregate concrete filled steel tube columns", Compos. Part B, 173(9), 106938. https://doi.org/10.1016/j.compositesb.2019.106938.
  21. Shaban, W.M., Elbaz, K., Yang, J., Thomas, B.S., Shen, X., Li, L., ... & Li, L. (2021), "Effect of pozzolan slurries on recycled aggregate concrete: Mechanical and durability performance", Constr. Build. Mater., 276(3), 121940. https://doi.org/10.1016/j.conbuildmat.2020.121940.
  22. Tam, V.W.Y., Gao, X.F. and Tam, C.M. (2006), "Environmental enhancement through use of recycled aggregate concrete in a two-stage mixing approach", Human Ecolog. Risk Assess, 12(2), 277-288. https://doi.org/10.1080/10807030500531653
  23. Wang, C. (2013), "Research on seismic behavior of steel reinforced recycled concrete short columns based on OPENSEES", Xi'an University of Architecture and Technology, China. (in Chinese)
  24. Wang, C.Q. and Xiao, J.Z. (2018), "Evaluation of the stress-strain behavior of confined recycled aggregate concrete under monotonic dynamic loadings", Cement Concrete Compos., 87(3), 149-163. https://doi.org/10.1016/j.cemconcomp.2017.12.012.
  25. Wang, C.Q. and Xiao, J.Z. (2021), "Investigation on the seismic damage of recycled aggregate concrete frame structure", J. Earthq. Eng., 25(5), 791-815. https://doi.org/10.1080/13632469.2018.1531091.
  26. Wang, C.Q., Wu, H.X. and Li, C.X. (2022), "Hysteresis and damping properties of steel and polypropylene fiber reinforced recycled aggregate concrete under uniaxial low-cycle loadings", Constr. Build. Mater., 319(14),126191. https://doi.org/10.1016/j.conbuildmat.2021.126191.
  27. Wang, C.Q., Xiao, J.Z., Qi, C.L. and Li, C.X. (2022), "Rate sensitivity analysis of structural behaviors of recycled aggregate concrete frame", J. Build. Eng., 45(1), 103634. https://doi.org/10.1016/j.jobe.2021.103634.
  28. Xi, J.C. (2021), "Experimental study and nonlinear analysis of seismic behavior of circular steel tubular steel reinforced recycled concrete columns", Xi'an University of Technology, China. (in Chinese)
  29. Xiao, J.Z. (2007), "Study on uniaxial compressive stress-strain curve of recycled concrete", J. Tongji Univ., 35(11), 1445-1449. (in Chinese) https://doi.org/10.3321/j.issn:0253-374X.2007.11.001
  30. Xiao, J.Z. (2007), Recycled Concrete, Construction Industry Press, Beijing, China. (in Chinese)
  31. Xiao, J.Z., Yang, J., Huang, Y.J. and Wang, Z.P. (2011), "Experimental study on axial compression of recycled concrete confined by steel tube", J. Build. Struct., 32(06), 92-98. (in Chinese)
  32. Xiaodong, H.A.N., Yue, Z.H.A.O., Yanze, Y.A.N.G., Siha, A. and Changdong, Z.H.O.U. (2020), "Experimental study on eccentric compression performance of circular steel tubular steel reinforced recycled concrete composite columns", J. Nat. Disast., 29(3), 89-99. (in Chinese)
  33. Xu, Z.B. (2017), "Research on hysteretic behavior of recycled concrete filled square steel tubular columns based on OPENSEES", Harbin Institute of Technology, China. (in Chinese)
  34. Xue, J.Y., Zhang, X., Ren, R., Zhai, L. and Ma, L.L. (2018), "Experimental and numerical study on seismic performance of steel reinforced recycled concrete frame structure under low-cyclic reversed loading", Adv. Struct. Eng., 21(12), 1895-1910. https://doi.org/10.1177/1369433218759080.
  35. Yang, Y.F. and Han, L.H. (2006), "Experimental behaviour of recycled aggregate concrete filled steel tubular columns", J. Constr. Steel Res., 62(2), 1310-1324. (in Chinese) https://doi.org/10.1016/j.jcsr.2006.02.010
  36. Yassin, M.H.M. (1994), "Nonlinear analysis of prestressed concrete structures under monotonic and cyclic loads", University of California, Berkeley, USA.
  37. Yu, C.Q., Tong, J.Z. and Tong, G.S. (2021), "Behavior and design of slender concrete-filled wide rectangular steel tubular columns under axial compression", Struct., 33(10), 3137-3146. https://doi.org/10.1016/j.istruc.2021.06.065.
  38. Zang, J.B. and Wu, B. (2022), "Axial compressive behavior of square steel tubular columns filled with steel stirrups reinforced recycled lump concrete", Struct., 36(2), 735-751. https://doi.org/10.1016/j.istruc.2021.12.040.
  39. Zhang, J., Liu, X., Wu, Z., Yu, H. and Fang, Q. (2021), "Fracture properties of steel fiber reinforced concrete: Size effect study via mesoscale modelling approach", Eng. Fract. Mech., 206(1), 108193. https://doi.org/10.1016/j.engfracmech.2021.108193.
  40. Zhang, Y.C. (2010), Design Principle of Steel Structure, Higher Education Press, Beijing, China. (in Chinese)
  41. Zhao, B.D., Liu, X.C. and Pei, C. (2013), "Nonlinear analysis of steel tube filled with steel-reinforced concrete after high temperature", Appl. Mech. Mater., 482(482-482), 11-14. https://doi.org/10.4028/www.scientific.net/AMM.482.11.
  42. Zhu, P., Hao, Y., Liu, H., Wei, D., Liu, S. and Gu, L. (2019), "Durability evaluation of three generations of 100% repeatedly recycled coarse aggregate concrete", Constr. Build. Mater., 210(6), 442-450. https://doi.org/10.1016/j.conbuildmat.2019.03.203.