Advances in aircraft and spacecraft science

Techno-Press (테크노프레스)
권호 표지
DOI QR코드

DOI QR Code

Fin failure diagnosis for non-linear supersonic air vehicle based on inertial sensors

  • Received : 2019.02.12
  • Accepted : 2019.05.23
  • Published : 2020.01.25
⟨ Previous Next ⟩

Abstract

In this paper, a new model-based Fault Detection and Diagnosis (FDD) method for an agile supersonic flight vehicle is presented. A nonlinear model, controlled by a classical closed loop controller and proportional navigation guidance in interception scenario, describes the behavior of the vehicle. The proposed FDD method employs the Inertial Navigation System (INS) data and nonlinear dynamic model of the vehicle to inform fins damage to the controller before leading to an undesired performance or mission failure. Broken, burnt, unactuated or not opened control surfaces cause a drastic change in aerodynamic coefficients and consequently in the dynamic model. Therefore, in addition to the changes in the control forces and moments, system dynamics will change too, leading to the failure detection process being encountered with difficulty. To this purpose, an equivalent aerodynamic model is proposed to express the dynamics of the vehicle, and the health of each fin is monitored by the value of a parameter which is estimated using an adaptive robust filter. The proposed method detects and isolates fins damages in a few seconds with good accuracy.

Keywords

References

  1. Anguelova, M. (2004), "Nonlinear observability and identifiability: General theory and a case study of a kinetic model S. cerevisiae", Chalmers University of Technology, Goteborg, Sweden.
  2. Basri, M.H., Lias, K., Abidin W.W.Z, Tay, K.M. and Zen, H. (2012), "Fault detection using dynamic parity space Aaproach", Proceedings of the Power Engineering and Optimization Conference (PEDCO), Melaka, Malaysia.
  3. Blanke, M. (1999), "Fault-tolerant control systems", Adv. Control, 171-196. https://doi.org/10.1007/978-1-4471-0853-5_6.
  4. Chen, W.H. (2003), "Nonlinear disturbance observer-enhanced dynamic inversion control of missiles", J. Guid. Control Dyn., 26(1), 161-166. https://doi.org/10.2514/2.5027.
  5. Crassidis, J.L. and Junkins, J.L. (2004), Optimal Estimation of Dynamic Systems, CRC Press.
  6. Crawford, L.S., Sharma, V. and Menon, P. (2000), "Numerical synthesis of a failure-tolerant, nonlinear adaptive autopilot", Proceedings of the 2000 IEEE International Conference on Control Applications, Anchorage, Alaska, U.S.A., September
  7. Frank, P.M. (1990), "Fault diagnosis in dynamic systems using analytical and knowledge-based redundancy: A survey and some new results", Automatica, 26(3), 459-474. https://doi.org/10.1016/0005-1098(90)90018-D.
  8. Gertler, J. and Singer, D. (1990), "A new structural framework for parity equation-based failure detection and isolation", Automatica, 26(2), 381-388. https://doi.org/10.1016/0005-1098(90)90133-3.
  9. Gertler, J. (1997), "Fault detection and isolation using parity relations", Control Eng. Practice, 5(5), 653-661. https://doi.org/10.1016/S0967-0661(97)00047-6.
  10. Halder, P., Chaudhuri, S. and Mukhopadhyay, S. (2003), "Fault detection, diagnosis and control in a tactical aerospace vehicle", Proceedings of the TENCON 2003 Conference on Convergent Technologies for the Asia Pacific Region, Bangalore, India, October.
  11. Hanlon, P.D. and Maybeck, P.S. (2000), "Multiple-model adaptive estimation using a residual correlation Kalman filter bank", IEEE T. Aerosp. Electron. Syst., 36(2), 393-406. https://doi.org/10.1109/7.845216.
  12. He, J., Qi, R., Jiang, B. and Zhai, R. (2017), "Fault-tolerant control with mixed aerodynamic surfaces and RCS jets for hypersonic reentry vehicles", Chin. J. Aeronaut., 30(2), 780-795. https://doi.org/10.1016/j.cja.2017.01.003.
  13. Hemsch, M. (1992), "Tactical missile aerodynamics-General topics", Progress Astronaut. Aeronaut., 141.
  14. Ishihara, S. and Yamakita, M. (2016), "Adaptive robust UKF for nonlinear systems with parameter uncertainties", Proceedings of the IECON 2016-42nd Annual Conference of the IEEE Industrial Electronics Society, Florence, Italy, October.
  15. Jiang, J. and Zhao, Q. (1997), "Should we use parameter estimation or state estimation based FDI algorithms?", IFAC Proc. Vol., 30(18) 459-464. https://doi.org/10.1016/S1474-6670(17)42444-X.
  16. Johnson, D.M. (1996), "A review of fault management techniques used in safety-critical avionic systems", Progress Aerosp. Sci., 32(5),415-431. https://doi.org/10.1016/0376-0421(96)82785-0.
  17. Juan, Z. (2011), "Fault detection for nonlinear systems based on parity space approach", Proceedings of the 30th Chinese Control Conference (CCC), Yantai, China, July.
  18. Julier, S.J. and Uhlmann, J.K. (1997), "New extension of the Kalman filter to nonlinear systems", Proceedings of the AeroSense'97: International Society for Optics and Photonics, Orlando, Florida, U.S.A.
  19. Kun, Q., Pang, X.P., Hao, Y. and Kai, L. (2010), "Aircraft health monitoring system using multiple-model adaptive estimation", Proceedings of the 2010 Second WRI Global Congress on Intelligent Systems, Wuhan, China, December.
  20. Lee, H., Snyder, S. and Hovakimyan, N. (2014), "An adaptive unknown input observer for fault detection and isolation of aircraft actuator faults", Proceedings of the 2014 AIAA Guidance, Navigation, and Control Conference, National Harbor, Maryland, U.S.A., January.
  21. Lee, H., Snyder, S., Patterson, A. and Hovakimyan, N. (2016), "Aircraft actuator fault detection and isolation using piecewise constant fault estimation scheme", Proceedings of the 2016 AIAA Guidance, Navigation, and Control Conference, San Diego, California, U.S.A., January.
  22. Lu, P., van Kampen, E., de Visser, C.C. and Chu, Q.P. (2017), "Framework for simultaneous sensor and actuator fault-tolerant flight control", J. Guid. Control Dyn., 40(8), 2133-2136. https://doi.org/10.2514/1.G002079.
  23. Mack, S., Tao, G. and Burkholder, J.O. (2010), "Adaptive detection of aircraft actuator failures and aerodynamic damage", Proceedings of the AIAA Guidance, Navigation and Control Conference, Toronto, Canada, August.
  24. Marzat, J., Piet-Lahanier, H., Damongeot, F. and Walter, E. (2009), "A new model-free method performing closed-loop fault diagnosis for an aeronautical system", Proceedings of the 7th Workshop on Advanced Control and Diagnosis, Zielona Gora, Poland, November.
  25. Marzat, J., Piet-Lahanier, H., Damongeot, F. and Walter, E. (2010), "Fault diagnosis for nonlinear aircraft based on control-induced redundancy", Proceedings of the IEEE Conference on Control and Fault-Tolerant Systems, SysTol2010, Nice, France, October.
  26. Marzat, J., Piet-Lahanier, H., Damongeot, F. and Walter E. (2012), "Model-based fault diagnosis for aerospace systems: a survey", Proc. Inst. Mech. Eng. Part G J. Aerosp. Eng., 226(10), 1329-1360. https://doi.org/10.1177%2F0954410011421717.
  27. Meskin, N., Jiang, T., Sobhani, E., Khorasani, K. and Rabbath, C. (2007), "Nonlinear geometric approach to fault detection and isolation in an aircraft nonlinear longitudinal model", Proceedings of the 2007 American Control Conference, New York, U.S.A., July.
  28. Patton, R.J. and Chen, J. (1994), "Review of parity space approaches to fault diagnosis for aerospace systems", J. Guid. Control Dyn., 17(2) 278-285. https://doi.org/10.2514/3.21194.
  29. Patton, R.J. (1997), "Fault-tolerant control systems: The 1997 situation", Proceedings of the IFAC Symposium on Fault Detection Supervision and Safety for Technical Processes, Kingston upon Hull, U.K., August.
  30. Rosema, C., Doyle, J., Auman, L., Underwood, M. and Blake, W.B. (2011), Missile DATCOM User's Manual-2011 Revision, Army Aviation and Missile Research Development ENG CTR Redstone Arsenal AL System Simulation and Development Directorate.
  31. Shahrokhi, T.S. (2015), "Fault Detection, Isolation and Identification of Autonomous Underwater Vehicles Using Dynamic Neural Networks and Genetic Algorithms", Ph.D. Dissertation, Concordia University, Montreal, Quebec, Canada.
  32. Simon, D. (2006), Optimal State Estimation: Kalman, H infinity, and Nonlinear Approaches, John Wiley & Sons.
  33. Stevens, B.L., Lewis, F.L. and Johnson, E.N. (2015), Aircraft Control and Simulation: Dynamics, Controls Design, and Autonomous Systems, John Wiley & Sons.
  34. Van Der Merwe, R., Doucet, A., De Freitas, N. and Wan, E. (2001), "The unscented particle filter", Adv. Neural Inform. Process. Syst., 584-590.
  35. Yang, X., Warren, M., Arain, B., Upcroft, B., Gonzalez, F. and Mejias, L. (2013), "A UKF-based estimation strategy for actuator fault detection of UASs", Proceedings of the 2013 International Conference on Unmanned Aircraft Systems (ICUAS), Atlanta, Georgia, U.S.A., May.
  36. Yu, C., Han, H.X. and Min, W. (2009), "Missile fault detection based on linear parameter varying fault detection filter", Inform. Technol. J., 8(3), 340-346. https://doi.org/10.3923/itj.2009.340.346
  37. Zhang, Y. and Jiang, J. (2008), "Bibliographical review on reconfigurable fault-tolerant control systems. Annual reviews in control", Ann. Rev. Control, 32(2), 229-252. https://doi.org/10.1016/j.arcontrol.2008.03.008.
  38. Zipfel, P.H. (2007), Modeling and Simulation of Aerospace Vehicle Dynamics, American Institute of Aeronautics and Astronautics.