Membrane and Water Treatment

  • 제10권6호
  • /
  • Pages.451-460
  • /
  • 2019
  • /
  • 2005-8624(pISSN)
  • /
  • 2092-7037(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Desalting enhancement for blend polyethersulfone/polyacrylonitrile membranes using nano-zeolite A

  • Mansor, Eman S. (Water pollution Research Department, Environmental Research Division, National Research Centre) ;
  • Jamil, Tarek S. (Water pollution Research Department, Environmental Research Division, National Research Centre) ;
  • Abdallah, Heba (Chemical Engineering and Pilot Plant Department, Engineering Research Division, National Research Centre) ;
  • Youssef, H.F. (Refractories, ceramics and building material department, National Research Centre) ;
  • Shaban, Ahmed M. (Water pollution Research Department, Environmental Research Division, National Research Centre) ;
  • Souaya, Eglal R. (Chemistry Department, Faculty of Science, Ain Shams University)
  • 투고 : 2018.01.15
  • 심사 : 2019.10.05
  • 발행 : 2019.11.25
⟨ 이전 논문 다음 논문 ⟩

초록

Thin film composite membranes incorporated with nano-sized hydrophilic zeolite -A were successfully prepared via interfacial polymerization (IP) on porous blend PES/PAN support for water desalination. The thin film nanocomposite membranes were characterized by SEM, contact angle and performance test with 7000 ppm NaCl solution at 7bar. The results showed that the optimum zeolite loading amount was determined to be 0.1wt% with permeate flux 29LMH.NaCl rejection was improved from 69% to 92% compared to the pristine polyamide membrane where the modified PA surface was more selective than that of the pristine PA. In addition, there was no significant change in the permeate flux of the thin film nanocomposite membrane compared with that of the pristine PA in spite of the formation of the dense polyamide layer. The stability of the polyamide layer was investigated for 15 days and the optimized membrane presented the highest durability and stability.

키워드

참고문헌

  1. Abdallah, H., Jamil, T.S., Shaban, A.M., Mansor, E.S. and Souaya, E.R. (2017), "The influence of the Polyacrylonitrile proportion on the fabricated UF blend membranes performance for humic acid removal", J. Polymer. Eng., 38(2), https://doi.org/10.1515/polyeng-2017-0003L.
  2. Bae, T.H. and Tak, T.M. (2005), "Effect of $TiO_2$ nanoparticles on fouling mitigation of ultrafiltration membranes for activated sludge filtration", J. Membr. Sci., 249, 102-108. https://doi.org/10.1016/j.memsci.2004.09.008
  3. Bao, M., Zhu, G., Wang, L., Wang, M. and Gao, C. (2013), "Preparation of mono dispersed spherical mesoporousnanosilica-polyamide thin film composite reverse osmosis membranes via interfacial polymerization", Desalination, 309, 261-266. https://doi.org/10.1016/j.desal.2012.10.028.
  4. Chen, Z., Holmberg, B., Li, W., Wang, X., Deng, W., Munoz, R. and Yan Y. (2006), "Nafion/Zeolite nano composite membrane by in situ crystallization for a direct methanol fuel cell", J. Chem. Mater, 18, 5669-5675. https://doi.org/10.1021/cm060841q.
  5. Childress, A.E. and Elimelech, M., (2000), "Relating Nanofiltration Membrane Performance to Membrane Charge (Electrokinetic) Characteristics", J. Environ. Sci. Technol., 34, 3710-3716. https://doi.org/10.1021/es0008620.
  6. Chung T.S, Jiang L.Y., Li Y. and Kulprathipanja, S. (2007), "Mixed matrix membranes (MMMs) comprising organic polymers with dispersed inorganic fillers for gas separation", J. Prog. Polym. Sci, 32, 483-507. https://doi.org/10.1016/j.prog,polymsci.
  7. Cong, H., Radosz, M., Towler, B.F. and Shen, Y. (2007), "Polymer-inorganic nanocomposite membranes for gas separation", J. Sep. Purif. Technol, 55, 281-291. https://doi.org/10.1016/j.seppur.2006.12.017.
  8. Dong, H., Qu, X.Y., Zhang, L., Cheng, L.H., Chen, H.L. and Gao, C.J. (2011), "Preparation and characterization of surfacemodified zeolite-polyamide thin film nanocomposite membranes for desalination", Desalination Water Treat., 34, 6-12. https://doi.org/10.5004/dwt.2011.2789
  9. Dong, H., Zhao, L., Zhang, L., Chen, H., Gao, C. and Winston Ho W.S. (2015), "High-flux reverse osmosis membranes incorporated with NaY zeolite nanoparticles for brackish water desalination", J. Membr. Sci., 476, 373-383. https://doi.org/10.1016/j.memsci.2014.11.054.
  10. Eber,t K., Fritsch, D., Koll, J. and Tjahjawiguna, C. (2004), "Influence of inorganic fillers on the compaction behavior of porous polymer based membranes", J. Membr. Sci, 233, 71-78. https://doi.org/10.1016/j.memsci.2003.12.012.
  11. Fathizadeh M., Aroujaliana A. and Raisi A. (2011),"Effect of added NaXnano-zeolite into polyamide as a top thin layer of membrane on water flux and salt rejection in a reverse osmosis process", J. of Membr.Sci,375, 88-95. https://doi.org/10.1016/j.memsci.2011.03.017
  12. Ferreira-Esmi, C., Schrive, L., Barre, Y., Palmeri, J. and Deratani, A. (2013), "Using nanofiltration in a 'zero-rejection' process:The removal of Ni2+ and Co2+ from salty wastewater", Desalin. Water Treat., 51, 476-484. https://doi.org/10.1080/19443994.2012.714526
  13. Freger V. (2003), "Nanoscale Heterogeneity of Polyamide Membranes Formed by Interfacial Polymerization", Langmuir, 19, 4791-4797. https://doi.org/10.1021/la020920q.
  14. Freger V. (2005), "Kinetics of Film Formation by Interfacial Polycondensation", Langmuir ,21,1884-1894.doiI:10.1021/la048085v
  15. Geise G. M., Park H.B., Sagle A.C., Freeman B.D. and McGrath J.E. (2011),"Water permeability and water/salt selectivity tradeoff in polymers for Desalination", J.Membr.Sci., 369, 130-138. doi.org/10.1016/j.memsci.2010.11.054
  16. Ghanbari M., EmadzadehD. and Lau WJ., (2015), "Synthesis and characterization of novel thin film nanocompositereverse osmosis membranes with improved organicfouling properties for water desalination", RSC Adv. 5, 21268-21276.
  17. Qin, J.J., Oo, M.H., Lee, H. and Coniglio, B. (2004), "Effect of feed pH on permeate pH and ion rejection under acidic conditions in NF process", J. Membr. Sci., 232, 153-159. https://doi.org/10.1016/j.memsci.2003.12.010
  18. Huang H., Qu X., Dong H., Zhang L. and Chen H. (2013), "Role of NaA zeolites in the interfacial polymerization process towards a polyamide nanocomposite reverse osmosis membrane", RSC Advances, 3, 8203-8207. https://doi.10.1039/C3RA40960K.
  19. Jamil, T.S., Mansor, E.S., Abdallah, H., Shaban, A.M. and Souaya, E.R. (2018), "Novel anti fouling mixed matrix $CeO_2/Ce_7O_{12}$nanofiltration membranes for heavy metal uptake". J. Environ. Chem. Eng., 6, 3273-3282. https://doi.org/10.1016/j.jece.2018.05.006
  20. Jamil, T.S., Mansor, E.S., Abdallah, H. and Shaban, A.M. (2018) "Innovative high flux/low pressure blend thin film composite membranes for water softening", J. Reactive Functional Polymers, 131, 384-399. https://doi.org/10.1016/j.reactfunctpolym.2018.08.007.
  21. Jeong, B.H., Hoek, E.M.V., Yan, Y.S., Subramani, A., Huang, X.F., Hurwitz, G., Ghosh, A.K. and Jawor, A. (2007), "Interfacial polymerization of thin film nanocomposites: a new concept for reverse osmosis membranes", J. Membr. Sci, 294, 102-107. https://doi.org/10.1016/j.memsci.2007.02.025.
  22. Kong, C., Koushima, A., Kamada, T., Shintani, T., Kanezashi, M., Yoshioka, T. and Tsuru, T. (2011), "Enhanced performance of inorganic polyamide nanocomposite membranes prepared by metal alkoxide assisted interfacial polymerization", J. Membr. Sci, 366, 382-388. https://doi.org/10.1016/j.memsci.2010.10.026.
  23. Lau, W.J., Ismail, A.F., Misdan, N. and Kassim, M.A. (2012), "A recent progress in thin film composite membrane: A review", Desalination, 287, 190-199. https://doi.org/10.1016/j.desal.2011.04.004.
  24. Li D. and Wang H. (2013), "Thin Film Nanocomposite Membranes for Water Desalination", Mater. Membr. Water Treat., 163-194. https://doi.org/10.1002/9783527668502.ch7.
  25. Li Z.H., Zhang H.P., Zhang P., Li G.C., Wu Y.P. and Zhou X.D. (2008),"Effects of the porous structure on conductivity of nanocomposite polymer electrolyte for lithium on batteries", J. Membr. Sci, 322, 416-422. https://doi.org/10.1016/j.memsci.2008.05.074.
  26. Lind M.L., Ghosh A.K., Jawor A., Huang X., Hou W., Yang Y. and Hoek E.M.V. (2009), "Influence of Zeolite Crystal Size on Zeolite-Polyamide Thin Film Nanocomposite Membranes", Langmuir, 25, 10139-10145. https://doi.org/10.1021/la900938x.
  27. Lind M.L., Suk D.E., Nguyen T.V. and Hoek E.M.V. (2010), "Tailoring the structure of thin film nanocomposite membranes to achieve seawater RD membrane performance Tailoring the structure of thin film nanocomposite membranes to achieve seawater RD membrane performance", J. Enviro. Sci. Technol., 44(21), 8230-8235. https://doi.org/10.1021/es101569p.
  28. Loiola, A.R. andrade J.C.R.A., Sasaki J.M. and da Silva, L.R.D. (2012), "Structural analysis of zeolite NaA synthesized by a costeffective hydrothermal method using kaolin and its use as water softener", J. Colloid Interface Sci., 367, 34-39 https://doi.org/10.1016/j.jcis.2010.11.026
  29. Low, Z.X., Liu, Q., Shamsaei, E., Zhang, X. and Wang, H. (2015), "Preparation and Characterization of Thin-Film Composite Membrane with Nanowire-Modified Support for Forward Osmosis Process", J. Membranes, 5, 136-149. https://doi.org/10.3390/membranes5010136.
  30. Lu, J., Drzal, L.T., Worden, R.M. and Lee, I. (2007), "Simple fabrication of a highly sensitive glucose biosensor using enzymes immobilized in exfoliated graphite nano-platelets nafion membrane", J. Chem. Mater., 19, 6240-6246. https://doi.org/10.1021/cm702133u
  31. Ma, N.,Wei, J., Liao, R. and Tang, C.Y. (2012), "Zeolitepolyamide thin film nanocomposite membranes: Towards enhanced performance for forward osmosis", J. Membr. Sci., 405, 149-157. https://doi.org/10.1016/j.memsci.2012.03.002.
  32. Mahajan, R., Burns, R., Schaeffer, M. and Koros, W.J. (2002), "Challenges in forming successful mixed matrix membranes with rigid polymeric materials", J. Applied Polymer Sci., 86, 881. https://doi.org/10.1002/app.10998.
  33. Mansor, E,S., Jamil, T.S., Abdallah, H. and Shaban, AM. (2018), "Highly thin film nanocomposite membrane based metal organic complexes for brackish water desalination", J. Environ. Chem. Eng., 6, 5459-5469. https://doi.org/10.1016/j.jece.2018.08.034
  34. Maximous, N., Nakhla, G., Wong, K. and Wan, W. (2010), "Optimization of Al2O3/PES membranes for wastewater filtration", J. Separation Purification Technol., 73, 294-301. https://doi.org/10.1016/j.seppur.2010.04.016.
  35. Nyankson, E., Efavi, J.K., Yaya, A., Manu, G., Asare, K., Daafuor, J. and Abrokwah, R.Y. (2018), "Synthesis and characterisation of zeolite-A and Zn-exchanged zeolite-A based on naturalaluminosilicates and their potential applications", Cogent Eng. B, 1440480
  36. Pacheco, F.A., Pinnau, I., Reinhard, M. and Leckie, J.O. (2010), "Characterization of isolated polyamide thin films of RO and NF membranes using novel TEM techniques", J. Membr. Sci., 358, 51-59. https://doi.org/10.1016/j.memsci.2010.04.032.
  37. Peng, F., Pan, F., Sun, H., Lu, L. and Jiang, Z. (2007), "Novel nanocomposite pervaporation membranes composed of poly(vinylalcohol) and chitosan wrappedcarbonnanotube", J. Membr. Sci, 300-1319. https://doi.org/10.1016/j.memsci.2007.06.008.
  38. Rakhi, M.S., Babu, G.S. and Premalath, M. (2016), "Applications of Nanotechnology in Waste water treatment: A Review", Imperial J. Interdisciplinary Res., 14(1), https://doi.org/10.1166/jnn.2014.8898.
  39. Serpil, Y., Nevra, E. and Huseyin, D. (2012), "Influence of LbL surface modification on oxygen cross-over in self-assembled thin composite membranes", Appl. Surface Sci., 258, 3139-3146. https://doi.org/10.1016japsuse2011.11.05. https://doi.org/10.1016/j.apsusc.2011.11.051
  40. Sheikholeslami, R., Al-Mutaz, I.S., Tan, S. and Tan, S.D. (2002), "Some Aspects of Silica Polymerization and Fouling and its Pretreatment by Sodium Alumina, Lime and Soda Ash", Desalination, 150, 85-92. https://doi.org/10.1016/S0011-9164(02)00932-3.
  41. Solomon, M.F.J. (2013), "Thin Film Composite Membranes by Interfacial Polymerization for Organic Solvent Nanofiltration", Ph.D. Dissertation, Imperial College London, United Kingdom. https://doi.org/10.25560/14650.
  42. Soroko, I. and Livingston, A. (2009), "Impact of $TiO_2$ nanoparticles on morphology andperformance of crosslinked polyimide organic solvent nanofiltration (OSN) membranes", J. Membr. Sci, 343, 189-198. https://doi.org/10.1016/j.memsci.2009.07.026.
  43. Sorribas S., Gorgojo P., Tellez C., Coronas J. and Livingston A.G. (2013), "High flux thin film nanocomposite membranes based on metal-organic frameworks for organic solvent nanofiltration", J. Am. Chem. Soc., 135, 15201-15208. https://doi.org/10.1021/ja407665w.
  44. Tay, J.H., Liu, J. and Sun, D.D. (2002), "Effect of solution physico-chemistry on the charge property of nanofiltration membranes", Water Res., 36, 585-598. https://doi.org/10.1016/S0043-1354(01)00278-0.
  45. Treacy, M.M.J. and Higgins, J.B. (2001), "Collection of simulated XRD powder patterns for zeolites", Zeolite, 10(5), 313-520.
  46. Xie, W., Geise, G.M., Freeman, B.D., Lee, H.S., Byun, G. and McGrath, J.E. (2012), "Polyamide interfacial composite membranes prepared from m-phenylene diamine, trimesoyl chloride and a new disulfonated diamine", J.Membr.Sci., 403, 152-161.
  47. Yang, D., Li, J., Jiang, Z., Lu, L. and Chen, X. (2009), "Chitosan/$TiO_2$nanocompositepervaporation membranes for ethanol dehydration", J. Chem. Eng. Sci., 64, 3130-3137. https://doi.org/10.1016/j.ces.2009.03.042.
  48. Yin J. (2014), "Fabrication and modification of nanocomposite membranes for enhanced water purification", Ph.D. Dissertation, University of Missouri, https://hdl.handle.net/10355/46441.
  49. Yin, J., Kim, E., Yang, J. and Deng, B. (2012), "Fabrication of a novel thin-film nanocomposite (TFN) membrane containing MCM-41 silica nanoparticles (NPs) for water purification", J. Membr. Sci, 423, 238-246. https://doi.org/10.1016/j.memsci.2012.08.020.
  50. Youssef, H.F., Ibrahim, D. and Komarneni, S. (2008), "Microwave-Assisted versus Conventional Hydrothermal Synthesis of Zeolite A from Metakaolinite", Microporous Mesoporous Mater., 115, 527-534. https://doi.org/10.1016/j.micromeso.2008.02.030.
  51. Zhao, L., Chang, P.C.Y, Yen, C. and Ho, W.S.W. (2013),"Highflux and fouling-resistant membranes for brackish water desalination", J. Membr. Sci., 425, 1-10. https://doi.org/10.1016/j.memsci.2012.09.018.
  52. Zhao, H., Qiu, S., Wu, L., Zhang, L., Chen, H. and Gao, C. (2014), "Improving the performance of polyamide reverse osmosis membrane by incorporation of modified multi-walled carbon nanotubes", J. Membr.Sci., 450, 249-256. https://doi.org/10.1016/j.memsci.2013.09.014.
  53. Zhou, H. and Smith, D.W. (2002), "Advanced technologies in water and wastewater Treatment", J. Environ. Eng. Sci, 1, 247-264. https://doi.org/10.1139/s02-020.