Membrane and Water Treatment

Techno-Press (테크노프레스)
권호 표지
DOI QR코드

DOI QR Code

LLE and SLM studies for Pd(II) separation using a thiodiglycolamide-based ligand

  • Kumbhaj, Shweta (Department of Chemical Engineering, Institute of Chemical Technology, Matunga (East)) ;
  • Prabhu, Vandana (Department of Chemical Engineering, Institute of Chemical Technology, Matunga (East)) ;
  • Patwardhan, Anand V. (Department of Chemical Engineering, Institute of Chemical Technology, Matunga (East))
  • Received : 2016.12.08
  • Accepted : 2018.08.07
  • Published : 2018.11.25
⟨ Previous Next ⟩

Abstract

The present paper deals with the liquid-liquid extraction and flat sheet supported liquid membrane studies of Pd(II) separation from nitric acid medium using a novel synthesized ligand, namely, N,N,N',N'-tetraethyl-2,2-thiodiethanthiodiglycolamide (TETEDGA). The effect of various diluents and stripping reagents on the extraction of Pd(II) was studied. The liquid-liquid extraction studies showed complete extraction of Pd(II) in ~ 5 min. The influence of nitric acid and TETEDGA concentration on the distribution of Pd(II) has been investigated. The increase in nitric acid concentration resulted in increase in extraction of Pd(II). Stoichiometry of the extracted species was found to be $Pd(NO_3)_2{\cdot}TETEDGA$ by slope analysis method. Extraction studies with SSCD solution showed negligible uptake of Pt, Cr, Ni, and Fe, thus showing very high selectivity and extractability of TETEDGA for Pd(II). The flat sheet supported liquid membrane studies showed quantitative transport of Pd(II), ~99%, from the feed ($3M\;HNO_3$) to the strippant (0.02 M thiourea diluted in $0.4M\;HNO_3$) using 0.01 M TETEDGA as a carrier diluted in n-dodecane. Extraction time was ~160 min. Parameters such as feed acidity, TETEDGA concentration in membrane phase, membrane porosity etc. were optimized to achieve maximum transport rate. Permeability coefficient value of $2.66{\times}10^{-3}cm/s$ was observed using TETEDGA (0.01 M) as carrier, at 3 M, $HNO_3$ feed acidity across $0.2{\mu}m$ PTFE as membrane. The membrane was found to be stable over five runs of the operation.

Keywords

References

  1. Acres, G.J.K. (1984), "Platinum group metal catalysis at the end of this century", Met. Rev., 28(4), 150-157.
  2. Acres, G.J.K. (1987), "Platinum group metal catalysis at the end of this century", Mater. Des., 8(5), 258-262. https://doi.org/10.1016/0261-3069(87)90002-1
  3. Al-Bazi, S.J. and Freiser, H. (1987), "Mechanistic studies on the extraction of Pd(II) with dioctyl sulphide", Solv. Extr. Ion Exch., 5(2), 265-275. https://doi.org/10.1080/07366298708918566
  4. Ansari, S.A., Mohapatra, P.K., Tripathi, S.C., and Manchanda, V. K. (2006), "Transport of Americium (III) through a supported liquid membrane containing N, N, N', N'-tetraoctyl-3-oxapentane diamide (TODGA)in n-dodecane as the carrier", J. Membr. Sci., 282(1), 133-141. https://doi.org/10.1016/j.memsci.2006.05.013
  5. Barakat, M.A., EL-Mahdy, G.A., Hegazy, M. and Zahran, F. (2009), "Hydrometallurgical recovery of nano-palladium from spent catalyst", Open Miner. Process. J., 2, 31-36. https://doi.org/10.2174/1874841400902010031
  6. Barakat, M.A., Mahmoud, M.H.H. and Maharous, Y.S. (2006), "Recovery and separation of palladium from spent catalyst", Appl. Catal. A: Gen., 301(2), 182-186. https://doi.org/10.1016/j.apcata.2005.11.028
  7. Bartsch, R.A. and Way, J.D. (1996), "Chemical Separations with Liquid Membranes", ACS Symposium Series, 642, 1-10.
  8. Bhatluri, K.K., Manna, M.S., Ghoshal, A.K. and Saha, P. (2015), "Supported liquid membrane based removal of lead (II) and cadmium (II) from mixed feed: Conversion to solid waste by precipitation", J. Hazard. Mat., 299, 504-512. https://doi.org/10.1016/j.jhazmat.2015.07.030
  9. Boyadzheiv, L. (1990), "Liquid pertraction or liquid membranes: State of art", Sep. Sci. Tech., 25(3), 187-205. https://doi.org/10.1080/01496399008050329
  10. Boyadzheiv, L. and Lazarova, Z. (1995), "Membranes separation technology: Principles and applications", Liquid Membranes: Membrane Science and Technology Series, Vol. 2, Elsevier, The Netherlands, 23-87.
  11. Dakshinamoorthy, A., Dhami, P.S., Nayak, P.W., Dudwadkar, N. L., Munshi, S.K., Dey, P. and Venugopal, K.V. (2008), "Separation of palladium from high level liquid waste of PUREX origin by solvent extraction and precipitation methods using oximes", Desalination, 232(1), 26-36. https://doi.org/10.1016/j.desal.2007.11.052
  12. Danesi, P.R. (1984), "Separation of metal species by supported liquid membrane", Sep. Sci. Tech., 19(11-12), 857-894. https://doi.org/10.1080/01496398408068598
  13. Danesi, P.R., Chiarizia, R., Rickert, P. and Horwitz, E.P. (1985), "Separation of actinides and lanthanides from acidic nuclear waste by supported liquid membranes", Solv. Extr. Ion Exch., 3(1-2), 111-147. https://doi.org/10.1080/07366298508918505
  14. Guyon, V., Guy, A., Foos, J., Chomel, R., Moutarde, T., Lebuzyte, G. and Lemaire, M.J. (1994), "New extractant for selective recovery of palladium from high level radioactive waste", J. Radioanal. Nucl. Chem., 187(1), 19-24. https://doi.org/10.1007/BF02162630
  15. Huang, T.C. and Juang, R.S. (1987), "Transport of zinc through a supported liquid membrane using di (2-ethylhexyl) phosphoric acid", J. Membr. Sci., 31(2), 209-226. https://doi.org/10.1016/S0376-7388(00)82228-0
  16. Izatt, R.M., Roper, D.K., Bruening, R.L. and Lamb, J.D. (1989), "Macrocycle-mediated cation transport using hollow fiber supported liquid membranes", J. Membr. Sci., 45(1), 73-84. https://doi.org/10.1016/S0376-7388(00)80846-7
  17. Jagdale, Y.D., Patwardhan, A.W., Shah, K.A., Chaurasia, S., Patwardhan, A.V., Ansari, S.A. and Mohapatra, P.K. (2013), "Transport of strontium through a hollow fibre supported liquid membrane containing N, N, N', N'-tetraoctyl diglycolamide as the carrier", Desalination., 325, 104-112. https://doi.org/10.1016/j.desal.2013.06.014
  18. Kim, M.A., Lee, J.C., Kim, C.K., Kim, M.S. and Yoo, K.K. (2006), "Solvent extraction of platinum group metals from the leach liquor of spent automotive catalyst", J. Korean Inst. Res. Rec., 15(5), 3-10.
  19. Kovvali, A.S. and Sirkar, K.K. (2003), "Stable liquid membrane: Recent developments and future directions", Ann. Ny. Acad. Sci., 984(1), 279-288. https://doi.org/10.1111/j.1749-6632.2003.tb06006.x
  20. Mezhov, E.A., Kuchmunov, V.A. and Druzhenkov, V.V. (2002a), "Study of extraction of palladium from nitric acid solutions with nitrogen containing compound, as applied to recovery to fission palladium from spent nuclear fuel of nuclear power plants - Extraction and back washing conditions", Radiochemistry, 44, 135-140. https://doi.org/10.1023/A:1019663027481
  21. Mezhov, E.A., Kuchmunov, V.A. and Druzhenkov, V.V. (2002b), "Study of extraction of palladium from nitric acid solutions with nitrogen containing compound as applied to recovery to fission palladium from spent nuclear fuel of nuclear power plants: Optimization of extraction process for palladium recovery and refining", Radiochemistry, 44, 146-150. https://doi.org/10.1023/A:1019667128389
  22. Mowafy, E.A., Mohamed, D. and Alshammari, A. (2015), "Extraction and separation of selected platinum-group and base metal ions from nitric acid solutions using thiodiglycolamides (TDGA) as novel extractants", Sep. Sci. Tech., 50(15), 2352-2359.
  23. Nosrati, S., Jayakumar, N.S., Hashim, M.A. and Mukhopadhyay, S. (2013), "Performance evaluation of vanadium (IV) transport through supported ionic liquid membrane", J. Taiwan Inst. Chem. E., 44(3), 337-342. https://doi.org/10.1016/j.jtice.2012.12.010
  24. Panja, S., Mohapatra, P.K., Tripathi, S.C. and Manchanda, V.K. (2010), "Transport of thorium (IV) across a supported liquid membrane containing N, N, N', N'-tetraoctyl-3oxapentanediamide (TODGA) as the extractant", Sep. Sci. Tech., 45(8), 1112-1120. https://doi.org/10.1080/01496391003697416
  25. Panja, S., Ruhela, R., Das, A., Tripathi, S.C., Singh, A.K., Gandhi, P.M. and Hubli, R.C. (2014), "Carrier concentration transport of Pd(II) from nitric acid medium using Dithiodiglycolamide (DTDGA) across a supported liquid membrane (SLM)", J. Membr. Sci., 449, 67-73. https://doi.org/10.1016/j.memsci.2013.07.045
  26. Pearson, R.G. (1968), "Hard and soft acids and bases HSAB part I Fundamental principal", J. Chem. Educ., 45(9), 581. https://doi.org/10.1021/ed045p581
  27. Raj, M.M., Dharmaraja, A., Panchanatheswaran, K., Venkatesan, K.A., Srinivasan, T.G. and Rao, V. (2004), "Extraction of fission palladium (II) from nitric acid by benzoylmethylenetriph-enylphosphorane (BMTTP)", Hydrometallurgy, 84(1), 118-124. https://doi.org/10.1016/j.hydromet.2006.05.003
  28. Rizvi, G.H., Mathur, J.N., Murali, M.S. and Iyer, R.H. (1996), "Recovery of fission product palladium from acidic high level waste solutions", Sep. Sci. Tech., 31(13),1805-1816. https://doi.org/10.1080/01496399608001011
  29. Ruhela, R., Panja, S., Sharma, J.N., Tripathi, B.S., Hubli, R.C. and Suri, A.K. (2012), "Facilitated transport of Pd(II) through a supported liquid membrane (SLM) containing N,N,N',N'-tetra-(2-ethylhexyl) thiodiglycolamide T(2EH)TDGA: A novel carrier", J. Hazard. Mat., 229-230, 66-71. https://doi.org/10.1016/j.jhazmat.2012.05.064
  30. Ruhela, R., Sharma, J.N., Tomar, B.S., Adya, V.C., Sheshgiri, T. K., Hubli, R.C. and Suri, A.K. (2011), "N, N, N', N'-tetra (2-Ethylhexyl) thiodiglycolamide T (2EH) TDGA: A promising ligand for separation and recovery of palladium from High Level Liquid Waste (HLLW) solutions", Sep. Sci. Tech., 46(6), 965-971. https://doi.org/10.1080/01496395.2010.539191
  31. Ruhela, R., Sharma, J.N., Tomar, B.S., Panja, S., Tripathi, S.C., Hubli, R.C. and Suri, A.K. (2010), "N, N, N', N'-Tetra(2-ethylhexyl) thiodiglycolamide T(2EH)TDGA: A novel ligand for the extraction of palladium from high level liquid waste (HLLW)", Radiochim. Acta., 98(4), 209-214. https://doi.org/10.1524/ract.2010.1712
  32. Ruhela, R., Tomar, B.S., Sharma, J.N., Sheshgiri, T.K., Adya, V. C., Hubli, R.C. and Suri, A.K. (2013), "Studies on the separation and recovery of palladium from simulated high level liquid waste (SHLW) solution with novel extractant N, N, N', N'-tetra (2-ethylhexyl) dithiodiglycolamide DTDGA", Sep. Sci. Tech., 48(7), 1049-1055. https://doi.org/10.1080/01496395.2012.724140
  33. Shailesh, S., Pathak, P.N., Mohapatra, P.K. and Manchanda, V.K. (2006), "Transport studies of uranium across a supported liquid membrane containing N, N-di(2-isobutyramide (D2EHIBA) as the carrier", J. Membr. Sci., 272(1), 143-151. https://doi.org/10.1016/j.memsci.2005.07.030
  34. Sharma, S., Panja, S., Ghosh, S.K., Dhami, P.S. and Gandhi, P.M. (2016), "Efficient transport of Am (III) from nitric acid medium using a new conformationally constrained (N, N, N', N'-tetra-2-ethylhexyl) 7-oxabicyclo [2.2. 1] heptane-2, 3-dicarboxamide across a supported liquid membrane", J. Hazard. Mat., 305, 171-177. https://doi.org/10.1016/j.jhazmat.2015.11.045
  35. Shukla, J.P., Singh, R.K., Sawant, S.R. and Varadarajan, N. (1993), "Liquid-liquid extraction of palladium (II) from nitric by bis(2-ethylhexyl) sulphoxide", Anal. Chim. Acta, 276(1),181-187. https://doi.org/10.1016/0003-2670(93)85054-N
  36. Sirkar, K.K. (2006), "Membranes, interface and separation: novel process and technique - An overview", Proceeding of the 17th International Congress of Chemical and Process Engineering, Czech Republic, Prague, August.
  37. Sriram, S., Mohapatra, P.K., Pandey, A.K., Manchanda, V.K. and Badheka, L.P. (2007), "Facilitated transport of americium (III) from nitric acid media using dimethyldibutyltetradecyl-1,3-malonamide", J. Membr. Sci., 177, 163-175.
  38. Vernekar, P.V., Jagdale, Y.D., Sharma, A.D., Patwardhan, A.W., Patwardhan, A.V., Ansari, S.A. and Mohapatra, P.K. (2014), "Simultaneous extraction of neodymium and uranium using hollow fibre supported liquid membrane", Sep. Sci. Tech., 49(10), 1509-1520. https://doi.org/10.1080/01496395.2014.890628
  39. Vernekar, P.V., Jagdale, Y.D., Patwardhan, A.W., Patwardhan, A.V., Ansari, S.A., Mohapatra, P.K. and Manchanda, V.K. (2013), "Transport of cobalt (II) through a hollow fibre supported liquid membrane containing di-(2-ethylhexyl) phosphoric acid (D2EHPA) as the carrier", Chem. Eng. Res. Des., 91(1),141-157. https://doi.org/10.1016/j.cherd.2012.06.019