한국농공학회논문집 (Journal of The Korean Society of Agricultural Engineers)

  • 제60권2호
  • /
  • Pages.25-36
  • /
  • 2018
  • /
  • 1738-3692(pISSN)
  • /
  • 2093-7709(eISSN)
한국농공학회 (The Korean Society of Agricultural Engineers)
권호 표지
DOI QR코드

DOI QR Code

점적관개용 디스크 여과기의 디스크 홈 단면 형상에 따른 수두 손실 특성 분석

Analysis of Disk Filter Head Losses due to the Shapes of Disk Grooves in Drip Irrigation System

  • Jung, Seung-Yeon (Department of Rural Systems Engineering, Seoul National University) ;
  • Choi, Won (Department of Rural Systems Engineering, Research Institute for Agriculture & Life Sciences, Seoul National University) ;
  • Choi, Jin-Yong (Department of Rural Systems Engineering, Research Institute for Agriculture & Life Sciences, Seoul National University) ;
  • Kim, Maga (Department of Rural Systems Engineering, Seoul National University) ;
  • Lee, Yoonhee (Department of Rural Systems Engineering, Seoul National University)
  • 투고 : 2017.11.03
  • 심사 : 2017.12.22
  • 발행 : 2018.03.31
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

Drip irrigation system is a low energy cost method which can efficiently save and supply water by dropping water slowly on the crop's root zone during crop growth. In the drip irrigation system, disk filters take an important role to physically remove impurity (inorganic and suspended organic) particles present in agricultural water which can cause emitter clogging. For the purpose, both top-and-bottom surfaces of the disk are grooved in micron size flowing from outside to inside. However, many congested flow paths in disk filter media incur higher head loss of inflow water resulting in relatively decreasing velocities depending on operation time than sand and mesh filters. Therefore, it is important to optimize the structure of disk filter in micro irrigation system. The head loss of disk filter media takes also charge of more than 60 % of total head loss in whole disk filter. This study is to find the appropriate cross-sectional shape of the disk groove to minimize the head loss by executing the experiment. The experiment used three disk filters that have similar filter body but have a half-elliptic and two kinds of triangular cross sections. The experimental results showed that the disk filter with half-elliptic cross sections of disk grooves have less head loss than the disk filter with regular triangular one.

키워드

참고문헌

  1. Alhands, M. N., and J. F. Pranchaska, 1996. Disc filtration: something old, something new. In Proc. the American Filtration and Separation Society Meeting, 496-500. Valley Forge, VA, Northport, Alabama.: AFS.
  2. Benham, B. L., and B. B. Ros, 2002. Filtration, treatment, and maintenance considerations for micro-irrigation systems. Virginia Cooperative Extension, 442-757.
  3. Capra, A., and B. Scicolone, 2004. Emitter and filter tests for wastewater reuse by drip irrigation. Agricultural water management 68(2): 135-149. doi:10.1016/j.agwat.2004.03.005.
  4. Demir, V., H. Yurdem, A. Yazgi, and A. Degirmencioglu. 2009. Determination of the head losses in metal body disc filters used in drip irrigation systems. Turkish Journal of Agriculture and Forestry, 33(3): 219-229. doi:10.3906/tar-0811-1.
  5. Duran-Ros, M., J. Puig-Bargues, G. Arbat, J. Barragan, and F. R. de Cartagena. 2009. Effect of filter, emitter and location on clogging when using effluents. Agricultural Water Management, 96(1): 67-79. doi:10.1016/j.agwat.2008.06.005.
  6. Duran-Ros, M., G. Arbat, J. Barragan, F. R. de Cartagena, and J. Puig-Bargues. 2010. Assessment of head loss equations developed with dimensional analysis for micro irrigation filters using effluents. Biosystems Engineering, 106(4): 521-526. doi:10.1016/j.biosystemseng.2010.06.001.
  7. Kim, C. S., J. H. Kim, S. H. Go, and G. H. Lee. 1991, Studies on the cucumber cultivation by automatic irrigation system in the greenhouse. Journal of the Korean Society of Agricultural Engineers 33(1): 89-99 (in Korean).
  8. Kim, H. J., D. W. Son, S. O. Hur, M. Y. Roh, K. Y. Jung, J. M. Park, J. Y. Rhee, and D. H. Lee. 2009. Comparison of wetting and drying characteristics in differently textured soils under drip irrigation. Journal of Bio-Environment Control 18(4): 309-315 (in Korean).
  9. Hassanli, A. M., M. A. Ebrahimizadeh, and S. Beecham, 2009. The effects of irrigation methods with effluent and irrigation scheduling on water use efficiency and corn yields in an arid region. Agricultural Water Management 96(1): 93-99. doi:10.1016/j.agwat.2008.07.004.
  10. Lee, N. H., H. C. Hwang, S. W. Nam, S. G. Hong, and W. J. Jeon. 1998. A study on the utilization of irrigation systems for greenhouse farming. Journal of the Korean Society of Rural Planning 4(2): 37-45 (in Korean).
  11. Liu, G., H. Jiang, D. Liao, and Y. Deng, 2017. Comparative experiments on the technological performance of disc filters. In Proc. IOP Conference Series: Materials Science and Engineering 207(1): p. 012066. IOP Publishing. doi:10.1088/1757-899X/207/1/012066.
  12. Nam, W. H., J. Y. Choi, S. K. Choi, E. M. Hong, S. H. Jeon, and S. O. Hur, 2012. Discharge uniformity and performance assessment of drip irrigation system. Journal of the Korean Society of Agricultural Engineers, 54(4): 29-38 (in Korean). doi:10.5389/KSAE.2012.54.4.029.
  13. Puig-Bargues, J., G. Arbat, J. Barragan, and F. R. de Cartagena, 2005. Effluent particle removal by microirrigation system filters. Spanish Journal of Agricultural Research, 3(2): 182-191. doi:10.5424/sjar/2005032-139.
  14. Puig-Bargues, J., J. Barragan, and F. R. de Cartagena, 2005. Development of equations for calculating the head loss in effluent filtration in microirrigation systems using dimensional analysis. Biosystems Engineering, 92(3): 383-390. doi:10.1016/j.biosystemseng.2005.07.009.
  15. Ribeiro, T. A. P., J. E. S. Paterniani, R. P. D. S. Airold, and M. J. M. D. Silva, 2004. Water quality and head loss in irrigation filters. Scientia Agricola, 61(6): 563-572. doi:10.1590/S0103-90162004000600001.
  16. Sivanappan, R. K., 1994. Prospects of micro-irrigation in India. Irrigation and Drainage System, 8(1): 49-58. doi:10.1007/BF00880798.
  17. Tajrishy, M. A., D. J. Hills, and G. Tchobanoglous, 1994. Pretreatment of secondary effluent for drip irrigation. Journal of Irrigation and Drainage Engineering ASCE 120(4): 716-731. doi:10.1061/(ASCE)0733-9437(1994)120:4(716).
  18. Wu, W., W. Chen, H. Liu, S. Yin, and Y. Niu, 2014. A new model for head loss assessment of screen filters developed with dimensional analysis in drip irrigation systems. Irrigation and Drainage, 63(4): 523-531. doi:10.1002/ird.1846.
  19. Wu, W., W. Chen, H. Liu, S. Yin, Z. Bao, and Y. Niu, 2014. A dimensional analysis model for the calculation of head loss due to disc filters in drip irrigation systems. Irrigation and Drainage, 63(3): 349-358. doi:10.1002/ird.1814.
  20. Yurdem, H., V. Demir, and A. Degirmencioglu, 2008. Development of a mathematical model to predict head losses from disc filters in drip irrigation systems using dimensional analysis. Biosystems Engineering, 100(1): 14-23. doi:10.1016/j.biosystemseng.2008.01.003.
  21. Yurdem, H., V. Demir, and A. Degirmencioglu, 2010. Development of a mathematical model to predict clean water head losses in hydrocyclone filters in drip irrigation systems using dimensional analysis. Biosystems Engineering, 105(4): 495-506. doi:10.1016/j.biosystemseng.2010.02.001.