Membrane and Water Treatment

  • 제6권1호
  • /
  • Pages.77-94
  • /
  • 2015
  • /
  • 2005-8624(pISSN)
  • /
  • 2092-7037(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Ultrafiltration membranes for drinking-water production from low-quality surface water: A case study in Spain

  • Rojas-Serrano, Fatima (Technologies for Water Management and Treatment Research Group, University of Granada, Department of Civil Engineering) ;
  • Alvarez-Arroyo, Rocio (Technologies for Water Management and Treatment Research Group, University of Granada, Department of Civil Engineering) ;
  • Perez, Jorge I. (Technologies for Water Management and Treatment Research Group, University of Granada, Department of Civil Engineering) ;
  • Plaza, Fidel (Department of Research and Development, CADAGUA S.A.) ;
  • Garralon, Gloria (Department of Research and Development, CADAGUA S.A.) ;
  • Gomez, Miguel A. (Technologies for Water Management and Treatment Research Group, University of Granada, Department of Civil Engineering)
  • 투고 : 2013.12.05
  • 심사 : 2014.12.23
  • 발행 : 2015.01.25
⟨ 이전 논문 다음 논문 ⟩

초록

Ultrafiltration membranes have several advantages over conventional drinking-water treatment. However, this technology presents major limitations, such as irreversible fouling and low removal of natural organic matter. Fouling depends heavily on the raw-water quality as well as on the operating conditions of the process, including flux, permeate recovery, pre-treatment, chemical cleaning, and backwashing. Starting with the premise that the optimisation of operating variables can improve membrane performance, different experiments were conducted in a pilot plant located in Granada (Spain). Several combinations of permeate and backwashing flow rates, backwashing frequencies, and aeration flow rates were tested for low-quality water coming from Genil River with the following results: the effluent quality did not depend on the combination of operating conditions chosen; and the membrane was effective for the removal of microorganisms, turbidity and suspended solids but the yields for the removal of dissolved organic carbon were extremely low. In addition, the threshold transmembrane pressure (-0.7 bar) was reached within a few hours and it was difficult to recover due to the low efficiency of the chemical cleanings. Moreover, greater transmembrane pressure due to fouling also increased the energy consumption, and it was not possible to lower it without compromising the permeate recovery. Finally, the intensification of aeration contributed positively to lengthening the operation times but again raised energy consumption. In light of these findings, the feasibility of ultrafiltration as a single treatment is questioned for low-quality influents.

키워드

참고문헌

  1. Amy, G. (2008), "Fundamental understanding of organic matter fouling of membranes", Desalination, 231(1-3), 44-51. https://doi.org/10.1016/j.desal.2007.11.037
  2. Aoustin, E., Schafer, A.I., Fane, A.G. and Waite, T.D. (2001), "Ultrafiltration of natural organic matter", Sep. Purif. Tech., 22-23, 63-78. https://doi.org/10.1016/S1383-5866(00)00143-X
  3. Arnal, J.M., Sancho, M., Garcia Fayos, B., Lora, J. and Verdu, G. (2007), "Aquapot: UF real applications for water potabilization in developing countries. Problems, location and solutions adopted", Desalination, 204(1-3), 316-321. https://doi.org/10.1016/j.desal.2006.02.037
  4. Baker, R.W. (2004), Membrane Technology and Applications, John Wiley and Sons, Chichester, WS, UK.
  5. Bellara, S.R., Cui, Z.F. and Pepper, D.S. (1996), "Gas sparging to enhance permeate flux in ultrafiltration using hollow fibre membranes", J. Memb. Sci., 121(2), 175-184. https://doi.org/10.1016/S0376-7388(96)00173-1
  6. Betancourt, W.Q. and Rose, J.B. (2004), "Drinking water treatment processes for removal of Cryptosporidium and Giardia", Vet. Parasitol., 126(1-2), 219-234. https://doi.org/10.1016/j.vetpar.2004.09.002
  7. Braak, E., Alliet, M., Schetrite, S. and Albasi, C. (2011), "Aeration and hydrodynamics in submerged membrane bioreactors", J. Memb. Sci., 379(1-2), 1-18. https://doi.org/10.1016/j.memsci.2011.06.004
  8. Cabassud, C., Laborie, S. and Laine, J.M. (1997), "How slug flow can improve ultrafiltration flux in organic hollow fibres", J. Memb. Sci., 128(1), 93-101. https://doi.org/10.1016/S0376-7388(96)00316-X
  9. Cheng, T.W. and Lee, Z.W. (2008), "Effects of aeration and inclination on flux performance of submerged membrane filtration", Desalination, 234 (1-3), 74-80. https://doi.org/10.1016/j.desal.2007.09.072
  10. Cornelissen, E.R., Vrouwenvelder, J.S., Heijman, S.G.J., Viallefont, X.D., Van Der Kooij, D. and Wessels, L.P. (2007), "Periodic air/water cleaning for control of biofouling in spiral wound membrane elements", J. Memb. Sci., 287(1), 94-101. https://doi.org/10.1016/j.memsci.2006.10.023
  11. Cornelissen, E.R., Rebour, L., van der Kooij, D. and Wessels, L.P. (2009), "Optimization of air/water cleaning (AWC) in spiral wound elements", Desalination, 236(1-3), 266-272. https://doi.org/10.1016/j.desal.2007.10.076
  12. Crozes, G.F., Jacangelo, J.G., Anselme, C. and Laine, J.M. (1997) "Impact of ultrafiltration operating conditions on membrane irreversible fouling", J. Memb. Sci., 124(1), 63-76. https://doi.org/10.1016/S0376-7388(96)00244-X
  13. Cui, Z.F. and Taha, T. (2003), "Enhancement of ultrafiltration using gas sparging: A comparison of different membrane modules", J. Chem. Tech. Biotech., 78(2-3), 249-253. https://doi.org/10.1002/jctb.763
  14. Cui, Z.F., Chang, S. and Fane, A.G. (2003), "The use of gas bubbling to enhance membrane processes", J. Memb. Sci., 221(1-2), 1-35. https://doi.org/10.1016/S0376-7388(03)00246-1
  15. Fernandez, G., Plaza F., Garralon, G., Garralon, A., Perez, J.I. and Gomez, M.A. (2012), "A comparative study of ultrafiltration and physicochemical process as pretreatment of seawater reverse osmosis", Desal. Wat. Treat., 42(1-3), 73-79. https://doi.org/10.1080/19443994.2012.683142
  16. Gao, W., Liang, H., Ma, J., Han, M., Chen, Z., Han, Z. and Li, G. (2011), "Membrane fouling control in ultrafiltration technology for drinking water production: A review", Desalination, 272(1-3), 1-8. https://doi.org/10.1016/j.desal.2011.01.051
  17. Ghosh, R. (2006), "Enhancement of membrane permeability by gas-sparging in submerged hollow fibre ultrafiltration of macromolecular solutions: Role of module design", J. Memb. Sci., 274(1-2), 73-82. https://doi.org/10.1016/j.memsci.2005.08.002
  18. Guo, X., Zhang, Z., Fang, L. and Su, L. (2009), "Study on ultrafiltration for surface water by a polyvinylchloride hollow fiber membrane", Desalination, 238(1-3), 183-191. https://doi.org/10.1016/j.desal.2007.11.064
  19. Huang, H., Schwab, K. and Jacangelo, J.G. (2009), "Pretreatment for low pressure membranes in water treatment: A review", Environ. Sci. Tech., 43(9), 3011-3019. https://doi.org/10.1021/es802473r
  20. Jacangelo, J.G., Trussell, R.R. and Watson, M. (1997), "Role of membrane technology in drinking water treatment in the United States", Desalination, 113(2-3), 119-127. https://doi.org/10.1016/S0011-9164(97)00120-3
  21. Ji, L. and Zhou, J. (2006), "Influence of aeration on microbial polymers and membrane fouling in submerged membrane bioreactors", J. Memb. Sci., 276(1-2), 168-177. https://doi.org/10.1016/j.memsci.2005.09.045
  22. Judd, S. (2011), The MBR book: Principles and Applications of Membrane Bioreactors for Water and Wastewater Treatment, Elsevier, Oxford, OX, UK.
  23. Kimura, K., Hane, Y., Watanabe, Y., Amy, G. and Ohkuma, N. (2004), "Irreversible membrane fouling during ultrafiltration of surface water", Wat. Res., 38(14-15), 3431-3441. https://doi.org/10.1016/j.watres.2004.05.007
  24. Laborie, S., Cabassud, C., Durand-Bourlier, L. and Laine, J.M. (1998), "Fouling control by air sparging inside hollow fibre membranes - effects on energy consumption", Desalination, 118(1-3), 189-196. https://doi.org/10.1016/S0011-9164(98)00124-6
  25. Laine, J., Vial, D. and Moulart, P. (2000), "Status after 10 years of operation - Overview of UF technology today", Desalination, 131(1-3), 17-25. https://doi.org/10.1016/S0011-9164(00)90002-X
  26. Li, N. (2008), Advanced Membrane Technology and Applications, John Wiley and Sons, Hoboken, NJ, USA.
  27. Liu, J., Liu, B., Liu, T., Bai, Y. and Yu, S. (2014), "Coagulation-bubbling-ultrafiltration: effect of floc properties on the performance of the hybrid process", Desalination, 333(1), 126-133. https://doi.org/10.1016/j.desal.2013.11.029
  28. Masse, A., Nguyen Thi, H., Legentilhomme, P. and Jaouen, P (2011), "Dead-end and tangential ultrafiltration of natural salted water: Influence of operating parameters on specific energy consumption", J. Memb. Sci., 380(1-2) 192-198. https://doi.org/10.1016/j.memsci.2011.07.002
  29. Mijatovic, I., Matosic, M., Cerneha, B.H. and Bratulic, D. (2004), "Removal of natural organic matter by ultrafiltration and nanofiltration for drinking water production", Desalination, 169(3), 223-230. https://doi.org/10.1016/j.desal.2004.01.002
  30. Mosqueda-Jimenez, D.B., Huck, P.M. and Basu, O.D. (2008), "Fouling characteristics of an ultrafiltration membrane used in drinking water treatment", Desalination, 230(1-3), 79-91. https://doi.org/10.1016/j.desal.2007.09.014
  31. Peter-Varbanets, M., Zurbrugg, C., Swartz, C. and Pronk, W. (2009), "Decentralized systems for potable water and the potential of membrane technology", Wat. Res., 43(2), 245-265. https://doi.org/10.1016/j.watres.2008.10.030
  32. Porcelli, N. and Judd, S. (2010), "Chemical cleaning of potable water membranes: A review", Sep. Purif. Tech., 71(2), 137-143. https://doi.org/10.1016/j.seppur.2009.12.007
  33. Rojas, J.C., Moreno, B., Garralon, G., Plaza, F., Perez, J. and Gomez, M.A. (2008), "Potabilization of low NOM reservoir water by ultrafiltration spiral wound membranes", J. Hazard. Mat., 158(2-3), 593-598. https://doi.org/10.1016/j.jhazmat.2008.01.107
  34. Rojas, J.C., Garralon, G., Plaza, F., Perez, J., Moreno, B. and Gomez, M.A. (2010), "Humic acids removal by aerated spiral-wound ultrafiltration membrane combined with coagulation-hydraulic flocculation", Desalination, 266(1-3), 128-133. https://doi.org/10.1016/j.desal.2010.08.013
  35. Shi, X., Tal, G., Hankins, N.P. and Gitis, V. (2014), "Fouling and cleaning of ultrafiltration membranes: A review". J. Water Process Engin., 1(121-138). https://doi.org/10.1016/j.jwpe.2014.04.003
  36. Xia, S., Li, X., Liu, R. and Li, G. (2005), "Pilot study of drinking water production with ultrafiltration of water from the Songhuajiang River (China)", Desalination, 179(1-3), 369-374. https://doi.org/10.1016/j.desal.2004.12.025

피인용 문헌

  1. Integrated in-line coagulation-aerated ultrafiltration for drinking-water production: A case study from laboratory to pilot plant vol.50, pp.13, 2015, https://doi.org/10.1080/10934529.2015.1064284
  2. Comparative study of in-line coagulation and/or ozonization pre-treatment for drinking-water production with spiral-wound ultrafiltration membranes vol.105, 2016, https://doi.org/10.1016/j.cep.2016.04.004
  3. Autopsy of ultrafiltration membranes for drinking-water production with in-line coagulation and ozonation pre-treatments vol.57, pp.42, 2016, https://doi.org/10.1080/19443994.2015.1106986
  4. Economical selection of optimum pressurized hollow fiber membrane modules in water purification system using RbLCC vol.8, pp.2, 2017, https://doi.org/10.12989/mwt.2017.8.2.137
  5. Characterization of a protein-based filtering cartridge for the removal of atrazine-induced effects on living cultured cells vol.10, pp.2, 2015, https://doi.org/10.12989/mwt.2019.10.2.121
  6. Performance evaluation of organic matter adsorption from actual graywater using GAC: OrbitrapTM MS and optimization vol.10, pp.6, 2015, https://doi.org/10.12989/mwt.2019.10.6.471