Journal of the Korea Concrete Institute (콘크리트학회논문집)

Korea Concrete Institute (한국콘크리트학회)
권호 표지
DOI QR코드

DOI QR Code

Effects of the Reaction Degree of Ground Granulated Blast Furnace Slag on the Properties of Cement Paste

고로슬래그 미분말의 반응도가 시멘트 페이스트의 물성에 미치는 영향에 관한 연구

  • Kim, Dong-Yeon (Dept. of Sustainable Architecture Engineering, Hanyang University) ;
  • Cho, Hyeong-Kyu (Dept. of Sustainable Architecture Engineering, Hanyang University) ;
  • Lee, Han-Seung (School of Architecture, Hanyang University ERICA)
  • 김동연 (한양대학교 대학원 건축환경공학과) ;
  • 조형규 (한양대학교 대학원 건축환경공학과) ;
  • 이한승 (한양대학교 ERICA 건축학부)
  • Received : 2014.06.02
  • Accepted : 2014.10.14
  • Published : 2014.12.31
Download PDF
⟨ Previous Next ⟩

Abstract

The usage of Ground Granulated Blast Furnance Slag (GGBFS) has been increased recently. Studies on the cement hydration model incorporating GGBFS as well as the properties of cement paste done with GGBFS such as compressive strength, hydration products and hydration heat have been the subjects of many researches. However, studies on the reaction degree of GGBFS that affect the properties of cement paste incorporating GGBFS are lacking globally and specially in Korea. Thus, in this study, the reaction degree of GGBFS using the method if selective dissolution, compressive strength, the amount of chemical bound water and $Ca(OH)_2$ were measured and analysed in accordance with water-binder ratio, replacement ratio of GGBFS, and curing temperature. The results show that the reaction degree of GGBFS, the amount of chemical bound water and $Ca(OH)_2$ in cement paste with GGBFS were higher in conditions where the replacement ratio of GGBFS was low and both water-binder ratio and curing temperature were high. Finally, the reaction degree of GGBFS was achieved at a value between 0.3~0.4.

최근 고로슬래그 미분말의 사용량이 증가함에 따라 고로슬래그 미분말 혼입 시멘트의 수화반응 모델뿐만 아니라 압축강도, 수화생성물, 수화열 등 고로슬래그 미분말 혼입 시멘트 페이스트의 물성에 관한 연구가 활발히 진행되고 있다. 하지만 고로슬래그 미분말 혼입 시멘트 페이스트의 물성에 큰 영향을 끼치는 고로슬래그 미분말의 반응도에 대한 연구는 세계적으로도 부족하며 특히 국내에서는 전무한 실정이다. 따라서 본 연구는 선택적 추출법을 이용하여 시멘트 페이스트 내 고로슬래그 미분말의 반응도를 정량분석하고 물 바인더비, 치환율, 양생온도에 따라 압축강도, 화학결합수, $Ca(OH)_2$을 측정하여 비교 분석 하였다. 실험결과 시멘트 페이스트 내 고로슬래그 미분말의 반응도, 화학결합수, $Ca(OH)_2$은 치환율이 낮고 물 바인더비와 양생 온도가 높을수록 높게 나타났으며 특히 고로슬래그 미분말의 반응도는 최종적으로 약 0.3~0.4 값에 수렴하는 것으로 나타났다.

Keywords

References

  1. Yoshio, K. and Sakai, E., "Admixtures for new ground granulated blast furnace slag", 2007, pp. 23-30.
  2. Numata, S., "Trend in Uses and research works of ground granulated blst furnace slag as replacement of cement for concrete", Concrete Journal, Vol. 33, No. 5, 1995, pp. 15-24.
  3. Leng, F., Feng, N., and Lu, X., "An Experiment Study on the Properties of Resistance to Diffusion of Chloride Ions of Fly Ash and Blast Furnace Slag Concrete", Cement and Concrete Research, Vol. 30, No. 6, 2000, pp. 989-992. https://doi.org/10.1016/S0008-8846(00)00250-7
  4. Wang, X.Y., Lee, H.S., Park, K.B., Kim, J.J., and Gorden, J.S., "A Multi-Phase Kinetic Model to Simulate Hydration of Slag-Cement Blends", Cement and Concrete Composites, Vol. 32, No. 6, 2010, pp. 468-477. https://doi.org/10.1016/j.cemconcomp.2010.03.006
  5. Wang, X.Y. and Lee, H.S., "Modeling the Hydration of Concrete Incorporating Fly Ash or Slag", Cement and Concrete Research, Vol. 40, No. 7, 2010, pp. 984-996. https://doi.org/10.1016/j.cemconres.2010.03.001
  6. Wang, X.Y., Cho, H.K., and Lee, H.S., "Prediction of Temperature Distribution in Concrete Incorporating Fly Ash or Slag using a Hydration Model", Composites Part B: Engineering, Vol. 42, No. 1, 2011, pp. 27-40. https://doi.org/10.1016/j.compositesb.2010.09.017
  7. Kocaba, V., Gallucci, E., and Scrivener, K.L., "Methods for Determination of Degree of Reaction of Slag in Blended Cement Pastes", Cement and Concrete Research, Vol. 42, No. 3, 2012, pp. 511-525. https://doi.org/10.1016/j.cemconres.2011.11.010
  8. Cement and Concrete Encyclopedia, Japan Cement Association, 1996, pp. 94-103.
  9. Lee, S.H., Kim, W.K., and Kang, S.H., "Slag and Concrete Hydration Mechanism of Ground Granulated Blast Furnace Slag", Korea Concrete Institute, Vol. 24, No. 6, 2012, pp. 31-34.
  10. Maekawa, K., Chaube, R., and Kishi, T., Modeling of concrete performance:hydration, microstructure formation and mass transport. Routledge, London, 1999, pp. 178-248.
  11. Lumley, J.S., Gollop, R.S., Moir, G.K., and Taylor, H.F.W., "Degrees of Reaction of the Slag in Some Blends with Portland Cements", Cement and Concrete Research, Vol. 26, No. 1, 1996, pp. 139-151. https://doi.org/10.1016/0008-8846(95)00190-5