Advances in Energy Research

  • 제1권2호
  • /
  • Pages.147-163
  • /
  • 2013
  • /
  • 2287-6316(pISSN)
  • /
  • 2287-6324(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Optimization and characterization of biodiesel produced from vegetable oil

  • Mustapha, Amina T. (Department of Chemical Engineering, School of Engineering and Engineering Technology, Federal University of Technology) ;
  • Abdulkareem, Saka A. (Department of Chemical Engineering, School of Engineering and Engineering Technology, Federal University of Technology) ;
  • Jimoh, Abdulfatai (Department of Chemical Engineering, School of Engineering and Engineering Technology, Federal University of Technology) ;
  • Agbajelola, David O. (Department of Chemical Engineering, School of Engineering and Engineering Technology, Federal University of Technology) ;
  • Okafor, Joseph O. (Department of Chemical Engineering, School of Engineering and Engineering Technology, Federal University of Technology)
  • 투고 : 2013.03.05
  • 심사 : 2013.11.04
  • 발행 : 2013.06.25
⟨ 이전 논문 다음 논문 ⟩

초록

The world faces several issues of energy crisis and environmental deterioration due to over-dependence on single source of which is fossil fuel. Though, fuel is needed as ingredients for industrial development and growth of any country, however the fossil fuel which is a major source of energy for this purpose has always been terrifying thus the need for alternative and renewable energy sources. The search for alternative energy sources resulted into the acceptance of a biofuel as a reliable alternative energy source. This work presents the study of optimization of process of transesterification of vegetable oil to biodiesel using NaOH as catalyst. A $2^4$ factorial design method was employed to investigate the influence of ratio of oil to methanol, temperature, NaOH concentration, and transesterification time on the yield of biodiesel from vegetable oil. Low and high levels of the key factors considered were 4:1 and 6:1 mole ratio, 30 and $60^{\circ}C$ temperatures, 0.5 and 1.0 wt% catalyst concentration, and 30 and 60 min reaction time. Results obtained revealed that oil to methanol molar ratio of 6:1, tranesetrification temperature of $60^{\circ}C$, catalyst concentration of 1.0wt % and reaction time of 30 min are the best operating conditions for the optimum yield of biofuel from vegetable oil, with optimum yield of 95.8%. Results obtained on the characterizzation of the produced biodiesel indicate that the specific gravity, cloud point, flash point, sulphur content, viscosity, diesel index, centane number, acid value, free glycerine, total glycerine and total recovery are 0.8899, 4, 13, 0.0087%, 4.83, 25, 54.6. 0.228mgKOH/g, 0.018, 0.23% and 96% respectively. Results also indicate that the qualities of the biodiesel tested for are in conformity with the set standard. A model equation was developed based on the results obtained using a statistical tool. Analysis of variance (ANOVA) of data shows that mole ratio of ground nut oil to methanol and transesterification time have the most pronounced effect on the biodiesel yield with contributions of 55.06% and 9.22% respectively. It can be inferred from the results various conducted that vegetable oil locally produced from groundnut oil can be utilized as a feedstock for biodiesel production.

키워드

참고문헌

  1. Abdulkareem, A.S., Abdulfatai, J., Afolabi, A.S., Odigure, J.O. and Patience, D. (2013), Production and characterization of biodiesel from non-edible oils: an alternative energy source to petrol diesel, Energy Conservation, Chapter 7, Intech Publication.
  2. Alamu, O.J., Akintola, T.A., Enweremadu, C.C. and Adeleke, A.E. (2008), "Characterization of palm-kernel oil biodiesel produced through NaOH-catalyzed transesterification process", Sci. Res. Essay, 3(7), 308-311.
  3. Ahmad, M., Samuel, S., Zafari, M., Khan, M.A., Tariq, M., Ali, S. and Sultana, S. (2009), "Physicochemical characterization of eco-friendly rice bran oil biodiesel", Energ. Source. Part A, 33(14), 1386-1397.
  4. Canakci, M., Erdil, A. and Arcaklioglu, E. (2006), "Performance and exhaust emission of a biodiesel engine", Appl. Energ., 83(6), 594-605. https://doi.org/10.1016/j.apenergy.2005.05.003
  5. Cynthia, O.U. (2011), "Effects of reaction parameters on biodiesel production from groundnut oil", Bachelor's Degree, Federal University of Technology, Minna.
  6. David, K.K. and Julius, C.A. (2010), "Optimization of factors affecting the production of biodiesel from crude palm kernel oil and ethanol", Int. J. Energ. Environ., 1(4), 675-682.
  7. El- Diwani, G. and El-Rafie, S. (2008), "Modification of thermal and oxidative properties of biodiesel produced from vegetable oils", Int. J. Environ. Sci. Tech., 5(3), 391-400. https://doi.org/10.1007/BF03326034
  8. El- Diwani, G., Attia, N.K. and Hawash, S.I. (2009), "Development and evaluation of biodiesel fuel and by- product from jatropha oil", Int. J. Environ. Sci. Tech., 6(2), 219-224. https://doi.org/10.1007/BF03327625
  9. Emil, A., Zahira, Y., Siti, K.K., Manal, I. and Jumat, S. (2009), "Characteristic and composition of jatropha curcas oil seed from Malaysia and its potential as biodiesel feedstock", Eur. J. Sci. Res., 29(3), 396-403.
  10. Freedman, B., Butterfield, R.O. and Pryde E.H. (1986), "Transesterification kinetics of soybean oil", J. Am. Oil Chem. Soc., 63(10), 1375-1380. https://doi.org/10.1007/BF02679606
  11. Galadima, A., Garba, Z.N. and Ibrahim, B.M. (2008), "Homogenous and heterogeneous transesterification of groundnut oil for synthesizing methyl biodiesel", Int. J. Pure Appl. Sci., 2(3), 138-144.
  12. Gerhard Knothe (2011), Department of Agriculture's National Center for Agricultural Utilization Research, Vegetable oil-based diesel fuels, Peoria, Illinois
  13. Gerpen, V.J. (2004), "Biodiesel processing and production", Fuel Process. Technol., 86(10), 1097-1107.
  14. Ibeto, C.N., Ofoefule, A.U. and Ezeugwu, H.C. (2011), "Fuel quality assessment of biodiesel produced from groundnut oil (Arachis hypogea) and its blend with petroleum diesel", Am. J. Food Technol., 6(9), 798-803. https://doi.org/10.3923/ajft.2011.798.803
  15. Issariyakul, T., Kulkarni, M.G., Dalai, A.K. and Bakhshi, N.N. (2006), "Production of biodiesel from waste fryer grease using mixed methanol/ethanol system", Fuel Process. Technol., 88(4), 429-436.
  16. Lang, X., Dalai, A.K., Bakhshi, N.N., Reaney, M.J. and Hertz, P.B. (2001) "Preparation and characterization of bio-diesels from various bio-oils", Bioresource Technol., 80(1), 53-62. https://doi.org/10.1016/S0960-8524(01)00051-7
  17. Ma, F. and Hanna, M.A. (1990), "Biodiesel production: a review", Bioresource Technol., 70(1), 1-15.
  18. Meher, L.C., Dharmagadda, V.S. and Naik, S.N. (2006), "Optimization of alkali-catalyzed transesterification of pongamia pinnata oil for production of biodiesel", Bioresource Technol., 97(5), 1392-1397. https://doi.org/10.1016/j.biortech.2005.07.003
  19. Nakpong, P. and Wootthikanokkhan, S. (2010), "High free fatty acid coconut oil as a potential feedstock for biodiesel production in Thailand", Renew. Energ., 35(8), 1682-1687. https://doi.org/10.1016/j.renene.2009.12.004
  20. Nakpong, P. and Wootthikanokkhan, S. (2009), "Biodiesel production from mixtures of vegetable oil and used cooking oil", Asian J. Energ. Environ., 10(4), 221-229.
  21. Raafat, A.A. (2010), "Different techniques for the production of biodiesel from waste vegetable oil", Int. J. Environ. Sci. Tech., 7(1), 183-213. https://doi.org/10.1007/BF03326130
  22. Roseli, A.P. Ferrari, Anna Leticia M. Turtelli Pighinelli and Kil Jin Park (2011), "Biodiesel production and quality", Food Technology Institute and Campinas State University, Brazil.
  23. Shahbaz, K., Mjalli, F.S., Hashim, M.A. and Al . Nashef, I.M. (2010), "Using deep eutectic solvents for the removal of glycerol from palm oil-based biodiesel", J. Appl. Sci., 10, 3349-3354. https://doi.org/10.3923/jas.2010.3349.3354
  24. Sharma, Y.C. and Singh, B. (2009), "Development of biodiesel: current scenario", Renew. Sust. Energ. Rev., 13(6-7), 1646-1651. https://doi.org/10.1016/j.rser.2008.08.009
  25. Shuguang D. (2011), "Occurrence and treatment of arsenic in groundwater and soil in Northern Mexico and South-Western USA", Chemosphere, 83, 211-225. https://doi.org/10.1016/j.chemosphere.2010.12.067
  26. Silva, G.F., Camargo, F.L. and Ferreira, A.L.O (2011), "Application of response surface methodology for optimization of biodiesel production by transesterification of soybean oil with ethanol", Fuel Process. Technol., 92(3), 407-413. https://doi.org/10.1016/j.fuproc.2010.10.002