Membrane and Water Treatment

  • 제1권4호
  • /
  • Pages.273-282
  • /
  • 2010
  • /
  • 2005-8624(pISSN)
  • /
  • 2092-7037(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

COD removal from industrial wastewater plants using reverse osmosis membrane

  • Madaeni, S.S. (Membrane Research Center, Department of Chemical Engineering, Razi University) ;
  • Samieirad, S. (Membrane Research Center, Department of Chemical Engineering, Razi University)
  • 투고 : 2010.01.11
  • 심사 : 2010.06.17
  • 발행 : 2010.10.25
⟨ 이전 논문 다음 논문 ⟩

초록

Treatment and reuse of industrial wastewater is becoming a major goal due to water scarcity. This may be carried out using membrane separation technology in general and reverse osmosis (RO) in particular. In the current study, polyamide (FT-30) membrane was employed for treatment of wastewater obtained from Faraman industrial zone based in Kermanshah (Iran). The effects of operating conditions such as transmembrane pressure, cross flow velocity, temperature and time on water flux and rejection of impurities including COD by the membrane were elucidated. The aim was an improvement in membrane performance. The results indicate that most of the chemical substances are removed from the wastewater. In particular COD removal was increased from 64 to around 100% as temperature increased from 15 to $45^{\circ}C$. The complete COD removal was obtained at transmembrane pressure of 20 bars and cross flow velocity of 1.5 m/s. The treated wastewater may be reused for various applications including makeup water for cooling towers.

키워드

참고문헌

  1. Ahmad, A.L., Ismail, S. and Bhatia, S. (2005), "Ultrafiltration behavior in the treatment of agro Industry effluent: Pilot scale studies", Chem. Eng. Sci., 60(3), 5385-5394. https://doi.org/10.1016/j.ces.2005.04.021
  2. Bes-Pia, A., Mendoza-Roca, J.A., Alcaina-Miranda, M.I. and Iborra-Clar, A. (2002), "Reuse of wastewater of the textile industry after its treatment with a combination of physico chemical treatment and membrane technologies", Desalination, 149, 169-174. https://doi.org/10.1016/S0011-9164(02)00750-6
  3. Bhattacharjee, S., Datta, S. and Bhattacharjee, C. (2006), "Performance study during ultrafiltration of Kraft black liquor using rotating disk membrane module", J. Clean. Prod., 14, 497-504. https://doi.org/10.1016/j.jclepro.2005.02.004
  4. Bodalo-Santoyo, A., Gomez-Carrasco, J.L., Gomez, E. and Hidalgo-Montesinos, A.M. (2004), "Spiral wound membrane reverse osmosis and the treatment of industrial effluents", Desalination, 160(3), 151-158. https://doi.org/10.1016/S0011-9164(04)90005-7
  5. Cowan, J.A.C., MacTavish, F., Brouckaert, C.J. and Jacobs, E.P. (1992), "Membrane treatment strategies for red meat abattoir effluents", Water Sci. Technol., 25(10), 137.
  6. Cuda, P., Pospisil, P. and Tenglerova, J. (2006), "Reverse osmosis in water treatment for boilers", Desalination, 198, 41-46. https://doi.org/10.1016/j.desal.2006.09.007
  7. Das, C. and Gupta, S. (2007), "Treatment of soaking effluent from a tannery using membrane separation processes", Desalination, 216(1), 160-173. https://doi.org/10.1016/j.desal.2007.01.006
  8. Dean Spatz, D. (1991), Osmonics pure water handbook, Minnetonka, USA.
  9. Galambos, I., Molina, J., Jaray, P., Vatai, G. and Bekassy, E. (2004), "High organic content industrial wastewater treatment by membrane filtration", Desalination, 162, 117-120. https://doi.org/10.1016/S0011-9164(04)00034-7
  10. Ghabris, A., Abdel-Jawad, M. and Aly, J. (1989), "Municipal wastewater renovation by reverse osmosis", Desalination, 75, 213-218. https://doi.org/10.1016/0011-9164(89)85015-5
  11. Hussain, A.A., Nataraj, S.K., Abashar, M.E.E., Al-Mutaz, I.S. and Aminabhavi, T.M. (2008), "Prediction of physical properties of nanofiltration membranes using experiment and theoretical models", J. Membrane Sci., 310, 321-336. https://doi.org/10.1016/j.memsci.2007.11.005
  12. Lee, J.W., Kwon, T.O. and Moon, I.S. (2005), "Performance of polyamide reverse osmosis membranes for steel wastewater reuse", Desalination, 177, 69-82. https://doi.org/10.1016/j.desal.2004.10.033
  13. Lobo, A., Cambiella, A., Manuel Benito, J. and Pazos, C. (2006), "Ultrafiltration of oil in water emulsions with ceramic membranes: Influence of pH and cross flow velocity", J. Membrane Sci., 278, 328-334. https://doi.org/10.1016/j.memsci.2005.11.016
  14. Lynch, S., Smith, J., Rando, L. and Yauger, W. (1984), Isolation or concentration of organic substances from water an evaluation of reverse osmosis concentration, Report EPA-600 /1-84-018, US Environmental Protection Agency.
  15. Madaeni, S.S. and Mansourpanah, Y. (2003), "COD removal from concentrated wastewater using membranes", Filtr. Separat., 40(1), 40-46. https://doi.org/10.1016/S0015-1882(03)00038-7
  16. Madaeni, S.S., Tahmasebi, K. and Kerendi, S.H. (2004), "Sugar syrup concentration using reverse osmosis membranes", Eng. Life Sci., 4(2), 178-190.
  17. Mohammadi, T. and Esmaeelifar, A. (2004), "Wastewater treatment using ultrafiltration at a vegetable oil factory", Desalination, 166, 329-337. https://doi.org/10.1016/j.desal.2004.06.087
  18. Nataraj, K.S., Hosamani, K.M. and Aminabhavi, T.M. (2006a), "Distillery waste water treatment by the membrane based nanofiltration and reverse osmosis processes", Water Res., 40(10), 2349-2356. https://doi.org/10.1016/j.watres.2006.04.022
  19. Nataraj, S.K., Hosamani, K.M. and Aminabhavi, T.M. (2006b), "Electrodialytic removal of nitrate and hardness of simulated mixtures using ion-exchange membranes", J. Appl. Polym. Sci., 99, 1788-1794 https://doi.org/10.1002/app.22710
  20. Nataraj, S.K., Hosamani, K.M. and Aminabhavi, T.M. (2007a), "Potential application of electrodialytic pilot plant containing ion exchange membrane in chromium removal", Desalination, 217, 181-190. https://doi.org/10.1016/j.desal.2007.02.012
  21. Nataraj, S.K., Sridhar, S., Shaikha, I.N., Reddy, D.S. and Aminabhavi, T.M. (2007b), "Membrane-based microfiltration/electrodialysis hybrid process for the treatment of paper industry wastewater", Sep. Purif. Tech., 57, 185-192. https://doi.org/10.1016/j.seppur.2007.03.014
  22. Pusch, W., Yu, Y. and Zheng, L. (1989), "Solute-solute and solute membrane interactions in hyperfiltration of binary and ternary aqueous organic feed solutions", Desalination, 75, 3-14 https://doi.org/10.1016/0011-9164(89)85001-5
  23. Saffaj, N., Alami Younssi, S., Albizane, A., Messouadi, A., Bouhri, M. and Persin, M. (2004), "Preparation and characterization of ultrafiltration membranes for toxic removal from waste water", Desalination, 168, 259-263. https://doi.org/10.1016/j.desal.2004.07.006
  24. Siler, J. and Bhattacharyya, D. (1985), "Low pressure reverse osmosis membrane: concentration and treatment of hazardous wastes", Waste Hazard. Matter, 2, 45-65. https://doi.org/10.1089/hwm.1985.2.45
  25. Sostar-Turk, S., Petrini , I. and Simoni , M. (2005), "Laundry wastewater treatment using coagulation and membrane filtration", Resour. Conserv. Recy., 44(3), 185-196. https://doi.org/10.1016/j.resconrec.2004.11.002
  26. Stephenson, T., Judd, S. and Jefferson, B. (2000), Membrane bioreactor for wastewater treatment, IWA Publishing, London.
  27. Williams, M., Deshmukh, R. and Bhattacharyya, D. (1990), "Separation of hazardous organics by reverse osmosis membranes", Environ. Prog., 9, 118-125. https://doi.org/10.1002/ep.670090220

피인용 문헌

  1. Effect of coagulation conditions on ultrafiltration for wastewater effluent vol.8, pp.2, 2010, https://doi.org/10.12989/mwt.2017.8.2.185
  2. Microwave- vs Ultrasonic-synthesisof magnetic Moringa oleifera coagulant for the reduction of chemical oxygen demand in palm oil wastewater vol.24, pp.None, 2021, https://doi.org/10.1016/j.eti.2021.102069