Membrane and Water Treatment

  • 제1권1호
  • /
  • Pages.1-12
  • /
  • 2010
  • /
  • 2005-8624(pISSN)
  • /
  • 2092-7037(eISSN)
테크노프레스 (Techno-Press)
권호 표지
DOI QR코드

DOI QR Code

Application of membrane distillation process for tap water purification

  • Gryta, Marek (West Pomeranian University of Technology, Szczecin Institute of Chemical Technology and Environment Engineering)
  • 투고 : 2009.03.18
  • 심사 : 2009.06.16
  • 발행 : 2010.01.25
⟨ 이전 논문 다음 논문 ⟩

초록

Membrane distillation process was used for purification of pre-treated natural water (tap water). The rejection of inorganic and organic compounds in this process was investigated. The obtained rejection of inorganic solutes was closed to 100%, but the volatile organic compounds (VOCs) diffused through the membrane together with water vapour. The content of trihalomethanes (THMs) in the obtained distillate was two-three fold higher than that in the feed, therefore, the rejection of the total organic compounds present in the tap water was reduced to a level of 98%. The intensive membranes scaling was observed during the water separation. The morphology and composition of the fouling layer was studied using scanning electron microscopy coupled with energy dispersion spectrometry. The influence of thermal water pre-treatment performed in a heat exchanger followed by filtration on the MD process effectiveness was evaluated. This procedure caused that significantly smaller amounts of $CaCO_3$ crystallites were deposited on the membrane surface, and a high permeate flux was maintained over a period of 160 h.

키워드

참고문헌

  1. Abu Al-Rub, F.A., Banat, F. and Beni-Melhim, K. (2002), "Parametric sensitivity analysis of direct-contact membrane distillation", Sep. Sci. Technol., 373, 3245-3271.
  2. Alklaibi, A.M. and Lior, N. (2004), "Membrane-distillation desalination: status and potential", Desalination, 171, 111-131.
  3. Bonyadi, S. and Chung, T.S. (2007), "Flux enhancement in membrane distillation by fabrication of dual layer hydrophilic-hydrophobic hollow fiber membranes", J. Membrane Sci., 306, 134-146. https://doi.org/10.1016/j.memsci.2007.08.034
  4. Drioli, E., Curcio, E., Criscuoli, A. and Di Profio, G. (2004), "Integrated system for recovery of $CaCO_{3}$, NaCl, $MgSO_{4}$ $7H_{2}O$ from nanofiltration retentate", J. Membrane Sci., 239, 27-38. https://doi.org/10.1016/j.memsci.2003.09.028
  5. El-Bourawi, M.S., Ding, Z., Ma, R. and Khayet, M. (2006), "A framework for better understanding membrane distillation separation process", J. Membrane Sci., 285, 4-29. https://doi.org/10.1016/j.memsci.2006.08.002
  6. Gryta, M., Tomaszewska, M., Morawski, A.W. and Grzechulska, J. (2001), "Membrane distillation of NaCl solution containing natural organic matter", J. Membrane Sci., 181, 279-287. https://doi.org/10.1016/S0376-7388(00)00582-2
  7. Gryta, M. (2005), "Osmotic MD and other membrane distillation variants", J. Membrane Sci., 246, 145-156. https://doi.org/10.1016/j.memsci.2004.07.029
  8. Gryta, M. (2005), "Long-term performance of membrane distillation process", J. Membrane Sci., 265, 153-159. https://doi.org/10.1016/j.memsci.2005.04.049
  9. Gryta, M., Tomaszewska, M. and Karakulski, K. (2006), "Wastewater treatment by membrane distillation", Desalination, 198, 67-73. https://doi.org/10.1016/j.desal.2006.09.010
  10. Gryta, M. (2007), "Influence of polypropylene membrane surface porosity on the performance of membrane distillation process", J. Membrane Sci., 287, 67-78. https://doi.org/10.1016/j.memsci.2006.10.011
  11. Gryta, M. (2008a), "Fouling in direct contact membrane distillation", J. Membrane Sci., 325, 383-394. https://doi.org/10.1016/j.memsci.2008.08.001
  12. Gryta, M. (2008b), "Alkaline scaling in the membrane distillation process", Desalination, 228, 128-134. https://doi.org/10.1016/j.desal.2007.10.004
  13. Gryta, M. (2008c), "Chemical pretreatment of feed water for membrane distillation", Chem. Pap., 62(1), 100- 105. https://doi.org/10.2478/s11696-007-0085-5
  14. Gryta, M. (2009), "$CaSO_{4}$ scaling in membrane distillation process", Chem. Pap., 63(2), 146-151. https://doi.org/10.2478/s11696-008-0095-y
  15. Hsu, S.T., Cheng, K.T. and Chiou, J.S. (2002), "Seawater desalination by direct contact membrane distillation", Desalination, 143, 279-287. https://doi.org/10.1016/S0011-9164(02)00266-7
  16. Karakulski, K., Gryta, M. and Morawski, A. (2002), "Membrane processes used for potable water quality improvement", Desalination, 145, 315-319. https://doi.org/10.1016/S0011-9164(02)00429-0
  17. Karakulski, K. and Gryta, M. (2005), "Water demineralisation by NF/MD integrated processes", Desalination, 177, 109-119. https://doi.org/10.1016/j.desal.2004.11.018
  18. Karakulski, K., Gryta, M. and Sasim, M. (2006), "Production of process water using integrated membrane processes", Chem. Pap., 60(6), 416-421. https://doi.org/10.2478/s11696-006-0076-y
  19. Karakulski, K., Gryta, M. and Morawski, A.W. (2009), "Membrane processes used for separation of effluents from wire productions", Chem. Pap., 63(2), 205-211. https://doi.org/10.2478/s11696-009-0006-x
  20. Lawson, K.W. and Lloyd, D.R. (1997), "Membrane distillation", J. Membrane Sci., 124, 1-25. https://doi.org/10.1016/S0376-7388(96)00236-0
  21. Li, B. and Sirkar, K.K. (2004), "Novel membrane and device for direct contact membrane distillation-based desalination process", Ind. Eng. Chem. Res., 43, 5300-5309. https://doi.org/10.1021/ie030871s
  22. Martinez-Diez, L. and Florido-Diaz, F.J. (2001), "Desalination of brines by membrane distillation", Desalination, 137, 267-273. https://doi.org/10.1016/S0011-9164(01)00228-4
  23. Singh, R. (2006), Hybrid membrane systems for water purification, Elsevier, Oxford.
  24. Song, L., Li, B., Sirkar, K.K. and Gilron, J. (2007), "Direct contact membrane distillation - based desalination: novel membranes, devices, large-scale studies, and a model", Ind. Eng. Chem. Res., 46, 2307-2323. https://doi.org/10.1021/ie0609968
  25. Srisurichan, S., Jiraratananon, R. and Fane, A.G. (2005), "Humic acid fouling in the membrane distillation", Desalination, 174, 63-72. https://doi.org/10.1016/j.desal.2004.09.003
  26. Teoh, M.M., Bonyadi, S. and Chung, T.S. (2008), "Investigation of different hollow fiber module designs or flux enhancement in the membrane distillation process", J. Membrane Sci., 311, 371-379. https://doi.org/10.1016/j.memsci.2007.12.054
  27. Tun, C.M., Fane, A.G., Matheickal, J.T. and Sheikholeslami, R. (2005), "Membrane distillation crystallization of concentrated salts-flux and crystal formation", J. Membrane Sci., 257, 144-155. https://doi.org/10.1016/j.memsci.2004.09.051
  28. Viessman, W. and Hammer, M.J. (2005), Water supply and pollution control, Person Education, New Jersey.
  29. Wang, K.Y., Chung, T.S. and Gryta, M. (2008), "Modified single layer PVDF hollow fiber membrane for desalination through membrane distillation process", Chem. Eng. Sci., 63, 2587-2589. https://doi.org/10.1016/j.ces.2008.02.020

피인용 문헌

  1. Review of membrane distillation process for water purification vol.57, pp.7, 2016, https://doi.org/10.1080/19443994.2014.985728
  2. Emerging membrane technologies developed in NUS for water reuse and desalination applications: membrane distillation and forward osmosis vol.2, pp.1, 2011, https://doi.org/10.12989/mwt.2011.2.1.001
  3. Theoretical and experimental analysis of multi-effect air gap membrane distillation process (ME-AGMD) vol.3, pp.3, 2015, https://doi.org/10.1016/j.jece.2015.07.017
  4. A critical review of membrane crystallization for the purification of water and recovery of minerals vol.15, pp.3, 2016, https://doi.org/10.1007/s11157-016-9403-0
  5. Preparation and characterization of PVDF/TiO2composite ultrafiltration membranes using mixed solvents vol.7, pp.5, 2016, https://doi.org/10.12989/mwt.2016.7.5.377
  6. Reverse Osmosis and Membrane Distillation for Desalination of Groundwater: A Review vol.2011, 2011, https://doi.org/10.5402/2011/523124
  7. Fouling and its control in membrane distillation—A review vol.475, 2015, https://doi.org/10.1016/j.memsci.2014.09.042
  8. Advances in Membrane Distillation for Water Desalination and Purification Applications vol.5, pp.4, 2013, https://doi.org/10.3390/w5010094
  9. Performance evaluation of hollow fiber air gap membrane distillation module with multiple cooling channels vol.385, 2016, https://doi.org/10.1016/j.desal.2016.01.005
  10. Recovery and development of correlations for heat and mass transfer in vacuum membrane distillation for desalination vol.57, pp.55, 2016, https://doi.org/10.1080/19443994.2016.1189245
  11. Status of membrane distillation for water and wastewater treatment—A review vol.52, pp.28-30, 2014, https://doi.org/10.1080/19443994.2013.808422
  12. Heat and mass transfer analysis in air gap membrane distillation process for desalination vol.2, pp.3, 2010, https://doi.org/10.12989/mwt.2011.2.3.159
  13. Empirical modelling of chemically enhanced backwash during ultrafiltration process vol.2, pp.4, 2010, https://doi.org/10.12989/mwt.2011.2.4.225
  14. Evaluation of the efficiency of cleaning method in direct contact membrane distillation of digested livestock wastewater vol.8, pp.2, 2017, https://doi.org/10.12989/mwt.2017.8.2.113
  15. Study on the heat and mass transfer in ultrasonic assisting vacuum membrane distillation vol.8, pp.3, 2010, https://doi.org/10.12989/mwt.2017.8.3.293
  16. Multi- effect air gap membrane distillation process for pesticide wastewater treatment vol.8, pp.6, 2017, https://doi.org/10.12989/mwt.2017.8.6.529
  17. fMWNTs/GO/MnO2 nanocomposites as additives in a membrane for the removal of crystal violet vol.12, pp.5, 2021, https://doi.org/10.12989/mwt.2021.12.5.205
  18. Modeling of the flow inside a pore in vacuum membrane distillation vol.6, pp.3, 2010, https://doi.org/10.1007/s41207-021-00275-2