대한기계학회논문집B (Transactions of the Korean Society of Mechanical Engineers B)

  • 제34권2호
  • /
  • Pages.165-171
  • /
  • 2010
  • /
  • 1226-4881(pISSN)
  • /
  • 2288-5324(eISSN)
대한기계학회 (The Korean Society of Mechanical Engineers)
권호 표지
DOI QR코드

DOI QR Code

HCCI 엔진용 산화촉매의 반응특성

Reaction Characteristics of Oxidation Catalysts for HCCI Engine

  • 박성용 (전남대학교 기계시스템공학부) ;
  • 김화남 (전남대학교 기계시스템공학부) ;
  • 최병철 (전남대학교 기계시스템공학부)
  • Park, Sung-Yong (School of Mechanical System Engineering, Chonnam Nat'l Univ.) ;
  • Kim, Hwa-Nam (School of Mechanical System Engineering, Chonnam Nat'l Univ.) ;
  • Choi, Byung-Chul (School of Mechanical System Engineering, Chonnam Nat'l Univ.)
  • 발행 : 2010.02.01
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

HCCI 엔진은 배출가스 중 PM과 NOx 가 저감되나, 일반적으로 상용디젤 엔진보다 HC, CO 가 증가하는 특성을 보인다. 특히 과도한 HC 에서 발생하는 SOF 로 인해 total PM 에 영향을 미친다. 이는 HCCI 엔진에서 DOC 를 통한 HC 저감이 중요하며 HC 의 정화성능이 우수한 OC 의 개발이 필요하다. 실험은 모델가스를 이용하여 2Pt/1Pd 의 충전량이 다른 3 종의 OC(600cpsi cordierite)를 가지고 수행하였다. OC 에서 HC, SV, $H_2O$, $O_2$의 조건을 달리하여 OC 성능특성을 $LOT_{50}$에서 평가하였다. 그 결과 CO 는 $170^{\circ}C$에서 3 종의 촉매 모두 90% 이상의 정화특성을 나타내었고 Pd 가 충전 된 OC 는 열화 된 후 Pt 만충전 된 OC 보다 우수한 내구특성을 나타내었다. Fresh 와 aged 된 OC 에서 SV 의 증가 및 $H_2O$의 반응참여는 $LOT_{50}$성능이 낮아지는 결과를 나타내었다.

The Homogeneous Charge Compression Ignition (HCCI) engine concept allows for both NOx and particulate matter to be reduced simultaneously, and it is a promising way to meet the next environmental challenges. Unfortunately, HCCI combustion often increases CO and HC emissions. The development of oxidation catalyst (OC) requires high conversion efficiency for CO and HC at low temperature. Conventional oxidation catalyst technologies may not be able to convert these emissions because of the saturation of active catalytic sites. The OC used in this study was 600 cpsi cordierite. Three kinds of OC with different amounts of Pt and Pd were used. The influence of the space velocity (SV), $H_2O$ and $O_2$ concentration was also studied. All types of OCs were found to have over 90% CO conversion efficiencies at $170^{\circ}C$. When in the presence of water vapor, CO conversion was increased, but $C_3H_8$ conversion was decreased. The performance of the OC was not influenced by initial the HC concentration. The 2Pt/Pd catalyst was better in terms of thermal aging than the Pt-only catalyst. The $LOT_{50}$ of both fresh and aged OC was increased with increasing SV and with the presence of $H_2O$.

키워드

참고문헌

  1. Kim, D. S., Kim, M. Y. and Lee, C. S., 2005, "Combustion and Emission Characteristics of Partial Homogeneous Charge Compression Ignition Engine," Combustion Science and Technology, Vol.177, pp.107-125. https://doi.org/10.1080/00102200590883778
  2. Christensen, M. and Johansson, B., 2000, "Supercharged Homogeneous Charge Compression Ignition (HCCI) with Exhaust Gas Recirculation and Pilot Fuel," SAE 2000-01-1835.
  3. QU, S. SHI, L. K. and CUI, Y., 2009, "Effect of Dirct In-Cylinder $CO_2$ Injection On HCCI Combustion And Emission Characteristics," International Journal of Automotive Technology, Vol. 10, No. 5, pp. 529−535 https://doi.org/10.1007/s12239-009-0061-x
  4. Bae, C. S., 2003, "Diesel-Fueled HCCI Engines and Alternative Fuel," Journal of the KSAE, Vol. 25, No. 5, pp.10-14.
  5. Arregle, V., Bermúdez, J. R., Serrano, E., Fuentes, 2006, "Procedure for Engine Transient Cycle Emissions Testing in Real Time," Experimental Thermal and Fluid Science, Vol. 30, Issue 5, pp. 485-496. https://doi.org/10.1016/j.expthermflusci.2005.10.002
  6. Olof, E., Bengt, J. Fredrik, A, S., 2000, "Hydrocarbon (HC) Reduction of Exhaust Gases from a Homogeneous Charge Compression Ignition (HCCI) Engine Using Different Catalytic Mesh-Coatings," SAE2000-01-1847
  7. Kim. H. N., Jung. K. S, Choi. B. C. and Lim. M. T., 2008, "Size distributions and number concentrations of particles from the DOC and CDPF," Journal of Mechanical Science and Technology, Vol. 22, 1793-1799. https://doi.org/10.1007/s12206-008-0610-7
  8. Jung, K, S., Kim, H, N. and Sung, Y, H., 2006, "Performance Characteristics of Diesel Oxidation Catalysts Designed for Low Temperature Exhaust Gas of HCCI engines," KSAE06-S0055, pp.340-345.
  9. Jung, K, S., Jeong, J, W, Sung, Y, H., Kim, H, N., 2007, "Conversion Characteristics of Diesel Oxidation Catalysts for HCCI Engines," KSAE07-S0045, pp.294-299.
  10. Park, S, Y., Kim. H. N., Choi. B. C., 2009, "Emission characteristics of exhaust gases and nanoparticles from a diesel engine with biodiesel-diesel blended fuel (BD20)," Journal of Mechanical Science and Technology, Vol. 23, No. 9, pp.2555-2564. https://doi.org/10.1007/s12206-009-0704-x
  11. Son, G. S., 2008, "Characteristics and Technologies of Diesel Oxidation Catalysts for commercial Vehicles," Journal of the KSAE, Vol. 30, Issue 1, pp.44-54.
  12. H. K., 1991, "Performance of Palladium Automotive Catalysts," Toyota Motor Corp., SAE 910842.
  13. Kaspar J., Fornasiero, P., Hickey N., 2003, "Automotive catalytic converters: current status and some perspectives," Catalysis Today, Vol. 77, Issue 4, 15 January, pp.419-449. https://doi.org/10.1016/S0920-5861(02)00384-X
  14. Kim, D, S., Lee, C, S., 2006, "Improved emission characteristics of HCCI engine by various premixed fuels and cooled EGR," Fuel, Vol.85, Issues 5-6, March-April, pp.695-704. https://doi.org/10.1016/j.fuel.2005.08.041
  15. Majewski. W. A., Khair. M. K., "Diesel Emissions and Their Control," SAE international, pp. 367-401.
  16. Shazam. W., Linjie. H, Tohru N., Hiroyuki O., 2008, "Oxidation Catalysts for Natural Gas Engine Operating under HCCI or SI Conditions," SAE 062008-101-0807.