International Journal of Air-Conditioning and Refrigeration

  • 제17권1호
  • /
  • Pages.25-31
  • /
  • 2009
  • /
  • 2010-1325(pISSN)
  • /
  • 2010-1333(eISSN)
대한설비공학회 (The Society of Air-Conditioning and Refrigerating Engineers of Korea)
권호 표지

The Effect of Solution Pressure to the Release in a Supercooled Aqueous Solution

  • Kang, Chae-Dong (Department of Mechanical Engineering, Chonbuk National University) ;
  • Kim, Byung-Seon (Samsung Electronics Co.) ;
  • Hong, Hi-Ki (School of Mechanical and Industrial System Engineering, KyungHee University)
  • 발행 : 2009.03.31
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

Supercooled type ice storage system with aqueous solution (or water) may have trouble with non-uniform release of supercooling even though it contributes to the simplicity of system and ecological improvement. The non-uniform release increases the instability of the system because it may cause an ice blockage in pipe or cooling part. In order to suppress the release of the supercooling, a cooling experiment was tried to an ethylene glycol(EG) 3 mass% solution corresponding with pressurization. Also, the frequency ratio of the release of the supercooling was measured to the pressurization from 101 to 505 kPa. At results, the frequency ratio of supercooling release tends to decrease as the pressure of the aqueous solution increased in each cooling rate. Moreover, it tends to decrease as the cooling rate of the solution decreased in each pressure.

키워드

참고문헌

  1. Tanino, M. Kozawa, Y. Mito, D., Development of active control method for supercooling releasing of water, Proc. Paris Workshop, IIR, 2000, p.127-139
  2. Tanino, M. Iribe, M. Okonogi, T. and Kozawa, Y., Ice-storage system using supercooled water, Trans. JAR, 1995, 12(3) p.275-284.(Japanese)
  3. H. A. C. Thijssen, M. A. G. Vorstman, J. A. Roels, 1968, Heterogeneous primary nucleation of ice in water and aqueous solutions, Journal of Crystal Growth, Vol. 3-4, pp.355-359 https://doi.org/10.1016/0022-0248(68)90174-7
  4. Michelmore, R.W. Franks, F., 1982, Nucleation rates of ice in undercooled water and aqueous solutions of polyethylene glycol, Cryobiology, Vol.19, No.2, pp. 163-171 https://doi.org/10.1016/0011-2240(82)90137-7
  5. Saito, A. Utaka, Y. Okawa, S. Matsuzawa, K. Tamaki, A., 1990, Fundamental research on the supercooling phenomenon on heat transfer surfaces— investigation of an effect of characteristics of surface and cooling rate on a freezing temperature of supercooled water, Int. J. Heat Mass Transfer, Vol.33, No.8, pp. 1697-1709; Okawa, S. Saito, A. and Suto, H., 2002, The experimental study on freezing of supercooled water using metallic surface, Int. J. Refrig., Vol. 25, Iss 5, pp.514-520 https://doi.org/10.1016/S0140-7007(01)00038-X
  6. Okawa, S. Saito, A. and Minami, R., 2001, The solidification phenomenon of the supercooled water containing solid particles, Int. J. Refrig., Vol.24, No.1, pp.108-117 https://doi.org/10.1016/S0140-7007(00)00060-8
  7. Hozumi, T. Saito, A. Okawa, S. Matsui, T., 2002, Freezing phenomena of supercooled water under impacts of ultrasonic waves, Int. J. Refrig., Vol.25, No.7, pp.948-953 https://doi.org/10.1016/S0140-7007(01)00104-9
  8. Zhang, X. Inada, T. Yabe, A. Lu, S. and Kozawa, Y., 2001, Active control of phase change from supercooled water to ice by ultrasonic vibration: 2. Generation of ice slurries and effect of bubble nuclei, Int. J. Heat Mass Transfer, Vol.44, pp.4533-4539 https://doi.org/10.1016/S0017-9310(01)00058-8
  9. Hozumi, T. Saito, A. Okawa, S. and Matsumura, T., 2002, Effect of bubble nuclei in freezing of supercooled water, International Journal of Refrigeration Vol. 25, Iss.2, pp. 243-249 https://doi.org/10.1016/S0140-7007(01)00085-8
  10. This law was proposed in 1803 by W. Henry, 'The amount of a gas absorbed by a liquid is in proportion to the pressure of the gas above the liquid, provided that no chemical action occurs'(in expression of Encyclopedia Britannica)
  11. Lee, D. Kim, B. Peck, J. Hong, H. and Kang, C., 2006, Ice Slurry Formation of a Solution in a Pressurized Plate Heat Exchanger, The Magazine of SAREK, Vol. 18, No. 7, pp. 596-602. (Korean)
  12. Lee, D. Peck, J. Hong, H. Kang, C., 2007, Influence of the supercooling degree and cooling rate on a continuous ice formation by a supercooled aqueous solution in flow using a plate heat exchanger, The Magazine of the SAREK, Vol.19 No.9, pp.647-653 (Korean)
  13. ASHRAE Handbook-Fundamentals, 2007