Journal of Power Electronics

  • 제9권6호
  • /
  • Pages.823-834
  • /
  • 2009
  • /
  • 1598-2092(pISSN)
  • /
  • 2093-4718(eISSN)
전력전자학회 (The Korean Institute of Power Electronics)
권호 표지

A Single-Stage AC/DC Converter with Low Voltage Stresses and Reduced Switching Losses

  • Kim, Kyu-Tae (Dept. of Electronic and Electrical Engineering, Pohang University of Science and Technology) ;
  • Choi, Woo-Young (Dept. of Electronic and Electrical Engineering, Pohang University of Science and Technology) ;
  • Kwon, Jung-Min (Dept. of Electronic and Electrical Engineering, Pohang University of Science and Technology) ;
  • Kwon, Bong-Hwan (Dept. of Electronic and Electrical Engineering, Pohang University of Science and Technology)
  • 발행 : 2009.11.20
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

This paper proposes a high-efficiency single-stage ac/dc converter. The proposed converter features low voltage stresses and reduced switching losses. It operates at the boundary of discontinuous- and continuous-conduction modes by employing variable switching frequency control. The turn-on switching loss of the switch can be reduced by turning it on when the voltage across it is at a minimum. The voltage across the bulk capacitor is independent of the output loads and maintained within the practical range for the universal line input, so the problem of high voltage stress across the bulk capacitor is alleviated. Moreover, the voltage stress of the output diodes is clamped to the output voltage, and the output diodes are turned off at zero-current. Thus, the reverse-recovery related losses of the output diodes are eliminated. The operational principles and circuit analysis are presented. A prototype circuit was built and tested for a 150 W (50V/3A) output power. The experimental results verify the performance of the proposed converter.

키워드

참고문헌

  1. M. K. H. Cheung, M. H. L. Cheung, and C. K. Tse, "Practical design and evaluation of a 1kW PFC power supply based on reduced redundant power processing principle," IEEE Trans. Ind. Electron., Vol. 55, No. 2, pp. 665-673, Feb. 2008 https://doi.org/10.1109/TIE.2007.909078
  2. J. M. Kwon, W. Y. Choi, and B. H. Kwon, "Cost-effective boost converter with reverse-recovery reduction and power factor correction," IEEE Trans. Ind. Electron., Vol. 55, No. 1, pp. 471-473, Jan. 2008 https://doi.org/10.1109/TIE.2007.896526
  3. E. H. Ismail, A. J. Sabzali, and M. A. Al-Saffar, "Buck-boost-type unity power factor rectifier with extended voltage conversion ratio," IEEE Trans. Ind. Electron., Vol. 55, No. 3, pp. 1123-1132, Mar. 2008 https://doi.org/10.1109/TIE.2007.909763
  4. W. Y. Choi, J. M. Kwon, E. H. Kim, J. J. Lee, and B. H. Kwon, "Bridgeless boost rectifier with low conduction losses and reduced diode reverse-recovery problems," IEEE Trans. Ind. Electron., Vol. 54, No. 2, pp. 769-780, Apr. 2007 https://doi.org/10.1109/TIE.2007.891991
  5. W. Y. Choi and B. H. Kwon, "An efficient power-factor correction scheme for plasma display panels," IEEE/OSA J. Display. Technol., Vol. 4, No. 1, pp. 70-80, Mar. 2008 https://doi.org/10.1109/JDT.2007.901557
  6. D. G. Koen, D. M. Van de Sype, A. P. M. Van den Bossche, and J. A. Melkebeek, "Input-current distortion of CCM boost PFC converters operated in DCM," IEEE Trans. Ind. Electron., Vol. 54, No. 2, pp. 858-865, Apr. 2007 https://doi.org/10.1109/TIE.2007.892252
  7. M. H. Todorovic, L. Palma, and P. N. Enjeti, "Design of a wide input range dc-dc converter with a robust power control scheme suitable for fuel cell power conversion," IEEE Trans. Ind. Electron., Vol. 55, No. 3, pp. 1247-1255, Mar. 2008 https://doi.org/10.1109/TIE.2007.911200
  8. J. P. Lee, B. D. Min, T. J. Kim, D. W. Yoo, and J. Y. Yoo, "A novel topology for photovoltaic dc/dc full-bridge converter with flat efficiency under wide PV module voltage and load range," IEEE Trans. Ind. Electron., Vol. 55, No. 7, pp. 2655-2663, Jul. 2008 https://doi.org/10.1109/TIE.2008.924165
  9. A. Khaligh, A. M. Rahimi, and A. Emadi, "Modified pulse-adjustment technique to control dc/dc converters driving variable constant-power loads," IEEE Trans. Ind. Electron., Vol. 55, No. 3, pp. 1133-1146, Mar. 2008 https://doi.org/10.1109/TIE.2007.909757
  10. C. Qiao and K. M. Smedley, "A topology survey of single-stage power factor corrector with a boost type input-current-shaper," IEEE Trans. Power Electron., Vol. 16, No. 3, pp. 360-368, May 2001 https://doi.org/10.1109/63.923768
  11. W. Y. Choi, J. M. Kwon, H. L. Do, and B. H. Kwon, "Single-stage half-bridge converter with high power factor," in Proc. of IEE Power Electron. App., Vol. 152, No. 3, pp. 634-642, May 2005 https://doi.org/10.1049/ip-epa:20045138
  12. M. A. Dalla Costa, J. M. Alonso, J. C. Miranda, J. Garcia, and D. G. Lamar, "A single-stage high-power-factor electronic ballast based on integrated buck flyback converter to supply metal halide lamps," IEEE Trans. Ind. Electron., Vol. 55, No. 3, pp. 1112-1122, Mar. 2008 https://doi.org/10.1109/TIE.2007.909729
  13. C. B. Nascimento and A. J. Perin, "High power factor electronic ballast for fluorescent lamps with reduced input filter and low cost of implementation," IEEE Trans. Ind. Electron., Vol. 55, No. 2, pp. 711-721, Feb. 2008 https://doi.org/10.1109/TIE.2007.908536
  14. J. J. Lee, J. M. Kwon, E. H. Kim, W. Y. Choi, and B. H. Kwon, "Single-stage single-switch PFC flyback converter using a synchronous rectifier," IEEE Trans. Ind. Electron., Vol. 55, No. 3, pp. 1352-1365, Mar. 2008 https://doi.org/10.1109/TIE.2007.911908
  15. Q. Jinrong, Q. Zhao, and F. C. Lee, "Single-stage single-switch power-factor-correction ac/dc converters with dc-bus voltage feedback for universal line applications," IEEE Trans. Power Electron., Vol. 13, No. 6, pp. 1079-1088, Nov. 1998 https://doi.org/10.1109/63.728335
  16. Q. Zhao, F. C. Lee, and F. Tsai, "Voltage and current stress reduction in single-stage power factor correction ac/dc converters with bulk capacitor voltage feedback," IEEE Trans. Power Electron., Vol. 17, No. 4, pp. 477-484, Jul. 2002 https://doi.org/10.1109/TPEL.2002.800997
  17. Q. Zhao, M. Xu, F. C. Lee, and J. Qian, "Single-switch parallel power factor correction ac-dc converters with inherent load current feedback," IEEE Trans. Power Electron., Vol. 19, No. 4, pp. 928-936, Jul. 2004 https://doi.org/10.1109/TPEL.2004.830087
  18. W. Y. Choi, J. M. Kwon, J. J. Lee, H. Y. Jang, and B. H. Kwon, "Single-stage soft-switching converter with boost type of active-clamp for wide input voltage ranges," IEEE Trans. Power Electron., Vol. 24, No. 3, pp. 730-741, Mar. 2009 https://doi.org/10.1109/TPEL.2008.2008307
  19. K. B. Park, C. E. Kim, G. W. Moon, and M. J. Youn, "A new high efficiency PWM single-switch isolated converter," Journal of Power Electronics, Vol. 7, No. 4, pp. 301-309, Oct. 2007
  20. G. Moschopoulos, Y. Liu, and S. Bassan, "Modified Ac-Dc single-stage converters," Journal of Power Electronics, Vol. 7, No. 1, pp. 44-54, Jan. 2007
  21. B. H. Lee, C. E. Kim, K. B. Park, and G. W. Moon, "A new single-stage PFC AC/DC converter with low link-capacitor voltage," Journal of Power Electronics, Vol. 7, No. 4, pp. 328-335, Oct. 2007
  22. G. Moschopoulos and P. Jain, "Single-phase single-stage power-factor-corrected converter topologies," IEEE Trans. Ind. Electron., Vol. 52, No. 1, pp. 23-35, Feb. 2005 https://doi.org/10.1109/TIE.2004.841148
  23. J. Y. Lee, "Single-stage ac/dc converter with input-current dead-zone control for wide input voltage ranges," IEEE Trans. Ind. Electron., Vol. 54, No. 2, pp. 724-732, Apr. 2007 https://doi.org/10.1109/TIE.2007.891765
  24. J. M. Alonso, M. A. Dalla Costa, and C. Ordiz, "Integrated buck-flyback converter as a high-power-factor off-line power supply," IEEE Trans. Ind. Electron., Vol. 55, No. 3, pp. 1090-1100, Mar. 2008 https://doi.org/10.1109/TIE.2007.908530
  25. L. Huber and M. M. Jovanovic, "Design optimization of single-stage single-switch input-current shapers," IEEE Trans. Power Electron., Vol. 15, No. 1, pp. 174-184, Jan. 2000 https://doi.org/10.1109/63.817375
  26. H. E. Tacca, "Power factor correction using merged flyback-forward converters," IEEE Trans. Power Electron., Vol. 15, No. 4, pp. 585-594, Jul. 2000 https://doi.org/10.1109/63.849028
  27. J. M. Kwon, W. Y. Choi, H. L. Do, and B. H. Kwon, "Single-stage half-bridge converter using a coupled- inductor," in Proc. of IEE Power Electron. App., Vol. 152, No. 3, pp. 748-756, May 2005
  28. Y. Panov and M. M. Jovanovic, "Adaptive off-time control for variable-frequency, soft-switched flyback converter at light loads," IEEE Trans. Power Electron., Vol. 17, No. 4, pp. 596-603, Jul. 2002 https://doi.org/10.1109/TPEL.2002.800958