한국축산식품학회지 (Food Science of Animal Resources)

  • 제28권4호
  • /
  • Pages.415-421
  • /
  • 2008
  • /
  • 2636-0772(pISSN)
  • /
  • 2636-0780(eISSN)
한국축산식품학회 (Korean Society for Food Science of Animal Resources)
권호 표지
DOI QR코드

DOI QR Code

초고압 열처리가 가열 돈육의 품질특성에 미치는 효과

Effects of Thermal Processing Combined with High Pressure on the Characteristics of Cooked Pork

  • 홍근표 (건국대학교 축산식품생물공학) ;
  • 심국보 (건국대학교 축산식품생물공학) ;
  • 최미정 (태국 국립과학기술개발연구원) ;
  • 민상기 (건국대학교 축산식품생물공학)
  • Hong, Geun-Pyo (Department of Food Science and Biotechnology of Animal Resources, Konkuk University) ;
  • Shim, Kook-Bo (Department of Food Science and Biotechnology of Animal Resources, Konkuk University) ;
  • Choi, Mi-Jung (National Nanotechnology Center, National Science and Technology Development Agency) ;
  • Min, Sang-Gi (Department of Food Science and Biotechnology of Animal Resources, Konkuk University)
  • 발행 : 2008.10.31
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

This study evaluated the effects of thermal processing combined with high pressure on the properties of cooked pork. Pressurization followed by heating (PFH), heating followed by pressurization (HFP) and heating under pressurization (HUP) treatments were compared to a heated only control. Cooked meat without simultaneous pressurization showed little or no decrease in water binding properties relative to the control, regardless of the sequence of pressurization and heating. However, HUP treated pork had significantly higher water binding properties than the control (p<0.05). The pH values of all treatments were not significantly different with the exception of HUP at 300 MPa. The HUP treated pork showed the best tenderizing effects among all the treatments tested and the effect was more significant at increased pressure levels (p<0.05). In addition, increasing pressure levels significantly increased the L-values of pork (p<0.05). PFH and HFP treated pork had significantly lower a-values (p<0.05), while no significant differences were observed in HUP. HUP treated pork had the lowest b-values at 100 MPa. however, the differences were not significant at increasing pressure levels. These results indicate that heating under pressure is the best cooking condition for improving the quality characteristics of pork without adversely affecting its appearance.

키워드

참고문헌

  1. Balny, C. and Masson, P. (1993) Effects of high pressure on proteins. Food Rev. Int. 9, 611-628 https://doi.org/10.1080/87559129309540980
  2. Boonyaratanakornkit, B. B., Park, D. S., and Clark, D. S. (2002) Pressure effects on intra- and intermolecular interactions within proteins. Biochim. Biophys. Acta. 1595, 235-249 https://doi.org/10.1016/S0167-4838(01)00347-8
  3. Bouton, P. E., Ford, A. L., Harris, P. V., Macfarlane, J. J., and Oshea, J. M. (1977a) Pressure-heat treatment of postrigor muscle: Effects on tenderness. J. Food Sci. 42, 132-135 https://doi.org/10.1111/j.1365-2621.1977.tb01235.x
  4. Bouton, P. E., Ford, A. L., Harris, P. V., Macfarlane, J. J., and Oshea, J. M. (1977b) Pressure-heat treatment of post-rigor muscle: objective-subjective measurements. J. Food Sci. 42, 857-859, 865 https://doi.org/10.1111/j.1365-2621.1977.tb12623.x
  5. Bouton, P. E., Harris, P. V., Macfarlane, J. J., and Óshea, J. M. (1978) Pressure-heat treatment of meat: Effect on connective tissue. J. Food Sci. 43, 301-303, 326 https://doi.org/10.1111/j.1365-2621.1978.tb02290.x
  6. Carballo, J., Cofrades, S., Fernández-Martín, F., and Jiménez- Colmenero, F. (2001) Pressure-assisted gelation of chemically modified poultry meat batters. Food Chem. 75, 203-209 https://doi.org/10.1016/S0308-8146(01)00199-6
  7. Cheftel. J. C. (1995) Review: high pressure, microbial inactivation and food preservation. Food Sci. Technol. Int. 1, 75-90 https://doi.org/10.1177/108201329500100203
  8. Cheftel, J. C. and Culioli, J. (1997) Effects of high pressure on meat: A review. Meat Sci. 46, 211-236 https://doi.org/10.1016/S0309-1740(97)00017-X
  9. Heremans, R. and Smeller, L. (1998) Protein structure and dynamics at high pressure. Biochim. Biophys. Acta. 1386, 353-370 https://doi.org/10.1016/S0167-4838(98)00102-2
  10. Hong, G. P., Ko, S. H., Choi, M. J., and Min, S. G. (2007) Effects of pressure assisted freezing on physicochemical properties of pork. Korean J. Food Sci. Ani. Resour. 27, 190-196 https://doi.org/10.5851/kosfa.2007.27.2.190
  11. Hong, G. P., Lee, S., and Min, S. G. (2003) Studies on physico- chemical properties of spreadable liver sausage during storage period. Korean J. Food Sci. Ani. Resour. 23, 56-62
  12. Hong, G. P., Park, S. H., Kim, J. Y., Lee, S. K., and Min, S. G. (2005) Effects of time-dependent high pressure treatment on physico-chemical properties of pork. Food Sci. Biotechnol. 14, 808-812
  13. Horgan, D. J. (1979) ATPase activities of sarcoplasmic reticulum isolated from rabbit and bovine muscle subjected to pre-rigor pressure treatment. J. Food Sci. 44, 492-500 https://doi.org/10.1111/j.1365-2621.1979.tb03819.x
  14. Knorr, D., Heinz, V., and Buckow, R. (2006) High pressure application for food biopolymers. Biochim. Biophys. Acta. 1764, 619-631 https://doi.org/10.1016/j.bbapap.2006.01.017
  15. Knorr, D., Schlueter, O., and Heinz, V. (1998) Impact of high hydrostatic pressure on phase transitions of foods. Food Technol. 52, 42-45
  16. Ko, S. H., Hong, G. P., Park, S. H., Choi, M. J., and Min, S. G. (2006) Studies on physical properties of pork frozen by various high pressure freezing process. Korean J. Food Sci. Ani. Resour. 26, 464-470
  17. Koohmaraie, M., Kennick, W. H., Elgasim, E. A., and Anglemier, A. F. (1984) Effect of prerigor pressurization on the activity of calcium-activated factor. J. Food Sci. 49, 680-684 https://doi.org/10.1111/j.1365-2621.1984.tb13187.x
  18. Locker, R. H. and Wild, D. J. C. (1984) Tenderisation of meat by pressure-heat involves weakening of the gap filaments in the myofibril. Meat Sci. 10, 207-233 https://doi.org/10.1016/0309-1740(84)90023-8
  19. Ma, H. J. and Ledward, D. A. (2004) High pressure/thermal treatment effects on the texture of beef muscle. Meat Sci. 68, 347-355 https://doi.org/10.1016/j.meatsci.2004.04.001
  20. Macfarlane, J. J. (1973) Pre-rigor pressurization of muscle: effects on pH, shear value and taste panel assessment. J. Food Sci. 38, 294-298 https://doi.org/10.1111/j.1365-2621.1973.tb01409.x
  21. Macfarlane, J. J. (1985) High pressure technology and meat quality. In: Developments in meat science. Lawrie, R. (ed), Elsevier, Inc., NY, Vol. 3, pp. 155-184
  22. Macfarlane, J. J., McKenzie, I. J., Turner, R. H., and Jones, P. N. (1981) Pressure treatment of meat: Effects on thermal transitions and shear values. Meat Sci. 5, 307-317 https://doi.org/10.1016/0309-1740(81)90020-6
  23. Priev, A., Almagor, A., Yedgar, S., and Gavish, B. (1996) Glycerol decreases the volume and compressibility of protein interior. Biochemistry 35, 2061-2066 https://doi.org/10.1021/bi951842r
  24. Saad-Nehme, J., Silva, J. L., and Meyer-Fernandes, J. R. (2002) Osmolytes protect mitochondrial $F_0F_1$-ATPase complex against pressure inactivation. Biochim. Biophys. Acta. 1546, 164-170
  25. Smeller, L. (2002) Pressure-temperature phase diagram of biomolecules. Biochim. Biophys. Acta. 1595, 11-29 https://doi.org/10.1016/S0167-4838(01)00332-6
  26. Suzuki, A., Homma, Y., Kim, K., Ikeuchi, Y., Sugiyama, T., and Saito, M. (2001) Pressure-induced changes in the connectin/ titin localization in the myofibrils revealed by immunoelectron microscopy. Meat Sci. 59, 193-197 https://doi.org/10.1016/S0309-1740(01)00070-5
  27. Suzuki, A., Kim, K., and Ikeuchi, Y. (1996) Understanding the pressure effects on postmortem muscle. In: High pressure bioscience and biotechnology. Hayashi, R. and Balny, C. (eds), Elsevier, Inc., Japan, Vol. 13, pp. 289-298
  28. Suzuki, A., Watanabe, M., and Ikeuchi, Y. (1993) Effects of high-pressure treatment on the ultrastructure and thermal behaviour of beef intramuscular collagen. Meat Sci. 35, 17-25 https://doi.org/10.1016/0309-1740(93)90067-R
  29. Thawatchai, S. and Apichartsrangkoon, A. (2007) Combination effects of ultra-high pressure and temperature on the physical and thermal properties of ostrich meat sausage (yor). Meat Sci. 76, 555-560 https://doi.org/10.1016/j.meatsci.2007.01.007
  30. Ueno, Y., Ikeuchi, Y., and Suzuki, A. (1999) Effects of high pressure treatments on intramuscular connective tissue. Meat Sci. 52, 143-150 https://doi.org/10.1016/S0309-1740(98)00161-2

피인용 문헌

  1. Systematic review of emerging and innovative technologies for meat tenderisation vol.132, 2017, https://doi.org/10.1016/j.meatsci.2017.04.241
  2. A meta-analysis of the effects of shockwave and high pressure processing on color and cook loss of fresh meat vol.132, 2017, https://doi.org/10.1016/j.meatsci.2017.04.016
  3. Effects of Immersion Liquids Containing Citrus junos and Prunus mume Concentrate and High Hydrostatic Pressure on Shelf-life and Quality of Scomber japonicus during Refrigerated Storage vol.43, pp.10, 2014, https://doi.org/10.3746/jkfn.2014.43.10.1555
  4. Application of a Kiwifruit (Actinidia chinensis) to Improve the Textural Quality on Beef Bulgogi Treated with Hydrostatic Pressure vol.29, pp.3, 2009, https://doi.org/10.5851/kosfa.2009.29.3.317
  5. Quality Improvement of Galbijjim Using Superheated Steam and High Hydrostatic Pressure vol.43, pp.9, 2014, https://doi.org/10.3746/jkfn.2014.43.9.1423
  6. High pressure/thermal combinations on texture and water holding capacity of chicken batters vol.30, 2015, https://doi.org/10.1016/j.ifset.2015.06.002
  7. Inhibitory Effect of High Hydrostatic Pressure Treatments on Histamine Production in Mackerel Scomber japonicus vol.46, pp.6, 2013, https://doi.org/10.5657/KFAS.2013.0733
  8. A meta-analysis of the effect of high pressure processing on four quality traits of fresh pork pp.01458892, 2019, https://doi.org/10.1111/jfpp.13895
  9. 침지액 및 초정수압의 병행처리에 의한 고등어(Scomber japonicus)의 물리화학적 품질 특성 변화 vol.44, pp.2, 2008, https://doi.org/10.4014/mbl.1512.12001
  10. Effects of different thawing methods on physicochemical properties and structure of largemouth bass ( Micropterus salmoides ) vol.85, pp.3, 2020, https://doi.org/10.1111/1750-3841.15029
  11. Effects of different thawing methods on conformation and oxidation of myofibrillar protein from largemouth bass(Micropterus salmoides) vol.85, pp.8, 2008, https://doi.org/10.1111/1750-3841.15336