Journal of Advanced Marine Engineering and Technology

  • 제31권2호
  • /
  • Pages.145-151
  • /
  • 2007
  • /
  • 2234-7925(pISSN)
  • /
  • 2234-8352(eISSN)
한국마린엔지니어링학회 (The Korean Society of Marine Engineering)
권호 표지
DOI QR코드

DOI QR Code

4.57 mm 세관 열교환기 내 이산화탄소의 증발열전달 특성

Evaporation Heat Transfer Characteristics of Carbon Dioxide in the Inner Diameter Tube of 4.57 mm

  • 구학근 (동명대학교 환경설비공학과)
  • 발행 : 2007.03.31
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

The evaporation heat transfer coefficient of $CO_2$(R-744) in a horizontal tube was investigated experimentally. The main components or the refrigerant loop are a receiver, a variable-speed pump, a mass flow meter, a pre-heater and evaporator(test section). The test section consists of a smooth, horizontal stainless steel tube of inner diameter of 4.57 mm. The experiments were conducted at mass flux of 200 to $500\;kg/m^2s$, saturation temperature of -5 to $5^{\circ}C$, and heat flux of 10 to $40\;kW/m^2$. The test results showed the heat transfer of $CO_2$ has a greater effect on nucleate boiling more than convective boiling. Mass flux of $CO_2$ does not effect nucleate boiling too much. In comparison with test results and existing correlations, the best fit of the present experimental data is obtained with the correlation of Jung et al. But existing correlations failed to predict the evaporation heat transfer coefficient of $CO_2$, therefore, it is necessary to develope reliable and accurate predictions determining the evaporation heat transfer coefficient of $CO_2$ in a horizontal tube.

키워드

참고문헌

  1. S. H. Yoon, 'Studies on the characterist ics of evaporation and supercritical gas cooling heat transfer of carbon dioxide', Seoul National University, School of Mechanical and Aerospace Engineering, Thesis for the Degree of Doctor of Philosophy, 2002
  2. L. Yun, Y. C. Kim and M. S. Kim, 'Two-phase flow patterns of $CO_2$ in a narrow rectangular channel', International Congress of Refrigeration 2003, Washington D. C., pp. 1-7, 2003
  3. Z. Yuan, M, Michael and D. Jafer, 'Forced Convection Boiling Heat Transfer of $CO_2$ in Horizontal Tubes', Xth ASME/JSME Joint Thermal Engineering Conference, 1999
  4. E. Hihara and S, Tanaka,'Boiling Heat Transfer of Carbon dioxide in Horizontal Tubes', Proc. 4th IIR-Gustav Lorentzen Conf. On atural Working Fluids, Purdue University, USA, pp. 279-284, 2000
  5. 윤백, 박현연, 유국철, 김용찬, '관순법을 이용한 공조기 사이클 시뮬레이션', 대한설비공학회, 제11권, 제4호, pp. 499-510, 1999
  6. J. Y. Choi, A. M. Kedzierski and A. P. Domanski, 'A Generalized pressure drop correlation for evaporation and condensation of alternative refrigerants in smooth tube and micro-fin tube', NISTIR 6333, pp. 7-15, 1999
  7. Y. Zhao, M. M. Ohadi, S. V. Dessiatoun, M. Molki and J. Darabi, 'Forced convection boiling heat transfer of $CO_2$ in horizontal tube', in : AJTE99-6249, Proc. 5th ASME/JSME Joint Thermal Engineering Conference, San Diego, California, 1999
  8. C. C. Son, D. H. Kim, S. M. Choi, Y. R. Kim and H. K. Hoo, 'Evaporation heat transfer characteristics of $CO_2$ in a horizontal tube', International Journal of Air-Conditioning and Refrigeration, Vol. 13, No. 4, pp. 167-174, 2005
  9. M. G. Cooper, 'Heat Flow Rates in Saturated Nucleate Pool Boiling a Wide-ranging Examination Using Reduced Properties', Advances in Heat Transfer, Vol. 16, pp. 157-239, 1984 https://doi.org/10.1016/S0065-2717(08)70205-3
  10. M. M. Shah, 'A general correlation for heat transfer during film condensation inside pipes', International Journal of Heat and Mass Transfer, Vol. 22, pp. 157-165, 1979 https://doi.org/10.1016/0017-9310(79)90108-X
  11. K. E. Gungor and R. H. S. Winterton, 'Simplified General Correlation for Flow Saturated Boiling and Comparisons of Correlations with Data', Chem. Eng. Res, Des., Vol. 65, pp. 148-156, 1987
  12. Kandlikar, S. G., 'A general correlation for saturated two-phase flow boiling horizontal and vertical tubes', Trans. ASME, Vol. 112, pp. 219-228, 1990 https://doi.org/10.1115/1.2910348
  13. D. S. Jung, M. Mclinden, R. Radermacher and D. Didion, 1989, 'A Study of Flow Boiling Heat Transfer with Refrigerant Mixtures', International Journal of Heat and Mass Transfer, Vol. 32, No. 9, pp. 1751-1764, 1989 https://doi.org/10.1016/0017-9310(89)90057-4
  14. Z. Liu and R. H. S. Winterton, 'A General Correlation for Saturated and Sub cooled Flow Boiling in Tubes and Annuli, Based on a Nucleate Pool Boiling Equation', International Journal of Heat and Mass Transfer, Vol. 34, No. 1, pp. 2759-2766, 1991 https://doi.org/10.1016/0017-9310(91)90234-6