대한인간공학회지 (Journal of the Ergonomics Society of Korea)

  • 제26권2호
  • /
  • Pages.157-165
  • /
  • 2007
  • /
  • 1229-1684(pISSN)
  • /
  • 2093-8462(eISSN)
대한인간공학회 (Ergonomics Society of Korea)
권호 표지
DOI QR코드

DOI QR Code

다탄성 Insole의 Workload 감소 효과에 관한 연구

The Study on Workload Reducing Effects of Multi-Elastic Insoles

  • 이창민 (동의대학교 산업경영공학과) ;
  • 이경득 (부산신발산업진흥센터) ;
  • 오연주 (동의대학교 산업경영공학과) ;
  • 김진훈 (동의대학교 산업경영공학과)
  • Lee, Chang-Min (Department of Industrial and Management Engineering, Dongeui University) ;
  • Lee, Kyun-Deuk (Busan Footwear Industrial Promotion Center) ;
  • Oh, Yeon-Ju (Department of Industrial and Management Engineering, Dongeui University) ;
  • Kim, Jin-Hoon (Department of Industrial and Management Engineering, Dongeui University)
  • 발행 : 2007.05.31
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

The Work-Related Musculoskeletal Disorders (WMSDs) can be occurred by various factors such as repetition, forceful exertions and awkward postures. Especially, occurrences of the WMSDs on the waist and lower limb are reported in workplaces, demanded standing postures for a long time, in service and manufacturing industry. The static and standing postures without movement for a long time increase work loads to the lower limb and the waist. Accordingly, anti-fatigue mat or anti-fatigue insole is used as a preventing device of the WMSDs. However anti-fatigue mats are limited in space and movement. In this study, multi-elastic insoles are designed and shown the effects of the workload reduction for a long time under the standing work. The foot pressures and EMG (Electromyography) are measured at 0 hour and after 2 hours by 6 health students in their twenties. The 6 prototype insoles are designed with three elastic (Low, Medium and High). These insoles are compared with no insole (insole type 7) as control group. The EMG measurement was conducted to waist (erector spinae muscle), thigh (vastus lateralis muscle) and calf (gastrocnemius muscle). The foot pressure is analyzed by mean pressure value and the EMG analysis is investigated through MF (Median Frequency), MPF (Mean Power Frequency) and ZCR (Zero Crossing Rate). The results of the foot pressure show that the multi-elastic insoles had smaller foot pressure value than that of no-insole. Moreover, Insole 2 and Insole 3 have the smallest increasing rate in foot pressure. The EMG results show that the multi-elastic insoles had smaller EMG shift value than that of no-insole in 2 hour, and then shift value shows the smallest value in Insole 2. Therefore, this study presents that the multi-elastic insoles have reducing effects of the work load for a long time standing work in both side of foot pressure and EMG.

키워드

참고문헌

  1. 강동묵, 이종태, 강민숙, 박성희, 엄상화, 김성준, 정귀원, 손해숙, 박봉진, 미용업 종사자들의 피부, 호흡기 및 근골격계 자각 증상에 관한 유병률, 대한산업의학회지, 11(3), 385-392, 1999
  2. 노동부, 2005 년도 산업재해 현황, 노동부, 2006
  3. 이창민, 오연주, 생체역학적 분석을 통한 보행부하 감소용 인솔 개발, 대한인간공학회지, 24(4), 23-30, 2005
  4. 이창민, 오연주, 이준수, 이경득, Outsole 경도에 따른 피로도 분석에 관한 연구, 산업기술연구지, 20, 59-65, 2006
  5. 한국산업안전공단, 하지 부위의 근골격계 질환, 2004
  6. Cook, J., Branch, T. P., Baranowski, T. J. and Hutton, W. C., The effect of surgical floor mats in prolonged standing: An EMG study of the lumber Para spinal and anterior tibialis muscles, Journal of Biomedical Engineering, 15(3), 247-250, 1993 https://doi.org/10.1016/0141-5425(93)90122-F
  7. Djupsjobacka, M., Johansson, H., Bergenheim, M. and Wenngren, B. I., Influences on the gamma-muscle-spindle system from muscle afferents stimulated by increased intramuscular concentration of bradykinin and 5HT, Meurosci. Rec., 22, 325-333, 1995
  8. Hansen, L., Winkel, J. and Jorgensen, K., Significance of mat and shoe softness during prolonged work in upright position: Based on measurements of low back muscle EMG, foot volume changes, discomfort and ground reactions, Applied Ergonomics. Health, 62, 217-224, 1998
  9. Konz, S., Bandla, V., Ray, M. and Sambasivan, J., Standing on concrete vs. floor mats, In Advances in Industrial Ergonomics and Safety II, Taylor & Francis, 991-998, 1990
  10. Krijnen, R. M. A., De Boer, E. M., Ader, H. J. and Bruynzeel, D. P., Venous insufficiency in male workers with a standing profession. Part 2: Diurnal volume changes of the lower legs, Dermatology, 194, 121-126, 1996
  11. Magora, A., Investigations of the relation between low back pain and occupation, Ind. Med., 12, 164-169, 1972
  12. Peter Konrad, The ABC of EMG, Version 1.0. Noraxon INC, 2005
  13. Phyllis M. King, A comparison of the effects of floor mats and shoe in-soles on standing fatigue, Applied Ergonomics, 33(5), 477-484, 2002 https://doi.org/10.1016/S0003-6870(02)00027-3
  14. Ryan, G. A., The prevalence of musculoskeletal symptoms in super market workers, Ergonomics, 32, 359-370, 1989 https://doi.org/10.1080/00140138908966103
  15. Rys, M., Konz, S., Bandla, V. and Sambasivan, J., Standing on concrete vs floor mats, Advances in Industrial Ergonomics and Safety II, 991-998, 1990
  16. Xu, Y., Bach, E. and Orthed, E., Work environment and low back pain: The influence of occupational activities, Occup. Environ. Med., 34, 741-745, 1997
  17. Zhang, L., Drury, C. and Wooley, S., Constrained standing: Evaluating the foot/floor interface, Ergonomics, 34, 175-192, 1991 https://doi.org/10.1080/00140139108967305

피인용 문헌

  1. Comparative Analysis of Foot Pressure Distribution by Functional Insole to be Transformed and Restored During Walking vol.21, pp.2, 2011, https://doi.org/10.5103/KJSB.2011.21.2.231