Journal of Advanced Marine Engineering and Technology

The Korean Society of Marine Engineering (한국마린엔지니어링학회)
권호 표지
DOI QR코드

DOI QR Code

Effect on Characteristics of Exhaust Emissions by Using Emulsified Fuel in Diesel Engine

디젤기관에 있어서 에멀젼연료가 배기배출물 특성에 미치는 영향

  • Published : 2007.01.31
Download PDF
⟨ Previous Next ⟩

Abstract

Diesel engines have high thermal efficiency, and they have less CO & HC emissions than another engines. while NOx & Soot emissions are very much. compared with exhaust emission standards. However, the limit level is more and more strengthened yearly due to the importance of environmental protection. So, the optimal countermeasures for the reduction of NOx & Soot emissions below limit level are required. Therefore. the author has investigated the effects of emulsified fuel on the characteristics of exhaust emissions. using an four-cycle, four-cylinder and direct injection diesel engine because the using of emulsified fuel among various methods for reducing NOx & Soot emissions is simple in installation low in cost and high in efficiency. The results of investigation according to various operating conditions are as follows : 1) Specific fuel consumption increase maximum 19.8% at low load. but is not affected at full load. 2) In case of emulsion ratio 25%, NOx emission decrease 32% at 75% load. 30% at full load. 3) In case of emulsion ratio 25%, Soot emission decrease 84% at 75% load, 59% at full load.

Keywords

References

  1. Susumu Kohketsu, Kazutoshi Mori, Kenji Sakai and Hiroshi Nakagawa, 'Reduction of Exhaust Emission with New Water Injection System in a Diesel Engine', SAE paper 960033, 1996
  2. Masahiro Ishida, Hironobu Ueki Daisaku Sakahuchi, 'Prediction of NOx Reduction rate due to Port Water Injection in a DI Diesel Engine', SAE paper 972961, 1997
  3. M. A. Psota, W. L. Easley, T. H Fort, and A. M. Mellor, 'Water Infection Effects on NOx Emission for Engines Utilizing Diffusion Flame Combustion', SAE Paper, 971657, 1997
  4. R. J. Crookes, M. A. Nazha, M. S. Janota, and T. Slorey, 'Investigation into the Combustion of Water/Kiesel Fuel Emulsions', SAE Paper, 80094, 1980
  5. Yasufumi Yoshimoto, Toshinori Kuramoto, Ziye Li, Minoru Tsukahara, 'Influence of Water Content Ratio on Combustion Fluctuation of Diesel Engine Using Emulsified Fuel', Journal of MESJ, Vol. 26 NO. 1, pp. 16-23, 1998
  6. Lebederv, O.N., 'Special characteristics of the combustion of water-fuel emulsions in diesels', Fizika Goreniya, vol. 14, no. 2, pp. 142-145, 1976
  7. 吉本唐文, 材上 正, '유화연료의 미세폭발에 관한 연구', 일본기계학회논문집, Vol 55, No. 519
  8. 곽인석, '에멀션 연료를 사용한 디젤기관의 내구성 및 연소특성에 관한 연구', 석사학위논문, 한국해양대학교, 2002

Cited by

  1. Effect of fuel component on nitrous oxide emission characteristics in diesel engine vol.38, pp.9, 2014, https://doi.org/10.5916/jkosme.2014.38.9.1045
  2. Investigation on emission characteristics of nitrous oxide from marine diesel engine vol.38, pp.9, 2014, https://doi.org/10.5916/jkosme.2014.38.9.1051
  3. Influence of fuel injection pattern on combustion and emissions characteristics of diesel engine by using emulsified fuel applied with EGR system vol.38, pp.9, 2014, https://doi.org/10.5916/jkosme.2014.38.9.1064
  4. Effect of Storage Tank Structure Variation on Fuel Shiftting vol.39, pp.6, 2015, https://doi.org/10.5916/jkosme.2015.39.6.599
  5. Basic Study of Spray-Behavior Characteristics of Emulsified Fuel vol.38, pp.9, 2014, https://doi.org/10.3795/KSME-B.2014.38.9.763
  6. 디젤엔진에서 연료 분사시기가 아산화질소에 미치는 영향 vol.18, pp.6, 2007, https://doi.org/10.9726/kspse.2014.18.6.106
  7. Feasibility Study of Emission Reduction on Marine Engine with Variation of Emulsified Water Concentration and Turbocharger Compression Ratio vol.10, pp.4, 2020, https://doi.org/10.3390/app10041215
  8. Exhaust Gas Emission Improvements of Water/Bunker C Oil-Emulsified Fuel Applied to Marine Boiler vol.9, pp.5, 2007, https://doi.org/10.3390/jmse9050477